Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector End Views
- ABS Electronic Control Unit Connector End Views
- ABS Motor Relay Harness Connector A-47 Connector End View
- ABS Valve Relay Harness Connector A-46 Connector End View
- A/T Solenoid Valve Assembly Connector End View
- Auto-Cruise ECU Connector End View
- Automatic Compressor ECU Connector End View
- Blower Resistor Connector End View
- Brakelight Switch Connector C-61 Or B-06 Connector End View
- Camshaft Position Sensor Connector End View (1.8L)
- Combination Meter Harness Connector B-07 Connector End View
- Combination Meter Harness Connector B-08 Connector End View
- Crankshaft Position Sensor Connector End View (1.5L)
- Crankshaft Position Sensor Connector End View (1.8L)
- Distributor Assembly Connector End View (1.5L)
- Dual Pressure Switch Connector End View
- EGR Solenoid Connector End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View
- FTDP Sensor Intermediate Connector E-22 Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay & Multiport Fuel Injection Relay Connector End View
- Fuel Tank Differential Pressure Sensor Connector E-23 Connector End View
- Generator Field Connector End View
- Heated Oxygen Sensor Connector End View
- Hydraulic Unit Harness Connector A-40 Connector End View
- IAT Sensor Connector End View (1.5L)
- IAT Sensor Connector End View (1.8L)
- Idle Air Control (IAC) Motor Connector End View
- Ignition Coil With Built-In Power Transistor Connector End View (1.8L)
- Ignition Failure Sensor Connector End View (1.8L)
- In-Line Harness Connector A-05 Connector End View
- In-Line Harness Connector B-35 Connector End View
- In-Line Harness Connector B-36 Connector End View
- In-Line Harness Connector B-49 Connector End View
- In-Line Harness Connector B-51 Connector End View
- Joint Connector B-24 Connector End View
- Joint Connector B-41 Connector End View
- Junction Block Harness Connector B-60 Connector End View
- Junction Block Harness Connector B-63 Connector End View
- Junction Block Harness Connector B-66 Connector End View
- Junction Block Harness Connector B-67 Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- OBD-II Data Link Connector (DLC) Connector End View
- Park Neutral Position Switch Connector End View
- Powertrain Control Module Connector End Views
- Purge Solenoid Connector End View
- Radiator Cooling Fan Relay Connector End View
- SRS ECU Connector End Views
- Sunroof Motor Connector End View
- Throttle Position Sensor Connector End View
- Vehicle Speed Sensor Connector End View
- Ventilation Solenoid Connector End View
- Volume Airflow Sensor Connector End View
- Starter Relay End View
- Connector End Views
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Cruise Control Systems
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Tests
- System Tests
- Notes
- Test No. 1 : Scan Tool Communication With All Systems Not Possible
- Test No. 2: Scan Tool Communication With Cruise Control Ecu Not Possible
- Test No. 3: Cruise Control Does Not Cancel When Brake Pedal Is Depressed
- Test No. 4: Cruise Control Does Not Cancel When Clutch Is Depressed
- Test No. 5: Cruise Control Does Not Cancel When Transaxle Is Shifted To "N" Range
- Test No. 6: Cruise Control Does Not Cancel When Cancel Is Selected On Switch
- Test No. 7: Cruise Control Cannot Be Set
- Test No. 8: Vehicle Speed Varies With Cruise Control Set
- Test No. 9: Cruise Control Indicator On Instrument Cluster Does Not Illuminate; Cruise Control Is Normal
- Component Tests
- Pin Voltage Tests
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- Power Mirrors
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Body & Frame
- Power Door Locks
- Power Mirrors
- Sun Roof/T-Top/Convertible Top
- Power Windows
- Brakes
- Anti-Lock Brakes
- Anti-Lock - Mirage
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Trouble Code Definition
- Diagnostic Tests
- Notes
- DTCS 11, 12, 13 & 14:
- DTC 15: Wheel Speed Sensor - Abnormal Output Signal
- DTC 16: Abs Electronic Control Unit Power Supply
- DTCS 21, 22, 23 & 24:
- DTC 33: Stoplight Switch Circuit
- DTCS 41, 42, 43, & 44:
- DTC 51: Abs Valve Relay Circuit
- DTC 53A: Abs Motor Relay Circuit (Motor Does Not Run)
- DTC 53B: Abs Motor Relay Circuit (Motor Keeps Running)
- DTC 63: Faulty Abs Ecu
- Symptom Tests
- Notes
- Test 1: No Communication With Scan Tool (All Systems)
- Test 2: No Communication With Scan Tool (Abs Only)
- Test 3: Abs Warning Light Inoperative (Ignition On)
- Test 4: Abs Warning Light Remains On
- Test 5: Abs Warning Light Inoperative (Start Position)
- Test 6: Abnormal Abs Warning Light Operation
- Test 7: Brake Operation Is Abnormal
- Component Tests
- Removal & Installation
- Overhaul
- Adjustments
- Torque Specifications
- Pin Voltage Charts
- Wiring Diagrams
- Anti-Lock - Mirage
- Mechanical - Hydraulic
- Disc & Drum
- Description
- Bleeding Brake System
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc & Drum Brake Specifications
- Disc Brake & Drum Brake Specifications (Diamante)
