Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations- Diagnostic Connector (DLC) Locations
- Electrical Component Locator
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label
- Fuse Block - Underhood - Top View
- Fuse Block - Underhood - Bottom View
- Fuse Block - Left I/P Label
- Fuse Block - Left I/P - Top View
- Fuse Block - Left I/P, C1, C2 - Bottom View
- Fuse Block - Left I/P, C3 - Bottom View
- Fuse Block - Right I/P Label
- Fuse Block - Right I/P - Top View
- Fuse Block - Right I/P, C1, C2 - Bottom View
- Fuse Block - Right I/P, C3 - Bottom View
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Splice Pack Connector End Views
- Repair Instructions
- Special Tools and Equipment
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector End Views
- Turn Signal/Multifunction Switch, C3 Connector End View
- Washer Fluid Level Sensor Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Wiper Motor Assembly Connector End View
- Sunroof Motor/Actuator Connector End View
- Sunroof Switch Connector End View
- Air Temperature Actuator Connector End View
- A/C Compressor Clutch Connector End View
- A/C Refrigerant Pressure Sensor Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Assembly Connector End View
- HVAC Control Assembly, C1 Connector End View
- HVAC Control Assembly, C2 Connector End View
- Body Control Module (BCM), C1 Connector End View
- Body Control Module (BCM), C2 Connector End View
- Body Control Module (BCM), C3 Connector End View
- Data Link Connector (DLC) Connector End View
- Cigar Lighter Connector End View
- Ignition Switch - C1 Connector End View
- Ignition Switch - C2 Connector End View
- Clutch Pedal Position (CPP) Switch Connector End View
- Cruise Control Module (CCM) Connector End View
- TCC/Brake Switch Connector End View
- Seat Belt Switch Connector End View
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Passlock™ Sensor Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Horn Assembly Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Park/Neutral Position (PNP) Switch Connector End View
- Stop Lamp Switch, C1 Connector End View
- Stop Lamp Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Park/Neutral Position Switch Connector End View
- Output Speed Sensor (OSS) Connector, Wiring Harness Side Connector End View
- Cruise Control Brake Switch Connector, Wiring Harness Side Connector End View
- Automatic Transmission Fluid Pressure Manual Valve Position Switch, Wiring Harness Side Connector End View
- 1-2 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- 2-3 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- Torque Converter Clutch Pulse Width Modulated (TCC PWM) Solenoid Valve Connector, Wiring Harness Side Connector End View
- Pressure Control Solenoid Valve, Wiring Harness Side Connector End View
- Input Speed Sensor, Wiring Harness Side Connector End View
- AT Inline Harness Connector, Engine Side Connector End View
- AT Inline Harness Connector, Transmission Side Connector End View
- Door Lock Actuator - Driver Connector End View
- Door Lock Actuator - Passenger Connector End View
- Door Lock Actuator - LR Connector End View
- Door Lock Actuator - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver (Coupe) Connector End View
- Window Switch - Driver C1 (Sedan) Connector End View
- Window Switch - Driver C2 (Sedan) Connector End View
- Window Switch - Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Electronic Brake Control Module (EBCM) Connector End View
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Rear Compartment Lid Release Switch Connector End View
- Rear Compartment Lid Release Actuator Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Steering Wheel Module Connector End View
- Audio Amplifier (U85) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio, C1 Connector End View
- Radio, C2 (U2K) Connector End View
- Speaker - LF Tweeter (U85) Connector End View
- Speaker - LF (U85) Connector End View
- Speaker - LF (UQ8) Connector End View
- Speaker - LR (UQ8) Connector End View
- Speaker - LR (U85) Connector End View
- Speaker - RF Tweeter (U85) Connector End View
- Speaker - RF (UQ8) Connector End View
- Speaker - RF (U85) Connector End View
- Speaker - RR (U85) Connector End View
- Speaker - RR (UQ8) Connector End View
- Coolant Level Switch Connector End View
- Cooling Fan - Left (LA1) Connector End View
- Cooling Fan - Left (L61) Connector End View
- Cooling Fan - Right (LA1) Connector End View
- Cooling Fan - Right (L61) Connector End View
- Generator (LA1) Connector End View
- Generator (L61) Connector End View
- Seat Adjuster Switch - Driver (AG1) Connector End View
- Seat Adjuster Switch - Driver (AH3) Connector End View
- Seat Horizontal Motor (AG1) Connector End View
- Seat Rear Vertical Motor (AG1) Connector End View
- Seat Front Vertical Motor (AG1) Connector End View
- Seat Vertical Motor (AH3) Connector End View
- Ambient Light Sensor Connector End View
- Auxiliary Park Lamp - LF Connector End View
- Auxiliary Park Lamp - RF Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Backup Lamp Switch Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Dome Lamp Connector End View
- Door Ajar Switch - LR Connector End View
- Door Ajar Switch - RR Connector End View
- Door Jamb Switch - LF Connector End View
- Door Jamb Switch - RF Connector End View
- Daytime Running Lamps (DRL) Resistor Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Fog Lamp Switch Connector End View
- Hazard Switch Connector End View
- Headlamp - Left Connector End View
- Headlamp - Right Connector End View
- Inside Rearview Mirror w/Reading Lamps Connector End View
- I/P Compartment Lamp/Switch Connector End View
- I/P Dimmer Switch Connector End View
- I/P Dimming Module Connector End View
- Lamp Assembly - LR Connector End View
- Lamp Assembly - RR Connector End View
- License Lamp Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - RF Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Shift Indicator Lamp Connector End View
- Stop Lamp Switch - C1 Connector End View
- Stop Lamp Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C1 Connector End View
- Turn Signal/Multifunction Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C3 Connector End View
- Rear Window Defogger Grid C1 Connector End View
- Rear Window Defogger Grid C2 Connector End View
- Engine Oil Pressure (EOP) Sensor Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Powertrain Control Module (PCM) C1 (3.4L) Connector End View
- Powertrain Control Module (PCM) C2 (3.4L) Connector End View
- Camshaft Position (CMP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor A (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor B (3.4L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (3.4L) Connector End View
- Exhaust Gas Recirculation (EGR) Valve (3.4L) Connector End View
- Fuel Injector 1 (3.4L) Connector End View
- Fuel Injector 2 (3.4L) Connector End View
- Fuel Injector 3 (3.4L) Connector End View
- Fuel Injector 4 (3.4L) Connector End View
- Fuel Injector 5 (3.4L) Connector End View
- Fuel Injector 6 (3.4L) Connector End View
- Fuel Pump and Sender Assembly (3.4L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (3.4L) Connector End View
- Idle Air Control (IAC) Valve (3.4L) Connector End View
- Ignition Control Module (ICM), C1 (3.4L) Connector End View
- Ignition Control Module (ICM), C2 (3.4L) Connector End View
- Ignition Control Module (ICM), C3 (3.4L) Connector End View
- Intake Air Temperature (IAT) Sensor (3.4L) Connector End View
- Knock Sensor (KS) (3.4L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (3.4L) Connector End View
- Mass Air Flow (MAF) Sensor (3.4L) Connector End View
- Throttle Position (TP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor (2.2L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (2.2L) Connector End View
- Fuel Injector 1 (2.2L) Connector End View
- Fuel Injector 2 (2.2L) Connector End View
- Fuel Injector 3 (2.2L) Connector End View
- Fuel Injector 4 (2.2L) Connector End View
- Fuel Pump and Sender Assembly (2.2L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (2.2L) Connector End View
- Idle Air Control (IAC) Valve (2.2L) Connector End View
- Ignition Control Module (ICM) (2.2L) Connector End View
- Intake Air Temperature (IAT) Sensor (2.2L) Connector End View
- Knock Sensor (KS) (2.2L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (2.2L) Connector End View
- Throttle Position (TP) Sensor (2.2L) Connector End View
- Powertrain Control Module (PCM) C1 (2.2L) Connector End View
- Powertrain Control Module (PCM) C2 (2.2L) Connector End View
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label
- Fuse Block - Underhood - Top View
- Fuse Block - Underhood - Bottom View
- Fuse Block - Left I/P Label
- Fuse Block - Left I/P - Top View
- Fuse Block - Left I/P, C1, C2 - Bottom View
- Fuse Block - Left I/P, C3 - Bottom View
- Fuse Block - Right I/P Label
- Fuse Block - Right I/P - Top View
- Fuse Block - Right I/P, C1, C2 - Bottom View
- Fuse Block - Right I/P, C3 - Bottom View
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Splice Pack Connector End Views
- Repair Instructions
- Special Tools and Equipment
- OEM Connector End Views
- Accessories & Equipment
- Anti-Theft Systems
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Keyless Entry System
- Theft Deterrent System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Theft Deterrent
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B2947: Security System Sensor Power Circuit Low
- DTC B2948: Security System Sensor Power Circuit High
- DTC B2957: Security System Sensor Data Circuit Low
- DTC B2958: Security System Sensor Data Circuit High
- DTC B2960: Security System Sensor Data Incorrect but Valid
- DTC B3031: Security System Controller In Learn Mode
- DTC B3033: Security System Indicates Tamper
- DTC P1626: Theft Deterrent Fuel Enable Signal Lost
- DTC P1630: Theft Deterrent Learn Mode Active
- DTC P1631: Theft Deterrent Fuel Enable Signal Not Correct
- DTC P1632: Theft Deterrent Fuel Disable Signal Received
- Symptoms - Theft Deterrent
- Security Indicator Inoperative
- Repair Instructions
- Description and Operation
- Door System, Mirror System & Window System
- Communication Devices
- Computer/Integrating Systems
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Computer/Integrating Systems
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1000: Electronic Control Unit (ECU) Performance
- DTC B1001: Option Configuration Error
- DTC B1009: EEPROM Checksum Mismatch
- DTC B1369: Device Ignition 0 (UNLOCK, ON, and START) Circuit Open
- DTC B1374: Device Ignition 1 (ON and START) Circuit Open
- DTC B1379: Device Ignition 3 (ON) Circuit Open
- DTC U1000 and U1255: Class 2 Data Link Malfunction/Lost Communications
- DTC U1001-U1254: Lost Communications With Control Module(s)
- DTC U1300, U1301, or U1305: Class 2 Data Link Low or High
- Symptoms - Computer/Integrating Systems
- Scan Tool Does Not Power Up
- Scan Tool Does Not Communicate with Class 2 Device
- Power Mode Mismatch
- Control Module References
- Repair Instructions
- Description and Operation
- Programming And Setup - All Systems
- Repair Instructions
- Service Programming System (SPS)
- Audio Amplifier Programming and Setup
- Body Control Module Programming and Setup
- Cruise Control Module Programming and Setup
- Digital Radio Receiver Programming and Setup
- Electronic Brake Control Module Programming and Setup
- Ignition Control Module Programming and Setup
- Inflatable Restraint Sensing and Diagnostic Module Programming and Setup
- Instrument Panel Cluster Programming and Setup
- Powertrain Control Module Programming and Setup (3.4L)
- Radio Programming and Setup
- Remote Control Door Lock Receiver Programming and Setup
- Sunroof Control Module Programming and Setup
- Repair Instructions
- Computer/Integrating Systems
- Cruise Control Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Cruise Control
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions (Cruise Control)
- Scan Tool Data Definitions (Disengage History)
- DTC Table
- DTC P1554: Cruise Control Feedback Circuit
- DTC P1585: Cruise Control Inhibit Output Circuit
- Symptoms - Cruise Control
- Cruise Control Inoperative/Malfunctioning
- Repair Instructions
- Description and Operation
- Entertainment Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Entertainment
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1001: Options Configuration Error (Recalibrate)
- DTC B1025, B1035, B1045, or B1055: Audio Output Circuit
- DTC B1259: Antenna Ground Circuit
- DTC B1780: Theftlock Enabled
- Symptoms - Entertainment
- Audio System Troubleshooting Hints
- Radio Poor Reception
- Digital Radio Poor or No Reception
- Audio Distortion - One or More Speakers
- Audio Too Loud at Low Settings
- Tape Player Weak, Slow, or Garbled Output
- Steering Wheel Controls Inoperative
- Reduced Volume - One or More Speakers
- Speakers Inoperative - One or More
- Speakers Inoperative - All
- Radio Setup
- Digital Radio Receiver Setup
- Speaker Replacement Reference
- Repair Instructions
- Radio Replacement
- Receiver Replacement - Digital Radio
- Amplifier Replacement
- Cassette Player Care and Cleaning
- Radio Antenna Module Replacement
- Antenna Module Coil Replacement
- Fixed Antenna Replacement
- Antenna Replacement - Digital Radio (U2K)
- Antenna Extension Cable Replacement
- Antenna Cable Replacement (Pontiac)
- Coaxial Cable Replacement - Digital Radio
- Speaker Replacement - Front Lower
- Speaker Replacement - Front Upper
- Speaker Replacement - Rear
- Description and Operation
- Radio/Audio System Description and Operation
- Special Tools and Equipment
- Exterior Lights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B2532: Front Foglamps Control Circuit Low
- DTC B2533: Front Foglamps Control Circuit High
- DTC B2558: Passenger Compartment Lamp Control Circuit High
- DTC B2575: Headlamp Control Circuit
- DTC B2577: Headlamp Control Circuit Low
- DTC B2578: Headlamp Control Circuit High
- DTC B2585: Parklamp Control Circuit
- DTC B2587: Parklamp Control Circuit Low
- DTC B2588: Parklamp Control Circuit High
- DTC B2600: Daytime Running Lamp Control System Circuit
- DTC B2601: Daytime Running Lamp Control System Circuit Range/Performance
- DTC B2602: Daytime Running Lamp Control System Circuit Low
- DTC B2603: Daytime Running Lamp Control System Circuit High
- DTC B2647: Ambient Light Sensor Circuit Low
- DTC B2648: Ambient Light Sensor Circuit High
- Symptoms - Lighting Systems
- Automatic Lamp Control Inoperative
- Backup Lamps Always On
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative (From I/P Dimmer Switch)
- Courtesy Lamps Inoperative (From Door Switch)
- Daytime Running Lamps (DRL) Indicator Inoperative
- Daytime Running Lamps (DRL) Inoperative
- Dome Lamps Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlamps Inoperative - Flash to Pass
- High Beam Indicator Inoperative
- Illuminated Entry Lamps Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park Lamps Inoperative
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Repair Instructions
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Fog Lamp Switch Replacement - Front
- Door Jamb Switch Replacement - Rear
- Hazard Warning Switch Replacement
- Instrument Panel (I/P) Dimmer Switch Replacement
- Module Replacement - Panel Dimming
- Daytime Running Lamps (DRL) Ambient Light Sensor Replacement
- Instrument Panel (I/P) Compartment Lamp Switch Replacement
- Instrument Panel (I/P) Storage Compartment Lamp Replacement
- Rearview Mirror Lamp Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement (With Sunroof)
- Dome Lamp Replacement (Without Sunroof)
- Headlamp Assembly or Headlamp Bulb and/or Cornering, Sidemarker, Park, Turn Signal Bulb Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front
- Fog Lamp Aiming Procedure
- High Mounted Stop Lamp Replacement
- Backup Lamp Replacement
- License Lamp Replacement
- Tail Lamp Assembly and/or Backup, Sidemarker, Stop, Turn Signal Bulb Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Gauges & Instrument Panels
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1365: Device Ignition 0 (UNLOCK, ON and START) Circuit
- DTC B2965: Key In Ignition Circuit Open
- DTC P0461: Fuel Level Sensor Performance
- DTC P0462: Fuel Level Sensor Circuit Low Voltage
- DTC P0463: Fuel Level Sensor Circuit High Voltage
- DTC P0520: Engine Oil Pressure (EOP) Sensor Circuit
- Symptoms - Instrument Panel, Gages and Console
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On
- Low Fuel Indicator Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Trip Odometer and Reset Switch Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement (Pontiac)
- Closeout/Insulator Panel Replacement - Right (Outboard)
- Closeout/Insulator Panel Replacement - Right (Inboard)
- Closeout/Insulator Panel Replacement - Left (Outboard)
- Closeout/Insulator Panel Replacement - Left (Inboard)
- Knee Bolster Reinforcement Replacement
- Trim Plate Replacement - Instrument Panel (I/P) Accessory (Pontiac)
- Trim Plate Bezel Replacement - Instrument Panel (I/P) Cluster (Pontiac)
- Instrument Panel (I/P) Outer Trim Cover Replacement
- Storage Compartment Replacement - Instrument Panel (I/P) (Pontiac)
- Compartment Replacement - Instrument Panel (I/P)
- Defroster Grille Replacement (Pontiac)
- Trim Pad Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Instrument Panel Cluster (IPC) Indicator Lamp Replacement
- Console Replacement - Front Floor (Pontiac)
- Bracket Replacement - Console Floor
- Console Armrest Replacement - Front Floor
- Trim Plate Replacement - Front Floor Console (Pontiac)
- Cupholder Replacement - Front Floor Console
- Description and Operation
- Special Tools and Equipment
- Instrument Panel System Displays, Gauges And Console
- Headlights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B2532: Front Foglamps Control Circuit Low
- DTC B2533: Front Foglamps Control Circuit High
- DTC B2558: Passenger Compartment Lamp Control Circuit High
- DTC B2575: Headlamp Control Circuit
- DTC B2577: Headlamp Control Circuit Low
