Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Antenna
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Anti-Theft System
- Description & Operation
- Arming & Disarming
- Component Locations
- Programming
- Programming New Module
- Replacing Ignition Key
- Customizing UTD System
- Exiting Programming Mode
- Exit Lighting And Delayed Illumination
- Last Door Closed Locking & Lockout Prevention
- Remote Lock Control Verification
- Theft-Deterrent Arming Method
- Theft-Deterrent Arming Verification
- Driver's Door Alarm Delay & Shock Sensor Enable
- Adjustments
- Trouble Shooting
- System Testing
- Notes
- Universal Theft Deterrent (UTD) Tests
- Parking Lights Do Not Flash With UTD System Armed, Disarmed Or In Alarm Cycle
- Shock Sensor Does Not Respond to Physical Shocks Or Blows To Vehicle With UTD System Armed
- UTD System Red LED Does Not Illuminate
- Horns Do Not Operate With UTD System Functions, But Operate Normally With Steering Wheel Horn Switch
- Pass-Key II(R) Tests
- Notes
- Engine Does Not Crank, SECURITY Indicator Illuminates For About 5 Seconds, Then Goes Out
- Engine Cranks But Will Not Start, SECURITY Indicator Illuminates For About 5 Seconds, Then Goes Out
- SECURITY Indicator On Steady, Engine Starts
- SECURITY Indicator Never Illuminates, Engine Starts
- Lock Cylinder & Harness Test
- Removal & Installation
- Wiring Diagrams
- Hatch Release - Power
- Description
- Operation
- Trouble Shooting
- System Tests
- Notes
- Rear Compartment Lid Release Inoperative
- Rear Compartment Lid Release Does Not Operate From Rear Compartment Lid Release Switch
- Rear Compartment Lid Release Operates From Rear Compartment Lid Release Switch, But Does Not Operate From Remote Keyless Entry
- Rear Compartment Lid Release Operates From Remote KeylessEntry, But Does Not Operate From Rear Compartment Lid Release Switch
- Removal & Installation
- Wiring Diagrams
- Power Door Lock System
- Remote Keyless Entry Systems
- Description & Operation
- Component Locations
- Programming Procedures
- Trouble Shooting
- System Check
- System Testing
- Notes
- Remote Transmitter Inoperative (Functions Normally From Switches)
- Left Door Lock Actuator Inoperative From Remote Control Door Lock Transmitter & Door Lock Switches/Right Actuator Okay
- Right Door Lock Actuator Inoperative From Transmitter & Door Lock Switches
- Body Control Module (BCM)/Remote Transmitter Will Not Program
- All Functions Of Remote Transmitter & Power Door Locks Totally Inoperative/Fuses No. 7 & 8 Are Not Blown
- Power Door Locks Totally Inoperative From Both Power Door Lock Switches & From Remote Transmitter/Transmitter Operates Dome Light & Hatch Release Normally
- Power Door Locks Totally Inoperative From Both Power Door Lock Switches/Locks Operate Normally From Remote Transmitter
- Power Door Locks Operate From One Power Door Lock Switch Only/Locks Operate Normally From Transmitter
- Lock Function Inoperative From Both Power Door Lock Switches & From Transmitter/Unlock Function Operates Normally
- Unlock Function Inoperative From Both Power Door Lock Switches & From Transmitter/Lock Function Operates Normally
- Left Door Lock Actuator Inoperative From Transmitter Only/Operates Normally From Lock Switches
- Right Door Lock Actuator Inoperative From Transmitter Only/Operates Normally From Lock Switches
- Dome Light (Coupe) Or Rear Courtesy Lights (Convertible) Will Not Turn On When Door Locks Are Locked Or Unlocked Using Transmitter/Light(S) Operate Normally From Switches
- Dome Light Will Not Turn On Using Switches Or Transmitter
- Rear Courtesy Lights Will Not Turn On Using Switches Or Transmitter
- Rear Compartment Lid Release Actuator Inoperative From Transmitter/Operates Normally From Rear Compartment Lid Release Switch (All Other RKE Transmitter Functions Normal)
- Removal & Installation
- Wiring Diagrams
- Anti-Theft System
- Body Interior
- Body Control Module
- Description & Operation
- Component Locations
- Programming BCM
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC 12: Diagnostic System Check
- DTC 21/31: Courtesy Lights Feed (Circuit Shorted To Ground)
- DTC 22/32: Courtesy Lights Return (Circuit Shorted To Battery)
- DTC 23/33: Retained Accessory Power (Circuit Shorted To Ground Or Battery)
- DTC 24/34: Fasten Seat Belt Indicator (Circuit Shorted To Ground Or Battery)
- DTC 25/35: Security Led Present (With Theft Deterrent Only)
- DTC 41: Last Transmitter Message Received Valid
- DTC 42: Last Transmitter Message Received Had Invalid Id
- DTC 43: Last Transmitter Message Received Had SUMCHECK Error
- DTC 44: Last Transmitter Message Received Had Encryption Error
- DTC 45: Receiver Processing Currently In 20-Second Lock-Out
- DTC 55: Begin Configuration Display
- Removal & Installation
- Wiring Diagrams
- Body Control Module
- Communication Devices
- Body Control Module
- Description & Operation
- Component Locations
- Programming BCM
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC 12: Diagnostic System Check
- DTC 21/31: Courtesy Lights Feed (Circuit Shorted To Ground)
- DTC 22/32: Courtesy Lights Return (Circuit Shorted To Battery)
- DTC 23/33: Retained Accessory Power (Circuit Shorted To Ground Or Battery)
- DTC 24/34: Fasten Seat Belt Indicator (Circuit Shorted To Ground Or Battery)
- DTC 25/35: Security Led Present (With Theft Deterrent Only)
- DTC 41: Last Transmitter Message Received Valid
- DTC 42: Last Transmitter Message Received Had Invalid Id
- DTC 43: Last Transmitter Message Received Had SUMCHECK Error
- DTC 44: Last Transmitter Message Received Had Encryption Error
- DTC 45: Receiver Processing Currently In 20-Second Lock-Out
- DTC 55: Begin Configuration Display
- Removal & Installation
- Wiring Diagrams
- Body Control Module
- Cruise Control Systems
- Description & Operation
- Component Locations
- Adjustments
- Trouble Shooting
- Diagnosis & Testing
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Description & Operation
- Component Locations
- Trouble Shooting
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Headlights
- Heated Glass/Defoggers
- Mirrors
- Seats
- Power Seat System
- Description
- Operation
- Adjustments
- Symptom Testing
- All Power Seat Functions Inoperative
- Entire Seat Will Not Go Forward Or Back; Up Or Down Functions Operate Normally
- Front Height Will Not Go Up Or Down; Forward Or Back Functions Operate Normally
- Rear Height Will Not Go Up Or Down; Forward Or Back Functions Operate Normally
- Entire Seat Will Not Go Up Or Down; Forward Or Back Functions Operate Normally
- Power Lumbar Seats (Firebird)
- Power Lumbar Seats System Check
- Test No. 1: Both Seats Inoperative & Pump Does Not Run
- Test No. 2: Lumbar Bladder Inoperative; Lateral Bladders Operate Normally
- Test No. 3: Lateral Bladders Inoperative; Lumber Bladder Operates Normally
- Test No. 4: Bladder(S) Inflate, But Do Not Deflate
- Test No. 5: Seat Air Pump Operates, But Bladder(S) Do Not Inflate
- Test No. 6: Driver's Seat Inoperative; Passenger's Seat Operates Normally
- Test No. 7: Passenger's Seat Inoperative; Driver's Seat Operates Normally
- Trouble Shooting
- Removal & Installation
- Wiring Diagrams
- Power Seat System
- Steering Column Switches
- Steering Column Switches
- Steering Wheel And Steering Column - Standard
- Model Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Removal & Installation
- Overhaul