- Disc Brake & Drum Brake Specifications (Eclipse)
- Disc Brake & Drum Brake Specifications (GALANT)
- Disc Brake & Drum Brake Specifications (Lancer)
- Disc Brake & Drum Brake Specifications (Mirage)
- Disc Brake & Drum Brake Specifications (Montero)
- Disc Brake & Drum Brake Specifications (Montero Sport)
- Disc & Drum
- Parking Brake System
- Traction Control
- Anti-Lock - Mirage
- Description
- Operation
- Component Locations
- Bleeding Brake System
- Trouble Shooting
- Self-Diagnostic System
- Diagnostic Trouble Code Definition
- Diagnostic Tests
- Notes
- DTCS 11, 12, 13 & 14:
- DTC 15: Wheel Speed Sensor - Abnormal Output Signal
- DTC 16: Abs Electronic Control Unit Power Supply
- DTCS 21, 22, 23 & 24:
- DTC 33: Stoplight Switch Circuit
- DTCS 41, 42, 43, & 44:
- DTC 51: Abs Valve Relay Circuit
- DTC 53A: Abs Motor Relay Circuit (Motor Does Not Run)
- DTC 53B: Abs Motor Relay Circuit (Motor Keeps Running)
- DTC 63: Faulty Abs Ecu
- Symptom Tests
- Notes
- Test 1: No Communication With Scan Tool (All Systems)
- Test 2: No Communication With Scan Tool (Abs Only)
- Test 3: Abs Warning Light Inoperative (Ignition On)
- Test 4: Abs Warning Light Remains On
- Test 5: Abs Warning Light Inoperative (Start Position)
- Test 6: Abnormal Abs Warning Light Operation
- Test 7: Brake Operation Is Abnormal
- Component Tests
- Removal & Installation
- Overhaul
- Adjustments
- Torque Specifications
- Pin Voltage Charts
- Wiring Diagrams
- Anti-Lock - Mirage
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- OEM Connector End Views
- Connector End Views
- ABS Electronic Control Unit Connector End Views
- ABS Motor Relay Harness Connector A-47 Connector End View
- ABS Valve Relay Harness Connector A-46 Connector End View
- A/T Solenoid Valve Assembly Connector End View
- Auto-Cruise ECU Connector End View
- Automatic Compressor ECU Connector End View
- Blower Resistor Connector End View
- Brakelight Switch Connector C-61 Or B-06 Connector End View
- Camshaft Position Sensor Connector End View (1.8L)
- Combination Meter Harness Connector B-07 Connector End View
- Combination Meter Harness Connector B-08 Connector End View
- Crankshaft Position Sensor Connector End View (1.5L)
- Crankshaft Position Sensor Connector End View (1.8L)
- Distributor Assembly Connector End View (1.5L)
- Dual Pressure Switch Connector End View
- EGR Solenoid Connector End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View
- FTDP Sensor Intermediate Connector E-22 Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay & Multiport Fuel Injection Relay Connector End View
- Fuel Tank Differential Pressure Sensor Connector E-23 Connector End View
- Generator Field Connector End View
- Heated Oxygen Sensor Connector End View
- Hydraulic Unit Harness Connector A-40 Connector End View
- IAT Sensor Connector End View (1.5L)
- IAT Sensor Connector End View (1.8L)
- Idle Air Control (IAC) Motor Connector End View
- Ignition Coil With Built-In Power Transistor Connector End View (1.8L)
- Ignition Failure Sensor Connector End View (1.8L)
- In-Line Harness Connector A-05 Connector End View
- In-Line Harness Connector B-35 Connector End View
- In-Line Harness Connector B-36 Connector End View
- In-Line Harness Connector B-49 Connector End View
- In-Line Harness Connector B-51 Connector End View
- Joint Connector B-24 Connector End View
- Joint Connector B-41 Connector End View
- Junction Block Harness Connector B-60 Connector End View
- Junction Block Harness Connector B-63 Connector End View
- Junction Block Harness Connector B-66 Connector End View
- Junction Block Harness Connector B-67 Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- OBD-II Data Link Connector (DLC) Connector End View
- Park Neutral Position Switch Connector End View
- Powertrain Control Module Connector End Views
- Purge Solenoid Connector End View
- Radiator Cooling Fan Relay Connector End View
- SRS ECU Connector End Views
- Sunroof Motor Connector End View
- Throttle Position Sensor Connector End View
- Vehicle Speed Sensor Connector End View
- Ventilation Solenoid Connector End View
- Volume Airflow Sensor Connector End View
- Starter Relay End View
- Connector End Views
- OEM Connector End Views
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Motors, Switches, Relays
- OEM Connector End Views
- Connector End Views
- ABS Electronic Control Unit Connector End Views
- ABS Motor Relay Harness Connector A-47 Connector End View
- ABS Valve Relay Harness Connector A-46 Connector End View
- A/T Solenoid Valve Assembly Connector End View
- Auto-Cruise ECU Connector End View
- Automatic Compressor ECU Connector End View
- Blower Resistor Connector End View
- Brakelight Switch Connector C-61 Or B-06 Connector End View
- Camshaft Position Sensor Connector End View (1.8L)
- Combination Meter Harness Connector B-07 Connector End View
- Combination Meter Harness Connector B-08 Connector End View
- Crankshaft Position Sensor Connector End View (1.5L)
- Crankshaft Position Sensor Connector End View (1.8L)
