Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations- Diagnostic Connector (DLC) Locations
- Electrical Component Locator
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Special Tools and Equipment
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- OEM Connector End Views
- Connector End Views
- Ambient Air Temperature Sensor Connector End View
- Driver Information Center (DIC) Connector End View
- Electronic Compass Module Connector End View
- Engine Oil Level Switch (L26/L32) Connector End View
- Engine Oil Level Switch (LS4) Connector End View
- Engine Oil Pressure (EOP) Switch Connector End View
- Fuel Pump and Sender Assembly Connector End View
- Head Up Display (HUD) (UV6) Connector End View
- Head Up Display (HUD) Switch (UV6) Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Washer Fluid Level Switch Connector End View
- Windshield Wiper/Washer Switch Connector End View
- Windshield Wiper Motor Connector End View
- Sunroof Motor C1 Connector End View (Early Production)
- Sunroof Motor C2 Connector End View (Early Production)
- Sunroof Motor Connector End View (Late Production)
- Sunroof Module C1 Connector End View
- Sunroof Module C2 Connector End View
- Sunroof Switch Connector End View
- Heated Seat Element - Driver Back Connector End View
- Heated Seat Element - Driver Cushion Connector End View
- Heated Seat Element - Front Passenger Back Connector End View
- Heated Seat Element - Front Passenger Cushion Connector End View
- Heated Seat Relay - Driver Connector End View
- Heated Seat Relay - Front Passenger Connector End View
- Seat Adjuster Motor Assembly - Driver Connector End View
- Seat Adjuster Switch - Driver Connector End View
- Seat Horizontal Motor - Driver Connector End View
- Seat Lumbar Switch - Driver Connector End View
- Seat Lumbar Vertical Motor Connector End View
- Door Lock - Driver Connector End View
- Door Lock - Front Passenger Connector End View
- Door Lock - LR Connector End View
- Door Lock - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Front Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver C1 Connector End View
- Window Switch - Driver C2 Connector End View
- Window Switch - Front Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Ambient Light Sensor Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Brake Pedal Position Sensor Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Courtesy/Reading Lamp - Front (TR9, CF5) Connector End View
- Courtesy/Reading Lamp - Left Connector End View
- Courtesy/Reading Lamp - Right Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Headlamp - High Beam - Left Connector End View
- Headlamp - High Beam - Right Connector End View
- Headlamp Low Beam - Left Connector End View
- Headlamp Low Beam - Right Connector End View
- Interior Lamp Switch Connector End View
- I/P Compartment Lamp and Switch Connector End View
- I/P Courtesy Lamp - Left Connector End View
- I/P Courtesy Lamp - Right Connector End View
- License Lamp - Left Connector End View
- License Lamp - Right Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - LR Connector End View
- Marker Lamp - RF Connector End View
- Marker Lamp - RR Connector End View
- Multifunction Turn Signal Lever - C1 Connector End View
- Multifunction Turn Signal Lever - C2 Connector End View
- Multifunction Turn Signal Lever - C3 Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- PRNDL Lamp Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Sunload Sensor Assembly Connector End View
- Tail Lamp - Left Connector End View
- Tail Lamp - Right Connector End View
- Tail/Stop and Turn Signal Lamp - Left Connector End View
- Tail/Stop and Turn Signal Lamp - Right Connector End View
- Vanity Mirror Lamp - Left (CF5) Connector End View
- Vanity Mirror Lamp - Left (TR9) Connector End View
- Vanity Mirror Lamp - Right (CF5) Connector End View
- Vanity Mirror Lamp - Right (TR9) Connector End View
- Accessory Power Outlet - Front Connector End View
- Accessory Power Outlet - Rear Connector End View
- Cooling Fan - Left Connector End View
- Cooling Fan - Right Connector End View
- Audio Amplifier - C1 (U87) Connector End View
- Audio Amplifier - C2 (U87) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio - C1 Connector End View
- Radio - C2 Connector End View
- Radio, C3 (US4) Connector End View
- Speaker - Center Connector End View
- Speaker - LF Door Connector End View
- Speaker - LF Door Tweeter Connector End View
- Speaker - RF Door Connector End View
- Speaker - RF Door Tweeter Connector End View
- Speaker - LR (UW6) Connector End View
- Speaker - LR (U87) Connector End View
- Speaker - RR (UW6) Connector End View
- Speaker - RR (U87) Connector End View
- Steering Wheel Controls - Left Connector End View
- Steering Wheel Controls - Right Connector End View
- Seat Belt Switch Connector End View
- Brake Booster Vacuum Sensor Connector End View (5.3L)
- Crankshaft Position (CKP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 2 Connector End View (5.3L)
- Fuel Injector 7 Connector End View (5.3L)
- Fuel Injector 5 Connector End View (5.3L)
- Fuel Injector 3 Connector End View (5.3L)
- Fuel Injector 1 Connector End View (5.3L)
- Fuel Injector 2 Connector End View (5.3L)
- Fuel Injector 4 Connector End View (5.3L)
- Fuel Injector 6 Connector End View (5.3L)
- Fuel Injector 8 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 2 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 1 Connector End View (5.3L)