- Torque Specifications
- Window Motors & Regulators
- Power Window System
- Description
- Operation
- Component Locations
- Adjustments
- Trouble Shooting
- System Tests
- Notes
- All Windows Inoperative
- Left Front Window Does Not Operate
- Right Front Window Does Not Operate From Both Switches, Left Window Operates Normally
- Both Windows Inoperative From Master Switch, Right Window Operates From Right Switch
- Both Windows And Radio Inoperative
- Right Front Window Is Inoperative At Individual Switch, Operates At Master Switch
- Right Front Window Is Inoperative At Master Switch, Operates At Individual Switch
- Express Down Does Not Operate
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Power Window System
- Wiper/Washer Systems
- Wiper System And Washer System - Front
- Description & Operation
- Adjustments
- Trouble Shooting
- Testing
- Notes
- Wipers Do Not Operate In Any Mode
- Wipers Run When Switch Is Off
- Wipers Do Not Run At High Speed (All Other Modes Okay)
- Wipers Operate Only In Hi Speed Setting, But Operate At Low Speed
- Wipers Do Not Run In Low Speed, Pulse Or Mist Modes (High Speed Is Okay)
- Pulse Delay Operates Incorrectly Or Not At All
- Wipers Do Not Park Properly
- Wipers Do Not Operate When Washer Switch Is Activated
- Washer Motor Does Not Operate
- Removal & Installation
- Wiring Diagrams
- Wiper System And Washer System - Front
- Anti-Theft Systems
- Body & Frame
- Body, Cab Control Systems
- Body Control Module
- Description & Operation
- Component Locations
- Programming BCM
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- DTC 12: Diagnostic System Check
- DTC 21/31: Courtesy Lights Feed (Circuit Shorted To Ground)
- DTC 22/32: Courtesy Lights Return (Circuit Shorted To Battery)
- DTC 23/33: Retained Accessory Power (Circuit Shorted To Ground Or Battery)
- DTC 24/34: Fasten Seat Belt Indicator (Circuit Shorted To Ground Or Battery)
- DTC 25/35: Security Led Present (With Theft Deterrent Only)
- DTC 41: Last Transmitter Message Received Valid
- DTC 42: Last Transmitter Message Received Had Invalid Id
- DTC 43: Last Transmitter Message Received Had SUMCHECK Error
- DTC 44: Last Transmitter Message Received Had Encryption Error
- DTC 45: Receiver Processing Currently In 20-Second Lock-Out
- DTC 55: Begin Configuration Display
- Removal & Installation
- Wiring Diagrams
- Body Control Module
- Door Locks
- Anti-Theft System
- Description & Operation
- Arming & Disarming
- Component Locations
- Programming
- Programming New Module
- Replacing Ignition Key
- Customizing UTD System
- Exiting Programming Mode
- Exit Lighting And Delayed Illumination
- Last Door Closed Locking & Lockout Prevention
- Remote Lock Control Verification
- Theft-Deterrent Arming Method
- Theft-Deterrent Arming Verification
- Driver's Door Alarm Delay & Shock Sensor Enable
- Adjustments
- Trouble Shooting
- System Testing
- Notes
- Universal Theft Deterrent (UTD) Tests
- Parking Lights Do Not Flash With UTD System Armed, Disarmed Or In Alarm Cycle
- Shock Sensor Does Not Respond to Physical Shocks Or Blows To Vehicle With UTD System Armed
- UTD System Red LED Does Not Illuminate
- Horns Do Not Operate With UTD System Functions, But Operate Normally With Steering Wheel Horn Switch
- Pass-Key II(R) Tests
- Notes
- Engine Does Not Crank, SECURITY Indicator Illuminates For About 5 Seconds, Then Goes Out
- Engine Cranks But Will Not Start, SECURITY Indicator Illuminates For About 5 Seconds, Then Goes Out
- SECURITY Indicator On Steady, Engine Starts
- SECURITY Indicator Never Illuminates, Engine Starts
- Lock Cylinder & Harness Test
- Removal & Installation
- Wiring Diagrams
- Hatch Release - Power
- Description
- Operation
- Trouble Shooting
- System Tests
- Notes
- Rear Compartment Lid Release Inoperative
- Rear Compartment Lid Release Does Not Operate From Rear Compartment Lid Release Switch
- Rear Compartment Lid Release Operates From Rear Compartment Lid Release Switch, But Does Not Operate From Remote Keyless Entry
- Rear Compartment Lid Release Operates From Remote KeylessEntry, But Does Not Operate From Rear Compartment Lid Release Switch
- Removal & Installation
- Wiring Diagrams
- Power Door Lock System
- Remote Keyless Entry Systems
- Description & Operation
- Component Locations
- Programming Procedures
- Trouble Shooting
- System Check
- System Testing
- Notes
- Remote Transmitter Inoperative (Functions Normally From Switches)
- Left Door Lock Actuator Inoperative From Remote Control Door Lock Transmitter & Door Lock Switches/Right Actuator Okay
- Right Door Lock Actuator Inoperative From Transmitter & Door Lock Switches
- Body Control Module (BCM)/Remote Transmitter Will Not Program
- All Functions Of Remote Transmitter & Power Door Locks Totally Inoperative/Fuses No. 7 & 8 Are Not Blown
- Power Door Locks Totally Inoperative From Both Power Door Lock Switches & From Remote Transmitter/Transmitter Operates Dome Light & Hatch Release Normally
- Power Door Locks Totally Inoperative From Both Power Door Lock Switches/Locks Operate Normally From Remote Transmitter
- Power Door Locks Operate From One Power Door Lock Switch Only/Locks Operate Normally From Transmitter
- Lock Function Inoperative From Both Power Door Lock Switches & From Transmitter/Unlock Function Operates Normally
- Unlock Function Inoperative From Both Power Door Lock Switches & From Transmitter/Lock Function Operates Normally
- Left Door Lock Actuator Inoperative From Transmitter Only/Operates Normally From Lock Switches
- Right Door Lock Actuator Inoperative From Transmitter Only/Operates Normally From Lock Switches
- Dome Light (Coupe) Or Rear Courtesy Lights (Convertible) Will Not Turn On When Door Locks Are Locked Or Unlocked Using Transmitter/Light(S) Operate Normally From Switches
- Dome Light Will Not Turn On Using Switches Or Transmitter
- Rear Courtesy Lights Will Not Turn On Using Switches Or Transmitter
- Rear Compartment Lid Release Actuator Inoperative From Transmitter/Operates Normally From Rear Compartment Lid Release Switch (All Other RKE Transmitter Functions Normal)
- Removal & Installation
- Wiring Diagrams
- Anti-Theft System
- Headlight Doors
- Mirrors
- Seats
- Power Seat System
- Description
- Operation
- Adjustments
- Symptom Testing
- All Power Seat Functions Inoperative
- Entire Seat Will Not Go Forward Or Back; Up Or Down Functions Operate Normally
- Front Height Will Not Go Up Or Down; Forward Or Back Functions Operate Normally
- Rear Height Will Not Go Up Or Down; Forward Or Back Functions Operate Normally
- Entire Seat Will Not Go Up Or Down; Forward Or Back Functions Operate Normally
- Power Lumbar Seats (Firebird)
- Power Lumbar Seats System Check
- Test No. 1: Both Seats Inoperative & Pump Does Not Run
- Test No. 2: Lumbar Bladder Inoperative; Lateral Bladders Operate Normally
- Test No. 3: Lateral Bladders Inoperative; Lumber Bladder Operates Normally
- Test No. 4: Bladder(S) Inflate, But Do Not Deflate
- Test No. 5: Seat Air Pump Operates, But Bladder(S) Do Not Inflate
- Test No. 6: Driver's Seat Inoperative; Passenger's Seat Operates Normally
- Test No. 7: Passenger's Seat Inoperative; Driver's Seat Operates Normally
- Trouble Shooting
- Removal & Installation
- Wiring Diagrams
- Power Seat System
- Sun Roof/T-Top/Convertible Top
- Windows
- Power Window System
- Description
- Operation
- Component Locations
- Adjustments