- Distributor Assembly Connector End View (1.5L)
- Dual Pressure Switch Connector End View
- EGR Solenoid Connector End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View
- FTDP Sensor Intermediate Connector E-22 Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay & Multiport Fuel Injection Relay Connector End View
- Fuel Tank Differential Pressure Sensor Connector E-23 Connector End View
- Generator Field Connector End View
- Heated Oxygen Sensor Connector End View
- Hydraulic Unit Harness Connector A-40 Connector End View
- IAT Sensor Connector End View (1.5L)
- IAT Sensor Connector End View (1.8L)
- Idle Air Control (IAC) Motor Connector End View
- Ignition Coil With Built-In Power Transistor Connector End View (1.8L)
- Ignition Failure Sensor Connector End View (1.8L)
- In-Line Harness Connector A-05 Connector End View
- In-Line Harness Connector B-35 Connector End View
- In-Line Harness Connector B-36 Connector End View
- In-Line Harness Connector B-49 Connector End View
- In-Line Harness Connector B-51 Connector End View
- Joint Connector B-24 Connector End View
- Joint Connector B-41 Connector End View
- Junction Block Harness Connector B-60 Connector End View
- Junction Block Harness Connector B-63 Connector End View
- Junction Block Harness Connector B-66 Connector End View
- Junction Block Harness Connector B-67 Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- OBD-II Data Link Connector (DLC) Connector End View
- Park Neutral Position Switch Connector End View
- Powertrain Control Module Connector End Views
- Purge Solenoid Connector End View
- Radiator Cooling Fan Relay Connector End View
- SRS ECU Connector End Views
- Sunroof Motor Connector End View
- Throttle Position Sensor Connector End View
- Vehicle Speed Sensor Connector End View
- Ventilation Solenoid Connector End View
- Volume Airflow Sensor Connector End View
- Starter Relay End View
- Connector End Views
- OEM Connector End Views
- Starters
- Wiring Diagrams
- OEM Connector End Views
- Connector End Views
- ABS Electronic Control Unit Connector End Views
- ABS Motor Relay Harness Connector A-47 Connector End View
- ABS Valve Relay Harness Connector A-46 Connector End View
- A/T Solenoid Valve Assembly Connector End View
- Auto-Cruise ECU Connector End View
- Automatic Compressor ECU Connector End View
- Blower Resistor Connector End View
- Brakelight Switch Connector C-61 Or B-06 Connector End View
- Camshaft Position Sensor Connector End View (1.8L)
- Combination Meter Harness Connector B-07 Connector End View
- Combination Meter Harness Connector B-08 Connector End View
- Crankshaft Position Sensor Connector End View (1.5L)
- Crankshaft Position Sensor Connector End View (1.8L)
- Distributor Assembly Connector End View (1.5L)
- Dual Pressure Switch Connector End View
- EGR Solenoid Connector End View
- Engine Control Module (ECM) Connector End Views
- Engine Coolant Temperature Sensor Connector End View
- FTDP Sensor Intermediate Connector E-22 Connector End View
- Fuel Injector Connector End View
- Fuel Pump Relay & Multiport Fuel Injection Relay Connector End View
- Fuel Tank Differential Pressure Sensor Connector E-23 Connector End View
- Generator Field Connector End View
- Heated Oxygen Sensor Connector End View
- Hydraulic Unit Harness Connector A-40 Connector End View
- IAT Sensor Connector End View (1.5L)
- IAT Sensor Connector End View (1.8L)
- Idle Air Control (IAC) Motor Connector End View
- Ignition Coil With Built-In Power Transistor Connector End View (1.8L)
- Ignition Failure Sensor Connector End View (1.8L)
- In-Line Harness Connector A-05 Connector End View
- In-Line Harness Connector B-35 Connector End View
- In-Line Harness Connector B-36 Connector End View
- In-Line Harness Connector B-49 Connector End View
- In-Line Harness Connector B-51 Connector End View
- Joint Connector B-24 Connector End View
- Joint Connector B-41 Connector End View
- Junction Block Harness Connector B-60 Connector End View
- Junction Block Harness Connector B-63 Connector End View
- Junction Block Harness Connector B-66 Connector End View
- Junction Block Harness Connector B-67 Connector End View
- Manifold Absolute Pressure Sensor Connector End View
- OBD-II Data Link Connector (DLC) Connector End View
- Park Neutral Position Switch Connector End View
- Powertrain Control Module Connector End Views
- Purge Solenoid Connector End View
- Radiator Cooling Fan Relay Connector End View
- SRS ECU Connector End Views
- Sunroof Motor Connector End View
- Throttle Position Sensor Connector End View
- Vehicle Speed Sensor Connector End View
- Ventilation Solenoid Connector End View
- Volume Airflow Sensor Connector End View
- Starter Relay End View
- Connector End Views
- System Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Body Computer
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Top/Sunroof
- Power Windows
- Radio
- Starting/Charging
- Supplemental Restraints
- Transmission
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Specifications & Drive Belt Routing