- Camshaft Position (CMP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 1 Connector End View (5.3L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (5.3L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Connector End View (5.3L)
- Intake Air Temperature (IAT)/Mass Air Flow (MAF) Sensor Connector End View (5.3L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (5.3L)
- Throttle Actuator Control (TAC) Module Connector End View (5.3L)
- Engine Oil Pressure (EOP) Sensor Connector End View (5.3L)
- Value Lifter Oil Manifold (VLOM) Assembly Connector End View (5.3L)
- Powertrain Control Module (PCM) C1 (NU3) Connector End View
- Powertrain Control Module (PCM) C1 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C2 (NU3) Connector End View
- Powertrain Control Module (PCM) C2 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C3 (NU3) Connector End View
- Powertrain Control Module (PCM) C3 (w/o NU3) Connector End View
- Accelerator Pedal Position (APP) Sensor Connector End View (3.8L)
- Barometric Pressure (BARO) Sensor (L32) Connector End View (3.8L)
- Camshaft Position (CMP) Sensor Connector End View (3.8L)
- Crankshaft Position (CKP) Sensor Connector End View (3.8L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (3.8L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Connector End View (3.8L)
- Evaporative Emissions (EVAP) Canister Vent Solenoid Connector End View (3.8L)
- Exhaust Gas Recirculation (EGR) Valve Connector End View (3.8L)
- Fuel Injector 1 Connector End View (3.8L)
- Fuel Injector 2 Connector End View (3.8L)
- Fuel Injector 3 Connector End View (3.8L)
- Fuel Injector 4 Connector End View (3.8L)
- Fuel Injector 5 Connector End View (3.8L)
- Fuel Injector 6 Connector End View (3.8L)
- Fuel Pump and Sender Assembly Connector End View (3.8L)
- Fuel Tank Pressure (FTP) Sensor Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (w/o NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 2 Connector End View (3.8L)
- Ignition Control Module (ICM) Connector End View (3.8L)
- Knock Sensor (KS) Bank 1 Connector End View (3.8L)
- Knock Sensor (KS) Bank 2 Connector End View (3.8L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (3.8L)
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Connector End View (3.8L)
- Secondary Air Injection (AIR) Control Solenoid Valve/Pressure Sensor Bank 2 Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Relay Connector End View (3.8L)
- Secondary Air Injection (AIR) Valve Relay Connector End View (3.8L)
- Supercharger Boost Control Solenoid (L32) Connector End View (3.8L)
- Throttle Actuator Control (TAC) Module Connector End View (3.8L)
- Horn Assembly Connector End View
- Theft Deterrent Exciter Module Connector End View
- Rear Compartment Lid Ajar Switch Connector End View
- Theft LED Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Brake Fluid Pressure Sensor Connector End View (JL4)
- Brake Fluid Pressure Sensor Connector End View (LS4)
- Electronic Brake Control Module (EBCM) Connector End View
- Steering Angle Sensor Connector End View (JL4)
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Yaw and Lateral Acceleration Sensor Connector End View (JL4)
- Body Control Module (BCM) C1 Connector End View
- Body Control Module (BCM) C2 Connector End View
- Body Control Module (BCM) C3 Connector End View
- Data Link Connector (DLC) Connector End View (L26/L32)
- Data Link Connector (DLC) Connector End View (LS4)
- Splice Pack SP 205 Connector End View
- Rear Window Defogger Grid, C1 Connector End View
- Rear Window Defogger Grid, C2 Connector End View
- Inside Rearview Mirror Connector End Views
- Vehicle Communication Interface Module (VCIM) - C1 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C2 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C3 (US4) Connector End Views
- Rear Compartment Lid Latch Connector End View
- A/C Compressor Clutch Connector End View (L26/L32)
- A/C Compressor Clutch Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (L26/L32)
- Air Temperature Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Control Processor Connector End View
- HVAC Control Module Connector End View
- Mode Actuator Connector End View
- Recirculation Actuator Connector End View
- AT Inline 20-way Connector End View, Engine Side
- AT Inline 20-way Connector End View, Transmission Side
- TAP Shift Switch - Right Connector End View
- TAP Shift Switch - Left Connector End View
- Vehicle Speed Sensor Connector End View, Wiring Harness Side
- 1-2 Shift Solenoid Valve Connector End View, Wiring Harness Side
- 2-3 Shift Solenoid Valve Connector End View, Wiring Harness Side
- Automatic Transmission Fluid Pressure Manual Valve Position Switch Connector End View, Wiring Harness Side
- Input Speed Sensor Connector End View, Wiring Harness Side
- Pressure Control Solenoid Valve Connector End View, Wiring Harness Side
- Torque Converter Clutch Pulse Width Modulated Solenoid Valve Connector End View, Wiring Harness Side
- Transmission Fluid Temperature Sensor Connector End View, Wiring Harness Side
- Transmission Internal Mode Switch Connector End View, Wiring Harness Side
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Air Temperature Actuator - Left Connector End View
- Air Temperature Actuator - Right Connector End View
- Air Temperature Sensor - Inside Connector End View
- Air Temperature Sensor - Lower Left Connector End View
- Air Temperature Sensor - Lower Right Connector End View