- Trouble Shooting
- System Tests
- Notes
- All Windows Inoperative
- Left Front Window Does Not Operate
- Right Front Window Does Not Operate From Both Switches, Left Window Operates Normally
- Both Windows Inoperative From Master Switch, Right Window Operates From Right Switch
- Both Windows And Radio Inoperative
- Right Front Window Is Inoperative At Individual Switch, Operates At Master Switch
- Right Front Window Is Inoperative At Master Switch, Operates At Individual Switch
- Express Down Does Not Operate
- Removal & Installation
- Torque Specifications
- Wiring Diagrams
- Power Window System
- Body, Cab Control Systems
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System With Traction Control System - BOSCH 5.3
- Model Identification
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic System Check
- Symptom Tests
- Notes
- Test A: Abs Indicator On With No DTCS Set (Grand PRIX & 1998 "F" Body)
- Test A: Abs Indicator On With No DTCS Set (1999 "F" Body, & Intrigue)
- Test B: Abs Indicator Inoperative With No DTCS Set (1998 "F" Body)
- Test B: Abs Indicator Inoperative With No DTCS Set (1999 "F" Body)
- Test C: Traction Off Indicator On With No DTCS Set (1999 "F" Body, & Intrigue)
- Test C: Traction Off Indicator On With No DTCS Set (Grand PRIX)
- Test D: Traction Off Indicator Inoperative With No DTCS Set (Grand PRIX)
- Test D: Traction Off Indicator Inoperative With No DTCS Set (1999 "F" Body, & Intrigue)
- Test E: No Communication With EBTCM
- Test F: Abs Indicator Off With No DTCS Set (Grand PRIX)
- Test F: Abs Indicator Off With No DTCS Set (Intrigue)
- Test G: Low Traction Indicator On All Of The Time (Grand PRIX & 1998 "F" Body)
- Test G: Low Traction Indicator On All Of The Time (1999 "F" Body, & Intrigue)
- Test H: Low Traction Indicator Inoperative (Grand PRIX & 1998 "F" Body)
- Test H: Low Traction Indicator Inoperative (1999 "F" Body, & Intrigue)
- Test I: ASR Indicator On With No DTCS Set (1999 "F" Body)
- Test J: ASR Indicator Inoperative With No DTCS Set (1999 "F" Body)
- Diagnostic Tests
- Notes
- DTC C0035: Left Front Wheel Speed Circuit Malfunction
- DTC C0036: Left Front Wheel Speed Circuit Range/Performance
- DTC C0040: Right Front Wheel Speed Circuit Malfunction
- DTC C0041: Right Front Wheel Speed Circuit Range/Performance
- DTC C0045: Left Rear Wheel Speed Circuit Malfunction
- DTC C0046: Left Rear Wheel Speed Circuit Range/Performance
- DTC C0050: Right Rear Wheel Speed Circuit Malfunction
- DTC C0051: Right Rear Wheel Speed Circuit Range/Performance
- DTC C0055: Rear Wheel Speed Circuit Malfunction ("F" Body W/O Traction Control)
- DTC C0056: Rear Wheel Speed Circuit Range/Performance ("F" Body W/O Traction Control)
- DTC C0060: Left Front Abs Solenoid No. 1 Circuit Malfunction
- DTC C0065: Left Front Abs Solenoid No. 2 Circuit Malfunction
- DTC C0070: Right Front Abs Solenoid No. 1 Circuit Malfunction
- DTC C0075: Right Front Abs Solenoid No. 2 Circuit Malfunction
- DTC C0080: Left Rear Abs Solenoid No. 1 Circuit Malfunction
- DTC C0085: Left Rear Abs Solenoid No. 2 Circuit Malfunction
- DTC C0090: Right Rear Abs Solenoid No. 1 Circuit Malfunction
- DTC C0095: Right Rear Abs Solenoid No. 2 Circuit Malfunction
- DTC C0100: Rear Abs Solenoid No. 1 Circuit Malfunction ("F" Body)
- DTC C0105: Rear Abs Solenoid No. 2 Circuit Malfunction ("F" Body)
- DTC C0110: Pump Motor Circuit Malfunction (Grand PRIX)
- DTC C0110: Pump Motor Circuit Malfunction (Intrigue)
- DTC C0110: Pump Motor Circuit Malfunction ("F" Body)
- DTC C0121: Valve Relay Circuit Malfunction (Grand PRIX)
- DTC C0121: Valve Relay Circuit Malfunction (Intrigue)
- DTC C0121: Valve Relay Circuit Malfunction ("F" Body)
- DTC C0141: Left TCS Solenoid No. 1 Circuit Malfunction ("W" Body)
- DTC C0146: Left TCS Solenoid No. 2 Circuit Malfunction ("W" Body)
- DTC C0151: Right TCS Solenoid No. 1 Circuit Malfunction ("W" Body)
- DTC C0156: Right TCS Solenoid No. 2 Circuit Malfunction ("W" Body)
- DTC C0161: Abs/TCS Brake Switch Circuit Malfunction
- DTC C0166: TCS Priming Line Valve Circuit Malfunction ("F" Body)
- DTC C0171: TCS Pilot Valve Circuit Malfunction ("F" Body)
- DTC C0181: Throttle Reduction Motor Circuit Malfunction ("F" Body)
- DTC C0182: Throttle Reduction Motor Circuit Range/Performance ("F" Body)
- DTC C0236: TCS Rpm Signal Circuit Malfunction ("F" Body & Grand PRIX)
- DTC C0236: TCS Rpm Signal Circuit Malfunction (Intrigue)
- DTC C0237: TCS Throttle Position Signal Malfunction ("F" Body)
- DTC C0238: TCS Throttle Position Sensor Comparison Malfunction ("F" Body)
- DTC C0239: TCS Spark Retard Monitoring Malfunction ("F" Body)
- DTC C0240: Pcm Traction Control Not Allowed ("W" Body & 1999 "F" Body)
- DTC C0241: Pcm Indicated Requested Torque Malfunction (1999 "F" Body & Intrigue)
- DTC C0244: PWM Delivered Torque Malfunction ("W" Body & 1999 "F" Body)
- DTC C0245: Wheel Speed Sensor Frequency Error
- DTC C0266: Ads Controller Malfunction (1998 "F" Body)
- DTC C0450: Steer Assist Control Actuator Circuit Malfunction (1998 Grand PRIX)
- DTC C0550: Ecu Malfunction
- DTC C0896: Device Voltage Range/Performance
- DTC C0901: Device #2 Voltage Low
- DTC U1304: Lost Communication With UART System
- Removal & Installation
- Electronic Brake Control Module (EBCM) Or Electronic Brake Traction Control Module (EBTCM)
- Brake Pressure Modulator Valve (BPMV)
- Adjuster Assembly ("F" Body)
- Accelerator & Servo Control Module ("F" Body)
- Traction Control Switch (CAMARO)
- Traction Control Switch (Firebird)
- Wheel Speed Sensor
- Toothed Sensor Ring
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brake System With Traction Control System - BOSCH 5.3
- Mechanical - Hydraulic
- Disc Brakes
- Description & Operation
- Bleeding Brake System
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Disc Brake Specifications
- Hydraulic Component Specifications
- Torque Specifications
- Disc Brakes
- Anti-Lock Brake System With Traction Control System - BOSCH 5.3
- Model Identification
- Description
- Operation
- Bleeding Brake System
- Diagnosis & Testing
- Diagnostic System Check
- Symptom Tests
- Notes
- Test A: Abs Indicator On With No DTCS Set (Grand PRIX & 1998 "F" Body)
- Test A: Abs Indicator On With No DTCS Set (1999 "F" Body, & Intrigue)
- Test B: Abs Indicator Inoperative With No DTCS Set (1998 "F" Body)
- Test B: Abs Indicator Inoperative With No DTCS Set (1999 "F" Body)
- Test C: Traction Off Indicator On With No DTCS Set (1999 "F" Body, & Intrigue)
- Test C: Traction Off Indicator On With No DTCS Set (Grand PRIX)
- Test D: Traction Off Indicator Inoperative With No DTCS Set (Grand PRIX)
- Test D: Traction Off Indicator Inoperative With No DTCS Set (1999 "F" Body, & Intrigue)
- Test E: No Communication With EBTCM
- Test F: Abs Indicator Off With No DTCS Set (Grand PRIX)
- Test F: Abs Indicator Off With No DTCS Set (Intrigue)
- Test G: Low Traction Indicator On All Of The Time (Grand PRIX & 1998 "F" Body)
- Test G: Low Traction Indicator On All Of The Time (1999 "F" Body, & Intrigue)
- Test H: Low Traction Indicator Inoperative (Grand PRIX & 1998 "F" Body)
- Test H: Low Traction Indicator Inoperative (1999 "F" Body, & Intrigue)
- Test I: ASR Indicator On With No DTCS Set (1999 "F" Body)
- Test J: ASR Indicator Inoperative With No DTCS Set (1999 "F" Body)
- Diagnostic Tests
- Notes
- DTC C0035: Left Front Wheel Speed Circuit Malfunction