- Belt Routing
- Timing/Water Pump Belt Routing (Diamante)
- A/C, Generator & Power Steering Belt Routing (Eclipse & GALANT 2.4L)
- A/C, Generator & Power Steering Belt Routing (Eclipse & GALANT 3.0L)
- Timing/Water Pump Belt Routing (Eclipse & GALANT 3.0L)
- A/C & Generator Belt Routing (Lancer)
- A/C, Generator & Power Steering Belt Routing (Mirage 1.5L)
- A/C, Generator & Power Steering Belt Routing (Mirage 1.8L)
- Timing/Water Pump Belt Routing (Mirage 1.8L)
- Accessory Drive Belt Routing (Montero)
- Accessory Drive Belt Routing (Montero Sport)
- Specifications
- Belt Routing
- Specifications & Drive Belt Routing
- Cooling Fans
- Cooling System (Mechanical)
- Specifications & Drive Belt Routing
- Belt Routing
- Timing/Water Pump Belt Routing (Diamante)
- A/C, Generator & Power Steering Belt Routing (Eclipse & GALANT 2.4L)
- A/C, Generator & Power Steering Belt Routing (Eclipse & GALANT 3.0L)
- Timing/Water Pump Belt Routing (Eclipse & GALANT 3.0L)
- A/C & Generator Belt Routing (Lancer)
- A/C, Generator & Power Steering Belt Routing (Mirage 1.5L)
- A/C, Generator & Power Steering Belt Routing (Mirage 1.8L)
- Timing/Water Pump Belt Routing (Mirage 1.8L)
- Accessory Drive Belt Routing (Montero)
- Accessory Drive Belt Routing (Montero Sport)
- Specifications
- Belt Routing
- Specifications & Drive Belt Routing
- Mechanical
- 1.8L 4 Cylinder
- On-Vehicle Service
- General Information
- Service Specifications
- Sealants
- Special Tools
- Troubleshooting
- Component On-Vehicle Service
- Drive Belt Tension Check And Adjustment
- Power Steering Oil Pump And Air Conditioning Compressor Drive Belt Tension Check And Adjustment
- Ignition Timing Check
- Curb Idle Speed Check
- Idle Mixture Check
- Compression Pressure Check
- Manifold Vacuum Check
- Timing Belt Tension Adjustment
- Lash Adjuster Check
- Purging Of The Lash Adjuster
- Engine Assembly
- Crankshaft Pulley
- Camshaft And Camshaft Oil Seal
- Oil Pan
- Crankshaft Oil Seal
- Cylinder Head Gasket
- Timing Belt
- Engine Overhaul
- Specifications
- Overhaul
- Generator And Ignition System
- Timing Belt
- Fuel And Emission Control System
- Intake And Exhaust Manifolds
- Water Pump And Water Hose
- Rocker Arms And Camshaft
- Cylinder Head And Valves
- Oil Pump And Oil Pan
- Piston And Connecting Rod
- Crankshaft And Cylinder Block
- Torque Specifications
- On-Vehicle Service
- 1.8L 4 Cylinder
- Starters
- Timing Belt Replacement - 1.8L - VINS C & D
- Accessory Drive Belts
- Engine Performance
- Engine Controls - On-Vehicle Adjustments
- Application
- Emissions
- EGR Function Testing - CHRYSLER/MITSUBISHI
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - 1997-2012 MITSUBISHI
- Introduction
- 1997
- 1998-2001
- 2002-2003
- 2004-2005
- 2006-07 Eclipse & 2006 GALANT
- 2006 Endeavor
- 2007 GALANT & 2007 Endeavor
- 2007 Outlander
- 2008 Eclipse
- 2008 Endeavor, 2008-10 GALANT, 2009-11 Eclipse & 2009-10 Outlander
- 2008 Lancer
- 2008 Outlander
- 2009 Lancer
- 2009 Lancer SPORTBACK
- 2010 Lancer & Lancer SPORTBACK
- 2011-12 GALANT, 2012 Eclipse & 2012 Outlander
- 2011 Lancer, 2011 Lancer SPORTBACK & 2011 Outlander
- 2012 Lancer & 2012 Lancer SPORTBACK
- Engine Controls - Pin Voltage Charts
- Introduction
- Pin Voltage Tests
- Resistance & Continuity Tests
- Notes
- Pin Resistance & Continuity (Diamante)
- Pin Resistance & Continuity (Eclipse 2.4L, Eclipse SPYDER 2.4L & GALANT 2.4L)
- Pin Resistance & Continuity (Eclipse 3.0L, Eclipse SPYDER 3.0L & GALANT 3.0L)
- Pin Resistance & Continuity (Lancer)
- Pin Resistance & Continuity (Mirage)
- Pin Resistance & Continuity (Montero)
- Pin Resistance & Continuity (Montero Sport 3.0L/3.5L)
- Remove, Overhaul & Install
- Engine Controls - Removal, Overhaul & Installation
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Cooling System
- Ignition Systems
- Fuel Systems
- Notes
- Fuel System Pressure Release
- Fuel Filter
- Fuel Pressure Regulator
- Fuel Pump
- Fuel Rails & Injectors
- Notes
- Removal (Diamante)
- Installation (Diamante)
- Removal (Eclipse 2.4L & Galant 2.4L)
- Installation (Eclipse 2.4L & Galant 2.4L)
- Removal (Eclipse 3.0L & Galant 3.0L)
- Installation (Eclipse 3.0L & Galant 3.0L)
- Removal (Lancer & Mirage)
- Installation (Lancer & Mirage)
- Removal (Montero & Montero Sport)
- Installation (Montero & Montero Sport)
- Fuel Tank
- Fuel Tank Leveling Valve
- Fuel Tank Pressure Sensor
- Heated Oxygen Sensors
- Throttle Body
- Removal (Diamante)
- Disassembly & Reassembly (Diamante)
- Installation (Diamante)
- Removal (Eclipse & Galant)
- Disassembly & Reassembly (Eclipse & Galant)
- Installation (Eclipse & Galant)
- Removal (Lancer)
- Disassembly & Reassembly (Lancer)
- Installation (Lancer)
- Removal (Mirage)
- Disassembly & Reassembly (Mirage)
- Installation (Mirage)
- Removal (Montero & Montero Sport)
- Disassembly & Reassembly (Montero & Montero Sport)
- Installation (Montero & Montero Sport)
- Emission Systems & Sub-Systems
- Torque Specifications
- Engine Controls - Removal, Overhaul & Installation