- DTC B2578: Headlamp Control Circuit High
- DTC B2585: Parklamp Control Circuit
- DTC B2587: Parklamp Control Circuit Low
- DTC B2588: Parklamp Control Circuit High
- DTC B2600: Daytime Running Lamp Control System Circuit
- DTC B2601: Daytime Running Lamp Control System Circuit Range/Performance
- DTC B2602: Daytime Running Lamp Control System Circuit Low
- DTC B2603: Daytime Running Lamp Control System Circuit High
- DTC B2647: Ambient Light Sensor Circuit Low
- DTC B2648: Ambient Light Sensor Circuit High
- Symptoms - Lighting Systems
- Automatic Lamp Control Inoperative
- Backup Lamps Always On
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative (From I/P Dimmer Switch)
- Courtesy Lamps Inoperative (From Door Switch)
- Daytime Running Lamps (DRL) Indicator Inoperative
- Daytime Running Lamps (DRL) Inoperative
- Dome Lamps Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlamps Inoperative - Flash to Pass
- High Beam Indicator Inoperative
- Illuminated Entry Lamps Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park Lamps Inoperative
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Repair Instructions
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Fog Lamp Switch Replacement - Front
- Door Jamb Switch Replacement - Rear
- Hazard Warning Switch Replacement
- Instrument Panel (I/P) Dimmer Switch Replacement
- Module Replacement - Panel Dimming
- Daytime Running Lamps (DRL) Ambient Light Sensor Replacement
- Instrument Panel (I/P) Compartment Lamp Switch Replacement
- Instrument Panel (I/P) Storage Compartment Lamp Replacement
- Rearview Mirror Lamp Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement (With Sunroof)
- Dome Lamp Replacement (Without Sunroof)
- Headlamp Assembly or Headlamp Bulb and/or Cornering, Sidemarker, Park, Turn Signal Bulb Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front
- Fog Lamp Aiming Procedure
- High Mounted Stop Lamp Replacement
- Backup Lamp Replacement
- License Lamp Replacement
- Tail Lamp Assembly and/or Backup, Sidemarker, Stop, Turn Signal Bulb Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Heated Glass/Defoggers
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Windshield Upper Reveal Molding Replacement
- Windshield Side Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Quarter Window Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Horns
- Horn System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Horn System
- Ignition Switch/Steering Lock
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Multifunction, Turn Signal Switch Replacement
- Tilt Lever Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Lower Bearing and Steering Column Jacket Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Infotainment
- Entertainment System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Entertainment
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1001: Options Configuration Error (Recalibrate)
- DTC B1025, B1035, B1045, or B1055: Audio Output Circuit
- DTC B1259: Antenna Ground Circuit
- DTC B1780: Theftlock Enabled
- Symptoms - Entertainment
- Audio System Troubleshooting Hints
- Radio Poor Reception
- Digital Radio Poor or No Reception
- Audio Distortion - One or More Speakers
- Audio Too Loud at Low Settings
- Tape Player Weak, Slow, or Garbled Output
- Steering Wheel Controls Inoperative
- Reduced Volume - One or More Speakers
- Speakers Inoperative - One or More
- Speakers Inoperative - All
- Radio Setup
- Digital Radio Receiver Setup
- Speaker Replacement Reference
- Repair Instructions
- Radio Replacement
- Receiver Replacement - Digital Radio
- Amplifier Replacement
- Cassette Player Care and Cleaning
- Radio Antenna Module Replacement
- Antenna Module Coil Replacement
- Fixed Antenna Replacement
- Antenna Replacement - Digital Radio (U2K)
- Antenna Extension Cable Replacement
- Antenna Cable Replacement (Pontiac)
- Coaxial Cable Replacement - Digital Radio
- Speaker Replacement - Front Lower
- Speaker Replacement - Front Upper
- Speaker Replacement - Rear
- Description and Operation
- Radio/Audio System Description and Operation
- Special Tools and Equipment
- Entertainment System
- Interior/Exterior Trim
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Exterior Trim
- Specifications
- Repair Instructions
- Emblem/Nameplate Repair
- Emblem/Nameplate Replacement - Front Fender
- Emblem/Nameplate Replacement - Door
- Emblem/Nameplate Replacement - Rear Compartment Lid
- Grille Replacement
- Molding Replacement - Front Bumper Fascia
- Molding Replacement - Rear Bumper Fascia
- Molding Replacement - Rocker Panel
- Decal and Stripe Replacement
- Special Tools and Equipment
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1365: Device Ignition 0 (UNLOCK, ON and START) Circuit
- DTC B2965: Key In Ignition Circuit Open
- DTC P0461: Fuel Level Sensor Performance
- DTC P0462: Fuel Level Sensor Circuit Low Voltage
- DTC P0463: Fuel Level Sensor Circuit High Voltage
- DTC P0520: Engine Oil Pressure (EOP) Sensor Circuit
- Symptoms - Instrument Panel, Gages and Console
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On
- Low Fuel Indicator Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Trip Odometer and Reset Switch Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement (Pontiac)
- Closeout/Insulator Panel Replacement - Right (Outboard)
- Closeout/Insulator Panel Replacement - Right (Inboard)
- Closeout/Insulator Panel Replacement - Left (Outboard)
- Closeout/Insulator Panel Replacement - Left (Inboard)
- Knee Bolster Reinforcement Replacement
- Trim Plate Replacement - Instrument Panel (I/P) Accessory (Pontiac)
- Trim Plate Bezel Replacement - Instrument Panel (I/P) Cluster (Pontiac)
- Instrument Panel (I/P) Outer Trim Cover Replacement
- Storage Compartment Replacement - Instrument Panel (I/P) (Pontiac)
- Compartment Replacement - Instrument Panel (I/P)
- Defroster Grille Replacement (Pontiac)
- Trim Pad Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Instrument Panel Cluster (IPC) Indicator Lamp Replacement
- Console Replacement - Front Floor (Pontiac)
- Bracket Replacement - Console Floor
- Console Armrest Replacement - Front Floor
- Trim Plate Replacement - Front Floor Console (Pontiac)
- Cupholder Replacement - Front Floor Console
- Description and Operation
- Special Tools and Equipment
- Interior Trim
- Specifications
- Repair Instructions
- Eliminating Unwanted Odors in Vehicles
- Door Sill Plate Replacement
- Carpet Retainer Replacement - Front
- Carpet Retainer Replacement - Rear
- Floor Carpet Drying
- Carpet Replacement - Front
- Headliner Replacement
- Coat Hook Replacement (Sedan)
- Coat Hook Replacement (Coupe)
- Console Replacement - Overhead
- Sunshade Replacement
- Sunshade Anchor Replacement
- Garnish Molding Replacement - Windshield Pillar
- Trim Panel Replacement - Upper Center Pillar
- Trim Panel Replacement - Lower Center Pillar
- Trim Panel Replacement - Rear Quarter Upper (Coupe)
- Trim Panel Replacement - Rear Quarter Upper (Sedan)
- Trim Panel Replacement - Rear Quarter Lower
- Panel Replacement - Rear Compartment Closeout
- Trim Panel Replacement - Rear Window Shelf
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Interior/Illumination Lights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B2532: Front Foglamps Control Circuit Low
- DTC B2533: Front Foglamps Control Circuit High
- DTC B2558: Passenger Compartment Lamp Control Circuit High
- DTC B2575: Headlamp Control Circuit
- DTC B2577: Headlamp Control Circuit Low
- DTC B2578: Headlamp Control Circuit High
- DTC B2585: Parklamp Control Circuit
- DTC B2587: Parklamp Control Circuit Low
- DTC B2588: Parklamp Control Circuit High
- DTC B2600: Daytime Running Lamp Control System Circuit
- DTC B2601: Daytime Running Lamp Control System Circuit Range/Performance
- DTC B2602: Daytime Running Lamp Control System Circuit Low
- DTC B2603: Daytime Running Lamp Control System Circuit High
- DTC B2647: Ambient Light Sensor Circuit Low
- DTC B2648: Ambient Light Sensor Circuit High
- Symptoms - Lighting Systems
- Automatic Lamp Control Inoperative
- Backup Lamps Always On
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative (From I/P Dimmer Switch)
- Courtesy Lamps Inoperative (From Door Switch)
- Daytime Running Lamps (DRL) Indicator Inoperative
- Daytime Running Lamps (DRL) Inoperative
- Dome Lamps Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Low and High Beams
- Headlamps Inoperative - Flash to Pass
- High Beam Indicator Inoperative
- Illuminated Entry Lamps Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Park Lamps Inoperative
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Inoperative
- Repair Instructions
- Stop Lamp Switch Adjustment
- Stop Lamp Switch Replacement
- Fog Lamp Switch Replacement - Front
- Door Jamb Switch Replacement - Rear
- Hazard Warning Switch Replacement
- Instrument Panel (I/P) Dimmer Switch Replacement
- Module Replacement - Panel Dimming
- Daytime Running Lamps (DRL) Ambient Light Sensor Replacement
- Instrument Panel (I/P) Compartment Lamp Switch Replacement
- Instrument Panel (I/P) Storage Compartment Lamp Replacement
- Rearview Mirror Lamp Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement (With Sunroof)
- Dome Lamp Replacement (Without Sunroof)
- Headlamp Assembly or Headlamp Bulb and/or Cornering, Sidemarker, Park, Turn Signal Bulb Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front
- Fog Lamp Aiming Procedure
- High Mounted Stop Lamp Replacement
- Backup Lamp Replacement
- License Lamp Replacement
- Tail Lamp Assembly and/or Backup, Sidemarker, Stop, Turn Signal Bulb Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Memory Modules
- Mirrors
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Windshield Upper Reveal Molding Replacement
- Windshield Side Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Quarter Window Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Seats
- Seat System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seat Replacement - Front Bucket
- Seat Cushion Replacement - Front
- Seat Cushion Cover Replacement - Front
- Seat Cushion Frame Replacement - Front
- Seat Back Replacement - Front
- Seat Back Cover Replacement - Front
- Seat Back Frame Replacement - Front
- Seat Back Recliner Replacement - Front
- Seat Back Recliner Handle Replacement - Front
- Seat Back Recliner Cable Replacement - Front
- Lumbar Replacement - Front Seat
- Lumbar Actuator Replacement - Manual
- Seat Adjuster Replacement - Front
- Seat Adjuster Handle Replacement - Two-Way Manual
- Seat Adjuster Motor Replacement - Front
- Seat Switch Replacement - Power
- Seat Adjuster Phase Adjustment - Power
- Drive Cable Replacement - Horizontal and Vertical
- Actuator Replacement - Horizontal
- Actuator Replacement - Front and Rear Vertical
- Head Restraint Replacement - Front Seat
- Head Restraint Retainer Replacement - Front Seat
- Seat Cushion Replacement - Rear
- Seat Cushion Cover Replacement - Rear
- Seat Back Replacement - Rear
- Seat Back Replacement - Rear Split Folding
- Seat Back Cover and Pad - Rear Split Folding
- Seat Back Bolster Replacement - Rear Split Folding
- Seat Back Bolster Cover and Pad - Split Folding
- Seat Back Cover Replacement - Rear
- Seat Back Latch Replacement - Rear Folding
- Seat Back Center Pivot Replacement - Rear Folding
- Seat Back Latch Striker Replacement - Rear Folding
- Description and Operation
- Seat System
- Steering Column Switches
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Multifunction, Turn Signal Switch Replacement
- Tilt Lever Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Lower Bearing and Steering Column Jacket Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Window Motors & Regulators
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Windshield Upper Reveal Molding Replacement
- Windshield Side Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Quarter Window Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Wiper/Washer Systems
- Wiper System & Washer System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Washer Solvent Container Replacement
- Washer Solvent Container Level Sensor Replacement
- Washer Pump Replacement
- Hose Replacement - Windshield Washer
- Wiper Arm Replacement
- Wiper Arm Blade Replacement
- Wiper Blade Element Replacement
- Wiper Motor Cover Replacement
- Wiper Motor Replacement
- Wiper Transmission Replacement
- Wiper Chatter Repair
- Windshield Glass Cleaning
- Blade Element Cleaning
- Description and Operation
- Special Tools and Equipment
- Wiper System & Washer System
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Keyless Entry System
- Theft Deterrent System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Theft Deterrent
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B2947: Security System Sensor Power Circuit Low
- DTC B2948: Security System Sensor Power Circuit High
- DTC B2957: Security System Sensor Data Circuit Low
- DTC B2958: Security System Sensor Data Circuit High
- DTC B2960: Security System Sensor Data Incorrect but Valid
- DTC B3031: Security System Controller In Learn Mode
- DTC B3033: Security System Indicates Tamper
- DTC P1626: Theft Deterrent Fuel Enable Signal Lost
- DTC P1630: Theft Deterrent Learn Mode Active
- DTC P1631: Theft Deterrent Fuel Enable Signal Not Correct
- DTC P1632: Theft Deterrent Fuel Disable Signal Received
- Symptoms - Theft Deterrent
- Security Indicator Inoperative
- Repair Instructions
- Description and Operation
- Door System, Mirror System & Window System
- Exterior Body Panels
- Air/Wind Noise Symptoms
- Body Front End
- Specifications
- Repair Instructions
- Hood Adjustment
- Hood Bumper Replacement (Front)
- Hood Bumper Replacement - Side
- Hood Replacement
- Hood Hinge Replacement
- Hood Latch Replacement
- Hood Latch Support Replacement
- Hood Latch Release Cable Replacement
- Hood Latch Release Handle Replacement
- Hood Latch Striker Replacement
- Hood Insulator Replacement
- Hood Hold-Open Rod Replacement
- Headlamp Housing Panel Replacement
- Air Deflector Replacement - Front
- Fender Replacement - Front
- Air Inlet Grille Panel Replacement
- Seal Replacement - Hood Front
- Seal Replacement - Plenum to Hood
- Seal Replacement - Hood Rear Side
- Mounting Bracket Replacement - Air Cleaner
- Battery Tray Replacement
- Front Fender Liner Replacement
- Special Tools and Equipment
- Body Rear End
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Rear Compartment Lid Switch Replacement (Pontiac)
- Compartment Sill Plate Replacement - Rear
- Compartment Trim Panel Replacement - Rear
- Wheelhouse Liner Panel Replacement - Rear
- Compartment Lid Applique Replacement - Rear
- Spoiler Replacement - Rear
- Fuel Filler Door Replacement
- Fuel Filler Pocket Replacement
- Compartment Lid Replacement - Rear (Pontiac)
- Hinge Replacement - Rear Compartment Lid
- Torque Rod Replacement - Rear Compartment Lid
- Lock Cylinder Replacement - Rear Compartment Lid (Pontiac)
- Latch Replacement - Rear Compartment Lid
- Overslam Bumper Replacement - Rear Compartment Lid
- Lock Striker Replacement - Rear Compartment Lid
- Pressure Relief Valve Replacement
- Weatherstrip Replacement - Rear Compartment Opening
- Description and Operation
- Special Tools and Equipment
- Bumper System
- Specifications
- Repair Instructions
- Fascia Replacement - Front Bumper
- Fascia Support Replacement - Front Bumper
- Impact Bar Replacement - Front Bumper
- Energy Absorber Replacement - Front
- Fascia Replacement - Rear Bumper
- Fascia Support Replacement - Rear Bumper Outer
- Fascia Reinforcement Replacement - Rear Bumper
- Energy Absorber Replacement - Rear
- Impact Bar Replacement - Rear Bumper
- Bracket Replacement - Rear Bumper (Fascia)
- Bracket Replacement - Rear Bumper (Side Support)
- Description and Operation
- Squeaks And Rattles
- Water Leaks
- Exterior/Interior Trim
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Exterior Trim
- Specifications
- Repair Instructions
- Emblem/Nameplate Repair
- Emblem/Nameplate Replacement - Front Fender
- Emblem/Nameplate Replacement - Door
- Emblem/Nameplate Replacement - Rear Compartment Lid
- Grille Replacement
- Molding Replacement - Front Bumper Fascia
- Molding Replacement - Rear Bumper Fascia
- Molding Replacement - Rocker Panel
- Decal and Stripe Replacement
- Special Tools and Equipment
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1365: Device Ignition 0 (UNLOCK, ON and START) Circuit
- DTC B2965: Key In Ignition Circuit Open
- DTC P0461: Fuel Level Sensor Performance
- DTC P0462: Fuel Level Sensor Circuit Low Voltage
- DTC P0463: Fuel Level Sensor Circuit High Voltage
- DTC P0520: Engine Oil Pressure (EOP) Sensor Circuit
- Symptoms - Instrument Panel, Gages and Console
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On
- Low Fuel Indicator Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Trip Odometer and Reset Switch Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement (Pontiac)
- Closeout/Insulator Panel Replacement - Right (Outboard)
- Closeout/Insulator Panel Replacement - Right (Inboard)
- Closeout/Insulator Panel Replacement - Left (Outboard)
- Closeout/Insulator Panel Replacement - Left (Inboard)
- Knee Bolster Reinforcement Replacement
- Trim Plate Replacement - Instrument Panel (I/P) Accessory (Pontiac)
- Trim Plate Bezel Replacement - Instrument Panel (I/P) Cluster (Pontiac)
- Instrument Panel (I/P) Outer Trim Cover Replacement
- Storage Compartment Replacement - Instrument Panel (I/P) (Pontiac)
- Compartment Replacement - Instrument Panel (I/P)
- Defroster Grille Replacement (Pontiac)
- Trim Pad Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Instrument Panel Cluster (IPC) Indicator Lamp Replacement
- Console Replacement - Front Floor (Pontiac)
- Bracket Replacement - Console Floor
- Console Armrest Replacement - Front Floor
- Trim Plate Replacement - Front Floor Console (Pontiac)
- Cupholder Replacement - Front Floor Console
- Description and Operation
- Special Tools and Equipment
- Interior Trim
- Specifications
- Repair Instructions
- Eliminating Unwanted Odors in Vehicles
- Door Sill Plate Replacement
- Carpet Retainer Replacement - Front