- DTC C0036: Left Front Wheel Speed Circuit Range/Performance
- DTC C0040: Right Front Wheel Speed Circuit Malfunction
- DTC C0041: Right Front Wheel Speed Circuit Range/Performance
- DTC C0045: Left Rear Wheel Speed Circuit Malfunction
- DTC C0046: Left Rear Wheel Speed Circuit Range/Performance
- DTC C0050: Right Rear Wheel Speed Circuit Malfunction
- DTC C0051: Right Rear Wheel Speed Circuit Range/Performance
- DTC C0055: Rear Wheel Speed Circuit Malfunction ("F" Body W/O Traction Control)
- DTC C0056: Rear Wheel Speed Circuit Range/Performance ("F" Body W/O Traction Control)
- DTC C0060: Left Front Abs Solenoid No. 1 Circuit Malfunction
- DTC C0065: Left Front Abs Solenoid No. 2 Circuit Malfunction
- DTC C0070: Right Front Abs Solenoid No. 1 Circuit Malfunction
- DTC C0075: Right Front Abs Solenoid No. 2 Circuit Malfunction
- DTC C0080: Left Rear Abs Solenoid No. 1 Circuit Malfunction
- DTC C0085: Left Rear Abs Solenoid No. 2 Circuit Malfunction
- DTC C0090: Right Rear Abs Solenoid No. 1 Circuit Malfunction
- DTC C0095: Right Rear Abs Solenoid No. 2 Circuit Malfunction
- DTC C0100: Rear Abs Solenoid No. 1 Circuit Malfunction ("F" Body)
- DTC C0105: Rear Abs Solenoid No. 2 Circuit Malfunction ("F" Body)
- DTC C0110: Pump Motor Circuit Malfunction (Grand PRIX)
- DTC C0110: Pump Motor Circuit Malfunction (Intrigue)
- DTC C0110: Pump Motor Circuit Malfunction ("F" Body)
- DTC C0121: Valve Relay Circuit Malfunction (Grand PRIX)
- DTC C0121: Valve Relay Circuit Malfunction (Intrigue)
- DTC C0121: Valve Relay Circuit Malfunction ("F" Body)
- DTC C0141: Left TCS Solenoid No. 1 Circuit Malfunction ("W" Body)
- DTC C0146: Left TCS Solenoid No. 2 Circuit Malfunction ("W" Body)
- DTC C0151: Right TCS Solenoid No. 1 Circuit Malfunction ("W" Body)
- DTC C0156: Right TCS Solenoid No. 2 Circuit Malfunction ("W" Body)
- DTC C0161: Abs/TCS Brake Switch Circuit Malfunction
- DTC C0166: TCS Priming Line Valve Circuit Malfunction ("F" Body)
- DTC C0171: TCS Pilot Valve Circuit Malfunction ("F" Body)
- DTC C0181: Throttle Reduction Motor Circuit Malfunction ("F" Body)
- DTC C0182: Throttle Reduction Motor Circuit Range/Performance ("F" Body)
- DTC C0236: TCS Rpm Signal Circuit Malfunction ("F" Body & Grand PRIX)
- DTC C0236: TCS Rpm Signal Circuit Malfunction (Intrigue)
- DTC C0237: TCS Throttle Position Signal Malfunction ("F" Body)
- DTC C0238: TCS Throttle Position Sensor Comparison Malfunction ("F" Body)
- DTC C0239: TCS Spark Retard Monitoring Malfunction ("F" Body)
- DTC C0240: Pcm Traction Control Not Allowed ("W" Body & 1999 "F" Body)
- DTC C0241: Pcm Indicated Requested Torque Malfunction (1999 "F" Body & Intrigue)
- DTC C0244: PWM Delivered Torque Malfunction ("W" Body & 1999 "F" Body)
- DTC C0245: Wheel Speed Sensor Frequency Error
- DTC C0266: Ads Controller Malfunction (1998 "F" Body)
- DTC C0450: Steer Assist Control Actuator Circuit Malfunction (1998 Grand PRIX)
- DTC C0550: Ecu Malfunction
- DTC C0896: Device Voltage Range/Performance
- DTC C0901: Device #2 Voltage Low
- DTC U1304: Lost Communication With UART System
- Removal & Installation
- Electronic Brake Control Module (EBCM) Or Electronic Brake Traction Control Module (EBTCM)
- Brake Pressure Modulator Valve (BPMV)
- Adjuster Assembly ("F" Body)
- Accelerator & Servo Control Module ("F" Body)
- Traction Control Switch (CAMARO)
- Traction Control Switch (Firebird)
- Wheel Speed Sensor
- Toothed Sensor Ring
- Adjustments
- Torque Specifications
- Wiring Diagrams
- Anti-Lock Brakes
- Drivelines & Axles
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electrical
- Body Electrical
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Testing Wiring Systems For Intermittent & Poor Connections
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrument Panel
- Description & Operation
- Component Locations
- Trouble Shooting
- Component Tests
- Removal & Installation
- Wiring Diagrams
- Instrument Panel
- Motors, Switches, Relays
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Testing Wiring Systems For Intermittent & Poor Connections
- Starter
- Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Antenna
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Body Electrical
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Engine Cooling Fan System - Cars
- Model Identification
- Description & Operation
- Trouble Shooting
- Electric Cooling Fan Circuit Diagnosis
- Notes
- 1.0L & 1.3L Metro & Firefly (CANADIAN)
- 1999 1.8L Prizm
- 2.2L & 2.4L "J" Bodies (Cavalier & SUNFIRE) 2.4L "N" Bodies (ACHIEVA, Grand Am & Skylark)
- 1998 2.4L "N" Body (Cutlass & MALIBU)
- 1999 2.4L: ALERO, Grand Am & MALIBU
- 3.0L: CATERA
- Notes
- Cooling Fan System Check
- Engine Cooling Fan Inoperative
- Engine Cooling Fan Low Speed Inoperative
- Auxiliary Engine Cooling Fan No. 1 Inoperative
- Auxiliary Engine Cooling Fan No. 2 Inoperative
- Auxiliary Cooling Fans No. 1 & 2 Inoperative
- Auxiliary Cooling Fans Inoperative At Low Speed
- Auxiliary Cooling Fans Inoperative At High Speed
- Auxiliary Cooling Fan Runs Continuously
- 1998 3.1L "N" Body (ACHIEVA, Grand Am & Skylark)
- 3.1L "N" Body (Cutlass & MALIBU); 3.4L (ALERO & Grand Am)
- 3.1L & 3.8L "W" Body (Century, 1998 Intrigue & Regal)
- 1998 3.1L & 3.8L "W" Body (Lumina & Monte CARLO)
- 3.1L & 3.8L "W" Body (Grand PRIX)
- 1999 3.5L & 3.8L: Intrigue
- 3.8L: BONNEVILLE, Eighty Eight, LESABRE, LSS & Regency
- 3.8L "C" Body (Park Avenue)
- 1998 3.8L: CAMARO & Firebird
- 1999 3.8L: CAMARO & Firebird
- 5.7L: CAMARO & Firebird
- 1998 3.8L "G" Body (Riviera)
- 3.8L: Riviera
- 1998 4.0L: "G" Body (Aurora)
- 1999 4.0L: Aurora, & 1998-99 4.6L: DEVILLE, ELDORADO & SEVILLE
- 5.7L: Corvette
- Removal & Installation
- Wiring Diagrams
- Cooling System (Mechanical)
- Engine Mechanical - 5.7L V8 - VIN [G]
- Engine Identification
- Adjustments
- Trouble Shooting
- Removal & Installation
- Overhaul
- Engine Oiling
- Torque Specifications
- Engine Specifications
- Starter
- Engine Performance
- Engine Adjustments - 5.7L
- Application
- Emissions
- EGR Function Testing - General Motors Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - PONTIAC
- Remove, Overhaul & Install
- Engine Control System - Removal & Installation & Overhaul - 5.7L
- Engine Control System - Sensor Range Charts - 5.7L
- Specifications
- System
- Engine Control System - Basic Diagnostic Procedures - 5.7L
- Engine Control System - System & Component Tests - 5.7L
- Engine Control System - Tests W/Codes - 5.7L
- Introduction
- Self-Diagnostic System
- Diagnostic System
- Diagnostic Procedure
- Powertrain On-Board Diagnostic (OBD) System Check
- DLC Diagnosis Or No Scan Tool Data
- Reading Trouble Codes
- Trouble Code Definitions
- Hard Or Intermittent Trouble Code Determination
- Clearing Diagnostic Trouble Codes (DTC)
- ECM/Pcm/VCM Location
- Diagnostic Materials
- Special Tools (Diagnostic)
- Scan Tool Usage
- Summary
- Diagnostic Trouble Codes
- Notes
- DTC P0101 - MAF Sensor System Performance
- DTC P0102 - MAF Sensor Circuit Low Frequency
- DTC P0103 - MAF Sensor Circuit High Frequency
- DTC P0107 - Map Sensor Circuit Low Voltage
- DTC P0108 - Map Sensor Circuit High Voltage
- IAT Temperature-To-Resistance Values
- DTC P0112 - IAT Sensor Circuit Low Voltage
- DTC P0113 - IAT Sensor Circuit High Voltage
- ECT Temperature-To-Resistance Values
- DTC P0117 - ECT Sensor Circuit Low Voltage