- Air Temperature Sensor - Upper Left Connector End View
- Air Temperature Sensor - Upper Right Connector End View
- HVAC Control Module, C1 Connector End View
- HVAC Control Module, C2 Connector End View
- Inflatable Restraint Front End Discriminating Sensor Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Side Impact Sensor - Left Connector End View (AY1)
- Inflatable Restraint Side Impact Sensor - Right Connector End View (AY1)
- Inflatable Restraint Steering Wheel Module Coil C1 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C2 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C3 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (W/O UK3)
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (UK3)
- Inflatable Restraint Steering Wheel Module Coil C5 Connector End View
- Roof Rail Module - Left Connector End View (AY1)
- Roof Rail Module - Right Connector End View (AY1)
- Seat Belt Pretensioner - Left Connector End View
- Seat Belt Pretensioner - Right Connector End View
- Cruise Control Switch Connector End View
- Battery Current Sensor Connector End View
- Generator Connector End View (L26/L32)
- Generator Connector End View (LS4)
- Hood Ajar Switch Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Magnasteer Actuator Connector End View
- Automatic Transmission Related Connector End Views
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Special Tools and Equipment
- OEM Connector End Views
- Accessories & Equipment
- Accessories Control Systems
- Anti-Theft Systems
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Keyless Entry System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Theft Deterrent System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Theft Deterrent
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2945
- DTC B2960
- DTC B3031
- DTC B3055
- DTC P1626
- DTC P1630
- DTC P1631
- Symptoms - Theft Deterrent
- Content Theft Deterrent (CTD) Alarm Mode Inoperative
- Content Theft Deterrent (CTD) Does Not Disarm with Key Lock
- Horn Inoperative in Content Theft Deterrent (CTD) Alarm Mode
- Lights Inoperative in Content Theft Deterrent (CTD) Alarm Mode
- Security Indicator LED Inoperative
- Repair Instructions
- Description and Operation
- Door System, Mirror System & Window System
- Communication Devices
- Computer/Integrating Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Computer/Integrating Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B1000
- DTC B1001
- DTC B1004
- DTC B1007
- DTC B1009
- DTC B1013
- DTC B1014
- DTC B1370
- DTC B1380
- DTC B1385
- DTC B1390
- DTC B1420
- DTC B1428
- DTC B1475
- DTC C0550
- DTC P2535
- DTC U0001
- DTC U0073
- DTC U0100 - U0299
- DTC U1000 and U1255
- DTC U1001-U1254
- DTC U1300, U1301, or U1305
- Symptoms - Computer/Integrating Systems
- Scan Tool Does Not Power Up
- Scan Tool Does Not Communicate with Class 2 Device
- Scan Tool Does Not Communicate with High Speed GMLAN Device
- Power Mode Mismatch
- Retained Accessory Power (RAP) On After Timeout
- Retained Accessory Power (RAP) Inoperative
- Control Module References
- Data Link References
- Repair Instructions
- Description and Operation
- Programming And Setup - All Systems
- Repair Instructions
- Service Programming System (SPS)
- Audio Amplifier Programming and Setup
- Blower Control Module Programming and Setup
- Body Control Module Programming and Setup
- Communication Interface Module (OnStar) Programming and Setup
- Digital Radio Receiver Programming and Setup
- Electronic Brake Control Module Programming and Setup
- Electronic Compass Module Programming and Setup
- Engine Control Module Programming and Setup
- Head Up Display Programming and Setup
- HVAC Control Module Programming and Setup
- Ignition Control Module Programming and Setup
- Inflatable Restraint Sensing and Diagnostic Module Programming and Setup
- Instrument Panel Cluster Programming and Setup
- Powertrain Control Module Programming and Setup
- Radio Programming and Setup
- Remote Control Door Lock Receiver Programming and Setup
- Sunroof Control Module Programming and Setup (1 Connector System)
- Sunroof Control Module Programming and Setup (2 Connector System)
- Throttle Actuator Control Module Programming and Setup
- Repair Instructions
- Computer/Integrating Systems
- Cruise Control Systems
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Cruise Control
- Scan Tool Data List
- Scan Tool Data Definitions (Disengage History)
- Scan Tool Data Definitions (Cruise Control)
- DTC P0564
- DTC P0567
- DTC P0568
- DTC P0608
- DTC P0703 (3.8L)
- DTC P0703 (5.3L)
- DTC P1574
- DTC P2162
- Symptoms - Cruise Control
- Cruise Control Inoperative/Malfunctioning
- Repair Instructions
- Description and Operation
- Entertainment Systems
- Cellular Communication System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Cellular Communication
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2455
- DTC B2470
- DTC B2476
- DTC B2482
- DTC B2483 or B2484
- DTC U1500
- OnStar Symptom Diagnosis
- Symptoms - Cellular Communication
- OnStar One or More Buttons Inoperative
- OnStar Call Center Remote Function Requests Inoperative
- Unable to Contact OnStar Call Center
- Microphone Inoperative - Caller Cannot Be Heard
- Voice Recognition Inoperative
- OnStar Steering Wheel Control Functions Inoperative
- OnStar Button LED Inoperative
- No (or Noisy) OnStar Audio
- Global Positioning System (GPS) Data Not Current or Inaccurate
- OnStar Reconfiguration
- Repair Instructions