- Sensor Range Charts
- Specifications
- System
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 1.8L
- Introduction
- Self-Diagnostic System
- Summary
- Intermittent Diagnostic Trouble Codes
- Diagnostic Circuit Check
- Component Locations
- Connector Identification
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0101: Volume Air Flow Sensor Circuit Range/Performance Problem
- DTC P0102: Volume Airflow Circuit Low Input
- DTC P0106: Barometric Pressure Circuit Range/Performance Problem
- DTC P0107: Barometric Pressure Circuit Low Input
- DTC P0108: Barometric Pressure Circuit High Input
- DTC P0111: Intake Air Temperature Circuit Range/Performance Problem
- DTC P0112: Intake Air Temperature Circuit Low Input
- DTC P0113: Intake Air Temperature Circuit High Input
- DTC P0116: Engine Coolant Temperature Circuit Range/Performance Problem
- DTC P0117: Engine Coolant Temperature Circuit Low Input
- DTC P0118: Engine Coolant Temperature Circuit High Input
- DTC P0121: Throttle Position Sensor Circuit Range/Performance Problem
- DTC P0122: Throttle Position Sensor Circuit Low Input
- DTC P0123: Throttle Position Sensor Circuit High Input
- DTC P0125: Insufficient Coolant Temperature For Closed Loop Fuel Control
- DTC P0132: Heated Oxygen Sensor Circuit High Voltage (Sensor 1)
- DTC P0133: Heated Oxygen Sensor Circuit Slow Response (Sensor 1)
- DTC P0134: Heated Oxygen Sensor Circuit No Activity Detected (Sensor 1)
- DTC P0135: Heated Oxygen Sensor Heater Circuit (Sensor 1)
- DTC P0137: Heated Oxygen Sensor Circuit Low Voltage (Sensor 2)
- DTC P0138: Heated Oxygen Sensor Circuit High Voltage (Sensor 2)
- DTC P0139: Heated Oxygen Sensor Circuit Slow Response (Sensor 2)
- DTC P0141: Heated Oxygen Sensor Heater Circuit (Sensor 2)
- DTC P0171: System Too Lean
- DTC P0172: System Too Rich
- DTC P0201, DTC P0202, DTC P0203 & P0204
- DTC P0300: Random Misfire Detected
- DTC P0301, DTC P0302, DTC P0303 & P0304
- DTC P0335: Crankshaft Position Sensor Circuit Malfunction
- DTC P0340: Camshaft Position Sensor Circuit Malfunction
- DTC P0401: Exhaust Gas RECIRCULATION Flow Insufficient Detected
- DTC P0403: Exhaust Gas RECIRCULATION Control Circuit
- DTC P0421: Warm-Up Catalyst Efficiency Below Threshold
- DTC P0441: Evaporative Emission Control System Incorrect Purge Flow
- DTC P0442: Evaporative Emission System Small Leak Detected
- DTC P0443: Evaporative Emission Control System Purge Control Valve Circuit
- DTC P0446: Evaporative Emission Control System Ventilation Solenoid Circuit Malfunction
- DTC P0451: Evaporative Emission Control System Pressure Sensor Range/Performance
- DTC P0452: Evaporative Emission Control System Pressure Sensor Low Input
- DTC P0453: Evaporative Emission Control System Pressure Sensor High Input
- DTC P0455: Evaporative Emission Control System Gross Leak Detected
- DTC P0500: Vehicle Speed Sensor (M/T Only)
- DTC P0506 Or DTC P0507
- DTC P0510: Closed Throttle Position Switch Malfunction
- DTC P0551: Power Steering Pressure Sensor Circuit Range/Performance
- DTC P1400: Manifold Differential Pressure Sensor Circuit Malfunction
- DTC P1500: Generator Fr Terminal Circuit Malfunction
- DTC P1603: Battery Back-Up Circuit Malfunction
- Verifying Repairs
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Notes
- Sensors
- Accelerator Pedal Position (APP) Sensor - Diamante With Traction Control
- Barometric Pressure (BARO) Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Differential Pressure (MDP) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Volume Air Flow (VAF) Sensor
- Switches
- Motors, Relays & Solenoids
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Engine Controls - Trouble Shooting - No Codes
- Engine Controls - Basic Diagnostic Procedures
- Testing & Diagnosis
- Engine Controls - Basic Diagnostic Procedures
- Introduction
- Preliminary Inspection & Adjustments
- Fuel System
- Ignition Checks
- Idle Speed & Ignition Timing
- Summary
- Engine Controls - Self-Diagnostics - 1.8L
- Introduction
- Self-Diagnostic System
- Summary
- Intermittent Diagnostic Trouble Codes
- Diagnostic Circuit Check
- Component Locations
- Connector Identification
- Diagnostic Trouble Code Definitions
- Diagnostic Tests
- Notes
- DTC P0101: Volume Air Flow Sensor Circuit Range/Performance Problem
- DTC P0102: Volume Airflow Circuit Low Input
- DTC P0106: Barometric Pressure Circuit Range/Performance Problem
- DTC P0107: Barometric Pressure Circuit Low Input
- DTC P0108: Barometric Pressure Circuit High Input
- DTC P0111: Intake Air Temperature Circuit Range/Performance Problem
- DTC P0112: Intake Air Temperature Circuit Low Input
- DTC P0113: Intake Air Temperature Circuit High Input
- DTC P0116: Engine Coolant Temperature Circuit Range/Performance Problem
- DTC P0117: Engine Coolant Temperature Circuit Low Input
- DTC P0118: Engine Coolant Temperature Circuit High Input
- DTC P0121: Throttle Position Sensor Circuit Range/Performance Problem
- DTC P0122: Throttle Position Sensor Circuit Low Input
- DTC P0123: Throttle Position Sensor Circuit High Input