- Carpet Retainer Replacement - Rear
- Floor Carpet Drying
- Carpet Replacement - Front
- Headliner Replacement
- Coat Hook Replacement (Sedan)
- Coat Hook Replacement (Coupe)
- Console Replacement - Overhead
- Sunshade Replacement
- Sunshade Anchor Replacement
- Garnish Molding Replacement - Windshield Pillar
- Trim Panel Replacement - Upper Center Pillar
- Trim Panel Replacement - Lower Center Pillar
- Trim Panel Replacement - Rear Quarter Upper (Coupe)
- Trim Panel Replacement - Rear Quarter Upper (Sedan)
- Trim Panel Replacement - Rear Quarter Lower
- Panel Replacement - Rear Compartment Closeout
- Trim Panel Replacement - Rear Window Shelf
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Frames, Subframes & Crossmembers
- Ignition Switch/Steering Lock
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Multifunction, Turn Signal Switch Replacement
- Tilt Lever Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Lower Bearing and Steering Column Jacket Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Mirrors
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Windshield Upper Reveal Molding Replacement
- Windshield Side Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Quarter Window Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Seats
- Seat System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seat Replacement - Front Bucket
- Seat Cushion Replacement - Front
- Seat Cushion Cover Replacement - Front
- Seat Cushion Frame Replacement - Front
- Seat Back Replacement - Front
- Seat Back Cover Replacement - Front
- Seat Back Frame Replacement - Front
- Seat Back Recliner Replacement - Front
- Seat Back Recliner Handle Replacement - Front
- Seat Back Recliner Cable Replacement - Front
- Lumbar Replacement - Front Seat
- Lumbar Actuator Replacement - Manual
- Seat Adjuster Replacement - Front
- Seat Adjuster Handle Replacement - Two-Way Manual
- Seat Adjuster Motor Replacement - Front
- Seat Switch Replacement - Power
- Seat Adjuster Phase Adjustment - Power
- Drive Cable Replacement - Horizontal and Vertical
- Actuator Replacement - Horizontal
- Actuator Replacement - Front and Rear Vertical
- Head Restraint Replacement - Front Seat
- Head Restraint Retainer Replacement - Front Seat
- Seat Cushion Replacement - Rear
- Seat Cushion Cover Replacement - Rear
- Seat Back Replacement - Rear
- Seat Back Replacement - Rear Split Folding
- Seat Back Cover and Pad - Rear Split Folding
- Seat Back Bolster Replacement - Rear Split Folding
- Seat Back Bolster Cover and Pad - Split Folding
- Seat Back Cover Replacement - Rear
- Seat Back Latch Replacement - Rear Folding
- Seat Back Center Pivot Replacement - Rear Folding
- Seat Back Latch Striker Replacement - Rear Folding
- Description and Operation
- Seat System
- Sun Roof/T-Top/Convertible Top
- Sunroof System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Roof
- Symptoms - Roof
- Power Sunroof Inoperative
- Power Sunroof Does Not Close
- Power Sunroof Window is Skewed
- Power Sunroof When Operated from Vent to Close One Side Will Drop Before the Other
- Power Sunroof When Closing from the Vent Position the Window Will Reverse Direction
- Power Sunroof Will Stop at the Wrong Location
- Power Sunroof Will Over Travel the Open Position and Stall the Motor
- Power Sunroof Will Over Travel the Close Position and Stall the Motor
- Repair Instructions
- Sunroof Window Height and Opening Fit Adjustment
- Sunroof Track Timing/Synchronization (MD4)
- Sunroof Drain Hose Replacement - Front
- Sunroof Drain Hose Replacement - Rear
- Sunroof Drain Inspection and Cleaning
- Sunroof Sunshade Panel Replacement
- Sunroof Window Replacement
- Sunroof Switch Replacement
- Sunroof Motor/Actuator Replacement (MD4)
- Sunroof Motor/Actuator Initialization/Teach Process (New Motor)
- Sunroof Motor/Actuator Initialization/Teach Process (Existing Motor)
- Sunroof Wiring Harness Replacement
- Sunroof Module Assembly Replacement (MD4)
- Sunroof Finishing Lace Replacement
- Sunroof Sunshade Stop Replacement
- Description and Operation
- Special Tools and Equipment
- Sunroof System
- Windows
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B3127 or B3128: Left Front/Driver Door Only Unlock Circuit Low Or High
- DTC B3132 or B3133: All Door Unlock Circuit Low Or High
- DTC B3137 or B3138: All Door Lock Circuit Low Or High
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Power Door Locks Inoperative - Lockout Feature
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Power Accessory Switch Panel Replacement
- Power Window Switch Replacement - Left Front
- Power Window Switch Replacement - Right Front
- Power Window Switch Replacement - Rear Door
- Power Door Lock Switch Replacement
- Power Mirror Switch Replacement
- Armrest Pull Cup Replacement
- Armrest Bracket Replacement
- Door Handle Bezel Replacement
- Window Regulator Handle Replacement - Door
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Trim Panel Insert Replacement - Front Door
- Access Cover Replacement - Front Door
- Energy Absorber Pad Replacement - Front Door
- Energy Absorber Pad Replacement - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Replacement - Front
- Door Replacement - Rear
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Check Link Replacement
- Door Check Link Replacement - Rear
- Lock Relay Replacement - Power Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Replacement - Inside
- Lock Replacement - Door
- Lock Replacement - Rear Door
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Striker Replacement - Door
- Door Hardware Lubrication
- Wiring Harness Replacement - Door
- Motor Replacement - Power Window
- Window Regulator Replacement - Front Door (Manual)
- Window Regulator Replacement - Front Door (Power)
- Window Regulator Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Replacement - Front Side Rear
- Window Run Channel Replacement
- Window Replacement - Rear Door Stationary
- Window Channel Replacement - Rear Door Front
- Door Frame Applique Replacement - Front
- Door Frame Applique Replacement - Rear
- Reveal Molding Replacement - Rear Door Window
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Sealing Strip Replacement - Front Door Auxiliary
- Sealing Strip Replacement - Rear Door Front Auxiliary
- Weatherstrip Replacement - Front Door Opening
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement
- Mirror Replacement - Remote
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Windshield Upper Reveal Molding Replacement
- Windshield Side Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Quarter Window Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Door Locks
- Brakes
- Anti-Lock Brakes
- Antilock Brake System And Traction Control System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Antilock Brake System
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Enhanced Diagnostics
- DTC Table
- DTC C1214: Solenoid Valve Relay Coil or Contact Circuit Open
- DTC C1217: Pump Motor Shorted to Ground
- DTC C1218: Pump Motor Circuit Short to Voltage or Motor Ground Open
- DTC C1221-C1235: Wheel Speed Sensor Input Signal(s)
- DTC C1236: Low System Supply Voltage
- DTC C1237: High System Supply Voltage
- DTC C1242 or C1243: Pump Motor Circuit Open or Pump Motor Stalled
- DTC C1254: Abnormal Shutdown Detected
- DTC C1255 or C1256: Loss of Class 2 Communication or EBCM/ECTCM Internal Malfunction
- DTC C1261-C1268: Inlet/Outlet Valve Solenoid Malfunction(s)
- DTC C1275: PCM Requested ETS to be Disabled
- DTC C1295: Brake Lamp Switch Circuit Open
- Symptoms - Antilock Brake System
- ABS Indicator Always On
- ABS Indicator Inoperative
- Low Traction Indicator Always On
- Low Traction Indicator Inoperative
- Traction Off Indicator Always On
- Traction Off Indicator Inoperative
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Antilock Brake System And Traction Control System
- Mechanical - Hydraulic
- Disc Brake System
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Disc Brakes
- Brake Rotor Thickness Measurement
- Brake Rotor Thickness Variation Measurement
- Brake Rotor Surface and Wear Inspection
- Brake Rotor Assembled Lateral Runout (LRO) Measurement
- Brake Pad Inspection
- Brake Caliper Inspection
- Disc Brake Mounting and Hardware Inspection - Front
- Disc Brake Mounting and Hardware Inspection - Rear
- Repair Instructions
- Brake Pads Replacement - Front
- Brake Pads Replacement - Rear
- Burnishing Pads and Rotors
- Brake Caliper Replacement - Front
- Brake Caliper Replacement - Rear
- Brake Caliper Overhaul - Front
- Brake Caliper Overhaul - Rear
- Disc Brake Hardware Replacement - Front
- Disc Brake Hardware Replacement - Rear
- Brake Caliper Bracket Replacement - Front
- Brake Caliper Bracket Replacement - Rear
- Brake Rotor Replacement - Front
- Brake Rotor Replacement - Rear
- Disc Brake Backing Plate Replacement - Rear
- Brake Rotor Assembled Lateral Runout (LRO) Correction
- Brake Rotor Assembled Lateral Runout (LRO) Correction - Indexing
- Brake Rotor Assembled Lateral Runout (LRO) Correction - Correction Plates
- Brake Rotor Assembled Lateral Runout (LRO) Correction - On-Vehicle Lathe
- Brake Rotor Refinishing
- Description and Operation
- Special Tools and Equipment
- Drum Brake System
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Hydraulic Brake System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Hydraulic Brakes
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC C1247: Low Brake Fluid Detected
- Symptoms - Hydraulic Brakes
- Brake Warning Indicator Always On
- Brake Warning Indicator Inoperative (w/o ABS)
- Brake Warning Indicator Inoperative (w/ABS)
- Brake Pulsation
- Brake System Noise
- Braking Action Uneven - Pulls to One Side
- Braking Action Uneven - Front to Rear
- Brake Pedal Excessive Travel
- Brake Pedal Excessive Effort
- Brakes Drag
- Brake System Slow Release
- Brake Fluid Loss
- Disc Brake System Diagnosis
- Drum Brake System Diagnosis
- Hydraulic Brake System Diagnosis
- Brake Assist System Diagnosis
- Brake System Vehicle Road Test
- Brake Pedal Travel Measurement and Inspection
- Brake System Vacuum Source Test
- Brake System External Leak Inspection
- Brake System Internal Leak Test
- Hydraulic Brake Component Operation Visual Inspection
- Brake Pipe and Hose Inspection
- Brake Pedal Pushrod Inspection
- Repair Instructions
- Master Cylinder Reservoir Filling
- Master Cylinder Reservoir Replacement
- Master Cylinder Replacement
- Master Cylinder Overhaul
- Master Cylinder Bench Bleeding
- Master Cylinder Fluid Level Sensor Replacement
- Brake Pedal Assembly Replacement
- Proportioning Valve Replacement
- Brake Pipe Replacement
- Brake Hose Replacement - Front
- Brake Hose Replacement - Rear (Disc)
- Brake Hose Replacement - Rear (Drum)
- Hydraulic Brake System Bleeding (Manual)
- Hydraulic Brake System Bleeding (Pressure)
- Hydraulic Brake System Flushing
- Vacuum Brake Booster Replacement (3.4L)
- Vacuum Brake Booster Check Valve and/or Hose Replacement (2.2L)
- Vacuum Brake Booster Check Valve and/or Hose Replacement (3.4L)
- Description and Operation
- Special Tools and Equipment
- Disc Brake System
- Parking Brake System
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Park Brake Shoe Replacement
- Park Brake Lever Assembly Replacement
- Park Brake Warning Lamp Switch Replacement
- Park Brake Hardware Replacement
- Park Brake Cable Replacement - Front
- Park Brake Cable Replacement - Rear (Disc Brakes)
- Park Brake Cable Replacement - Rear (Drum Brakes)
- Park Brake Cable Equalizer Replacement
- Park Brake Actuator Replacement
- Park Brake Adjustment
- Description and Operation
- Special Tools and Equipment
- Antilock Brake System And Traction Control System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Antilock Brake System
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Enhanced Diagnostics
- DTC Table
- DTC C1214: Solenoid Valve Relay Coil or Contact Circuit Open
- DTC C1217: Pump Motor Shorted to Ground
- DTC C1218: Pump Motor Circuit Short to Voltage or Motor Ground Open
- DTC C1221-C1235: Wheel Speed Sensor Input Signal(s)
- DTC C1236: Low System Supply Voltage
- DTC C1237: High System Supply Voltage
- DTC C1242 or C1243: Pump Motor Circuit Open or Pump Motor Stalled
- DTC C1254: Abnormal Shutdown Detected
- DTC C1255 or C1256: Loss of Class 2 Communication or EBCM/ECTCM Internal Malfunction
- DTC C1261-C1268: Inlet/Outlet Valve Solenoid Malfunction(s)
- DTC C1275: PCM Requested ETS to be Disabled
- DTC C1295: Brake Lamp Switch Circuit Open
- Symptoms - Antilock Brake System
- ABS Indicator Always On
- ABS Indicator Inoperative
- Low Traction Indicator Always On
- Low Traction Indicator Inoperative
- Traction Off Indicator Always On
- Traction Off Indicator Inoperative
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- OEM Connector End Views
- Connector End Views
- Turn Signal/Multifunction Switch, C3 Connector End View
- Washer Fluid Level Sensor Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Wiper Motor Assembly Connector End View
- Sunroof Motor/Actuator Connector End View
- Sunroof Switch Connector End View
- Air Temperature Actuator Connector End View
- A/C Compressor Clutch Connector End View
- A/C Refrigerant Pressure Sensor Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Assembly Connector End View
- HVAC Control Assembly, C1 Connector End View
- HVAC Control Assembly, C2 Connector End View
- Body Control Module (BCM), C1 Connector End View
- Body Control Module (BCM), C2 Connector End View
- Body Control Module (BCM), C3 Connector End View
- Data Link Connector (DLC) Connector End View
- Cigar Lighter Connector End View
- Ignition Switch - C1 Connector End View
- Ignition Switch - C2 Connector End View
- Clutch Pedal Position (CPP) Switch Connector End View
- Cruise Control Module (CCM) Connector End View
- TCC/Brake Switch Connector End View
- Seat Belt Switch Connector End View
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Passlock™ Sensor Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Horn Assembly Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Park/Neutral Position (PNP) Switch Connector End View
- Stop Lamp Switch, C1 Connector End View
- Stop Lamp Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Park/Neutral Position Switch Connector End View
- Output Speed Sensor (OSS) Connector, Wiring Harness Side Connector End View
- Cruise Control Brake Switch Connector, Wiring Harness Side Connector End View
- Automatic Transmission Fluid Pressure Manual Valve Position Switch, Wiring Harness Side Connector End View
- 1-2 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- 2-3 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- Torque Converter Clutch Pulse Width Modulated (TCC PWM) Solenoid Valve Connector, Wiring Harness Side Connector End View
- Pressure Control Solenoid Valve, Wiring Harness Side Connector End View
- Input Speed Sensor, Wiring Harness Side Connector End View
- AT Inline Harness Connector, Engine Side Connector End View
- AT Inline Harness Connector, Transmission Side Connector End View
- Door Lock Actuator - Driver Connector End View
- Door Lock Actuator - Passenger Connector End View
- Door Lock Actuator - LR Connector End View
- Door Lock Actuator - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver (Coupe) Connector End View
- Window Switch - Driver C1 (Sedan) Connector End View
- Window Switch - Driver C2 (Sedan) Connector End View
- Window Switch - Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Electronic Brake Control Module (EBCM) Connector End View
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Rear Compartment Lid Release Switch Connector End View
- Rear Compartment Lid Release Actuator Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Steering Wheel Module Connector End View
- Audio Amplifier (U85) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio, C1 Connector End View
- Radio, C2 (U2K) Connector End View
- Speaker - LF Tweeter (U85) Connector End View
- Speaker - LF (U85) Connector End View
- Speaker - LF (UQ8) Connector End View
- Speaker - LR (UQ8) Connector End View
- Speaker - LR (U85) Connector End View
- Speaker - RF Tweeter (U85) Connector End View
- Speaker - RF (UQ8) Connector End View
- Speaker - RF (U85) Connector End View
- Speaker - RR (U85) Connector End View
- Speaker - RR (UQ8) Connector End View
- Coolant Level Switch Connector End View
- Cooling Fan - Left (LA1) Connector End View
- Cooling Fan - Left (L61) Connector End View
- Cooling Fan - Right (LA1) Connector End View
- Cooling Fan - Right (L61) Connector End View
- Generator (LA1) Connector End View
- Generator (L61) Connector End View
- Seat Adjuster Switch - Driver (AG1) Connector End View
- Seat Adjuster Switch - Driver (AH3) Connector End View
- Seat Horizontal Motor (AG1) Connector End View
- Seat Rear Vertical Motor (AG1) Connector End View
- Seat Front Vertical Motor (AG1) Connector End View
- Seat Vertical Motor (AH3) Connector End View
- Ambient Light Sensor Connector End View
- Auxiliary Park Lamp - LF Connector End View
- Auxiliary Park Lamp - RF Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Backup Lamp Switch Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Dome Lamp Connector End View
- Door Ajar Switch - LR Connector End View
- Door Ajar Switch - RR Connector End View
- Door Jamb Switch - LF Connector End View
- Door Jamb Switch - RF Connector End View
- Daytime Running Lamps (DRL) Resistor Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Fog Lamp Switch Connector End View
- Hazard Switch Connector End View
- Headlamp - Left Connector End View
- Headlamp - Right Connector End View
- Inside Rearview Mirror w/Reading Lamps Connector End View
- I/P Compartment Lamp/Switch Connector End View
- I/P Dimmer Switch Connector End View
- I/P Dimming Module Connector End View
- Lamp Assembly - LR Connector End View
- Lamp Assembly - RR Connector End View
- License Lamp Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - RF Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Shift Indicator Lamp Connector End View
- Stop Lamp Switch - C1 Connector End View