- Coaxial Cable Replacement - Cellular Telephone
- Coaxial Cable Replacement - Global Positioning System (GPS) (Instrument Panel Extension Cable)
- Coaxial Cable Replacement - Global Positioning System (GPS) (Body Cable)
- Antenna Replacement - Cellular Communications
- Navigation Antenna Replacement
- Bracket Replacement - Vehicle Location Antenna Module
- Communication Interface Module Replacement
- Description and Operation
- OnStar Description and Operation
- Notes
- Vehicle Communication Interface Module (VCIM)
- OnStar® Button Assembly
- OnStar® Microphone
- Cellular and Navigation Antennas
- OnStar® Sleep Cycle
- Deactivated OnStar® Accounts
- OnStar® Reconfiguration Procedure
- OnStar® Cellular, GPS, and Diagnostic Limitations
- OnStar® Personal Calling
- Operation of the Hands-Free Cellular Phone
- OnStar® Steering Wheel Controls
- OPC Features
- Voice Feedback
- OPC Security/System Lock
- Nametags
- Mobile Identification Number and Mobile Directory Number
- Operation of the OnStar® Speech Recognition Systems
- OnStar Description and Operation
- Entertainment System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Entertainment
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B1001
- DTC B1025, B1035, B1045, or B1055
- DTC B1259
- DTC B1780
- Symptoms - Entertainment
- Audio System Troubleshooting Hints
- Radio Poor Reception
- Digital Radio Poor or No Reception
- Audio Distortion - One or More Speakers
- Audio Too Loud at Low Settings
- Tape Player Weak, Slow, or Garbled Output
- Steering Wheel Controls Inoperative
- Reduced Volume - One or More Speakers
- Speakers Inoperative - One or More
- Speakers Inoperative - All
- Radio Setup
- Digital Radio Receiver Setup
- Speaker Replacement Reference
- Repair Instructions
- Radio Replacement
- Receiver Replacement - Digital Radio
- Amplifier Replacement
- Radio Antenna Module Replacement
- Antenna Replacement - Digital Radio
- Antenna Extension Cable Replacement
- Antenna Cable Replacement
- Coaxial Cable Replacement - Digital Radio
- Speaker Replacement - Front
- Speaker Replacement - Front Door
- Speaker Replacement - Front Side Door Upper
- Speaker Replacement - Rear
- Speaker Grille Replacement - Front
- Speaker Grille Replacement - Front Door
- Speaker Grille Replacement - Rear
- Description and Operation
- Special Tools and Equipment
- Cellular Communication System
- Exterior Lights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2525
- DTC B2545
- DTC B2580
- DTC B2610
- DTC B2645
- DTC B3445
- DTC B3838
- DTC B3948
- DTC B3949
- DTC B3950
- DTC B3951
- DTC C0277
- DTC C0278
- DTC C0283
- DTC C0870
- DTC P0572
- DTC P0573
- Symptoms - Lighting Systems
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Daytime Running Lamps (DRL) Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Always On
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Flash to Pass
- Illuminated Entry Lamps Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Always On
- Park, License, and Tail Lamps Always On
- Park, License, and Tail Lamps Inoperative
- Reading Lamp(s) Always On
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Always On
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Always On or Flashing
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Always On
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Brake Pedal Position Sensor Calibration
- Brake Pedal Position Sensor Replacement
- Instrument Panel (I/P) Dimmer Switch Replacement
- Daytime Running Lamps (DRL) Ambient Light Sensor Replacement
- Courtesy Lamp Replacement - Instrument Panel
- Courtesy Lamp Replacement - Overhead Console
- Instrument Panel (I/P) Compartment Lamp Switch Replacement
- Vanity Mirror Lamp Bulb Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement
- Dome Lamp Bulb Replacement
- Headlamp Assembly or Headlamp Bulb Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front
- Fog Lamp Aiming Procedure
- Park/Turn Signal Lamp Bulb Replacement
- High Mounted Stop Lamp Replacement
- License Lamp/Backup Lamp Replacement
- License Lamp/Backup Lamp Bulb Replacement
- Tail Lamp Assembly and /or Backup, Sidemarker, Stop, Turn Signal Bulb Replacement
- Roof Side Rail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Gauges & Instrument Panels
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0931
- DTC B3619
- DTC B3620
- DTC B3621
- DTC B3634
- DTC P0461
- DTC P0462
- DTC P0463
- DTC P0464
- DTC P0520
- DTC P0521
- DTC P0522
- DTC P0523
- Symptoms - Instrument Panel, Gages and Console
- Fuel Gage Inaccurate or Inoperative
- Instrument Panel Cluster (IPC) Gages Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On (3.8L)
- Engine Oil Pressure Indicator Always On (5.3L)
- Engine Oil Temperature Indicator Always On
- Low Engine Oil Level Indicator Always On
- Low Engine Oil Level Indicator Inoperative
- MPH (Km/h) Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Switch(es) Inoperative
- Head Up Display (HUD) Inoperative
- Head Up Display (HUD) Hazard Indicators Inoperative
- Head Up Display (HUD) Image Adjustment Inoperative
- Head Up Display (HUD) Intensity Does Not Vary
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Ambient Air Temperature Gage Sensor Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement
- Electronic Compass Calibration
- Electronic Compass Module Replacement
- Head Up Display Window Cleaning
- Head Up Display Switch Replacement
- Head Up Display Replacement