- DTC P0125: Insufficient Coolant Temperature For Closed Loop Fuel Control
- DTC P0132: Heated Oxygen Sensor Circuit High Voltage (Sensor 1)
- DTC P0133: Heated Oxygen Sensor Circuit Slow Response (Sensor 1)
- DTC P0134: Heated Oxygen Sensor Circuit No Activity Detected (Sensor 1)
- DTC P0135: Heated Oxygen Sensor Heater Circuit (Sensor 1)
- DTC P0137: Heated Oxygen Sensor Circuit Low Voltage (Sensor 2)
- DTC P0138: Heated Oxygen Sensor Circuit High Voltage (Sensor 2)
- DTC P0139: Heated Oxygen Sensor Circuit Slow Response (Sensor 2)
- DTC P0141: Heated Oxygen Sensor Heater Circuit (Sensor 2)
- DTC P0171: System Too Lean
- DTC P0172: System Too Rich
- DTC P0201, DTC P0202, DTC P0203 & P0204
- DTC P0300: Random Misfire Detected
- DTC P0301, DTC P0302, DTC P0303 & P0304
- DTC P0335: Crankshaft Position Sensor Circuit Malfunction
- DTC P0340: Camshaft Position Sensor Circuit Malfunction
- DTC P0401: Exhaust Gas RECIRCULATION Flow Insufficient Detected
- DTC P0403: Exhaust Gas RECIRCULATION Control Circuit
- DTC P0421: Warm-Up Catalyst Efficiency Below Threshold
- DTC P0441: Evaporative Emission Control System Incorrect Purge Flow
- DTC P0442: Evaporative Emission System Small Leak Detected
- DTC P0443: Evaporative Emission Control System Purge Control Valve Circuit
- DTC P0446: Evaporative Emission Control System Ventilation Solenoid Circuit Malfunction
- DTC P0451: Evaporative Emission Control System Pressure Sensor Range/Performance
- DTC P0452: Evaporative Emission Control System Pressure Sensor Low Input
- DTC P0453: Evaporative Emission Control System Pressure Sensor High Input
- DTC P0455: Evaporative Emission Control System Gross Leak Detected
- DTC P0500: Vehicle Speed Sensor (M/T Only)
- DTC P0506 Or DTC P0507
- DTC P0510: Closed Throttle Position Switch Malfunction
- DTC P0551: Power Steering Pressure Sensor Circuit Range/Performance
- DTC P1400: Manifold Differential Pressure Sensor Circuit Malfunction
- DTC P1500: Generator Fr Terminal Circuit Malfunction
- DTC P1603: Battery Back-Up Circuit Malfunction
- Verifying Repairs
- Engine Controls - System & Component Testing
- Introduction
- Computerized Engine Controls
- Engine Sensors & Switches
- Notes
- Sensors
- Accelerator Pedal Position (APP) Sensor - Diamante With Traction Control
- Barometric Pressure (BARO) Sensor
- Camshaft Position (CMP) Sensor
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Differential Pressure (MDP) Sensor
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Volume Air Flow (VAF) Sensor
- Switches
- Motors, Relays & Solenoids
- Fuel System
- Idle Control System
- Ignition System
- Emission Systems & Sub-Systems
- Miscellaneous Controls
- Engine Controls - Trouble Shooting - No Codes
- Engine Controls - Basic Diagnostic Procedures
- Theory and Operation
- Engine Controls - Theory & Operation
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Engine Control Module/Powertrain Control Module (ECM/Pcm)
- Input Devices
- Notes
- Air Conditioning Switch
- Barometric (BARO) Pressure Sensor
- Camshaft Position (CMP) Sensor
- Closed Throttle Position Switch
- Crankshaft Position (CKP) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Fuel Tank Differential Pressure Sensor
- Fuel Level Sensor
- Fuel Temperature Sensor
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Knock Sensor (KS)
- Manifold Differential Pressure (MDP) Sensor
- Park/Neutral Position (PNP) Switch (Automatic Transmission)
- Power Steering Oil Pressure Switch
- Throttle Position (TP) Sensor
- Vehicle Speed Sensor (VSS)
- Volume Airflow (VAF) Sensor
- Output Signals
- Fuel System
- Ignition Systems
- Emission Systems
- Self-Diagnostic System
- Engine Controls - Theory & Operation
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures - Import
- Introduction
- ACURA
- AUDI
- BMW
- HONDA
- HYUNDAI
- INFINITI
- ISUZU
- Jaguar
- KIA
- Land Rover
- LEXUS
- MAZDA
- MERCEDES-BENZ
- Notes
- Synchronization Of Power Windows
- Activating Steering Angle Sensor
- Synchronization Of Sliding/Tilt-Up Roof
- Easy Entry/Exit Function
- Control Module Version Coding
- Enabling Code Function For Radio
- Notes
- Audio 5 & 10 Models Or Sound 10, 20 & 30 Models (CLK, E & SLK Class)
- Becker 2000 (CL, S & SL Class)
- Becker Mexico, Grand Prix, Europa & Avus Models (SL Class)
- Radio With Navigation Control Module (CL, S & SL Class)
- Radio With 4-Digit Fixed Code (CL, S & SL Class)
- Radio & Radio With Navigation Control Module With 5-Digit Fixed Code (CL, S & SL Class)
- Radio (ML Class)
- Programming Supplemental Restraint System Control Module
- MITSUBISHI
- NISSAN
- PORSCHE
- SAAB
- SUBARU
- SUZUKI
- TOYOTA
- Service Precautions (PRIUS)
- Immobilizer Programming (Except PRIUS)
- Additional Master Key Registration (Except PRIUS)
- Additional Sub-Key Registration (Except PRIUS)
- Erasure Of Transponder Key Code (Except PRIUS)
- Immobilizer Component Replacement Programming Procedures (PRIUS)
- Notes
- Programming When Replacing Transponder Key Electronic Control Unit