- Stop Lamp Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C1 Connector End View
- Turn Signal/Multifunction Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C3 Connector End View
- Rear Window Defogger Grid C1 Connector End View
- Rear Window Defogger Grid C2 Connector End View
- Engine Oil Pressure (EOP) Sensor Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Powertrain Control Module (PCM) C1 (3.4L) Connector End View
- Powertrain Control Module (PCM) C2 (3.4L) Connector End View
- Camshaft Position (CMP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor A (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor B (3.4L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (3.4L) Connector End View
- Exhaust Gas Recirculation (EGR) Valve (3.4L) Connector End View
- Fuel Injector 1 (3.4L) Connector End View
- Fuel Injector 2 (3.4L) Connector End View
- Fuel Injector 3 (3.4L) Connector End View
- Fuel Injector 4 (3.4L) Connector End View
- Fuel Injector 5 (3.4L) Connector End View
- Fuel Injector 6 (3.4L) Connector End View
- Fuel Pump and Sender Assembly (3.4L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (3.4L) Connector End View
- Idle Air Control (IAC) Valve (3.4L) Connector End View
- Ignition Control Module (ICM), C1 (3.4L) Connector End View
- Ignition Control Module (ICM), C2 (3.4L) Connector End View
- Ignition Control Module (ICM), C3 (3.4L) Connector End View
- Intake Air Temperature (IAT) Sensor (3.4L) Connector End View
- Knock Sensor (KS) (3.4L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (3.4L) Connector End View
- Mass Air Flow (MAF) Sensor (3.4L) Connector End View
- Throttle Position (TP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor (2.2L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (2.2L) Connector End View
- Fuel Injector 1 (2.2L) Connector End View
- Fuel Injector 2 (2.2L) Connector End View
- Fuel Injector 3 (2.2L) Connector End View
- Fuel Injector 4 (2.2L) Connector End View
- Fuel Pump and Sender Assembly (2.2L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (2.2L) Connector End View
- Idle Air Control (IAC) Valve (2.2L) Connector End View
- Ignition Control Module (ICM) (2.2L) Connector End View
- Intake Air Temperature (IAT) Sensor (2.2L) Connector End View
- Knock Sensor (KS) (2.2L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (2.2L) Connector End View
- Throttle Position (TP) Sensor (2.2L) Connector End View
- Powertrain Control Module (PCM) C1 (2.2L) Connector End View
- Powertrain Control Module (PCM) C2 (2.2L) Connector End View
- Connector End Views
- Power Outlets
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label
- Fuse Block - Underhood - Top View
- Fuse Block - Underhood - Bottom View
- Fuse Block - Left I/P Label
- Fuse Block - Left I/P - Top View
- Fuse Block - Left I/P, C1, C2 - Bottom View
- Fuse Block - Left I/P, C3 - Bottom View
- Fuse Block - Right I/P Label
- Fuse Block - Right I/P - Top View
- Fuse Block - Right I/P, C1, C2 - Bottom View
- Fuse Block - Right I/P, C3 - Bottom View
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Splice Pack Connector End Views
- Repair Instructions
- Special Tools and Equipment
- OEM Connector End Views
- Charging Systems
- Battery, Charging System And Starting System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC P0560: System Voltage
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0620: Generator Performance
- DTC P0621: Generator L-Terminal Circuit
- DTC P0622: Generator F-Terminal Circuit
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging (Non-HP2)
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click (LA1)
- Starter Solenoid Does Not Click (L61)
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Battery, Charging System And Starting System
- Component Locations
- Diagnostic Connector (DLC) Locations
- Electrical Component Locator
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label
- Fuse Block - Underhood - Top View
- Fuse Block - Underhood - Bottom View
- Fuse Block - Left I/P Label
- Fuse Block - Left I/P - Top View
- Fuse Block - Left I/P, C1, C2 - Bottom View
- Fuse Block - Left I/P, C3 - Bottom View
- Fuse Block - Right I/P Label
- Fuse Block - Right I/P - Top View
- Fuse Block - Right I/P, C1, C2 - Bottom View
- Fuse Block - Right I/P, C3 - Bottom View
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Splice Pack Connector End Views
- Repair Instructions
- Special Tools and Equipment
- Fuses & Circuit Breakers
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B1365: Device Ignition 0 (UNLOCK, ON and START) Circuit
- DTC B2965: Key In Ignition Circuit Open
- DTC P0461: Fuel Level Sensor Performance
- DTC P0462: Fuel Level Sensor Circuit Low Voltage
- DTC P0463: Fuel Level Sensor Circuit High Voltage
- DTC P0520: Engine Oil Pressure (EOP) Sensor Circuit
- Symptoms - Instrument Panel, Gages and Console
- Engine Coolant Temperature Gage Inaccurate or Inoperative
- Fuel Gage Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On
- Low Fuel Indicator Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Trip Odometer and Reset Switch Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement (Pontiac)
- Closeout/Insulator Panel Replacement - Right (Outboard)
- Closeout/Insulator Panel Replacement - Right (Inboard)
- Closeout/Insulator Panel Replacement - Left (Outboard)
- Closeout/Insulator Panel Replacement - Left (Inboard)
- Knee Bolster Reinforcement Replacement
- Trim Plate Replacement - Instrument Panel (I/P) Accessory (Pontiac)
- Trim Plate Bezel Replacement - Instrument Panel (I/P) Cluster (Pontiac)
- Instrument Panel (I/P) Outer Trim Cover Replacement
- Storage Compartment Replacement - Instrument Panel (I/P) (Pontiac)
- Compartment Replacement - Instrument Panel (I/P)
- Defroster Grille Replacement (Pontiac)
- Trim Pad Replacement - Instrument Panel (I/P)
- Instrument Panel Cluster (IPC) Replacement
- Instrument Panel Cluster (IPC) Indicator Lamp Replacement
- Console Replacement - Front Floor (Pontiac)
- Bracket Replacement - Console Floor
- Console Armrest Replacement - Front Floor
- Trim Plate Replacement - Front Floor Console (Pontiac)
- Cupholder Replacement - Front Floor Console
- Description and Operation
- Special Tools and Equipment
- Horns
- Horn System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Horn System
- Motors, Switches, Relays
- OEM Connector End Views
- Connector End Views
- Turn Signal/Multifunction Switch, C3 Connector End View
- Washer Fluid Level Sensor Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Wiper Motor Assembly Connector End View
- Sunroof Motor/Actuator Connector End View
- Sunroof Switch Connector End View
- Air Temperature Actuator Connector End View
- A/C Compressor Clutch Connector End View
- A/C Refrigerant Pressure Sensor Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Assembly Connector End View
- HVAC Control Assembly, C1 Connector End View
- HVAC Control Assembly, C2 Connector End View
- Body Control Module (BCM), C1 Connector End View
- Body Control Module (BCM), C2 Connector End View
- Body Control Module (BCM), C3 Connector End View
- Data Link Connector (DLC) Connector End View
- Cigar Lighter Connector End View
- Ignition Switch - C1 Connector End View
- Ignition Switch - C2 Connector End View
- Clutch Pedal Position (CPP) Switch Connector End View
- Cruise Control Module (CCM) Connector End View
- TCC/Brake Switch Connector End View
- Seat Belt Switch Connector End View
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Passlock™ Sensor Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Horn Assembly Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Park/Neutral Position (PNP) Switch Connector End View
- Stop Lamp Switch, C1 Connector End View
- Stop Lamp Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Park/Neutral Position Switch Connector End View
- Output Speed Sensor (OSS) Connector, Wiring Harness Side Connector End View
- Cruise Control Brake Switch Connector, Wiring Harness Side Connector End View
- Automatic Transmission Fluid Pressure Manual Valve Position Switch, Wiring Harness Side Connector End View
- 1-2 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- 2-3 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- Torque Converter Clutch Pulse Width Modulated (TCC PWM) Solenoid Valve Connector, Wiring Harness Side Connector End View
- Pressure Control Solenoid Valve, Wiring Harness Side Connector End View
- Input Speed Sensor, Wiring Harness Side Connector End View
- AT Inline Harness Connector, Engine Side Connector End View
- AT Inline Harness Connector, Transmission Side Connector End View
- Door Lock Actuator - Driver Connector End View
- Door Lock Actuator - Passenger Connector End View
- Door Lock Actuator - LR Connector End View
- Door Lock Actuator - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver (Coupe) Connector End View
- Window Switch - Driver C1 (Sedan) Connector End View
- Window Switch - Driver C2 (Sedan) Connector End View
- Window Switch - Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Electronic Brake Control Module (EBCM) Connector End View
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Rear Compartment Lid Release Switch Connector End View
- Rear Compartment Lid Release Actuator Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Steering Wheel Module Connector End View
- Audio Amplifier (U85) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio, C1 Connector End View
- Radio, C2 (U2K) Connector End View
- Speaker - LF Tweeter (U85) Connector End View
- Speaker - LF (U85) Connector End View
- Speaker - LF (UQ8) Connector End View
- Speaker - LR (UQ8) Connector End View
- Speaker - LR (U85) Connector End View
- Speaker - RF Tweeter (U85) Connector End View
- Speaker - RF (UQ8) Connector End View
- Speaker - RF (U85) Connector End View
- Speaker - RR (U85) Connector End View
- Speaker - RR (UQ8) Connector End View
- Coolant Level Switch Connector End View
- Cooling Fan - Left (LA1) Connector End View
- Cooling Fan - Left (L61) Connector End View
- Cooling Fan - Right (LA1) Connector End View
- Cooling Fan - Right (L61) Connector End View
- Generator (LA1) Connector End View
- Generator (L61) Connector End View
- Seat Adjuster Switch - Driver (AG1) Connector End View
- Seat Adjuster Switch - Driver (AH3) Connector End View
- Seat Horizontal Motor (AG1) Connector End View
- Seat Rear Vertical Motor (AG1) Connector End View
- Seat Front Vertical Motor (AG1) Connector End View
- Seat Vertical Motor (AH3) Connector End View
- Ambient Light Sensor Connector End View
- Auxiliary Park Lamp - LF Connector End View
- Auxiliary Park Lamp - RF Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Backup Lamp Switch Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Dome Lamp Connector End View
- Door Ajar Switch - LR Connector End View
- Door Ajar Switch - RR Connector End View
- Door Jamb Switch - LF Connector End View
- Door Jamb Switch - RF Connector End View
- Daytime Running Lamps (DRL) Resistor Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Fog Lamp Switch Connector End View
- Hazard Switch Connector End View
- Headlamp - Left Connector End View
- Headlamp - Right Connector End View
- Inside Rearview Mirror w/Reading Lamps Connector End View
- I/P Compartment Lamp/Switch Connector End View
- I/P Dimmer Switch Connector End View
- I/P Dimming Module Connector End View
- Lamp Assembly - LR Connector End View
- Lamp Assembly - RR Connector End View
- License Lamp Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - RF Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Shift Indicator Lamp Connector End View
- Stop Lamp Switch - C1 Connector End View
- Stop Lamp Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C1 Connector End View
- Turn Signal/Multifunction Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C3 Connector End View
- Rear Window Defogger Grid C1 Connector End View
- Rear Window Defogger Grid C2 Connector End View
- Engine Oil Pressure (EOP) Sensor Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Powertrain Control Module (PCM) C1 (3.4L) Connector End View
- Powertrain Control Module (PCM) C2 (3.4L) Connector End View
- Camshaft Position (CMP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor A (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor B (3.4L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (3.4L) Connector End View
- Exhaust Gas Recirculation (EGR) Valve (3.4L) Connector End View
- Fuel Injector 1 (3.4L) Connector End View
- Fuel Injector 2 (3.4L) Connector End View
- Fuel Injector 3 (3.4L) Connector End View
- Fuel Injector 4 (3.4L) Connector End View
- Fuel Injector 5 (3.4L) Connector End View
- Fuel Injector 6 (3.4L) Connector End View
- Fuel Pump and Sender Assembly (3.4L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (3.4L) Connector End View
- Idle Air Control (IAC) Valve (3.4L) Connector End View
- Ignition Control Module (ICM), C1 (3.4L) Connector End View
- Ignition Control Module (ICM), C2 (3.4L) Connector End View
- Ignition Control Module (ICM), C3 (3.4L) Connector End View
- Intake Air Temperature (IAT) Sensor (3.4L) Connector End View
- Knock Sensor (KS) (3.4L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (3.4L) Connector End View
- Mass Air Flow (MAF) Sensor (3.4L) Connector End View
- Throttle Position (TP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor (2.2L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (2.2L) Connector End View
- Fuel Injector 1 (2.2L) Connector End View
- Fuel Injector 2 (2.2L) Connector End View
- Fuel Injector 3 (2.2L) Connector End View
- Fuel Injector 4 (2.2L) Connector End View
- Fuel Pump and Sender Assembly (2.2L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (2.2L) Connector End View
- Idle Air Control (IAC) Valve (2.2L) Connector End View
- Ignition Control Module (ICM) (2.2L) Connector End View
- Intake Air Temperature (IAT) Sensor (2.2L) Connector End View
- Knock Sensor (KS) (2.2L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (2.2L) Connector End View
- Throttle Position (TP) Sensor (2.2L) Connector End View
- Powertrain Control Module (PCM) C1 (2.2L) Connector End View
- Powertrain Control Module (PCM) C2 (2.2L) Connector End View
- Connector End Views
- Power Outlets
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label
- Fuse Block - Underhood - Top View
- Fuse Block - Underhood - Bottom View
- Fuse Block - Left I/P Label
- Fuse Block - Left I/P - Top View
- Fuse Block - Left I/P, C1, C2 - Bottom View
- Fuse Block - Left I/P, C3 - Bottom View
- Fuse Block - Right I/P Label
- Fuse Block - Right I/P - Top View
- Fuse Block - Right I/P, C1, C2 - Bottom View
- Fuse Block - Right I/P, C3 - Bottom View
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Splice Pack Connector End Views
- Repair Instructions
- Special Tools and Equipment
- OEM Connector End Views
- Starter
- Battery, Charging System And Starting System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC P0560: System Voltage
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0620: Generator Performance
- DTC P0621: Generator L-Terminal Circuit
- DTC P0622: Generator F-Terminal Circuit
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging (Non-HP2)
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click (LA1)
- Starter Solenoid Does Not Click (L61)
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Battery, Charging System And Starting System
- Wiring Diagrams
- OEM Connector End Views
- Connector End Views
- Turn Signal/Multifunction Switch, C3 Connector End View
- Washer Fluid Level Sensor Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Wiper Motor Assembly Connector End View
- Sunroof Motor/Actuator Connector End View
- Sunroof Switch Connector End View
- Air Temperature Actuator Connector End View
- A/C Compressor Clutch Connector End View
- A/C Refrigerant Pressure Sensor Connector End View
- Blower Motor Connector End View
- Blower Motor Resistor Assembly Connector End View
- HVAC Control Assembly, C1 Connector End View
- HVAC Control Assembly, C2 Connector End View
- Body Control Module (BCM), C1 Connector End View
- Body Control Module (BCM), C2 Connector End View
- Body Control Module (BCM), C3 Connector End View
- Data Link Connector (DLC) Connector End View
- Cigar Lighter Connector End View
- Ignition Switch - C1 Connector End View
- Ignition Switch - C2 Connector End View
- Clutch Pedal Position (CPP) Switch Connector End View
- Cruise Control Module (CCM) Connector End View
- TCC/Brake Switch Connector End View
- Seat Belt Switch Connector End View
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Passlock™ Sensor Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Horn Assembly Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Park/Neutral Position (PNP) Switch Connector End View
- Stop Lamp Switch, C1 Connector End View
- Stop Lamp Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Park/Neutral Position Switch Connector End View
- Output Speed Sensor (OSS) Connector, Wiring Harness Side Connector End View
- Cruise Control Brake Switch Connector, Wiring Harness Side Connector End View
- Automatic Transmission Fluid Pressure Manual Valve Position Switch, Wiring Harness Side Connector End View
- 1-2 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- 2-3 Shift Solenoid (SS) Valve Connector, Wiring Harness Side Connector End View
- Torque Converter Clutch Pulse Width Modulated (TCC PWM) Solenoid Valve Connector, Wiring Harness Side Connector End View
- Pressure Control Solenoid Valve, Wiring Harness Side Connector End View
- Input Speed Sensor, Wiring Harness Side Connector End View
- AT Inline Harness Connector, Engine Side Connector End View
- AT Inline Harness Connector, Transmission Side Connector End View
- Door Lock Actuator - Driver Connector End View
- Door Lock Actuator - Passenger Connector End View
- Door Lock Actuator - LR Connector End View
- Door Lock Actuator - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver (Coupe) Connector End View
- Window Switch - Driver C1 (Sedan) Connector End View
- Window Switch - Driver C2 (Sedan) Connector End View