- Closeout/Insulator Panel Replacement - Right
- Closeout/Insulator Panel Replacement - Left
- Knee Bolster Replacement - Right
- Knee Bolster Replacement - Left
- Trim Plate Replacement - Instrument Panel (I/P)
- Trim Plate Replacement - Instrument Panel (I/P) Accessory
- Trim Panel Replacement - Instrument Panel (I/P) Upper
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Bezel Replacement - Instrument Panel (I/P) Cluster
- Filler Panel Replacement - Outer - Instrument Panel (I/P) Lower Trim
- Instrument Panel (I/P) Outer Trim Cover Replacement - Right
- Instrument Panel (I/P) Outer Trim Cover Replacement - Left
- Compartment Replacement - Instrument Panel (I/P) - Center
- Compartment Replacement - Instrument Panel (I/P)
- Striker Replacement - Instrument Panel (I/P) Compartment
- Latch Replacement - Instrument Panel (I/P) Compartment
- Lock Cylinder Replacement - Instrument Panel (I/P) Compartment Door
- Stop Replacement - I/P Compartment Door
- Dampener Replacement - I/P Compartment
- Trim Pad Replacement - Instrument Panel (I/P)
- Steering Column Filler Replacement
- Driver Information Center Replacement
- Instrument Panel Cluster (IPC) Replacement
- Compartment Replacement - Floor Console - Front
- Console Replacement - Front Floor
- Console Armrest Replacement - Front Floor
- Hinge Replacement - Floor Console Arm Rest
- Trim Plate Replacement - Front Floor Console
- Cup Holder Replacement - Front Floor Console - Rear
- Cover Replacement - Floor Console - Rear
- Description and Operation
- Instrument Panel Cluster (IPC) Description and Operation
- Indicator/Warning Message Description and Operation
- Driver Information Center (DIC) Description and Operation
- Head Up Display (HUD) Description and Operation
- Audible Warnings Description and Operation
- Special Tools and Equipment
- Instrument Panel System Displays, Gauges And Console
- Headlights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2525
- DTC B2545
- DTC B2580
- DTC B2610
- DTC B2645
- DTC B3445
- DTC B3838
- DTC B3948
- DTC B3949
- DTC B3950
- DTC B3951
- DTC C0277
- DTC C0278
- DTC C0283
- DTC C0870
- DTC P0572
- DTC P0573
- Symptoms - Lighting Systems
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Daytime Running Lamps (DRL) Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Always On
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Flash to Pass
- Illuminated Entry Lamps Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Always On
- Park, License, and Tail Lamps Always On
- Park, License, and Tail Lamps Inoperative
- Reading Lamp(s) Always On
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Always On
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Always On or Flashing
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Always On
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Brake Pedal Position Sensor Calibration
- Brake Pedal Position Sensor Replacement
- Instrument Panel (I/P) Dimmer Switch Replacement
- Daytime Running Lamps (DRL) Ambient Light Sensor Replacement
- Courtesy Lamp Replacement - Instrument Panel
- Courtesy Lamp Replacement - Overhead Console
- Instrument Panel (I/P) Compartment Lamp Switch Replacement
- Vanity Mirror Lamp Bulb Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement
- Dome Lamp Bulb Replacement
- Headlamp Assembly or Headlamp Bulb Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front
- Fog Lamp Aiming Procedure
- Park/Turn Signal Lamp Bulb Replacement
- High Mounted Stop Lamp Replacement
- License Lamp/Backup Lamp Replacement
- License Lamp/Backup Lamp Bulb Replacement
- Tail Lamp Assembly and /or Backup, Sidemarker, Stop, Turn Signal Bulb Replacement
- Roof Side Rail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Heated Glass/Defoggers
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Ambient Air Temperature Sensor Replacement
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Horns
- Horn System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Horn System
- Ignition Switch/Steering Lock
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Turn Signal Cancel Cam and Steering Shaft Upper Bearing Spring Replacement
- Multifunction, Turn Signal Switch Replacement
- Turn Signal Switch Housing Replacement
- Tilt Lever Replacement
- Steering Wheel Cover Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Steering Shaft, Lower Bearing, and Jacket Replacement
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Infotainment
- Cellular Communication System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Cellular Communication
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2455
- DTC B2470
- DTC B2476
- DTC B2482
- DTC B2483 or B2484
- DTC U1500
- OnStar Symptom Diagnosis
- Symptoms - Cellular Communication
- OnStar One or More Buttons Inoperative
- OnStar Call Center Remote Function Requests Inoperative
- Unable to Contact OnStar Call Center
- Microphone Inoperative - Caller Cannot Be Heard
- Voice Recognition Inoperative
- OnStar Steering Wheel Control Functions Inoperative
- OnStar Button LED Inoperative
- No (or Noisy) OnStar Audio
- Global Positioning System (GPS) Data Not Current or Inaccurate
- OnStar Reconfiguration
- Repair Instructions
- Coaxial Cable Replacement - Cellular Telephone
- Coaxial Cable Replacement - Global Positioning System (GPS) (Instrument Panel Extension Cable)
- Coaxial Cable Replacement - Global Positioning System (GPS) (Body Cable)
- Antenna Replacement - Cellular Communications