- DTC P0118 - ECT Sensor Circuit Voltage High
- DTC P0121 - TP Sensor Circuit Insufficient Activity
- DTC P0122 - TP Sensor Circuit Low Voltage
- DTC P0123 - TP Sensor Circuit High Voltage
- DTC P0125 - ECT Excessive Time To Reach Closed Loop
- DTC P0131 - Ho2S Circuit Voltage Low Bank 1, Sensor No. 1
- DTC P0132 - Ho2S Circuit Voltage High Bank 1, Sensor No. 1
- DTC P0133 - Ho2S Slow Response Bank 1, Sensor No. 1
- DTC P0134 - Ho2S Insufficient Activity Bank 1, Sensor No. 1
- DTC P0135 - Ho2S Heater Circuit Bank 1, Sensor No. 1
- DTC P0137 - Ho2S Circuit Voltage Low Bank 1, Sensor No. 2
- DTC P0138 - Ho2S Circuit Voltage High Bank 1, Sensor No. 2
- DTC P0140 - Ho2S Insufficient Activity Bank 1, Sensor No. 2
- DTC P0141 - HO2S HEATER CIRCUIT BANK 1, SENSOR No. 2
- DTC P0151 - Ho2S Circuit Voltage Low Bank 2, Sensor No. 1
- DTC P0152 - Ho2S Circuit Voltage High Bank 2, Sensor No. 1
- DTC P0153 - Ho2S Slow Response Bank 2 Sensor No. 1
- DTC P0154 - Ho2S Insufficient Activity Bank 2, Sensor No. 1
- DTC P0155 - Ho2S Heater Circuit Bank 2, Sensor No. 1
- DTC P0157 - Ho2S Circuit Voltage Low Bank 2, Sensor No. 2
- DTC P0158 - Ho2S Circuit Voltage High Bank 2 Sensor 2
- DTC P0160 - Ho2S Insufficient Activity Bank 2, Sensor No. 2
- DTC P0161 - Ho2S Heater Circuit Bank 2, Sensor 2
- DTC P0171 - Fuel Trim System Lean Bank 1
- DTC P0172 - Fuel Trim System Rich Bank 1
- DTC P0174 - Fuel Trim System Lean Bank 2
- DTC P0175 - Fuel Trim System Rich Bank 2
- DTC P0230 - Fuel Pump Control Circuit
- DTC P0300-P0308 - Engine Misfire Detected
- DTC P0325 - Knock Sensor Module Circuit
- DTC P0327 - Knock Sensor Circuit Front
- DTC P0332 - Knock Sensor Circuit
- DTC P0335 - Crankshaft Position (CKP) Sensor Circuit
- DTC P0341 - Camshaft Position Sensor Circuit Performance
- DTC P0342 - Camshaft Position Sensor Circuit Low Voltage
- DTC P0343 - Camshaft Position Sensor Circuit High Voltage
- DTC P0351 - Ignition Control No. 1 Circuit
- DTC P0352 - Ignition Control No. 2 Circuit
- DTC P0353 - Ignition Control No. 3 Circuit
- DTC P0354 - Ignition Control No. 4 Circuit
- DTC P0355 - Ignition Control No. 5 Circuit
- DTC P0356 - Ignition Control No. 6 Circuit
- DTC P0357 - Ignition Control No. 7 Circuit
- DTC P0358 - Ignition Control No. 8 Circuit
- DTC P0401 - EGR System Flow Insufficient
- DTC P0404 - EGR System Performance
- DTC P0405 - EGR Pintle Position Circuit Low Voltage
- DTC P0410 - Air System
- DTC P0412 - Air Solenoid Relay Control Circuit
- DTC P0418 - Air Pump Relay Control Circuit
- DTC P0420 - TWC System Low Efficiency Bank 1
- DTC P0430 - TWC System Low Efficiency Bank 2
- DTC P0440 - EVAP System
- DTC P0442 - EVAP System (Small Leak Detected)
- DTC P0443 - EVAP Purge Solenoid Control Circuit
- DTC P0446 - EVAP Canister Vent Blocked
- DTC P0449 - EVAP Canister Vent Solenoid Valve Control Circuit
- DTC P0452 - Fuel Tank Pressure Sensor Low Voltage
- DTC P0453 - Tank Pressure Sensor Circuit Fault (High Voltage)
- DTC P0461 - Fuel Level Sensor Circuit Performance
- DTC P0462 - Fuel Level Sensor Circuit Voltage Low
- DTC P0463 - Fuel Level Sensor Circuit Voltage High
- DTC P0480 - Cooling Fan Relay No. 1 Control Circuit
- DTC P0481 - Cooling Fan Relay No. 2 & 3 Control Circuit
- DTC P0500 - Vehicle Speed Sensor Circuit
- DTC P0506 - Idle System Low
- DTC P0507 - Idle Speed High
- DTC P0530 - A/C Refrigerant Pressure Sensor Circuit
- DTC P0562 - System Voltage Low
- DTC P0563 - System Voltage High
- DTC P0601 - Pcm Memory
- DTC P0602 - Pcm Not Programmed
- DTC P0604 - Pcm Ram Performance
- DTC P0608 - VSS Output Circuit
- DTC P0650 - Mil Control Circuit
- DTC P0654 - Engine Speed Output Circuit
- DTC P0656 - Fuel Gauge Control Circuit
- DTC P0801 - Reverse Inhibit Solenoid Control Circuit
- DTC P0803 - Skip Shift Solenoid Control Circuit
- DTC P0804 - Skip Shift Light Control Circuit
- DTC P1111 - IAT Sensor Circuit Intermittent High Voltage
- DTC P1112 - IAT Sensor Circuit Intermittent Low Voltage
- DTC P1114 - ECT Sensor Circuit Intermittent Low Voltage
- DTC P1115 - ECT Sensor Circuit Intermittent High Voltage
- DTC P1121 - TP Sensor Circuit Intermittent High Voltage
- DTC P1122 - TP Sensor Circuit Intermittent Low Voltage
- DTC P1133 - Ho2S Insufficient Switching Bank 1, Sensor 1
- DTC P1134 - Ho2S Transition Time Ratio Bank 1, Sensor 1
- DTC P1153 - Ho2S Insufficient Switching Bank 2, Sensor 1
- DTC P1154 - Ho2S Transition Time Ratio Bank 2, Sensor 1
- DTC P1258 - Engine Coolant Over-Temperature Fuel Disabled
- DTC P1336 - CKP System Variation Not Learned
- DTC P1380 - Abs DTC Rough Road Data Unstable
- DTC P1381 - Misfire Detected, No EBCM/Pcm Serial Data
- DTC P1404 - EGR Valve Pintle Stuck Open
- DTC P1415 - Air System Bank 1
- DTC P1416 - Air System Bank 2
- DTC P1441 - EVAP System Flow During Non-Purge
- DTC P1539 - A/C Clutch Status Circuit Voltage High
- DTC P1545 - A/C Clutch Relay Control Circuit
- DTC P1546 - A/C Clutch Status Circuit Voltage Low
- DTC P1626 - Theft Deterrent System Fuel Enable Circuit
- DTC P1639 - 5-Volt Reference No. 2 Circuit
- Engine Control System - Tests W/O Codes - 5.7L
- Introduction
- Symptoms
- Notes
- Preliminary Checks
- Symptom Diagnosis
- Hard Start
- Hesitation, Sag Or Stumble
- Vehicle Surges Or CHUGGLES
- Lack Of Power, Sluggish Or Spongy
- Engine Backfires
- Cuts Out, Misses
- Rough, Unstable Or Incorrect Idle, Stalling
- Poor Fuel Economy
- Engine Dieseling/Run-On
- Detonation/Spark Knock
- Excessive Exhaust Emissions Or Odors
- INTERMITTENTS
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Testing & Diagnosis
- Engine Control System - Basic Diagnostic Procedures - 5.7L
- Engine Control System - System & Component Tests - 5.7L
- Engine Control System - Tests W/Codes - 5.7L
- Introduction
- Self-Diagnostic System
- Diagnostic System
- Diagnostic Procedure
- Powertrain On-Board Diagnostic (OBD) System Check
- DLC Diagnosis Or No Scan Tool Data
- Reading Trouble Codes
- Trouble Code Definitions
- Hard Or Intermittent Trouble Code Determination
- Clearing Diagnostic Trouble Codes (DTC)
- ECM/Pcm/VCM Location
- Diagnostic Materials
- Special Tools (Diagnostic)
- Scan Tool Usage
- Summary
- Diagnostic Trouble Codes
- Notes
- DTC P0101 - MAF Sensor System Performance
- DTC P0102 - MAF Sensor Circuit Low Frequency
- DTC P0103 - MAF Sensor Circuit High Frequency
- DTC P0107 - Map Sensor Circuit Low Voltage
- DTC P0108 - Map Sensor Circuit High Voltage
- IAT Temperature-To-Resistance Values
- DTC P0112 - IAT Sensor Circuit Low Voltage
- DTC P0113 - IAT Sensor Circuit High Voltage
- ECT Temperature-To-Resistance Values
- DTC P0117 - ECT Sensor Circuit Low Voltage
- DTC P0118 - ECT Sensor Circuit Voltage High
- DTC P0121 - TP Sensor Circuit Insufficient Activity
- DTC P0122 - TP Sensor Circuit Low Voltage
- DTC P0123 - TP Sensor Circuit High Voltage
- DTC P0125 - ECT Excessive Time To Reach Closed Loop
- DTC P0131 - Ho2S Circuit Voltage Low Bank 1, Sensor No. 1
- DTC P0132 - Ho2S Circuit Voltage High Bank 1, Sensor No. 1
- DTC P0133 - Ho2S Slow Response Bank 1, Sensor No. 1
- DTC P0134 - Ho2S Insufficient Activity Bank 1, Sensor No. 1
- DTC P0135 - Ho2S Heater Circuit Bank 1, Sensor No. 1
- DTC P0137 - Ho2S Circuit Voltage Low Bank 1, Sensor No. 2
- DTC P0138 - Ho2S Circuit Voltage High Bank 1, Sensor No. 2
- DTC P0140 - Ho2S Insufficient Activity Bank 1, Sensor No. 2
- DTC P0141 - HO2S HEATER CIRCUIT BANK 1, SENSOR No. 2