- Window Switch - Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Electronic Brake Control Module (EBCM) Connector End View
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Rear Compartment Lid Release Switch Connector End View
- Rear Compartment Lid Release Actuator Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Steering Wheel Module Connector End View
- Audio Amplifier (U85) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio, C1 Connector End View
- Radio, C2 (U2K) Connector End View
- Speaker - LF Tweeter (U85) Connector End View
- Speaker - LF (U85) Connector End View
- Speaker - LF (UQ8) Connector End View
- Speaker - LR (UQ8) Connector End View
- Speaker - LR (U85) Connector End View
- Speaker - RF Tweeter (U85) Connector End View
- Speaker - RF (UQ8) Connector End View
- Speaker - RF (U85) Connector End View
- Speaker - RR (U85) Connector End View
- Speaker - RR (UQ8) Connector End View
- Coolant Level Switch Connector End View
- Cooling Fan - Left (LA1) Connector End View
- Cooling Fan - Left (L61) Connector End View
- Cooling Fan - Right (LA1) Connector End View
- Cooling Fan - Right (L61) Connector End View
- Generator (LA1) Connector End View
- Generator (L61) Connector End View
- Seat Adjuster Switch - Driver (AG1) Connector End View
- Seat Adjuster Switch - Driver (AH3) Connector End View
- Seat Horizontal Motor (AG1) Connector End View
- Seat Rear Vertical Motor (AG1) Connector End View
- Seat Front Vertical Motor (AG1) Connector End View
- Seat Vertical Motor (AH3) Connector End View
- Ambient Light Sensor Connector End View
- Auxiliary Park Lamp - LF Connector End View
- Auxiliary Park Lamp - RF Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Backup Lamp Switch Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Dome Lamp Connector End View
- Door Ajar Switch - LR Connector End View
- Door Ajar Switch - RR Connector End View
- Door Jamb Switch - LF Connector End View
- Door Jamb Switch - RF Connector End View
- Daytime Running Lamps (DRL) Resistor Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Fog Lamp Switch Connector End View
- Hazard Switch Connector End View
- Headlamp - Left Connector End View
- Headlamp - Right Connector End View
- Inside Rearview Mirror w/Reading Lamps Connector End View
- I/P Compartment Lamp/Switch Connector End View
- I/P Dimmer Switch Connector End View
- I/P Dimming Module Connector End View
- Lamp Assembly - LR Connector End View
- Lamp Assembly - RR Connector End View
- License Lamp Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - RF Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Shift Indicator Lamp Connector End View
- Stop Lamp Switch - C1 Connector End View
- Stop Lamp Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C1 Connector End View
- Turn Signal/Multifunction Switch - C2 Connector End View
- Turn Signal/Multifunction Switch - C3 Connector End View
- Rear Window Defogger Grid C1 Connector End View
- Rear Window Defogger Grid C2 Connector End View
- Engine Oil Pressure (EOP) Sensor Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Powertrain Control Module (PCM) C1 (3.4L) Connector End View
- Powertrain Control Module (PCM) C2 (3.4L) Connector End View
- Camshaft Position (CMP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor A (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor B (3.4L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (3.4L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (3.4L) Connector End View
- Exhaust Gas Recirculation (EGR) Valve (3.4L) Connector End View
- Fuel Injector 1 (3.4L) Connector End View
- Fuel Injector 2 (3.4L) Connector End View
- Fuel Injector 3 (3.4L) Connector End View
- Fuel Injector 4 (3.4L) Connector End View
- Fuel Injector 5 (3.4L) Connector End View
- Fuel Injector 6 (3.4L) Connector End View
- Fuel Pump and Sender Assembly (3.4L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (3.4L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (3.4L) Connector End View
- Idle Air Control (IAC) Valve (3.4L) Connector End View
- Ignition Control Module (ICM), C1 (3.4L) Connector End View
- Ignition Control Module (ICM), C2 (3.4L) Connector End View
- Ignition Control Module (ICM), C3 (3.4L) Connector End View
- Intake Air Temperature (IAT) Sensor (3.4L) Connector End View
- Knock Sensor (KS) (3.4L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (3.4L) Connector End View
- Mass Air Flow (MAF) Sensor (3.4L) Connector End View
- Throttle Position (TP) Sensor (3.4L) Connector End View
- Crankshaft Position (CKP) Sensor (2.2L) Connector End View
- Engine Coolant Temperature (ECT) Sensor (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Purge Solenoid (2.2L) Connector End View
- Evaporative Emission (EVAP) Canister Vent Solenoid (2.2L) Connector End View
- Fuel Injector 1 (2.2L) Connector End View
- Fuel Injector 2 (2.2L) Connector End View
- Fuel Injector 3 (2.2L) Connector End View
- Fuel Injector 4 (2.2L) Connector End View
- Fuel Pump and Sender Assembly (2.2L) Connector End View
- Fuel Tank Pressure (FTP) Sensor (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 1 (2.2L) Connector End View
- Heated Oxygen Sensor (HO2S) Sensor 2 (2.2L) Connector End View
- Idle Air Control (IAC) Valve (2.2L) Connector End View
- Ignition Control Module (ICM) (2.2L) Connector End View
- Intake Air Temperature (IAT) Sensor (2.2L) Connector End View
- Knock Sensor (KS) (2.2L) Connector End View
- Manifold Absolute Pressure (MAP) Sensor (2.2L) Connector End View
- Throttle Position (TP) Sensor (2.2L) Connector End View
- Powertrain Control Module (PCM) C1 (2.2L) Connector End View
- Powertrain Control Module (PCM) C2 (2.2L) Connector End View
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label
- Fuse Block - Underhood - Top View
- Fuse Block - Underhood - Bottom View
- Fuse Block - Left I/P Label
- Fuse Block - Left I/P - Top View
- Fuse Block - Left I/P, C1, C2 - Bottom View
- Fuse Block - Left I/P, C3 - Bottom View
- Fuse Block - Right I/P Label
- Fuse Block - Right I/P - Top View
- Fuse Block - Right I/P, C1, C2 - Bottom View
- Fuse Block - Right I/P, C3 - Bottom View
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Splice Pack Connector End Views
- Repair Instructions
- Special Tools and Equipment
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Cooling System (Mechanical)
- Engine Cooling System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Cooling
- Scan Tool Output Controls (3.4L LA1)
- Scan Tool Output Controls (2.2L L61)
- Scan Tool Data List (LA 1 3.4L)
- Scan Tool Data List (L61 2.2L)
- Scan Tool Data Definitions
- DTC Table
- DTC P0480 or P0481 (L61, 2.2L): Cooling Fan Relay 1 Or Relay 2 Control Circuit
- DTC P0480 or P0481 (LA1, 3.4L): Cooling Fan Relay 1 Or Relay 2 Control Circuit
- Symptoms - Engine Cooling
- Engine Coolant Temperature Indicator Always On
- Low Engine Coolant Indicator Always On
- Cooling Fan Always On
- Cooling Fan Inoperative (3.4L LA1)
- Cooling Fan Inoperative (2.2L L61)
- Engine Overheating
- Loss of Coolant
- Thermostat Diagnosis
- Coolant Heater Inoperative
- Engine Fails To Reach Normal Operating Temperature
- Pressure Cap Testing
- Coolant Leak Testing
- Repair Instructions
- Draining and Filling Cooling System (LA1)
- Draining and Filling Cooling System (L61)
- Flushing
- Radiator Cleaning
- Surge Tank Replacement (LA1)
- Surge Tank Replacement (L61)
- Surge Tank Hose/Pipe Replacement (L61)
- Surge Tank Hose/Pipe Replacement - Outlet (L61)
- Radiator Hose Replacement - Inlet (LA1)
- Radiator Hose Replacement - Inlet (L61)
- Radiator Hose Replacement - Outlet (LA1)
- Radiator Hose Replacement - Outlet (L61)
- Cooling Fan Replacement - Electric
- Cooling Fan Motor Replacement - Electric
- Thermostat Housing Replacement
- Thermostat Replacement (3.4L)
- Thermostat Bypass Pipes Replacement
- Water Pump Replacement (3.4L)
- Drain Cock Replacement
- Fan Shroud Replacement
- Radiator Replacement
- Radiator Support Replacement
- Coolant Heater Replacement (2.2L (L61))
- Coolant Heater Cord Replacement (2.2L (L61))
- Coolant Heater Cord Replacement (3.4L (LA1))
- Description and Operation
- Cooling System Description and Operation
- Special Tools and Equipment
- Engine Cooling System
- Engine Exhaust System
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Lubrication System
- Engine Mechanical - 3.4L
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Mechanical
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Coolant in Combustion Chamber
- Coolant in Engine Oil
- Engine Compression Test
- Cylinder Leakage Test
- Oil Consumption Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Drive Belt Chirping Diagnosis
- Drive Belt Squeal Diagnosis
- Drive Belt Whine Diagnosis
- Drive Belt Rumbling Diagnosis
- Drive Belt Vibration Diagnosis
- Drive Belt Falls Off Diagnosis
- Drive Belt Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- Repair Instructions
- On-Vehicle Repair Instructions
- Drive Belt Replacement
- Drive Belt Tensioner Replacement
- Engine Support Fixture
- Engine Mount Inspection
- Engine Mount Replacement - Right
- Engine Mount Bracket Replacement - Right
- Oil Filter Adapter and Bypass Valve Assembly Replacement
- Oil Level Indicator and Tube Replacement
- Intake Manifold Replacement - Upper
- Intake Manifold Replacement - Lower
- Positive Crankcase Ventilation (PCV) Valve Replacement
- Valve Rocker Arm Cover Replacement - Left
- Valve Rocker Arm Cover Replacement - Right
- Valve Rocker Arm and Push Rod Replacement
- Valve Stem Oil Seal and Valve Spring Replacement
- Valve Lifter Replacement
- Crankshaft Balancer Replacement
- Oil Pan Replacement
- Engine Oil Pressure Sensor and/or Switch Replacement
- Oil Pump Replacement
- Oil Pump Drive Replacement
- Crankshaft Front Oil Seal Replacement
- Engine Front Cover Replacement
- Timing Chain and Sprockets Replacement
- Cylinder Head Replacement - Left
- Cylinder Head Replacement - Right
- Engine Flywheel Replacement
- Crankshaft Rear Oil Seal Replacement
- Camshaft Rear Bearing Hole Plug Replacement
- Engine Replacement
- Engine Oil and Oil Filter Replacement
- Off-Vehicle Repair Instructions
- Draining Fluids and Oil Filter Removal
- Crankshaft Balancer Removal
- Engine Flywheel Removal
- Drive Belt Tensioner Removal
- Engine Mount Support and Strut Bracket Removal
- Engine Lift Bracket and Generator Bracket Removal
- Oil Level Indicator and Tube Removal
- Oil Filter Adapter Removal
- Exhaust Manifold Removal - Left
- Exhaust Manifold Removal - Right
- Water Outlet and Thermostat Removal
- Valve Rocker Arm Cover Removal - Left
- Valve Rocker Arm Cover Removal - Right
- Intake Manifold Removal - Upper
- Intake Manifold Removal - Lower
- Valve Rocker Arm and Push Rod Removal
- Valve Lifter Removal
- Water Pump Removal
- Cylinder Head Removal - Left
- Cylinder Head Removal - Right
- Oil Pan Removal
- Oil Pump Removal
- Oil Pump Drive Removal
- Crankshaft Front Oil Seal Removal
- Engine Front Cover Removal
- Timing Chain and Sprockets Removal
- Camshaft Removal
- Piston, Connecting Rod, and Bearing Removal
- Crankshaft Rear Oil Seal Removal
- Crankshaft and Bearings Removal
- Camshaft Bearing Removal
- Engine Block Disassemble
- Engine Block Cleaning and Inspection
- Cylinder Boring and Honing
- Engine Block Assemble
- Crankshaft and Bearings Cleaning and Inspection
- Crankshaft Balancer Cleaning and Inspection
- Engine Flywheel Cleaning and Inspection
- Piston and Connecting Rod Disassemble
- Piston, Connecting Rod, and Bearings Cleaning and Inspection
- Piston and Connecting Rod Assemble
- Camshaft and Bearings Cleaning and Inspection
- Timing Chain and Sprockets Cleaning and Inspection
- Valve Lifters Cleaning and Inspection
- Valve Rocker Arm and Push Rods Cleaning and Inspection
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Valve Guide Reaming/Valve and Seat Grinding
- Cylinder Head Assemble
- Oil Pump Disassemble
- Oil Pump Cleaning and Inspection
- Oil Pump Assemble
- Engine Front Cover Cleaning and Inspection
- Valve Rocker Arm Cover Cleaning and Inspection
- Oil Pan Cleaning and Inspection
- Intake Manifold Cleaning and Inspection - Lower
- Intake Manifold Cleaning and Inspection - Upper
- Exhaust Manifold Cleaning and Inspection
- Water Pump Cleaning and Inspection
- Thread Repair
- Service Prior to Assembly
- Camshaft Bearing Installation
- Crankshaft and Bearings Installation
- Crankshaft Rear Oil Seal Installation
- Piston, Connecting Rod, and Bearing Installation
- Camshaft Installation
- Timing Chain and Sprockets Installation
- Engine Front Cover Installation
- Crankshaft Front Oil Seal Installation
- Oil Pump Drive Installation
- Oil Pump Installation
- Oil Pan Installation
- Cylinder Head Installation - Left
- Cylinder Head Installation - Right
- Water Pump Installation
- Valve Lifter Installation
- Valve Rocker Arm and Push Rod Installation
- Intake Manifold Installation - Lower
- Intake Manifold Installation - Upper
- Valve Rocker Arm Cover Installation - Right
- Valve Rocker Arm Cover Installation - Left
- Water Outlet and Thermostat Installation
- Exhaust Manifold Installation - Left
- Exhaust Manifold Installation - Right
- Oil Filter Adapter Installation
- Oil Level Indicator and Tube Installation
- Engine Lift Bracket and Generator Bracket Installation
- Engine Mount Support and Strut Bracket Installation
- Drive Belt Tensioner Installation
- Engine Flywheel Installation
- Crankshaft Balancer Installation
- Engine Prelubing
- On-Vehicle Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Starter
- Battery, Charging System And Starting System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC P0560: System Voltage
- DTC P0562: System Voltage Low
- DTC P0563: System Voltage High
- DTC P0620: Generator Performance
- DTC P0621: Generator L-Terminal Circuit
- DTC P0622: Generator F-Terminal Circuit
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging (Non-HP2)
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click (LA1)
- Starter Solenoid Does Not Click (L61)
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Battery, Charging System And Starting System
- Cooling System (Mechanical)
- Engine Performance
- Emissions
- EGR Function Testing - General Motors Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - PONTIAC
- Specifications
- System
- Engine Controls - 3.4L - Introduction
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Mass Air Flow (MAF) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor Replacement - Position 1
- Heated Oxygen Sensor Replacement - Position 2
- Throttle Position (TP) Sensor Replacement
- Idle Air Control (IAC) Valve Replacement
- Accelerator Controls Cable Replacement
- Accelerator Controls Pedal Replacement
- Accelerator Controls Cable Bracket Replacement
- Throttle Body Assembly Replacement
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Tank Replacement
- Fuel Tank Pressure Sensor Replacement
- Fuel Level Sensor Replacement
- Filler Tube Replacement
- Fuel Sender Assembly Replacement
- Fuel Hose/Pipes Replacement - Engine Compartment
- Fuel Hose/Pipes Replacement - Chassis
- Fuel System Cleaning
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Fuel Injector Cleaning Procedure
- Fuel Injector Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Canister/Fuel Tank
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine/Chassis
- Evaporative Emission (EVAP) Canister Replacement
- Evaporative Emission (EVAP) System Cleaning
- Ignition Coil(s) Replacement
- Ignition Control Module Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement (7X Sensor)
- Crankshaft Position (CKP) Sensor Replacement (24X Sensor)
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Pipe Replacement
- Exhaust Gas Recirculation (EGR) System Cleaning
- Air Cleaner Intake Duct Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Notes
- PCM Function
- EEPROM
- Data Link Connector (DLC)
- Malfunction Indicator Lamp (MIL) Operation
- PCM Service Precautions
- Emissions Diagnosis For State I/M Programs
- Aftermarket (Add-On) Electrical And Vacuum Equipment
- Electrostatic Discharge (ESD) Damage
- Emissions Control Information Label
- Underhood Inspection
- Basic Knowledge Required
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Short Term Fuel Trim
- Long Term Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Powertrain Control Module (PCM) Description
- Special Tools and Equipment
- Engine Controls - 3.4L - Diagnostic Starting Point
- Engine Controls - 3.4L - DTC P0016 To DTC P0138
- Diagnostic Information & Procedures
- DTC Table
- DTC P0016: Crankshaft Position (CKP) - Camshaft Position (CMP) Correlation
- DTC P0030: HO2S Heater Control Circuit Bank 1 Sensor 1
- DTC P0036: HO2S Heater Control Circuit Bank 1 Sensor 2
- DTC P0101: Mass Air Flow (MAF) Sensor Performance
- DTC P0102: Mass Air Flow (MAF) Sensor Circuit Low Frequency
- DTC P0103: Mass Air Flow (MAF) Sensor Circuit High Frequency
- DTC P0107: Manifold Absolute Pressure (MAP) Sensor Circuit Low Voltage
- DTC P0108: Manifold Absolute Pressure (MAP) Sensor Circuit High Voltage
- DTC P0112: Intake Air Temperature (IAT) Sensor Circuit Low Voltage
- DTC P0113: Intake Air Temperature (IAT) Sensor Circuit High Voltage
- DTC P0116: Engine Coolant Temperature (ECT) Sensor Performance
- DTC P0117: Engine Coolant Temperature (ECT) Sensor Circuit Low Voltage
- DTC P0118: Engine Coolant Temperature (ECT) Sensor Circuit High Voltage
- DTC P0121: Throttle Position (TP) Sensor Performance
- DTC P0122: Throttle Position (TP) Sensor Circuit Low Voltage
- DTC P0123: Throttle Position (TP) Sensor Circuit High Voltage
- DTC P0125: Engine Coolant Temperature (ECT) Insufficient for Closed Loop Fuel Control
- DTC P0128: Engine Coolant Temperature (ECT) Below Thermostat Regulating Temperature
- DTC P0131: HO2S Circuit Low Voltage Bank 1 Sensor 1
- DTC P0132: HO2S Circuit High Voltage Bank 1 Sensor 1
- DTC P0133: HO2S Slow Response Bank 1 Sensor 1
- DTC P0134: HO2S Insufficient Activity Bank 1 Sensor 1
- DTC P0135: HO2S Heater Performance Bank 1 Sensor 1
- DTC P0137: HO2S Circuit Low Voltage Bank 1 Sensor 2
- DTC P0138: HO2S Circuit High Voltage Bank 1 Sensor 2