- Navigation Antenna Replacement
- Bracket Replacement - Vehicle Location Antenna Module
- Communication Interface Module Replacement
- Description and Operation
- OnStar Description and Operation
- Notes
- Vehicle Communication Interface Module (VCIM)
- OnStar® Button Assembly
- OnStar® Microphone
- Cellular and Navigation Antennas
- OnStar® Sleep Cycle
- Deactivated OnStar® Accounts
- OnStar® Reconfiguration Procedure
- OnStar® Cellular, GPS, and Diagnostic Limitations
- OnStar® Personal Calling
- Operation of the Hands-Free Cellular Phone
- OnStar® Steering Wheel Controls
- OPC Features
- Voice Feedback
- OPC Security/System Lock
- Nametags
- Mobile Identification Number and Mobile Directory Number
- Operation of the OnStar® Speech Recognition Systems
- OnStar Description and Operation
- Entertainment System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Entertainment
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B1001
- DTC B1025, B1035, B1045, or B1055
- DTC B1259
- DTC B1780
- Symptoms - Entertainment
- Audio System Troubleshooting Hints
- Radio Poor Reception
- Digital Radio Poor or No Reception
- Audio Distortion - One or More Speakers
- Audio Too Loud at Low Settings
- Tape Player Weak, Slow, or Garbled Output
- Steering Wheel Controls Inoperative
- Reduced Volume - One or More Speakers
- Speakers Inoperative - One or More
- Speakers Inoperative - All
- Radio Setup
- Digital Radio Receiver Setup
- Speaker Replacement Reference
- Repair Instructions
- Radio Replacement
- Receiver Replacement - Digital Radio
- Amplifier Replacement
- Radio Antenna Module Replacement
- Antenna Replacement - Digital Radio
- Antenna Extension Cable Replacement
- Antenna Cable Replacement
- Coaxial Cable Replacement - Digital Radio
- Speaker Replacement - Front
- Speaker Replacement - Front Door
- Speaker Replacement - Front Side Door Upper
- Speaker Replacement - Rear
- Speaker Grille Replacement - Front
- Speaker Grille Replacement - Front Door
- Speaker Grille Replacement - Rear
- Description and Operation
- Special Tools and Equipment
- Navigation Systems
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Cellular Communication System
- Interior/Exterior Trim
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Exterior Trim
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0931
- DTC B3619
- DTC B3620
- DTC B3621
- DTC B3634
- DTC P0461
- DTC P0462
- DTC P0463
- DTC P0464
- DTC P0520
- DTC P0521
- DTC P0522
- DTC P0523
- Symptoms - Instrument Panel, Gages and Console
- Fuel Gage Inaccurate or Inoperative
- Instrument Panel Cluster (IPC) Gages Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On (3.8L)
- Engine Oil Pressure Indicator Always On (5.3L)
- Engine Oil Temperature Indicator Always On
- Low Engine Oil Level Indicator Always On
- Low Engine Oil Level Indicator Inoperative
- MPH (Km/h) Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Switch(es) Inoperative
- Head Up Display (HUD) Inoperative
- Head Up Display (HUD) Hazard Indicators Inoperative
- Head Up Display (HUD) Image Adjustment Inoperative
- Head Up Display (HUD) Intensity Does Not Vary
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Ambient Air Temperature Gage Sensor Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement
- Electronic Compass Calibration
- Electronic Compass Module Replacement
- Head Up Display Window Cleaning
- Head Up Display Switch Replacement
- Head Up Display Replacement
- Closeout/Insulator Panel Replacement - Right
- Closeout/Insulator Panel Replacement - Left
- Knee Bolster Replacement - Right
- Knee Bolster Replacement - Left
- Trim Plate Replacement - Instrument Panel (I/P)
- Trim Plate Replacement - Instrument Panel (I/P) Accessory
- Trim Panel Replacement - Instrument Panel (I/P) Upper
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Bezel Replacement - Instrument Panel (I/P) Cluster
- Filler Panel Replacement - Outer - Instrument Panel (I/P) Lower Trim
- Instrument Panel (I/P) Outer Trim Cover Replacement - Right
- Instrument Panel (I/P) Outer Trim Cover Replacement - Left
- Compartment Replacement - Instrument Panel (I/P) - Center
- Compartment Replacement - Instrument Panel (I/P)
- Striker Replacement - Instrument Panel (I/P) Compartment
- Latch Replacement - Instrument Panel (I/P) Compartment
- Lock Cylinder Replacement - Instrument Panel (I/P) Compartment Door
- Stop Replacement - I/P Compartment Door
- Dampener Replacement - I/P Compartment
- Trim Pad Replacement - Instrument Panel (I/P)
- Steering Column Filler Replacement
- Driver Information Center Replacement
- Instrument Panel Cluster (IPC) Replacement
- Compartment Replacement - Floor Console - Front
- Console Replacement - Front Floor
- Console Armrest Replacement - Front Floor
- Hinge Replacement - Floor Console Arm Rest
- Trim Plate Replacement - Front Floor Console
- Cup Holder Replacement - Front Floor Console - Rear
- Cover Replacement - Floor Console - Rear
- Description and Operation
- Instrument Panel Cluster (IPC) Description and Operation
- Indicator/Warning Message Description and Operation
- Driver Information Center (DIC) Description and Operation
- Head Up Display (HUD) Description and Operation
- Audible Warnings Description and Operation
- Special Tools and Equipment
- Interior Trim
- Specifications
- Repair Instructions
- Eliminating Unwanted Odors in Vehicles
- Carpet Retainer Replacement - Front
- Floor Carpet Drying
- Carpet Replacement - Front