- DTC P0151 - Ho2S Circuit Voltage Low Bank 2, Sensor No. 1
- DTC P0152 - Ho2S Circuit Voltage High Bank 2, Sensor No. 1
- DTC P0153 - Ho2S Slow Response Bank 2 Sensor No. 1
- DTC P0154 - Ho2S Insufficient Activity Bank 2, Sensor No. 1
- DTC P0155 - Ho2S Heater Circuit Bank 2, Sensor No. 1
- DTC P0157 - Ho2S Circuit Voltage Low Bank 2, Sensor No. 2
- DTC P0158 - Ho2S Circuit Voltage High Bank 2 Sensor 2
- DTC P0160 - Ho2S Insufficient Activity Bank 2, Sensor No. 2
- DTC P0161 - Ho2S Heater Circuit Bank 2, Sensor 2
- DTC P0171 - Fuel Trim System Lean Bank 1
- DTC P0172 - Fuel Trim System Rich Bank 1
- DTC P0174 - Fuel Trim System Lean Bank 2
- DTC P0175 - Fuel Trim System Rich Bank 2
- DTC P0230 - Fuel Pump Control Circuit
- DTC P0300-P0308 - Engine Misfire Detected
- DTC P0325 - Knock Sensor Module Circuit
- DTC P0327 - Knock Sensor Circuit Front
- DTC P0332 - Knock Sensor Circuit
- DTC P0335 - Crankshaft Position (CKP) Sensor Circuit
- DTC P0341 - Camshaft Position Sensor Circuit Performance
- DTC P0342 - Camshaft Position Sensor Circuit Low Voltage
- DTC P0343 - Camshaft Position Sensor Circuit High Voltage
- DTC P0351 - Ignition Control No. 1 Circuit
- DTC P0352 - Ignition Control No. 2 Circuit
- DTC P0353 - Ignition Control No. 3 Circuit
- DTC P0354 - Ignition Control No. 4 Circuit
- DTC P0355 - Ignition Control No. 5 Circuit
- DTC P0356 - Ignition Control No. 6 Circuit
- DTC P0357 - Ignition Control No. 7 Circuit
- DTC P0358 - Ignition Control No. 8 Circuit
- DTC P0401 - EGR System Flow Insufficient
- DTC P0404 - EGR System Performance
- DTC P0405 - EGR Pintle Position Circuit Low Voltage
- DTC P0410 - Air System
- DTC P0412 - Air Solenoid Relay Control Circuit
- DTC P0418 - Air Pump Relay Control Circuit
- DTC P0420 - TWC System Low Efficiency Bank 1
- DTC P0430 - TWC System Low Efficiency Bank 2
- DTC P0440 - EVAP System
- DTC P0442 - EVAP System (Small Leak Detected)
- DTC P0443 - EVAP Purge Solenoid Control Circuit
- DTC P0446 - EVAP Canister Vent Blocked
- DTC P0449 - EVAP Canister Vent Solenoid Valve Control Circuit
- DTC P0452 - Fuel Tank Pressure Sensor Low Voltage
- DTC P0453 - Tank Pressure Sensor Circuit Fault (High Voltage)
- DTC P0461 - Fuel Level Sensor Circuit Performance
- DTC P0462 - Fuel Level Sensor Circuit Voltage Low
- DTC P0463 - Fuel Level Sensor Circuit Voltage High
- DTC P0480 - Cooling Fan Relay No. 1 Control Circuit
- DTC P0481 - Cooling Fan Relay No. 2 & 3 Control Circuit
- DTC P0500 - Vehicle Speed Sensor Circuit
- DTC P0506 - Idle System Low
- DTC P0507 - Idle Speed High
- DTC P0530 - A/C Refrigerant Pressure Sensor Circuit
- DTC P0562 - System Voltage Low
- DTC P0563 - System Voltage High
- DTC P0601 - Pcm Memory
- DTC P0602 - Pcm Not Programmed
- DTC P0604 - Pcm Ram Performance
- DTC P0608 - VSS Output Circuit
- DTC P0650 - Mil Control Circuit
- DTC P0654 - Engine Speed Output Circuit
- DTC P0656 - Fuel Gauge Control Circuit
- DTC P0801 - Reverse Inhibit Solenoid Control Circuit
- DTC P0803 - Skip Shift Solenoid Control Circuit
- DTC P0804 - Skip Shift Light Control Circuit
- DTC P1111 - IAT Sensor Circuit Intermittent High Voltage
- DTC P1112 - IAT Sensor Circuit Intermittent Low Voltage
- DTC P1114 - ECT Sensor Circuit Intermittent Low Voltage
- DTC P1115 - ECT Sensor Circuit Intermittent High Voltage
- DTC P1121 - TP Sensor Circuit Intermittent High Voltage
- DTC P1122 - TP Sensor Circuit Intermittent Low Voltage
- DTC P1133 - Ho2S Insufficient Switching Bank 1, Sensor 1
- DTC P1134 - Ho2S Transition Time Ratio Bank 1, Sensor 1
- DTC P1153 - Ho2S Insufficient Switching Bank 2, Sensor 1
- DTC P1154 - Ho2S Transition Time Ratio Bank 2, Sensor 1
- DTC P1258 - Engine Coolant Over-Temperature Fuel Disabled
- DTC P1336 - CKP System Variation Not Learned
- DTC P1380 - Abs DTC Rough Road Data Unstable
- DTC P1381 - Misfire Detected, No EBCM/Pcm Serial Data
- DTC P1404 - EGR Valve Pintle Stuck Open
- DTC P1415 - Air System Bank 1
- DTC P1416 - Air System Bank 2
- DTC P1441 - EVAP System Flow During Non-Purge
- DTC P1539 - A/C Clutch Status Circuit Voltage High
- DTC P1545 - A/C Clutch Relay Control Circuit
- DTC P1546 - A/C Clutch Status Circuit Voltage Low
- DTC P1626 - Theft Deterrent System Fuel Enable Circuit
- DTC P1639 - 5-Volt Reference No. 2 Circuit
- Engine Control System - Tests W/O Codes - 5.7L
- Introduction
- Symptoms
- Notes
- Preliminary Checks
- Symptom Diagnosis
- Hard Start
- Hesitation, Sag Or Stumble
- Vehicle Surges Or CHUGGLES
- Lack Of Power, Sluggish Or Spongy
- Engine Backfires
- Cuts Out, Misses
- Rough, Unstable Or Incorrect Idle, Stalling
- Poor Fuel Economy
- Engine Dieseling/Run-On
- Detonation/Spark Knock
- Excessive Exhaust Emissions Or Odors
- INTERMITTENTS
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Theory and Operation
- Engine Control System - Theory & Operation - 5.7L
- Introduction
- Air Induction System
- Computerized Engine Controls
- Notes
- Powertrain Control Module (Pcm)
- Input Devices
- Notes
- A/C Request Signal
- A/C Pressure Sensor
- A/C Pressure Switches
- A/C Temperature Sensors
- Battery Voltage
- Brake Switch Feedback
- Camshaft Position Sensor
- Crankshaft (4X/24X) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Coolant Level Switch
- Engine Oil Level Switch
- Engine Oil Pressure Switch
- Fuel Level Sensor
- Fuel Pump Feedback
- Fuel Tank Vapor Pressure Sensor
- Gear Switches
- Generator "L" Light Circuit
- Generator "F" Field Circuit
- Ignition/Crank Signal
- Intake Air Temperature (IAT) Sensor
- Knock Sensor
- Manifold Absolute Pressure (MAP) Sensor
- Mass Airflow (MAF) Sensor
- Oxygen Sensor (O2S)
- Park/Neutral Position (PNP) Switch
- Power Steering Pressure (PSP) Switch
- RPM Reference Signal
- Throttle Position (TP) Sensor
- Throttle Position Switch
- Transmission Fluid Temperature Sensor
- Transmission Range Switch
- Vehicle Speed Sensor (VSS)
- Output Signals
- Notes
- A/C Compressor Clutch
- Air Injection System
- Canister Purge Control Solenoid
- Coil-Near-Plug (CNP) Ignition
- Computer Controlled Coil Ignition (C(3)I)
- Cooling Fan Relay
- Digital EGR Valve
- EGR Control Solenoid
- Electronic Variable Orifice (EVO) Actuator
- Fuel Injectors
- Fuel Pump & Fuel Pump Relay
- HOT Light Or Coolant Temperature (TEMP) Light
- Idle Air Control (IAC) Valve
- Integrated Direct Ignition (IDI)
- Linear EGR Valve
- Knock Sensor Operation
- Malfunction Indicator Light (MIL)
- Self-Diagnostics
- Serial Data
- Shift Light
- Shift Solenoids (Electronically-Controlled Auto Transmission)
- Torque Converter Clutch
- Fuel System
- Ignition System
- Emission Systems
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Control System - Theory & Operation - 5.7L
- Vacuum Diagrams - 5.7L
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Introduction
- Computer Relearn Procedures
- Notes
- "C" Body
- "E" & "K" Bodies
- "F" Body
- "G" Body
- Notes
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (3.8L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (4.0L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (3.8L)
- Engine Oil Life Interval Programming (4.0L)
- Transaxle Fluid Life Interval Programming (4.0L)
- Vehicle Driveability Computer Relearn Procedure (All Models)
- "H" Body
- "J" Body
- "M" Body
- "N" Body
- Notes
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (2.4L)