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - DTC P0140 To DTC P0443
- Diagnostic Information & Procedures
- DTC Table
- DTC P0140: HO2S Circuit Insufficient Activity Bank 1 Sensor 2
- DTC P0141: HO2S Heater Performance Bank 1 Sensor 2
- DTC P0171: Fuel Trim System Lean Bank 1
- DTC P0172: Fuel Trim System Rich Bank 1
- DTC P0201-P0206: Injector Control Circuit(s)
- DTC P0230: Fuel Pump Relay Control Circuit
- DTC P0300-P0306: Engine Misfire Detected
- DTC P0315: Crankshaft Position (CKP) System Variation Not Learned
- DTC P0325: Knock Sensor (KS) Module Performance
- DTC P0327: Knock Sensor (KS) Circuit
- DTC P0335: Crankshaft Position (CKP) Sensor A Circuit
- DTC P0336: Crankshaft Position (CKP) Sensor A Performance
- DTC P0340: Camshaft Position (CMP) Sensor Circuit
- DTC P0341: Camshaft Position (CMP) Sensor Performance
- DTC P0350: Ignition Coil Control Circuit
- DTC P0385: Crankshaft Position (CKP) Sensor B Circuit
- DTC P0386: Crankshaft Position (CKP) Sensor B Performance
- DTC P0401: Exhaust Gas Recirculation (EGR) Flow Insufficient
- DTC P0403: Exhaust Gas Recirculation (EGR) Solenoid Control Circuit
- DTC P0404: Exhaust Gas Recirculation (EGR) Open Position Performance
- DTC P0405: Exhaust Gas Recirculation (EGR) Position Sensor Circuit Low Voltage
- DTC P0406: Exhaust Gas Recirculation (EGR) Position Sensor Circuit High Voltage
- DTC P0420: Catalyst System Low Efficiency Bank 1
- DTC P0442: Evaporative Emission (EVAP) System Small Leak Detected
- DTC P0443: Evaporative Emission (EVAP) Purge Solenoid Control Circuit
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - DTC P0446 To DTC P1640
- Diagnostic Information & Procedures
- DTC Table
- DTC P0446: Evaporative Emission (EVAP) Vent System Performance
- DTC P0449: Evaporative Emission (EVAP) Vent Solenoid Control Circuit
- DTC P0452: Fuel Tank Pressure (FTP) Sensor Circuit Low Voltage
- DTC P0453: Fuel Tank Pressure (FTP) Sensor Circuit High Voltage
- DTC P0455: Evaporative Emission (EVAP) System Large Leak Diagnostic
- DTC P0496: Evaporative Emission (EVAP) System Flow During Non-Purge
- DTC P0506: Idle Speed Low
- DTC P0507: Idle Speed High
- DTC P0601 To P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610: Control Module Communication Malfunction(s)
- DTC P0641: 5-Volt Reference 1 Circuit
- DTC P0650: Malfunction Indicator Lamp (MIL) Control Circuit
- DTC P0651: 5-Volt Reference 2 Circuit
- DTC P1106: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent High Voltage
- DTC P1107: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent Low Voltage
- DTC P1111: Intake Air Temperature (IAT) Sensor Circuit Intermittent High Voltage
- DTC P1112: Intake Air Temperature (IAT) Sensor Circuit Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent High Voltage
- DTC P1121: Throttle Position (TP) Sensor Circuit Intermittent High Voltage
- DTC P1122: Throttle Position (TP) Sensor Circuit Intermittent Low Voltage
- DTC P1133: HO2S Insufficient Switching Bank 1 Sensor 1
- DTC P1134: HO2S Transition Time Ratio Bank 1 Sensor 1
- DTC P1350: Ignition Bypass Circuit
- DTC P1404: Exhaust Gas Recirculation (EGR) Closed Position Performance
- DTC P1640: Control Module Output A Circuit
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - DTC P1650 To DTC P2A01
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - Troubleshooting & Diagnosis
- Diagnostic Information & Procedures
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Injector Balance Test with Tech 2
- Fuel Injector Circuit Diagnosis
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (Without Special Tool)
- Alcohol/Contaminants-in-Fuel Diagnosis (With Special Tool)
- Manifold Absolute Pressure (MAP) Sensor Diagnosis
- Idle Air Control (IAC) System Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Crankshaft Position Sensor (CKP) System Diagnosis
- Inspection/Maintenance (I/M) System Check
- Inspection/Maintenance (I/M) Complete System Set Procedure
- Inspection/Maintenance (I/M) System DTC Table
- Inspection/Maintenance (I/M) Catalyst System Set Procedure
- Inspection/Maintenance (I/M) Exhaust Gas Recirculation (EGR) System Set Procedure
- Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor/Oxygen Sensor (HO2S/O2S) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor (HO2S) Heater System Set Procedure
- Service Bay Test
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - Introduction
- Testing & Diagnosis
- Engine Controls - 3.4L - Introduction
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Intake Air Temperature (IAT) Sensor Replacement
- Mass Air Flow (MAF) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor Replacement - Position 1
- Heated Oxygen Sensor Replacement - Position 2
- Throttle Position (TP) Sensor Replacement
- Idle Air Control (IAC) Valve Replacement
- Accelerator Controls Cable Replacement
- Accelerator Controls Pedal Replacement
- Accelerator Controls Cable Bracket Replacement
- Throttle Body Assembly Replacement
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Tank Replacement
- Fuel Tank Pressure Sensor Replacement
- Fuel Level Sensor Replacement
- Filler Tube Replacement
- Fuel Sender Assembly Replacement
- Fuel Hose/Pipes Replacement - Engine Compartment
- Fuel Hose/Pipes Replacement - Chassis
- Fuel System Cleaning
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Fuel Injector Cleaning Procedure
- Fuel Injector Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Canister/Fuel Tank
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine/Chassis
- Evaporative Emission (EVAP) Canister Replacement
- Evaporative Emission (EVAP) System Cleaning
- Ignition Coil(s) Replacement
- Ignition Control Module Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement (7X Sensor)
- Crankshaft Position (CKP) Sensor Replacement (24X Sensor)
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Pipe Replacement
- Exhaust Gas Recirculation (EGR) System Cleaning
- Air Cleaner Intake Duct Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Notes
- PCM Function
- EEPROM
- Data Link Connector (DLC)
- Malfunction Indicator Lamp (MIL) Operation
- PCM Service Precautions
- Emissions Diagnosis For State I/M Programs
- Aftermarket (Add-On) Electrical And Vacuum Equipment
- Electrostatic Discharge (ESD) Damage
- Emissions Control Information Label
- Underhood Inspection
- Basic Knowledge Required
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Short Term Fuel Trim
- Long Term Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Powertrain Control Module (PCM) Description
- Special Tools and Equipment
- Engine Controls - 3.4L - Diagnostic Starting Point
- Engine Controls - 3.4L - DTC P0016 To DTC P0138
- Diagnostic Information & Procedures
- DTC Table
- DTC P0016: Crankshaft Position (CKP) - Camshaft Position (CMP) Correlation
- DTC P0030: HO2S Heater Control Circuit Bank 1 Sensor 1
- DTC P0036: HO2S Heater Control Circuit Bank 1 Sensor 2
- DTC P0101: Mass Air Flow (MAF) Sensor Performance
- DTC P0102: Mass Air Flow (MAF) Sensor Circuit Low Frequency
- DTC P0103: Mass Air Flow (MAF) Sensor Circuit High Frequency
- DTC P0107: Manifold Absolute Pressure (MAP) Sensor Circuit Low Voltage
- DTC P0108: Manifold Absolute Pressure (MAP) Sensor Circuit High Voltage
- DTC P0112: Intake Air Temperature (IAT) Sensor Circuit Low Voltage
- DTC P0113: Intake Air Temperature (IAT) Sensor Circuit High Voltage
- DTC P0116: Engine Coolant Temperature (ECT) Sensor Performance
- DTC P0117: Engine Coolant Temperature (ECT) Sensor Circuit Low Voltage
- DTC P0118: Engine Coolant Temperature (ECT) Sensor Circuit High Voltage
- DTC P0121: Throttle Position (TP) Sensor Performance
- DTC P0122: Throttle Position (TP) Sensor Circuit Low Voltage
- DTC P0123: Throttle Position (TP) Sensor Circuit High Voltage
- DTC P0125: Engine Coolant Temperature (ECT) Insufficient for Closed Loop Fuel Control
- DTC P0128: Engine Coolant Temperature (ECT) Below Thermostat Regulating Temperature
- DTC P0131: HO2S Circuit Low Voltage Bank 1 Sensor 1
- DTC P0132: HO2S Circuit High Voltage Bank 1 Sensor 1
- DTC P0133: HO2S Slow Response Bank 1 Sensor 1
- DTC P0134: HO2S Insufficient Activity Bank 1 Sensor 1
- DTC P0135: HO2S Heater Performance Bank 1 Sensor 1
- DTC P0137: HO2S Circuit Low Voltage Bank 1 Sensor 2
- DTC P0138: HO2S Circuit High Voltage Bank 1 Sensor 2
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - DTC P0140 To DTC P0443
- Diagnostic Information & Procedures
- DTC Table
- DTC P0140: HO2S Circuit Insufficient Activity Bank 1 Sensor 2
- DTC P0141: HO2S Heater Performance Bank 1 Sensor 2
- DTC P0171: Fuel Trim System Lean Bank 1
- DTC P0172: Fuel Trim System Rich Bank 1
- DTC P0201-P0206: Injector Control Circuit(s)
- DTC P0230: Fuel Pump Relay Control Circuit
- DTC P0300-P0306: Engine Misfire Detected
- DTC P0315: Crankshaft Position (CKP) System Variation Not Learned
- DTC P0325: Knock Sensor (KS) Module Performance
- DTC P0327: Knock Sensor (KS) Circuit
- DTC P0335: Crankshaft Position (CKP) Sensor A Circuit
- DTC P0336: Crankshaft Position (CKP) Sensor A Performance
- DTC P0340: Camshaft Position (CMP) Sensor Circuit
- DTC P0341: Camshaft Position (CMP) Sensor Performance
- DTC P0350: Ignition Coil Control Circuit
- DTC P0385: Crankshaft Position (CKP) Sensor B Circuit
- DTC P0386: Crankshaft Position (CKP) Sensor B Performance
- DTC P0401: Exhaust Gas Recirculation (EGR) Flow Insufficient
- DTC P0403: Exhaust Gas Recirculation (EGR) Solenoid Control Circuit
- DTC P0404: Exhaust Gas Recirculation (EGR) Open Position Performance
- DTC P0405: Exhaust Gas Recirculation (EGR) Position Sensor Circuit Low Voltage
- DTC P0406: Exhaust Gas Recirculation (EGR) Position Sensor Circuit High Voltage
- DTC P0420: Catalyst System Low Efficiency Bank 1
- DTC P0442: Evaporative Emission (EVAP) System Small Leak Detected
- DTC P0443: Evaporative Emission (EVAP) Purge Solenoid Control Circuit
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - DTC P0446 To DTC P1640
- Diagnostic Information & Procedures
- DTC Table
- DTC P0446: Evaporative Emission (EVAP) Vent System Performance
- DTC P0449: Evaporative Emission (EVAP) Vent Solenoid Control Circuit
- DTC P0452: Fuel Tank Pressure (FTP) Sensor Circuit Low Voltage
- DTC P0453: Fuel Tank Pressure (FTP) Sensor Circuit High Voltage
- DTC P0455: Evaporative Emission (EVAP) System Large Leak Diagnostic
- DTC P0496: Evaporative Emission (EVAP) System Flow During Non-Purge
- DTC P0506: Idle Speed Low
- DTC P0507: Idle Speed High
- DTC P0601 To P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610: Control Module Communication Malfunction(s)
- DTC P0641: 5-Volt Reference 1 Circuit
- DTC P0650: Malfunction Indicator Lamp (MIL) Control Circuit
- DTC P0651: 5-Volt Reference 2 Circuit
- DTC P1106: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent High Voltage
- DTC P1107: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent Low Voltage
- DTC P1111: Intake Air Temperature (IAT) Sensor Circuit Intermittent High Voltage
- DTC P1112: Intake Air Temperature (IAT) Sensor Circuit Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent High Voltage
- DTC P1121: Throttle Position (TP) Sensor Circuit Intermittent High Voltage
- DTC P1122: Throttle Position (TP) Sensor Circuit Intermittent Low Voltage
- DTC P1133: HO2S Insufficient Switching Bank 1 Sensor 1
- DTC P1134: HO2S Transition Time Ratio Bank 1 Sensor 1
- DTC P1350: Ignition Bypass Circuit
- DTC P1404: Exhaust Gas Recirculation (EGR) Closed Position Performance
- DTC P1640: Control Module Output A Circuit
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - DTC P1650 To DTC P2A01
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - Troubleshooting & Diagnosis
- Diagnostic Information & Procedures
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Injector Balance Test with Tech 2
- Fuel Injector Circuit Diagnosis
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (Without Special Tool)
- Alcohol/Contaminants-in-Fuel Diagnosis (With Special Tool)
- Manifold Absolute Pressure (MAP) Sensor Diagnosis
- Idle Air Control (IAC) System Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Crankshaft Position Sensor (CKP) System Diagnosis
- Inspection/Maintenance (I/M) System Check
- Inspection/Maintenance (I/M) Complete System Set Procedure
- Inspection/Maintenance (I/M) System DTC Table
- Inspection/Maintenance (I/M) Catalyst System Set Procedure
- Inspection/Maintenance (I/M) Exhaust Gas Recirculation (EGR) System Set Procedure
- Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor/Oxygen Sensor (HO2S/O2S) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor (HO2S) Heater System Set Procedure
- Service Bay Test
- Diagnostic Information & Procedures
- Engine Controls - 3.4L - Introduction
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles - 3.4L
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- General Information
- Introduction
- Conversion - English/Metric
- Equivalents - Decimal and Metric
- Arrows and Symbols
- Special Tools Ordering Information
- Diagnostic Work Sheets
- Training
- Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage
- Label - Vehicle Certification, Tire Place Card, Anti-Theft and Service Parts ID
- RPO Code Description
- Fasteners
- Thread Inserts
- Abbreviations and Meanings
- Registered and Non-Registered Trademarks
- Key and Lock Cylinder Coding
- Lifting and Jacking the Vehicle
- Strategy Based Diagnosis
- Introduction
- General Information
- Identification
- Metric Conversions
- OEM General Information
- Automatic Stop/Start Disable
- Cautions And Notices
- Introduction
- Definition of Caution, Notice, and Important
- ABS Component Handling Caution
- Approved Equipment for Collision Repair Caution
- Assistant Driving Caution
- Batteries Produce Explosive Gases Caution
- Battery Disconnect Caution
- Brake Dust Caution
- Brake Fluid Irritant Caution
- Breathing R-134a Caution
- Checking Hot Transmission Fluid through Drain Plug Hole Caution
- Cleaning Solvent Caution
- Clutch Dust Caution
- Electric Coolant Fan Caution
- Express Window Down Caution
- Eye Protection Caution
- Failure to Prep Primer Caution
- Fuel and EVAP Pipe Caution
- Fuel Gage Leak Caution
- Fuel Pipe Fitting Caution
- Fuel Rail Stop Bracket Installation Caution
- Fuel Storage Caution
- Gasoline/Gasoline Vapors Caution
- Glass and Sheet Metal Handling Caution
- Halogen Bulb Caution
- Lower O-Ring Removal Caution
- Moving Parts and Hot Surfaces Caution
- On-Vehicle Fire Extinguisher Caution
- Radiator Cap Removal Caution
- Relieving Fuel Pressure Caution
- Road Test Caution
- Safety Glasses Caution
- Safety Glasses and Compressed Air Caution
- Safety Goggles and Fuel Caution
- SIR Caution
- SIR Deployed Inflator Modules Are Hot Caution
- SIR Inflator Module Coil Caution
- SIR Inflatable Module Deployment Outside Vehicle Caution
- SIR Inflator Module Disposal Caution
- SIR Inflator Module Handling and Storage Caution
- SIR Special Tool Caution
- Tilt Spring Caution
- Vehicle Lifting Caution
- Window Retention Caution
- Work Stall Test Caution
- Apply Tape When Removing Body Panel Notice
- Belt Dressing Notice
- Brake Fluid Damage to Electrical Connections Notice
- Brake Fluid Effects on Paint and Electrical Components Notice
- Catalytic Converter Movement Notice
- Clearcoat/Ultraviolet Screeners Notice
- Clutch Hydraulic System Lubricant Notice
- Component Fastener Tightening Notice
- Cover and Plug Openings Notice
- Drive Axle Notice
- Emission Modification Notice
- Engine Emission Notice
- Excessive Force and Oxygen Sensor Notice
- Exterior Trim Emblem Removal Notice
- Fastener Notice
- Fuel Pressure Notice
- Fuel Tank Strap Fastener Notice
- Handling ESD Sensitive Parts Notice
- Handling IAC Valve Notice
- Heated Oxygen and Oxygen Sensor Notice
- Ignition OFF When Disconnecting Battery Notice
- Installing Hoses without Twists or Bends Notice
- Liftgate Assist Rod Notice
- Nylon Fuel Lines Notice
- OBDII Symbol Description Notice
- Oxygen Sensor Notice
- PCM and ESD Notice
- Pipe Wrench Positioning Notice
- Power Steering Hose Disconnected Notice
- Sealant Notice
- Service Programming System (SPS) Notice
- Silicon Contamination of Heated Oxygen Sensors Notice
- Single Cylinder Flooding Notice
- Steering Column in Lock Position Notice
- Steering Wheel in the Full Turn Position Notice
- Suspension Spring Handling Notice
- Test Lamp to Ignition Control Module Circuit Connector Notice
- Test Probe Notice
- Three-Way Catalytic Converter Damage Notice
- Transmission Fluid Vent Cap Removal Notice
- Window Edge Damage Notice
- Introduction
- General Information
- Introduction
- Conversion - English/Metric
- Equivalents - Decimal and Metric
- Arrows and Symbols
- Special Tools Ordering Information
- Diagnostic Work Sheets
- Training
- Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage
- Label - Vehicle Certification, Tire Place Card, Anti-Theft and Service Parts ID
- RPO Code Description
- Fasteners
- Thread Inserts
- Abbreviations and Meanings
- Registered and Non-Registered Trademarks
- Key and Lock Cylinder Coding
- Lifting and Jacking the Vehicle
- Strategy Based Diagnosis
- Introduction
- Vehicle DTC Information
- Vibration Symptoms Diagnosis And Correction
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Vibration Diagnosis and Correction
- Vibration Analysis - Road Testing
- Component Rotational Speed Calculation
- Vibration Analysis - Tire and Wheel
- Vibration Analysis - Hub and/or Axle Input
- Vibration Analysis - Engine
- Engine Order Classification
- Vibration Analysis - Engine/Accessory Isolation
- Vibration Analysis - Engine Balance
- Vibration Diagnostic Aids
- Vibration Diagnostic Aids - Vibration Intermittent or Not Duplicated
- Vibration Diagnostic Aids - Vibration Duplicated, Component Not Identified
- Vibration Diagnostic Aids - Vibration Duplicated, Difficult to Isolate/Balance Component
- Vibration Diagnostic Aids - Vibration Duplicated, Appears to Be Potential Operating Characteristic
- Symptoms - Vibration Diagnosis and Correction
- Vehicle-to-Vehicle Diagnostic Comparison
- Tire and Wheel Inspection
- Tire and Wheel Assembly Runout Measurement - On-Vehicle