- Programming When Replacing Hybrid Vehicle Control Electronic Control Unit
- Programming When Replacing Transponder Key Electronic Control Unit & Hybrid Vehicle Control Electronic Control Unit
- Programming If All Ignition Keys Are Lost
- Ignition Key Registration
- Additional Master Key Registration
- Additional Sub-Key Registration
- Erasure Of Transponder Key Code
- Power Sliding Door REINITIALIZATION Procedure (Sienna)
- Sun Roof Initialization (CAMRY & CELICA)
- VOLKSWAGEN
- VOLVO
- OBD-II Drive Cycles
- * Please Read This First *
- Drive Cycle Index
- Drive Cycle Procedures
- 1996 3000GT
- 1996 Eclipse & Eclipse SPYDER
- 1996-98 GALANT
- 1996-2000 Montero
- 1997 3000GT
- 1997-1999 Eclipse 2.4L
- 1997-99 Eclipse SPYDER With 2.0L Turbo And 2.4L
- 1997 Mirage 1.5L & 1.8L
- 1997-2000 MONTERO SPORT, 1998-99 3000GT, 1998-2001 Diamante, 1999-2000 GALANT & 1998-2000 MIRAGE
- 2000 Eclipse
- 2001 Eclipse & Eclipse SPYDER
- 2001 GALANT, 2004-05 Eclipse, Eclipse SPYDER, Lancer SPORTBACK, Montero Sport
- Notes
- Procedure 1 - Evaporative Emission Control System Leak Monitor
- Procedure 2 - Fuel Trim Monitor
- Procedure 3 - Catalytic Converter Monitor
- Procedure 4 - Heated Oxygen Sensor Monitor
- Procedure 5 - Exhaust Gas RECIRCULATION (EGR) System Monitor
- PROCEDURE 6 - OTHER MONITOR (main Components, Sensors And Switches, Wire Breakage And Short Circuit)
- 2001-02 Mirage
- 2001 Montero
- 2001 Montero Sport
- 2002-04 Diamante
- 2002-03 Eclipse
- 2002-03 GALANT & Montero Sport
- 2002-03 Lancer, Montero & 2003 Outlander
- 2004-05 Endeavor, GALANT, Lancer, Montero & Outlander
- 2006-07 Eclipse, 07 Eclipse SPYDER, 2006-07 Endeavor, 2006 GALANT, 2007 GALANT 3.8L, 2006 Lancer 2.0L, 2007 Lancer
- 2006 Lancer 2.4L, Lancer Evolution, Lancer SPORTBACK, Montero & Outlook
- 2007 GALANT 2.4L, Outlander
- 2007-09 Raider
- 2008-10 Eclipse, Eclipse SPYDER, Endeavor, GALANT, Lancer & Outlander
- 2011-12 Eclipse, Endeavor, GALANT
- 2011-12 Lancer 2.0L W/O Turbo & 2.4L & Outlander 2.4L & Outlander Sport
- 2011-12 Lancer 2.0L Turbo
- 2011-12 OUTLANTER 3.0L
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder
- Maintenance Service Reminder
- Timing Chain Maintenance Reminder
- Tire Pressure Monitor System Reminder
- Restraints
- Air Bag And Supplemental Restraint System (SRS) Component Inspection & Replacement Tables
- Air Bag Deactivation Procedures
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- Manual A/C-Heater Systems
- General Information
- Service Specifications
- Lubricants
- Special Tools
- Troubleshooting
- On-Vehicle Service
- Heater Control Assembly And A/C Switch
- Heater Unit And Heater Core
- Blower Assembly And Resistor
- Evaporator < Vehicles With A/C >
- Compressor And Tension Pulley
- Refrigerant Line
- Condenser And Condenser Fan Motor
- Ventilators
- Specifications
- Wiring Diagrams
- Manual A/C-Heater Systems
- Maintenance
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder
- Maintenance Service Reminder
- Timing Chain Maintenance Reminder
- Tire Pressure Monitor System Reminder
- Maintenance Reminder Light (Reset Procedures)
- Restraints
- Air Bag, SRS
- Air Bag Restraint Systems
- Description & Operation
- Component Locations
- System Operation Check
- Air Bag Safety Precautions
- Adjustments
- Disabling & Activating Air Bag System
- Disposal Procedures
- Post-Collision Inspection
- Removal & Installation
- Diagnostics
- Diagnostic Tests
- Inspection Procedure 1
- Inspection Procedure 2
- DTC 14: Analog "G" Sensor
- DTC 15 & 16: SAFING "G" Sensor
- DTC 21, 22, 61 & 62: Driver-Side Air Bag Module System
- DTC 24, 25, 64 & 65: Passenger Side Air Bag Module System
- DTC 26, 27, 66 & 67: Driver-Side Seat Belt PRETENSIONER System
- DTC 31 & 32: SRS Ecu Capacitor
- DTC 34: Connector Lock Circuit
- DTC 35: SRS Ecu Air Bag Deployment
- DTC 41 & 42: IG1 Power Circuit System
- DTC 43: Air Bag Warning Light Circuit
- DTC 44: Air Bag Warning Light Circuit
- DTC 45: SRS Ecu A/D Converter Circuit
- DTC 51 & 52: Driver-Side Air Bag Module
- DTC 54 & 55: Passenger-Side Air Bag Module
- DTC 56 & 57: Driver-Side Seat Belt PRETENSIONER
- Component Testing
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Air Bag Restraint Systems
- Air Bag, SRS
- Steering
- Manual Steering
- Manual & Power Steering
- General Information
- Service Specifications
- Lubricants
- Sealant
- Special Tools
- On-Vehicle Service
- Steering Wheel And Shaft
- Manual Steering Gear Box
- Power Steering Gear Box
- Removal And Installation
- Removal Service Points
- Inspection
- Gear Box Total Pinion Torque Check
- Tie-Rod For Swing Resistance Check
- Disassembly And Reassembly
- Disassembly Service Points
- Reassembly Service Points
- >A< Oil Seal Installation
- >B< Needle Roller Bearing/Ball Bearing Installation
- >C< Rack Installation
- >D< Oil Seal/Rack Bushing Installation
- >E< CIRCLIP Installation
- >F< Oil Seal/Ball Bearing Installation
- >G< Seal Ring Installation
- >H< Oil Seal Installation
- >I< End Plug Installation
- >J< Rack Support Cover Installation