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (3.1L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (2.4L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (Cutlass 3.1L & Malibu 3.1L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (Achieva 3.1L, Grand Am 3.1L & Skylark 3.1L)
- Password Learn Procedure For Anti-Theft System (Cutlass & Malibu)
- Password Learn Procedure For Anti-Theft System (Achieva, Grand Am & Skylark)
- Vehicle Driveability Computer Relearn Procedure (All Models)
- "S" Body
- "V" Body
- "W" Body
- Notes
- Electronically Erasable Programmable Read Only Memory (EEPROM) Programming (All Models)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (Century 3.1L & Grand Prix 3.1L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (Lumina 3.1L & Monte Carlo 3.1L)
- Crankshaft Position (CKP) Sensor Variation Learn Procedure (3.8L)
- Password Learn Procedure For Anti-Theft System (Century & Regal)
- Vehicle Driveability Computer Relearn Procedure (All Models)
- "Y" Body
- SATURN
- OBD-II Drive Cycles - 1996-00
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- Testing Wiring Systems For Intermittent & Poor Connections
- Service Precautions
- Intermittent Or Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Testing for Short to Ground
- Testing for Continuity
- Testing for a Short to Voltage
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Probing Electrical Connectors
- Testing Wiring Systems For Intermittent & Poor Connections
- Maintenance Reminder Light (Reset Procedures)
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Engine Oil Replacement Reminder Reset - Procedure 29
- Engine Oil Replacement Reminder Reset - Procedure 30
- Engine Oil Replacement Reminder Reset - Procedure 31
- Engine Oil Replacement Reminder Reset - Procedure 32
- Engine Oil Replacement Reminder Reset - Procedure 33
- Engine Oil Replacement Reminder Reset - Procedure 34
- Engine Oil Replacement Reminder Reset - Procedure 35
- Engine Oil Replacement Reminder Reset - Procedure 36
- Engine Oil Replacement Reminder Reset - Procedure 37
- Emissions Maintenance Reminder (Reminder Flag)
- Emissions Maintenance Reminder (Warning Light)
- Emissions Maintenance Reminder (Check Engine Light)
- Diesel Fuel Filter Replacement Reminder
- Maintenance Service Reminder
- Timing Belt Replacement Reminder
- Transmission Fluid Replacement Reminder
- Tire Pressure Monitor System Reminder
- Notes
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 06
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- TPMS Reminder Reset - Procedure 11
- TPMS Reminder Reset - Procedure 12
- TPMS Reminder Reset - Procedure 13
- TPMS Reminder Reset - Procedure 14
- TPMS Reminder Reset - Procedure 15
- TPMS Reminder Reset - Procedure 16
- TPMS Reminder Reset - Procedure 17
- TPMS Reminder Reset - Procedure 18
- TPMS Reminder Reset - Procedure 19
- TPMS Reminder Reset - Procedure 20
- TPMS Reminder Reset - Procedure 21
- TPMS Reminder Reset - Procedure 22
- TPMS Reminder Reset - Procedure 23
- TPMS Reminder Reset - Procedure 24
- TPMS Reminder Reset - Procedure 25
- TPMS Reminder Reset - Procedure 26
- TPMS Reminder Reset - Procedure 27
- TPMS Reminder Reset - Procedure 28
- TPMS Reminder Reset - Procedure 29
- TPMS Reminder Reset - Procedure 30
- TPMS Reminder Reset - Procedure 31
- TPMS Reminder Reset - Procedure 32
- TPMS Reminder Reset - Procedure 33
- TPMS Reminder Reset - Procedure 34
- TPMS Reminder Reset - Procedure 35
- TPMS Reminder Reset - Procedure 36
- TPMS Reminder Reset - Procedure 37
- Engine Oil Replacement Reminder
- Restraints
- Supplemental Inflatable Restraint System Component Inspection & Replacement Tables.
- Supplemental Inflatable Restraint System Deactivation Procedures
- Special Care During Mechanical Repairs
- CHRYSLER Corp.
- Ford Motor Co.
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling System (Continental, Crown Victoria, Grand Marquis & Town Car)
- Activating System
- Disabling System (Contour, Mystique & Windstar)
- Disabling System (Escort, Escort Coupe, "F" Series Pickups & Tracer)
- Disabling System ("E" Series Vans With One Battery)
- Disabling System ("E" Series Vans With Dual Batteries)
- Disabling System (Explorer, Expedition, Mountaineer, Navigator & Ranger)
- Disabling System (Mark VIII, Mustang, Sable & Taurus)
- Disabling System (Villager)
- Driver-Side Air Bag Module
- Removal & Installation (Expedition, Explorer, "E" Series Vans, "F" Series Pickups, Mountaineer, Navigator & Ranger)
- Removal & Installation (Continental, Crown Victoria, Grand Marquis, Mark VIII, Mustang, Sable, Taurus & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation (Escort, Escort Coupe & Tracer)
- Removal & Installation (Windstar)
- Passenger-Side Air Bag Module
- Removal & Installation (Continental, Crown Victoria, Grand Marquis & Town Car)
- Removal & Installation (Contour & Mystique)
- Removal & Installation ("E" Series Vans)
- Removal & Installation (Expedition, "F" Series Pickups & Navigator)
- Removal & Installation (Explorer & Mountaineer)
- Removal & Installation (Escort, Escort Coupe & Tracer)
- Removal & Installation (Mark VIII)
- Removal & Installation (Mustang & Ranger)
- Removal & Installation (Sable & Taurus)
- Removal & Installation (Windstar)
- Torque Specifications
- General Motors
- Notes
- System Operation Check
- Service Precautions
- Disabling & Activating Air Bag System
- Notes
- Disabling & Activating System (Corvette)
- Disabling & Activating System (Catera)
- Disabling & Activating System (Concours, DeVille, Eldorado & Seville)
- Disabling & Activating System (Cutlass & Malibu)
- Disabling & Activating System (Grand Prix)
- Disabling & Activating System (Lumina & Monte Carlo)
- Disabling & Activating System (Metro, Firefly (Canadian) & Tracker)
- Disabling & Activating System (Prizm)
- Disabling & Activating System (Saturn)
- Disabling & Activating System (Silhouette, Trans Sport & Venture)
- Disabling & Activating System (All Other Models)
- Jeep
- RPO Codes
- RPO Code Description (Codes 001-19F)
- RPO Code Description (Codes 19H-2EL)
- RPO Code Description (Codes 2F1-44I)
- RPO Code Description (Codes 44L-5J9)
- RPO Code Description (Codes 5K0-6FF)
- RPO Code Description (Codes 6FG-76A)
- RPO Code Description (Codes 76D-7XD)
- RPO Code Description (Codes 7XF-8M0)
- RPO Code Description (Codes 8M1-9C0)
- RPO Code Description (Codes 9C1-A0F)
- RPO Code Description (Codes A0G-Ar4)
- RPO Code Description (Codes Ar5-BCP)
- RPO Code Description (Codes BCQ-C12)
- RPO Code Description (Codes C13-Cur)
- RPO Code Description (Codes Cut-Dir)
- RPO Code Description (Codes Dr7-EHE)
- RPO Code Description (Codes EHF-F5P)
- RPO Code Description (Codes F5Q-G1V)
- RPO Code Description (Codes G1W-HFN)
- RPO Code Description (Codes HFO-JRG)
- RPO Code Description (Codes JRH-KLY)
- RPO Code Description (Codes KLZ-LQX)
- RPO Code Description (Codes LQY-MW9)
- RPO Code Description (Codes MWE-ODK)
- RPO Code Description (Codes ODL-Ora)
- RPO Code Description (Codes Orb-PDE)
- RPO Code Description (Codes PDF-QH6)
- RPO Code Description (Codes QH7-R8D)
- RPO Code Description (Codes R8E-T07)
- RPO Code Description (Codes T08-TJ0)
- RPO Code Description (Codes TJ1-U10)
- RPO Code Description (Codes U11-Us9)
- RPO Code Description (Codes USB-VG9)
- RPO Code Description (Codes VGA-W5Y)
- RPO Code Description (Codes W5Z-XE3)
- RPO Code Description (Codes XE4-Y9Z)