- Tire and Wheel Assembly Runout Measurement - Off-Vehicle
- Brake Rotor/Drum Balance Inspection
- Hub/Axle Flange and Wheel Stud Runout Inspection
- Tire and Wheel Assembly Isolation Test
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Reset Procedures
- ATEQ TPMS Reset Procedure
- Maintenance And Lubrication
- Maintenance Reminder Light (Reset Procedures)
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Engine Oil Replacement Reminder Reset - Procedure 29
- Engine Oil Replacement Reminder Reset - Procedure 30
- Engine Oil Replacement Reminder Reset - Procedure 31
- Engine Oil Replacement Reminder Reset - Procedure 32
- Engine Oil Replacement Reminder Reset - Procedure 33
- Engine Oil Replacement Reminder Reset - Procedure 34
- Engine Oil Replacement Reminder Reset - Procedure 35
- Engine Oil Replacement Reminder Reset - Procedure 36
- Engine Oil Replacement Reminder Reset - Procedure 37
- Emissions Maintenance Reminder (Reminder Flag)
- Emissions Maintenance Reminder (Warning Light)
- Emissions Maintenance Reminder (Check Engine Light)
- Diesel Fuel Filter Replacement Reminder
- Maintenance Service Reminder
- Timing Belt Replacement Reminder
- Transmission Fluid Replacement Reminder
- Tire Pressure Monitor System Reminder
- Notes
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 06
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- TPMS Reminder Reset - Procedure 11
- TPMS Reminder Reset - Procedure 12
- TPMS Reminder Reset - Procedure 13
- TPMS Reminder Reset - Procedure 14
- TPMS Reminder Reset - Procedure 15
- TPMS Reminder Reset - Procedure 16
- TPMS Reminder Reset - Procedure 17
- TPMS Reminder Reset - Procedure 18
- TPMS Reminder Reset - Procedure 19
- TPMS Reminder Reset - Procedure 20
- TPMS Reminder Reset - Procedure 21
- TPMS Reminder Reset - Procedure 22
- TPMS Reminder Reset - Procedure 23
- TPMS Reminder Reset - Procedure 24
- TPMS Reminder Reset - Procedure 25
- TPMS Reminder Reset - Procedure 26
- TPMS Reminder Reset - Procedure 27
- TPMS Reminder Reset - Procedure 28
- TPMS Reminder Reset - Procedure 29
- TPMS Reminder Reset - Procedure 30
- TPMS Reminder Reset - Procedure 31
- TPMS Reminder Reset - Procedure 32
- TPMS Reminder Reset - Procedure 33
- TPMS Reminder Reset - Procedure 34
- TPMS Reminder Reset - Procedure 35
- TPMS Reminder Reset - Procedure 36
- TPMS Reminder Reset - Procedure 37
- Engine Oil Replacement Reminder
- RPO Codes
- General Information
- Introduction
- Conversion - English/Metric
- Equivalents - Decimal and Metric
- Arrows and Symbols
- Special Tools Ordering Information
- Diagnostic Work Sheets
- Training
- Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage
- Label - Vehicle Certification, Tire Place Card, Anti-Theft and Service Parts ID
- RPO Code Description
- Fasteners
- Thread Inserts
- Abbreviations and Meanings
- Registered and Non-Registered Trademarks
- Key and Lock Cylinder Coding
- Lifting and Jacking the Vehicle
- Strategy Based Diagnosis
- Introduction
- General Information
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- HVAC Control Systems
- Heating, Ventilation And Air Conditioning
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Heating, Ventilation and Air Conditioning
- Leak Testing
- Air Conditioning (A/C) System Performance Test
- Air Conditioning (A/C) Diagnostics - Pressure Zone A
- Air Conditioning (A/C) Diagnostics - Pressure Zone B
- Air Conditioning (A/C) Diagnostics - Pressure Zone C
- Air Conditioning (A/C) Diagnostics - Pressure Zone D
- Heating Performance Diagnostic
- Defrosting Insufficient
- Noise Diagnosis - Blower Motor
- Noise Diagnosis - Air Conditioning (A/C) System
- Noise Diagnosis - HVAC Module
- Odor Diagnosis
- Repair Instructions
- Odor Correction
- Refrigerant Recovery and Recharging
- Flushing (LA1)
- Flushing (L61)
- Compressor Oil Balancing
- Compressor Replacement (L61)
- Compressor Replacement (LA1)
- Compressor Clutch Plate and Hub Assembly Removal (V5 - Direct Mount)
- Clutch Rotor and/or Bearing Removal (V5 - Direct Mount)
- Compressor Clutch Coil Removal (V5 - Direct Mount)
- Compressor Control Valve Assembly Removal (V5 - Direct Mount)
- Compressor Pressure Relief Valve Removal (CVC - Direct Mount)
- Compressor Pressure Relief Valve Removal (V5 - Direct Mount)
- Compressor Control Valve Assembly Install (V5 - Direct Mount)
- Compressor Clutch Plate/Hub Assembly Install (V5 - Direct Mount)
- Clutch Rotor and/or Bearing Install (V5 - Direct Mount)
- Compressor Clutch Coil Install (V5 - Direct Mount)
- Compressor Pressure Relief Valve Install (CVC - Direct Mount)
- Compressor Pressure Relief Valve Install (V5 - Direct Mount)
- Compressor Leak Testing (CVC7)
- Compressor Clutch Assembly Replacement (CVC )
- Clutch Rotor and/or Bearing Replacement (V-5 Direct Mount)
- Sealing Washer Replacement
- O-Ring Replacement
- Compressor Hose Assembly Replacement (LA1)
- Compressor Hose Assembly Replacement (L61)
- Evaporator Hose Assembly Replacement
- Expansion (Orifice) Tube Replacement
- Compressor Relay Replacement
- Service Ports Replacement
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement
- Condenser Replacement
- Accumulator Replacement
- HVAC Module Assembly Replacement
- Evaporator Core Replacement
- Heater Hose Replacement - Inlet (L61)
- Heater Hose Replacement - Inlet (LA1)
- Heater Hose Replacement - Outlet (L61)
- Heater Hose Replacement - Outlet (LA1)
- Blower Motor Relay Replacement
- Blower Motor Resistor Assembly Replacement
- Blower Motor Replacement
- Air Outlet Replacement - Instrument Panel - Left (Pontiac)
- Air Outlet Replacement - Instrument Panel - Center (Pontiac)
- Air Outlet Replacement - Instrument Panel - Right (Pontiac)
- Air Outlet Replacement - Defroster
- Air Outlet Replacement - Floor
- Air Outlet Replacement - Rear Floor
- Air Distribution Duct Replacement
- Defogger Outlet Duct Replacement - Side Window, LH (Pontiac)
- Defogger Outlet Duct Replacement - Side Window, RH (Pontiac)
- Vacuum Tank Replacement
- Vacuum Hose Harness Replacement
- Air Temperature Door Replacement
- Defroster Door Replacement
- Mode Door Replacement
- Recirculation Door Replacement
- Heater Door Replacement
- Heater Core Replacement
- Special Tools and Equipment
- HVAC Systems - Manual
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC P0530: Air Conditioning (A/C) Refrigerant Pressure Sensor Circuit
- DTC P0645: Air Conditioning (A/C) Clutch Relay Control Circuit
- Symptoms - HVAC Systems - Manual
- HVAC Compressor Clutch Does Not Engage
- HVAC Compressor Clutch Does Not Disengage
- Blower Motor Always On
- Blower Motor Inoperative
- Blower Motor Malfunction
- Too Hot in Vehicle
- Too Cold in Vehicle (Pontiac)
- Air Delivery Improper (Oldsmobile)
- Air Delivery Improper (Pontiac)
- Air Recirculation Malfunction (Oldsmobile Only)
- Vacuum Control System Diagnostic
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Heating, Ventilation And Air Conditioning
- HVAC Control Systems
- Maintenance
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - SIR
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC Table
- DTC B0016, B0017 or B0018: Passenger Frontal Deployment Loop (Single Stage or Stage 1) Malfunction(s)
- DTC B0022, B0024, or B0026: Driver Frontal Deployment Loop (Single Stage or Stage 1) Malfunction(s)
- DTC B0051: Deployment Commanded
- DTC B0053: Deployment Commanded with Loop DTCs Present
- DTC B1001: Option Configuration Error
- Symptoms - SIR
- Air Bag Indicator Circuit Malfunction
- SIR Disabling and Enabling Zones
- Repair Instructions
- SIR Service Precautions
- SIR Disabling and Enabling Zone 3
- SIR Disabling and Enabling Zone 5
- SIR Disabling and Enabling Zone 9
- Inflatable Restraint Sensing and Diagnostic Module Replacement
- Inflatable Restraint Steering Wheel Module Replacement
- Inflatable Restraint Steering Wheel Module Coil Replacement
- Inflatable Restraint Instrument Panel Module Replacement
- Repairs and Inspections Required After a Collision
- Inflator Module Handling and Scrapping
- Description and Operation
- SIR System Description and Operation
- SIR System Overview
- Frontal SIR System Description
- Air Bag Indicator
- Driver and Passenger Knee Bolsters
- Inflatable Restraint Inflator Modules
- Inflatable Restraint Sensing and Diagnostic Module (SDM)
- Inflatable Restraint Steering Wheel Module Coil
- Inflatable Restraint Wiring Harnesses
- Steering Wheel and Column
- SIR System Description and Operation
- Special Tools and Equipment
- Supplemental Inflatable Restraint System
- Restraints Control Systems
- Seat Belt System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Repairs and Inspections Required After a Collision
- Seat Belt Buckle Replacement - Front
- Seat Belt Buckle Replacement - Rear
- Seat Belt Latch Replacement - Center Rear
- Seat Belt Height Adjuster Replacement - Front
- Seat Belt Retractor Replacement - Front (Coupe)
- Seat Belt Retractor Replacement - Front (Sedan)
- Seat Belt Retractor Replacement - Rear
- Bracket Replacement - Child Seat Belt Restraint System
- Child Restraint Tether Anchor Replacement
- Guide Replacement - Rear Seat Shoulder Belt
- Description and Operation
- Seat Belt System
- Seat Belts
- Seat Belt System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Repairs and Inspections Required After a Collision
- Seat Belt Buckle Replacement - Front
- Seat Belt Buckle Replacement - Rear
- Seat Belt Latch Replacement - Center Rear
- Seat Belt Height Adjuster Replacement - Front
- Seat Belt Retractor Replacement - Front (Coupe)
- Seat Belt Retractor Replacement - Front (Sedan)
- Seat Belt Retractor Replacement - Rear
- Bracket Replacement - Child Seat Belt Restraint System
- Child Restraint Tether Anchor Replacement
- Guide Replacement - Rear Seat Shoulder Belt
- Description and Operation
- Seat Belt System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering System
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Power Steering System (w/o Electro-Hydraulic Steering)
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle, Clunk, or Shudder Noise from the Power Steering System (3.4)
- Whine or Growl Noise from the Power Steering System
- Steering Effort Hard in One or Both Directions
- Steering Effort Too Easy in One or Both Directions
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Flushing the Power Steering System
- Power Steering Pulley Replacement
- Power Steering Pump Replacement (2.2L)
- Power Steering Reservoir Replacement - Off Vehicle (CB Series)
- Power Steering Pump Flow Control Valve Replacement - Off Vehicle
- Power Steering Pump Drive Shaft Seal Replacement (CB)
- Rack and Pinion Outer Tie Rod End Replacement
- Rack and Pinion Boot Replacement
- Rack and Pinion Inner Tie Rod Replacement
- Power Steering Pressure Pipe/Hose Replacement (3.4L)
- Power Steering Return Hose Replacement (3.4L)
- Power Steering Gear Replacement
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle (Rack and Pinion)
- Rack and Pinion Boot and Breather Tube Replacement - Off Vehicle
- Tie Rod Replacement - Inner (Quiet Valve)
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Magnasteer)
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Stub Shaft Seals and Bearing Replacement - Off Vehicle
- Description and Operation
- Special Tools and Equipment
- Power Steering System
- Power Steering System
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Power Steering System (w/o Electro-Hydraulic Steering)
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle, Clunk, or Shudder Noise from the Power Steering System (3.4)
- Whine or Growl Noise from the Power Steering System
- Steering Effort Hard in One or Both Directions
- Steering Effort Too Easy in One or Both Directions
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Flushing the Power Steering System
- Power Steering Pulley Replacement
- Power Steering Pump Replacement (2.2L)
- Power Steering Reservoir Replacement - Off Vehicle (CB Series)
- Power Steering Pump Flow Control Valve Replacement - Off Vehicle
- Power Steering Pump Drive Shaft Seal Replacement (CB)
- Rack and Pinion Outer Tie Rod End Replacement
- Rack and Pinion Boot Replacement
- Rack and Pinion Inner Tie Rod Replacement
- Power Steering Pressure Pipe/Hose Replacement (3.4L)
- Power Steering Return Hose Replacement (3.4L)
- Power Steering Gear Replacement
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle (Rack and Pinion)
- Rack and Pinion Boot and Breather Tube Replacement - Off Vehicle
- Tie Rod Replacement - Inner (Quiet Valve)
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Magnasteer)
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Stub Shaft Seals and Bearing Replacement - Off Vehicle
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Multifunction, Turn Signal Switch Replacement
- Tilt Lever Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Lower Bearing and Steering Column Jacket Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Manual Steering
- Suspension
- Front Suspension
- Front Suspension System
- Specifications
- Repair Instructions
- Stabilizer Shaft Replacement
- Stabilizer Shaft Link Replacement
- Stabilizer Shaft Insulator Replacement
- Lower Ball Joint Replacement
- Wheel Bearing/Hub Replacement - Front
- Steering Knuckle Replacement
- Lower Control Arm Replacement
- Lower Control Arm Bushings Replacement
- Wheel Stud Replacement
- Strut and Knuckle Scribing
- Strut Assembly Replacement
- Suspension Shock/Strut Disposal
- Strut, Strut Component and/or Spring Replacement
- Description and Operation
- Special Tools and Equipment
- Suspension General Diagnosis
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Suspension General Diagnosis
- Symptoms - Suspension General Diagnosis
- Ride Diagnosis
- Vehicle Leads/Pulls
- Body Leans or Sways in Corners
- Suspension Bottoms
- Torque Steer
- Memory Steer
- Poor Directional Stability
- Noise Diagnosis - Front Suspension
- Noise Diagnosis - Rear Suspension
- Ball Joint Inspection
- Struts or Shock Absorbers On-Vehicle Testing
- Wheel Bearings Diagnosis
- Trim Height Inspection Procedure
- Special Tools and Equipment
- Front Suspension System
- Rear Suspension
- Rear Suspension System
- Specifications
- Repair Instructions
- Wheel Bearing/Hub Replacement - Rear (Drum Brakes)
- Wheel Bearing/Hub Replacement - Rear (Disc Brakes)
- Support Replacement
- Knuckle Replacement (Drum Brakes)
- Knuckle Replacement (Disc Brakes)
- Stabilizer Shaft Replacement
- Stabilizer Shaft Insulator Replacement
- Stabilizer Shaft Link Replacement
- Trailing Arm Replacement
- Strut Assembly Replacement
- Suspension Shock/Strut Disposal
- Strut, Strut Component and/or Spring Replacement
- Lateral Link Replacement
- Wheel Stud Replacement (Drum Brakes)
- Wheel Stud Replacement (Disc Brakes)
- Description and Operation
- Special Tools and Equipment
- Suspension General Diagnosis
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Suspension General Diagnosis
- Symptoms - Suspension General Diagnosis
- Ride Diagnosis
- Vehicle Leads/Pulls
- Body Leans or Sways in Corners
- Suspension Bottoms
- Torque Steer
- Memory Steer
- Poor Directional Stability
- Noise Diagnosis - Front Suspension
- Noise Diagnosis - Rear Suspension
- Ball Joint Inspection
- Struts or Shock Absorbers On-Vehicle Testing
- Wheel Bearings Diagnosis
- Trim Height Inspection Procedure
- Special Tools and Equipment
- Rear Suspension System
- Wheel Alignment System
- Wheels & Tire System
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transaxle - Hydraulic Diagrams - 4T40-E/4T45-E
- Automatic Transaxle - Overhaul - 4T40-E/4T45-E
- Specifications
- Component Locator
- Repair Instructions
- Torque Converter Assembly Removal
- Transmission Holding Fixture Assemble
- Stub Shaft Removal
- Output Shaft Speed Sensor Removal
- Oil Pan and Gasket Removal
- Oil Filter/Seal, Oil Level Control Valve Removal
- Oil Feed Pipes Removal
- Intermediate/Fourth Servo Removal
- Low and Reverse Servo Removal
- Case Side Cover Removal
- Output Shaft Sleeve Removal
- Oil Pump and Oil Pump Shaft Removal
- Wire Harness Disconnect
- Transmission Fluid Pressure (TFP) Switch Removal
- Control Valve Body Assembly and Gasket Removal
- Spacer Plate and Gasket Removal
- Checkball Removal
- Manual Valve Clip Removal
- Channel Plate and Gasket Removal
- Accumulator Spring Removal
- Drive Sprocket, Driven Sprocket, and Drive Link Removal
- Input Speed Sensor Removal
- Wiring Harness Removal
- Driven Sprocket Support Assembly Removal
- Second Clutch Plates Removal
- Reverse Input Clutch Housing Removal
- Intermediate Fourth Band Removal
- Direct/Coast Clutch and Reaction Gear Set Removal
- Input Carrier and Reaction Gear Assembly Removal
- Input Internal Gear, Forward Clutch Hub Removal
- Forward Clutch and Low/Reverse Band Removal
- Forward Clutch Support, Low Roller Clutch Removal
- Output Shaft and Final Drive Assembly Removal
- Final Drive Internal Gear Removal
- Manual Shift Shaft, Detent Lever, and Park Lock Removal
- Transmission Cooler Line Seals Removal
- Torque Converter Seal Removal
- Drive Sprocket Support Removal
- Right Hand Axle Seal Removal
- Case Inspection
- Actuator Guide Replacement
- Drive Sprocket Support Installation
- Torque Converter Seal Installation
- Transmission Cooler Line Seals Installation
- Manual Shift Shaft, Detent Lever, and Park Lock Installation
- Final Drive Assembly Disassemble
- Final Drive Assembly Assemble
- Final Drive Pinion End Play Check
- Fretting Ring, Final Drive Internal Gear Install
- Final Drive and Differential Assembly Install
- Output Shaft Inspect
- Output Shaft Installation
- Forward Clutch Support, Roller Clutch Disassemble
- Forward Clutch Support, Low Roller Clutch Assemble
- Forward Clutch Support, Low Roller Clutch Install
- Forward Clutch Assembly Disassemble
- Forward Clutch Assembly Assemble
- Forward Clutch Functional Air Check
- Low/Reverse Band Installation
- Forward Clutch Assembly Installation
- Input Internal Gear, Forward Clutch Hub Disassemble
- Input Internal Gear, Forward Clutch Hub Assemble
- Input Internal Gear, Forward Clutch Hub Install
- Reaction Internal Gear, Input Carrier Disassemble