- Sound Barrier Replacement - Rear Seat Back
- Headliner Replacement
- Assist Handle Replacement - Rear
- Console Replacement - Overhead
- Sunshade Replacement
- Sunshade Anchor Replacement
- Garnish Molding Replacement - Windshield Pillar
- Sail Panel Replacement
- Trim Panel Replacement - Upper Center Pillar
- Trim Panel Replacement - Lower Center Pillar
- Trim Panel Replacement - Rear Quarter Upper
- Trim Panel Replacement - Rear Quarter Lower
- Trim Panel Replacement - Rear Window Shelf
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Interior/Illumination Lights
- Lighting Systems
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Lighting Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2525
- DTC B2545
- DTC B2580
- DTC B2610
- DTC B2645
- DTC B3445
- DTC B3838
- DTC B3948
- DTC B3949
- DTC B3950
- DTC B3951
- DTC C0277
- DTC C0278
- DTC C0283
- DTC C0870
- DTC P0572
- DTC P0573
- Symptoms - Lighting Systems
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Daytime Running Lamps (DRL) Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Always On
- Hazard Lamps Inoperative
- Headlamps Always On - Low or High Beam
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low Beams
- Headlamps Inoperative - Flash to Pass
- Illuminated Entry Lamps Inoperative
- Interior Backlighting Does Not Dim
- Interior Backlighting Inoperative
- Instrument Panel (I/P) Compartment Lamp Inoperative
- Instrument Panel (I/P) Compartment Lamp Always On
- Park, License, and Tail Lamps Always On
- Park, License, and Tail Lamps Inoperative
- Reading Lamp(s) Always On
- Reading Lamp(s) Inoperative
- Rear Compartment Lamp(s) Always On
- Rear Compartment Lamp(s) Inoperative
- Stop Lamps Always On
- Stop Lamps Inoperative
- Turn Signal Lamps and/or Indicators Always On or Flashing
- Turn Signal Lamps and/or Indicators Inoperative
- Vanity Mirror Lamp(s) Always On
- Vanity Mirror Lamp(s) Inoperative
- Repair Instructions
- Brake Pedal Position Sensor Calibration
- Brake Pedal Position Sensor Replacement
- Instrument Panel (I/P) Dimmer Switch Replacement
- Daytime Running Lamps (DRL) Ambient Light Sensor Replacement
- Courtesy Lamp Replacement - Instrument Panel
- Courtesy Lamp Replacement - Overhead Console
- Instrument Panel (I/P) Compartment Lamp Switch Replacement
- Vanity Mirror Lamp Bulb Replacement
- Trans Floor Shift Control Indicator Lamp Replacement
- Dome Lamp Replacement
- Dome Lamp Bulb Replacement
- Headlamp Assembly or Headlamp Bulb Replacement
- Headlamp Aiming
- Fog Lamp Replacement - Front
- Fog Lamp Aiming Procedure
- Park/Turn Signal Lamp Bulb Replacement
- High Mounted Stop Lamp Replacement
- License Lamp/Backup Lamp Replacement
- License Lamp/Backup Lamp Bulb Replacement
- Tail Lamp Assembly and /or Backup, Sidemarker, Stop, Turn Signal Bulb Replacement
- Roof Side Rail Lamp Replacement
- Rear Compartment Lamp Replacement
- Description and Operation
- Lighting Systems
- Memory Modules
- Personalization Systems
- Description and Operation
- Personalization Description and Operation
- Vehicle Personalization
- Programming Features
- Enter Programming Mode
- Exterior Lighting Delay
- Interior Lights When Door Closed
- Interior Lights When Key Removed
- Auto Door Lock
- Auto Door Unlock
- Auto Door Unlock On
- Delayed Locking
- Remote Locks Feedback
- Theft Deterrent (if equipped)
- Key Cylinder Disarm (if equipped with Theft Deterrent)
- Lock Switch Arm (if equipped with Theft Deterrent)
- Programming Finished
- Programming Features with the Tech 2
- Additional Information
- Programming Features
- Description and Operation
- Personalization Systems
- Mirrors
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Ambient Air Temperature Sensor Replacement
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Seats
- Seat System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seat Replacement - Front Bucket
- Seat Cushion Replacement - Front
- Seat Cushion Cover Replacement - Front
- Seat Cushion Frame Replacement - Front
- Seat Back Replacement - Front
- Seat Back Cover Replacement - Front (Fold Flat)
- Seat Back Cover Replacement - Front (Except Fold Flat)
- Seat Back Pad Replacement - Front
- Seat Back Frame Replacement - Front
- Seat Back Recliner Handle Replacement - Front
- Seat Back Panel Replacement - Front
- Lumbar Replacement - Front Seat
- Lumbar Switch Replacement
- Seat Adjuster Replacement - Front (Six-Way Power)
- Seat Adjuster Replacement - Front (Two-Way Manual)
- Seat Adjuster Track Cover Replacement - Front
- Seat Switch Replacement - Power
- Seat Adjuster Phase Adjustment - Power
- Drive Cable Replacement - Horizontal
- Drive Cable Replacement - Vertical
- Relay Replacement - Heated Seats - Front
- Seat Back Heater Element Replacement - Front
- Seat Cushion Heater Element Replacement - Front
- Head Restraint Replacement - Front Seat
- Head Restraint Retainer Replacement - Front Seat
- Trim Panel Replacement - Front Seat
- Seat Cushion Replacement - Rear
- Seat Cushion Cover Replacement - Rear
- Seat Cushion Retainer Replacement - Rear
- Seat Back Replacement - Rear (Folding)
- Seat Back Frame Replacement - Rear (Folding)
- Seat Back Bolster Replacement - Rear Split Folding
- Seat Back Cover Replacement - Rear
- Seat Back Pad Replacement - Rear
- Description and Operation
- Special Tools and Equipment
- Seat System
- Steering Column Switches
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Turn Signal Cancel Cam and Steering Shaft Upper Bearing Spring Replacement