- RPO Code Description (Codes Ya2-ZD9)
- RPO Code Description (Codes ZDE-ZZZ)
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- A/C Compressor
- General Servicing
- Cabin Air Filter (Special Applications) - General Information
- HVAC System - Compressor Servicing
- HVAC System - Specifications
- HVAC System Compressor Refrigerant Oil Checking
- HVAC System General Servicing
- HVAC Control Systems
- HVAC System - Manual
- HVAC System - Manual - Trouble Shooting
- Model Identification
- Refrigerant System Diagnosis
- Heater System Diagnosis
- Heater Output Temperature Check
- Functional Test
- Insufficient Cooling (CCOT System)
- Checking Refrigerant Charge - Step 2 (V5/TXV System)
- Checking Compressor Clutch Engagement - Step 3 (V5/TXV System)
- Checking System Performance - Step 4 (V5/TXV System)
- Performance Diagnostic Chart - Step 5 (V5/TXV System)
- Diagnostic Code Procedures - Step 6 (V5/TXV System)
- Checking For No Stroke Compressor - Step 7 (V5/TXV System)
- Control Valve Diagnosis - Step 8 (V5/TXV System)
- Checking Refrigerant Charge - Step 2 (V5/VDOT System)
- Checking Compressor Clutch Engagement - Step 3 (V5/VDOT System)
- Checking System Performance - Step 4 (V5/VDOT System)
- CHECKING SYSTEM PERFORMANCE - STEP 4 (Cont.) (V5/VDOT SYSTEM)
- Right Area Diagnosis & Service - Step 5 (V5/VDOT System)
- Left Area Diagnosis & Service - Step 6 (V5/VDOT System)
- Control Valve Diagnosis - Step 7 (V5/VDOT System)
- Insufficient Heat Or Defrosting (Manual A/C-Heater Systems Only)
- Temperature Control Diagnosis (Manual A/C-Heater Systems Only)
- Blower Noise Diagnosis
- Operational Testing
- Electrical Trouble Shooting
- Maintenance
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Description & Operation
- Component Location
- Service Precautions
- Disabling & Activating Air Bag System
- Post-Collision Inspection
- Adjustments
- Disposal Procedures
- Removal & Installation
- Testing - System Operation Check
- Diagnosis - Testing
- Testing - Diagnostic
- Notes
- Sir Diagnostic System Check
- SDM Integrity Check
- Air Bag Warning Light Comes On Steady
- Air Bag Warning Light Does Not Come On
- DTC B1015: Passenger Deployment Loop Resistance High
- DTC B1016: Passenger Deployment Loop Resistance Low
- DTC B1017: Passenger Deployment Loop Open
- DTC B1018: Passenger Deployment Loop Short To Ground
- DTC B1019: Passenger Deployment Loop Short To Voltage
- DTC B1021: Driver Deployment Loop Resistance High
- DTC B1022: Driver Deployment Loop Resistance Low
- DTC B1024: Driver Deployment Loop Short To Ground
- DTC B1025: Driver Deployment Loop Short To Voltage
- DTC B1026: Driver Deployment Loop Open
- DTC B1051: Deployment Commanded
- DTC B1053: Deployment Commanded With Loop Malfunction
- DTC B1061: Air Bag Warning Light Circuit Failure
- DTC B1071: Internal SDM Failure
- Wire Repair
- Torque Specifications
- Wiring Diagrams
- Supplemental Inflatable Restraint System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Rack & Pinion Steering
- Model Identification
- Description & Operation
- Lubrication
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Power Rack & Pinion Steering
- Power Steering
- Power Rack & Pinion Steering
- Model Identification
- Description & Operation
- Lubrication
- Adjustments
- Testing
- Removal & Installation
- Overhaul
- Torque Specifications
- Power Rack & Pinion Steering
- Steering Wheel And Steering Column - Standard
- Model Identification
- Description & Operation
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Removal & Installation
- Overhaul
- Torque Specifications
- Manual Steering
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment Specifications & Adjustment Procedures
- Transmission
- Automatic Trans
- Automatic Transaxle Removal & Installation
- Automatic Transaxle Servicing
- Automatic Transmission Diagnosis - 4L60-E
- Description & Operation
- Trouble Shooting
- Electronic Self-Diagnostics
- Diagnostic Tests
- Diagnostic Test Description
- Using Diagnostic Tests & Wiring Diagrams
- On-Board Diagnostic (OBD) System Check
- DTC P0218: Transmission Fluid OVERTEMP
- DTC P0502: Vehicle Speed Sensor Circuit (Low Input)
- DTC P0503: Vehicle Speed Sensor Circuit (Intermittent)
- DTC P0560: System Voltage Malfunction
- DTC P0711: Trans. Fluid Temperature (TFT) Sensor Circuit (Range/Performance)
- DTC P0712: Trans. Fluid Temperature (TFT) Sensor Circuit (Low Input)
- DTC P0713: Trans. Fluid Temperature (TFT) Sensor Circuit (High Input)
- DTC P0719: Brake Switch Circuit Low Input (Switch Stuck On)
- DTC P0724: Brake Switch Circuit High Input (Switch Stuck Off)
- DTC P0740: TCC Solenoid Electrical Malfunction
- DTC P0742: TCC Circuit Inoperative (Stuck On)
- DTC P0748: Pressure Control Solenoid (PCS) Electrical Malfunction
- DTC P0751: 1-2 Shift Solenoid ("A") Performance Malfunction
- DTC P0753: 1-2 Shift Solenoid ("A") Electrical Malfunction
- DTC P0756: 2-3 Shift Solenoid ("B") Performance Malfunction
- DTC P0758: 2-3 Shift Solenoid ("B") Electrical Malfunction
- DTC P0785: 3-2 Shift Solenoid Electrical Malfunction
- DTC P1572: Traction Control System (TCS) Low Voltage Too Long
- DTC P1810: Transmission Fluid Pressure (TFP) Position Switch Assembly Malfunction
- DTC P1860: TCC PWM Solenoid Electrical Malfunction
- DTC P1870: Transmission Component Slipping
- Component Tests
- Wiring Diagrams
- Automatic Transmission Overhaul - 4L60-E
- Application
- Identification
- Description
- Lubrication
- On-Vehicle Service
- Adjustments
- Trouble Shooting
- Notes
- Symptom Diagnosis
- 1st Gear Only, No Upshift
- 1st Gear Start In 2nd Gear Start Mode
- Slips In 1st Gear
- Slipping Or Rough 1-2 Shift
- Slipping, Rough Or No 2-3 Shift
- 1st & 4th Or 2nd & 3rd Gear Only
- 3rd Gear Only
- 3-2 Flare Or Tie Up
- Slipping, Rough Or No 3-4 Shift
- No Reverse Or Slips In Reverse
- No Part-Throttle Or Delayed Downshifts
- Harsh Garage Shifts
- No Overrun Braking In Manual 3-2-1
- Drives (Creeps) In Neutral
- Starts In 2nd In "D"
- No Park
- Oil Pressure High Or Low
- Harsh Shifts
- High Or Low Shift Points
- No Converter Clutch Apply
- Converter Shudder
- No Converter Clutch Release
- Converter Clutch Applies When Cold
- Ratcheting Noise
- Oil Leaking Out Vent
- Vibration In Reverse & Whining Noise In Park
- Front Oil Leak
- Pump Bushing Spins Out, "Walks" Into Seal, Or Seizes To Converter Hub
- Falls Out Of 4th Gear During Coasting
- Binds Up On 3-4 Shift (Feels Like Brake Drag)
- No Forward Or Reverse Gears (Line Pressure Reading Okay)
- Binds Up In Reverse
- No Drive In "D" Range
- No Drive In "OD" Range
- Electronic Self-Diagnostics
- Testing
- Removal & Installation
- Transmission Disassembly
- Cleaning & Inspection
- Component Disassembly & Reassembly
- Transmission Reassembly
- Transmission Specifications
- Torque Specifications
- Shift Interlock Systems
- Manual Transmission Clutches
- Automatic Transmission Hydraulic Diagrams - 4L60-E
- Manual Trans
- Manual Transmission Servicing
- Overhaul T5 Manual Transmission
- Overhaul T56 Manual Transmission
- Identification
- Description
- Lubrication & Adjustments
- Trouble Shooting
- On-Vehicle Service
- Removal & Installation
- Transmission Disassembly
- Component Disassembly & Reassembly
- Reassembly Adjustments
- Transmission Reassembly
- Reverse Lockout & Gear Lockout (Skip Shift) System
- Torque Specifications
- Wiring Diagrams
- Automatic Trans
- External Pages