- Input Carrier Pinion Gear Clearance Check
- Reaction Internal Gear, Input Carrier Assemble
- Reaction Internal Gear, Input Carrier Installation
- Direct/Coast Clutch, Reaction Carrier Disassemble
- Reaction Carrier Pinion Clearance Check
- Direct/Coast Clutch, Reaction Carrier Assemble
- Direct and Coast Clutch Functional Air Checks
- Direct/Coast Clutch, Reaction Carrier Installation
- Selective Washer Measurement and Installation
- Reverse Input and Second Roller Clutch Disassemble
- Reverse Input and Second Roller Clutch Assemble
- Reverse Clutch Functional Air Check
- Reverse Input and Second Roller Clutch Installation
- Intermediate Fourth Band Assembly Installation
- Second Clutch Plate Installation
- Driven Sprocket Support Assembly Disassemble
- Drive Sprocket Support Assemble
- Second Clutch Functional Air Check
- Driven Sprocket Support Assembly Installation
- Wiring Harness Connection
- Input Speed Sensor Installation
- Drive, Driven Sprockets and Drive Link Disassemble
- Drive, Driven Sprockets and Drive Link Assemble
- Drive Sprocket, Driven Sprocket, and Drive Link Installation
- Channel Plate Assembly Disassemble
- Channel Plate Assembly Assemble
- Accumulator Springs Installation
- Channel Plate Assembly Installation
- Manual Valve Link Installation
- Checkballs Installation
- Spacer Plate and Gaskets Installation
- Control Valve Body Disassemble
- Control Valve Body Assemble
- Control Valve Assembly and Transmission Fluid Pressure (TFP) Switch Installation
- Wiring Harness Assembly Connect
- Oil Pump Cleaning and Inspection
- Oil Pump Assembly Installation
- Side Cover/Gaskets, Disassemble, Assemble, Install
- Side Cover Axle Seal Installation
- Output Shaft Sleeve Assembly Installation
- Stub Shaft Sleeve Assembly Installation
- Right Hand Axle Seal Assemble
- Output Shaft Speed Sensor Installation
- Intermediate/Fourth Servo Disassemble
- Intermediate/Fourth Servo Assemble and Installation
- Low and Reverse Servo Disassemble
- Low and Reverse Servo Assemble and Installation
- Oil Feed Pipes Assemble
- Filter Assembly and Seal Installation
- Oil Level Control Valve Installation
- Oil Pan and Gasket Installation
- Torque Converter Installation
- Description and Operation
- Automatic Transmission Hydraulic Diagrams
- Park or Neutral - Engine Running (W/o Electronic Range Select Mode)
- Park or Neutral - Engine Running (With Electronic Range Select Mode)
- Reverse (W/o Electronic Range Select Mode)
- Reverse (With Electronic Range Select Mode)
- Overdrive Range, First Gear (W/o Electronic Range Select Mode)
- Overdrive Range, First Gear (With Electronic Range Select Mode)
- Overdrive Range, Second Gear (W/o Electronic Range Select Mode)
- Overdrive Range, Second Gear (With Electronic Range Select Mode)
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (W/o Electronic Range Select Mode)
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (With Electronic Range Select Mode)
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (W/o Electronic Range Select Mode)
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (With Electronic Range Select Mode)
- Overdrive Range, 4-3 Downshift - Torque Converter Clutch (TCC) Not Applied (W/o Electronic Range Select Mode)
- Drive Range, Manual Third (from Overdrive Range) (W/o Electronic Range Select Mode)
- Manual Third Gear (With Electronic Range Select Mode)
- Drive Range, Manual Second (from Drive, Manual Third) (W/o Electronic Range Select Mode)
- Manual Second Gear (With Electronic Range Select Mode)
- Drive Range, Manual First (from Drive, Manual Second) (W/o Electronic Range Select Mode)
- Manual First Gear (With Electronic Range Select Mode)
- Automatic Transmission Hydraulic Diagrams
- Special Tools and Equipment
- Automatic Transmission - 4T40-E/4T45-E - Introduction (Diagnostic Information & Procedures)
- Automatic Transmission - 4T40-E/4T45-E - Introduction & Repair Procedures
- Specifications
- Transmission Fluid Temperature (TFT) Sensor Specifications
- Fastener Tightening Specifications
- Transmission General Specifications
- Fluid Capacity Specifications
- Range Reference
- Shift Solenoid Valve State and Gear Ratio
- Shift Speed
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Logic
- Transmission Range Switch Logic
- Line Pressure
- Component Resistance
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Shift Control Replacement
- Floor Shift Control Replacement
- Park/Neutral Position (PNP) Switch Replacement
- Oil Pan Replacement
- Oil Filter and Seal Replacement
- Vehicle Speed Sensor (VSS) Replacement
- Low/Reverse Servo Assembly Replacement
- Intermediate/Fourth Servo Assembly Replacement
- Automatic Transmission Oil Cooler Pipes Replacement
- Torque Converter, Turbine Shaft Seal Replacement
- Oil Feed Pipes Replacement
- Case Side Cover Replacement
- Case Side Cover Seal Replacement
- Wiring Harness Replacement
- Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid Replacement
- 1-2 Shift Solenoid Valve Replacement
- 2-3 Shift Solenoid Valve Replacement
- Pressure Control Solenoid (PCS) Replacement
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Replacement
- Control Valve Body Replacement
- Stub Axle Shaft Sleeve and Seal Replacement
- Output Axle Shaft Sleeve and Seal Replacement
- Transmission Mount Inspection
- Transmission Mount Replacement - Front
- Transmission Mount Replacement - Rear
- Transmission Mount Replacement - Left
- Transmission Replacement
- Description and Operation
- Transmission General Information
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Transmission Adaptive Functions
- Electronic Component Description
- Torque Converter Clutch Pulse Width Modulated Solenoid Valve
- Automatic Transmission Pressure Control Solenoid Valve
- Shift Solenoid Valves: 1-2 and 2-3
- Automatic Transmission Fluid Pressure Manual Valve Position Switch Assembly
- Output Speed Sensor (OSS)
- Input Speed Sensor (ISS)
- Automatic Transmission Fluid Temperature Sensor
- Park/Neutral Position Switch
- Automatic Transmission Inline 20-Way Connector Description
- Special Tools and Equipment
- Specifications
- Automatic Transmission - 4T40-E/4T45-E - DTC P0218 To P0745
- Diagnostic Information & Procedures
- DTC Table
- DTC P0218 (2.2L and 3.4L): Transmission Fluid Overtemperature
- DTC P0502 (2.2L): Vehicle Speed Sensor (VSS) Circuit Low Voltage
- DTC P0502 (3.4L): Vehicle Speed Sensor (VSS) Circuit Low Voltage
- DTC P0503 (2.2L): Vehicle Speed Sensor (VSS) Circuit Intermittent
- DTC P0503 (3.4L): Vehicle Speed Sensor (VSS) Circuit Intermittent
- DTC P0705 (2.2L and 3.4L): Transmission Range (TR) Switch Circuit
- DTC P0711 (2.2L): Transmission Fluid Temperature (TFT) Sensor Performance
- DTC P0711 (3.4L): Transmission Fluid Temperature (TFT) Sensor Performance
- DTC P0712 (2.2L): Transmission Fluid Temperature (TFT) Sensor Circuit Low Voltage
- DTC P0712 (3.4L): Transmission Fluid Temperature (TFT) Sensor Circuit Low Voltage
- DTC P0713 (2.2L): Transmission Fluid Temperature (TFT) Sensor Circuit High Voltage
- DTC P0713 (3.4L): Transmission Fluid Temperature (TFT) Sensor Circuit High Voltage
- DTC P0716 (2.2L): Input Speed Sensor Performance
- DTC P0716 (3.4L): Input Speed Sensor Performance
- DTC P0717 (2.2L): Input Speed Sensor Circuit Low Voltage
- DTC P0717 (3.4L): Input Speed Sensor Circuit Low Voltage
- DTC P0719 (2.2L): Brake Switch Circuit Low Voltage
- DTC P0719 (3.4L): Brake Switch Circuit Low Voltage
- DTC P0724 (2.2L): Brake Switch Circuit High Voltage
- DTC P0724 (3.4L): Brake Switch Circuit High Voltage
- DTC P0730 (2.2L and 3.4L): Incorrect Gear Ratio
- DTC P0741 (2.2L and 3.4L): Converter Clutch (TCC) System - Stuck Off
- DTC P0742 (2.2L): Torque Converter Clutch (TCC) System - Stuck On
- DTC P0742 (3.4L): Torque Converter Clutch (TCC) System - Stuck On
- DTC P0748 (2.2L): Pressure Control (PC) Solenoid Control Circuit
- Diagnostic Information & Procedures
- Automatic Transmission - 4T40-E/4T45-E - DTC P0748 To P2761
- Diagnostic Information & Procedures
- DTC Table
- DTC P0748 (3.4L): Pressure Control (PC) Solenoid Control Circuit
- DTC P0751 (2.2L and 3.4L): 1-2 Shift Solenoid (SS) Valve Performance - No First or Fourth Gear
- DTC P0752 (2.2L and 3.4L): 1-2 Shift Solenoid (SS) Valve Performance - No Second or Third Gear
- DTC P0753 (2.2L): 1-2 Shift Solenoid (SS) Control Circuit
- DTC P0753 (3.4L): 1-2 Shift Solenoid (SS) Control Circuit
- DTC P0756 (2.2L and 3.4L): 2-3 Shift Solenoid (SS) Valve Performance - No First or Second Gear
- DTC P0757 (2.2L and 3.4L): 2-3 Shift Solenoid (SS) Valve Performance - No Third or Fourth Gear
- DTC P0758 (2.2L): 2-3 Shift Solenoid (SS) Control Circuit
- DTC P0758 (3.4L): 2-3 Shift Solenoid (SS) Control Circuit
- DTC P1810 (2.2L): Transmission Fluid Pressure (TFP) Position Switch Circuit
- DTC P1810 (3.4L): Transmission Fluid Pressure (TFP) Position Switch Circuit
- DTC P1811 (2.2L and 3.4L): Maximum Adapt and Long Shift
- DTC P1816 (2.2L): Transmission Fluid Pressure (TFP) Valve Position Switch Indicates Park/Neutral (P/N) with Drive Ratio
- DTC P1816 (3.4L): Transmission Fluid Pressure (TFP) Valve Position Switch Indicates Park/Neutral (P/N) with Drive Ratio
- DTC P1818 (2.2L): Transmission Fluid Pressure (TFP) Valve Position Switch Indicates Drive without Drive Ratio
- DTC P1818 (3.4L): Transmission Fluid Pressure (TFP) Valve Position Switch Indicates Drive without Drive Ratio
- DTC P1887 (2.2L): Torque Converter Clutch (TCC) Release Switch Circuit
- DTC P1887 (3.4L): Torque Converter Clutch (TCC) Release Switch Circuit
- DTC P2761 (2.2L): Torque Converter Clutch (TCC) Pressure Control (PC) Solenoid Control Circuit
- DTC P2761 (3.4L): Torque Converter Clutch (TCC) Pressure Control (PC) Solenoid Control Circuit
- Diagnostic Information & Procedures
- Automatic Transmission - 4T40-E/4T45-E - Service, Diagnosis & Troubleshooting
- Diagnostic Information & Procedures
- Symptoms - Automatic Transmission
- Range Selector Displays Incorrect Range
- Transmission Fluid Checking Procedure
- Line Pressure Check Procedure
- Road Test Procedure
- Torque Converter Diagnosis Procedure
- Flexplate/Torque Converter Vibration Test
- Noise and Vibration Analysis
- Clutch Plate Diagnosis
- Engine Coolant/Water in Transmission
- Fluid Leak Diagnosis
- Case Porosity Repair
- Shift Solenoid Leak Test
- Automatic Transmission Oil Cooler Flushing and Flow Test (J 45096)
- Automatic Transmission Oil Cooler Flushing and Flow Test (J 35944-A)
- Automatic Transmission Fluid Leaks
- High or Low Line Pressure
- Inaccurate/Inconsistent Shift Points
- Harsh Shifts
- No Reverse or Slips in Reverse
- No First Gear, Slips in First Gear
- No Second Gear, Slips in Second Gear
- No Third Gear, Slips in Third Gear
- Second Gear Only
- No Fourth Gear, or Slips in Fourth Gear
- Loss of Drive
- Loss of Power
- Engine Stall
- First and Second Gears Only
- Third and Fourth Gears Only
- First and Fourth Gears Only
- Second and Third Gears Only
- No Park
- Ratcheting Noise
- No Engine Braking; All Manual Ranges
- No Engine Braking; Manual Second - Second Gear
- No Engine Braking; Manual First - First Gear
- Drives in Neutral
- No Gear Selection
- Shift Indicator Indicates Wrong Gear Selection
- Fluid Foaming
- Vibration
- Whine Noise Varying with RPM
- High Pitch Whine Noise
- Popping Noise
- Buzz Noise or High Frequency Rattle Sound
- Whine/Growl Noise That Changes with Vehicle Speed
- Final Drive Noise or Hum Noise
- Noise in Random Ranges
- Noise in First, Second, Third, or Fourth
- No Torque Converter Clutch (TCC) Release
- Torque Converter Clutch (TCC) Apply with Cold Engine
- Torque Converter Clutch (TCC) Shudder
- Diagnostic Information & Procedures
- Shift Interlock System
- Hydraulic Diagrams
- Automatic Transaxle - Hydraulic Diagrams - 4T40-E/4T45-E
- Automatic Transaxle - Overhaul - 4T40-E/4T45-E
- Specifications
- Component Locator
- Repair Instructions
- Torque Converter Assembly Removal
- Transmission Holding Fixture Assemble
- Stub Shaft Removal
- Output Shaft Speed Sensor Removal
- Oil Pan and Gasket Removal
- Oil Filter/Seal, Oil Level Control Valve Removal
- Oil Feed Pipes Removal
- Intermediate/Fourth Servo Removal
- Low and Reverse Servo Removal
- Case Side Cover Removal
- Output Shaft Sleeve Removal
- Oil Pump and Oil Pump Shaft Removal
- Wire Harness Disconnect
- Transmission Fluid Pressure (TFP) Switch Removal
- Control Valve Body Assembly and Gasket Removal
- Spacer Plate and Gasket Removal
- Checkball Removal
- Manual Valve Clip Removal
- Channel Plate and Gasket Removal
- Accumulator Spring Removal
- Drive Sprocket, Driven Sprocket, and Drive Link Removal
- Input Speed Sensor Removal
- Wiring Harness Removal
- Driven Sprocket Support Assembly Removal
- Second Clutch Plates Removal
- Reverse Input Clutch Housing Removal
- Intermediate Fourth Band Removal
- Direct/Coast Clutch and Reaction Gear Set Removal
- Input Carrier and Reaction Gear Assembly Removal
- Input Internal Gear, Forward Clutch Hub Removal
- Forward Clutch and Low/Reverse Band Removal
- Forward Clutch Support, Low Roller Clutch Removal
- Output Shaft and Final Drive Assembly Removal
- Final Drive Internal Gear Removal
- Manual Shift Shaft, Detent Lever, and Park Lock Removal
- Transmission Cooler Line Seals Removal
- Torque Converter Seal Removal
- Drive Sprocket Support Removal
- Right Hand Axle Seal Removal
- Case Inspection
- Actuator Guide Replacement
- Drive Sprocket Support Installation
- Torque Converter Seal Installation
- Transmission Cooler Line Seals Installation
- Manual Shift Shaft, Detent Lever, and Park Lock Installation
- Final Drive Assembly Disassemble
- Final Drive Assembly Assemble
- Final Drive Pinion End Play Check
- Fretting Ring, Final Drive Internal Gear Install
- Final Drive and Differential Assembly Install
- Output Shaft Inspect
- Output Shaft Installation
- Forward Clutch Support, Roller Clutch Disassemble
- Forward Clutch Support, Low Roller Clutch Assemble
- Forward Clutch Support, Low Roller Clutch Install
- Forward Clutch Assembly Disassemble
- Forward Clutch Assembly Assemble
- Forward Clutch Functional Air Check
- Low/Reverse Band Installation
- Forward Clutch Assembly Installation
- Input Internal Gear, Forward Clutch Hub Disassemble
- Input Internal Gear, Forward Clutch Hub Assemble
- Input Internal Gear, Forward Clutch Hub Install
- Reaction Internal Gear, Input Carrier Disassemble
- Input Carrier Pinion Gear Clearance Check
- Reaction Internal Gear, Input Carrier Assemble
- Reaction Internal Gear, Input Carrier Installation
- Direct/Coast Clutch, Reaction Carrier Disassemble
- Reaction Carrier Pinion Clearance Check
- Direct/Coast Clutch, Reaction Carrier Assemble
- Direct and Coast Clutch Functional Air Checks
- Direct/Coast Clutch, Reaction Carrier Installation
- Selective Washer Measurement and Installation
- Reverse Input and Second Roller Clutch Disassemble
- Reverse Input and Second Roller Clutch Assemble
- Reverse Clutch Functional Air Check
- Reverse Input and Second Roller Clutch Installation
- Intermediate Fourth Band Assembly Installation
- Second Clutch Plate Installation
- Driven Sprocket Support Assembly Disassemble
- Drive Sprocket Support Assemble
- Second Clutch Functional Air Check
- Driven Sprocket Support Assembly Installation
- Wiring Harness Connection
- Input Speed Sensor Installation
- Drive, Driven Sprockets and Drive Link Disassemble
- Drive, Driven Sprockets and Drive Link Assemble
- Drive Sprocket, Driven Sprocket, and Drive Link Installation
- Channel Plate Assembly Disassemble
- Channel Plate Assembly Assemble
- Accumulator Springs Installation
- Channel Plate Assembly Installation
- Manual Valve Link Installation
- Checkballs Installation
- Spacer Plate and Gaskets Installation
- Control Valve Body Disassemble
- Control Valve Body Assemble
- Control Valve Assembly and Transmission Fluid Pressure (TFP) Switch Installation
- Wiring Harness Assembly Connect
- Oil Pump Cleaning and Inspection
- Oil Pump Assembly Installation
- Side Cover/Gaskets, Disassemble, Assemble, Install
- Side Cover Axle Seal Installation
- Output Shaft Sleeve Assembly Installation
- Stub Shaft Sleeve Assembly Installation
- Right Hand Axle Seal Assemble
- Output Shaft Speed Sensor Installation
- Intermediate/Fourth Servo Disassemble
- Intermediate/Fourth Servo Assemble and Installation
- Low and Reverse Servo Disassemble
- Low and Reverse Servo Assemble and Installation
- Oil Feed Pipes Assemble
- Filter Assembly and Seal Installation
- Oil Level Control Valve Installation
- Oil Pan and Gasket Installation
- Torque Converter Installation
- Description and Operation
- Automatic Transmission Hydraulic Diagrams
- Park or Neutral - Engine Running (W/o Electronic Range Select Mode)
- Park or Neutral - Engine Running (With Electronic Range Select Mode)
- Reverse (W/o Electronic Range Select Mode)
- Reverse (With Electronic Range Select Mode)
- Overdrive Range, First Gear (W/o Electronic Range Select Mode)
- Overdrive Range, First Gear (With Electronic Range Select Mode)
- Overdrive Range, Second Gear (W/o Electronic Range Select Mode)
- Overdrive Range, Second Gear (With Electronic Range Select Mode)
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (W/o Electronic Range Select Mode)
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (With Electronic Range Select Mode)
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (W/o Electronic Range Select Mode)
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (With Electronic Range Select Mode)
- Overdrive Range, 4-3 Downshift - Torque Converter Clutch (TCC) Not Applied (W/o Electronic Range Select Mode)
- Drive Range, Manual Third (from Overdrive Range) (W/o Electronic Range Select Mode)
- Manual Third Gear (With Electronic Range Select Mode)
- Drive Range, Manual Second (from Drive, Manual Third) (W/o Electronic Range Select Mode)
- Manual Second Gear (With Electronic Range Select Mode)
- Drive Range, Manual First (from Drive, Manual Second) (W/o Electronic Range Select Mode)
- Manual First Gear (With Electronic Range Select Mode)
- Automatic Transmission Hydraulic Diagrams
- Special Tools and Equipment
- Automatic Trans
- External Pages