- >K< Total Pinion Torque Adjustment
- >L< Tab Washer/Tie-Rod Installation
- >M< Bellows Band Installation
- >N< Tie-Rod End/Tie-Rod End Locking Nut Installation
- Rack Check
- Pinion And Valve Assembly Check
- Bearing Check
- Other Check
- Power Steering Oil Pump
- Power Steering Hoses
- Manual & Power Steering
- Manual & Power Steering
- General Information
- Service Specifications
- Lubricants
- Sealant
- Special Tools
- On-Vehicle Service
- Steering Wheel And Shaft
- Manual Steering Gear Box
- Power Steering Gear Box
- Removal And Installation
- Removal Service Points
- Inspection
- Gear Box Total Pinion Torque Check
- Tie-Rod For Swing Resistance Check
- Disassembly And Reassembly
- Disassembly Service Points
- Reassembly Service Points
- >A< Oil Seal Installation
- >B< Needle Roller Bearing/Ball Bearing Installation
- >C< Rack Installation
- >D< Oil Seal/Rack Bushing Installation
- >E< CIRCLIP Installation
- >F< Oil Seal/Ball Bearing Installation
- >G< Seal Ring Installation
- >H< Oil Seal Installation
- >I< End Plug Installation
- >J< Rack Support Cover Installation
- >K< Total Pinion Torque Adjustment
- >L< Tab Washer/Tie-Rod Installation
- >M< Bellows Band Installation
- >N< Tie-Rod End/Tie-Rod End Locking Nut Installation
- Rack Check
- Pinion And Valve Assembly Check
- Bearing Check
- Other Check
- Power Steering Oil Pump
- Power Steering Hoses
- Manual Steering
- Suspension
- Front Suspension
- Rear Suspension
- Suspension - Rear
- General Information
- Service Specifications
- Special Tools
- Troubleshooting
- On-Vehicle Service
- Control Link, Upper Link And Lower Arm Removal And Installation
- Trailing Arm
- Strut Assembly
- Suspension - Rear
- Wheel Alignment
- Transmission
- Clutches
- Manual Trans
- Overhaul
- General Information
- Specifications
- Special Tools
- Transaxle
- Disassembly And Reassembly
- Disassembly Service Points
- >A< Sealing Cap Removal
- >B< Transaxle Case Removal
- >C< Reverse Idler Gear Shaft Removal
- >D< 3RD-4TH Speed Shift Rail/3RD-4TH Speed Shift Fork/5TH Speed Shift Fork/Snap Ring/Reverse Shift Lug/5TH Speed Shift Rail/Steel Ball/Reverse Interlock Rail Removal
- >E< 3RD-4TH Speed Shift Rail/3RD-4TH Speed Shift Fork/5TH Speed-Reverse Shift Rail/5TH Speed-Reverse Shift Fork Removal
- >F< Input Shaft/Output Shaft Removal
- Adjustment Before Reassembly Spacer Selection For Differential Case End Play Adjustment < F5M41 >
- Spacer Selection For Differential Case Preload Adjustment < F5M42 >
- Reassembly Service Points
- >A< Output Shaft/Input Shaft Installation
- >B< Output Shaft/Input Shaft Installation
- >C< Front Bearing Retainer Installation
- >D< Reverse Interlock Rail/Steel Ball/5TH Speed Shift Rail/Reverse Shift Lug/Snap Ring/5TH Speed Shift Fork/3RD-4TH Speed Shift Fork/3RD-4TH Speed Shift Rail Installation
- >E< 5TH Speed-Reverse Shift Fork/5TH Speed-Reverse Shift Rail/3RD-4TH Speed Shift Fork/3RD-4TH Speed Shift Rail Installation
- >F< Spring Pin Installation
- >G< Spacer Installation
- >H< Oil Guide Installation
- >I< Reverse Idler Gear Shaft Installation
- >J< Outer Race Installation
- >K< Transaxle Case Installation
- >L< Sealing Cap Installation
- >M< Reverse Idler Gear Shaft Bolt Installation
- >N< Under Cover Installation
- >O< Control Housing Installation
- >P< Speedometer Gear Installation
- >Q< Select Lever Installation
- Inspection
- Input Shaft
- Disassembly And Reassembly
- Disassembly Service Points
- Reassembly Service Points
- >A< Oil Seal Installation
- >B< Ball Bearing Installation
- >C< Snap Ring Installation
- >D< Synchronizer Spring Installation
- >E< 3RD-4TH Speed Synchronizer Hub Installation
- >F< Synchronizer Sleeve Installation
- >G< 4TH Speed Gear Sleeve Installation
- >H< 5TH Speed Gear Sleeve Installation
- >I< 5TH Speed Gear Installation
- >J< 5TH Speed-Reverse Synchronizer Hub Installation
- >K< Synchronizer Sleeve Installation
- >L< Thrust Plate Installation
- >M< Reverse Brake Sleeve Installation
- >N< Thrust Plate Stopper Installation
- >O< Ball Bearing Installation
- >P< Snap Ring Installation
- Inspection
- Output Shaft
- Disassembly And Reassembly
- Disassembly Service Points
- Reassembly Service Points
- >A< Roller Bearing Inner Race Installation
- >B< Snap Ring Installation
- >C< 1ST Speed Gear Sleeve Installation
- >D< Synchronizer Spring Installation
- >E< 1ST-2ND Speed Synchronizer Hub Installation
- >F< Synchronizer Sleeve Installation
- >G< Synchronizer Spring Installation
- >H< 2ND Speed Gear Sleeve Installation
- >I< 3RD Speed Gear Installation
- >J< Snap Ring Installation
- >K< 4TH Speed Gear Installation
- >L< 5TH Speed Gear Sleeve Installation
- >M< 5TH Speed-Reverse Synchronizer Hub Installation
- >N< Reverse Gear/Needle Roller Bearing/Reverse Gear Bearing Sleeve Installation
- >0< Ball Bearing Installation
- >P< Snap Ring Installation
- Inspection
- Reverse Idler Gear < F5M42 >
- Speedometer Gear
- Select Lever
- Control Housing
- Clutch Housing
- Transaxle Case
- Differential
- Removal & Installation - M/T
- Servicing - M/T
- Overhaul
- External Pages