- Multifunction, Turn Signal Switch Replacement
- Turn Signal Switch Housing Replacement
- Tilt Lever Replacement
- Steering Wheel Cover Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Steering Shaft, Lower Bearing, and Jacket Replacement
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Warning Systems
- Window Motors & Regulators
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Ambient Air Temperature Sensor Replacement
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Wiper/Washer Systems
- Wiper System & Washer System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Wiper/Washer Systems
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B3873
- DTC B3874
- DTC B3875
- DTC B3922
- Symptoms - Wiper/Washer Systems
- Low Washer Fluid Indicator Malfunction
- Washers Always On
- Washers Inoperative
- Wipers Always On
- Wipers Inoperative - All Modes
- Wipers Inoperative - One or More Modes
- Wipers Blades Do Not Park
- Wiper Arm Tip Pressure Check
- Wiper Blade Element Check
- Repair Instructions
- Washer Solvent Container Replacement
- Washer Solvent Container Level Sensor Replacement
- Washer Pump Replacement
- Hose Replacement - Windshield Washer
- Wiper Arm Replacement
- Wiper Arm Blade Replacement
- Wiper Blade Element Replacement
- Wiper Drive System Module Replacement
- Wiper Motor Replacement
- Wiper Motor Crank Arm Replacement
- Wiper Chatter Repair
- Windshield Glass Cleaning
- Blade Element Cleaning
- Wipers/Washer Switch Replacement
- Description and Operation
- Special Tools and Equipment
- Wiper System & Washer System
- Body & Frame
- Door Locks
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Keyless Entry System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Theft Deterrent System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Theft Deterrent
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2945
- DTC B2960
- DTC B3031
- DTC B3055
- DTC P1626
- DTC P1630
- DTC P1631
- Symptoms - Theft Deterrent
- Content Theft Deterrent (CTD) Alarm Mode Inoperative
- Content Theft Deterrent (CTD) Does Not Disarm with Key Lock
- Horn Inoperative in Content Theft Deterrent (CTD) Alarm Mode
- Lights Inoperative in Content Theft Deterrent (CTD) Alarm Mode
- Security Indicator LED Inoperative
- Repair Instructions
- Description and Operation
- Door System, Mirror System & Window System
- Exterior Body Panels
- Air/Wind Noise Symptoms
- Body Front End
- Specifications
- Repair Instructions
- Hood Adjustment
- Hood Bumper Replacement - Side
- Hood Replacement
- Hood Hinge Replacement
- Hood Latch Replacement
- Hood Latch Support Replacement
- Hood Latch Release Cable Replacement
- Hood Insulator Replacement
- Assist Rod Replacement - Hood
- Fender Replacement - Front
- Brace Replacement - Front Fender Upper Diagonal
- Plenum Chamber Water Deflector Replacement
- Air Inlet Grille Panel Replacement
- Seal Replacement - Hood Rear
- Seal Replacement - Hood Rear Side
- Front Fender Liner Replacement
- Fender Sound Insulator Replacement - Front
- Splash Shield Replacement - Engine
- Engine Dash Mat Replacement - Side
- Description and Operation
- Special Tools and Equipment
- Body Rear End
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Rear Compartment Lid Switch Replacement
- Rear Compartment Lid Ajar Switch Replacement
- Compartment Sill Plate Replacement - Rear
- Compartment Side Trim Replacement - LH Rear
- Compartment Side Trim Replacement - RH Rear
- Net Replacement - Rear Compartment Stowage Tray
- Compartment Front Trim Panel Replacement - Rear
- Floor Trim Plate Replacement - Rear
- Compartment Lid Trim Replacement - Rear
- Wheelhouse Liner Panel Replacement - Rear
- Spoiler Replacement - Rear
- Fuel Filler Door Replacement
- Fuel Filler Pocket Replacement
- Compartment Lid Replacement - Rear
- Hinge Replacement - Rear Compartment Lid
- Strut Replacement - Rear Compartment Lid
- Latch Replacement - Rear Compartment Lid
- Lock Striker Replacement - Rear Compartment Lid
- Wiring Harness Replacement - Rear Compartment Lid
- Pressure Relief Valve Replacement
- Weatherstrip Replacement - Rear Compartment Opening
- Description and Operation
- Special Tools and Equipment
- Bumper System
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Fascia Replacement - Front Bumper
- Fascia Grille Replacement - Front Bumper - Lower
- Fascia Support Replacement - Front Bumper Upper
- Impact Bar Replacement - Front Bumper
- Energy Absorber Replacement - Front
- Fascia Replacement - Rear Bumper
- Fascia Support Replacement - Rear Bumper Outer
- Energy Absorber Replacement - Rear
- Impact Bar Replacement - Rear Bumper
- Description and Operation
- Special Tools and Equipment
- Squeaks And Rattles
- Water Leaks
- Exterior/Interior Trim
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Exterior Trim
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0931
- DTC B3619
- DTC B3620
- DTC B3621
- DTC B3634
- DTC P0461
- DTC P0462
- DTC P0463
- DTC P0464
- DTC P0520
- DTC P0521
- DTC P0522
- DTC P0523
- Symptoms - Instrument Panel, Gages and Console
- Fuel Gage Inaccurate or Inoperative
- Instrument Panel Cluster (IPC) Gages Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On (3.8L)
- Engine Oil Pressure Indicator Always On (5.3L)
- Engine Oil Temperature Indicator Always On
- Low Engine Oil Level Indicator Always On
- Low Engine Oil Level Indicator Inoperative
- MPH (Km/h) Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Switch(es) Inoperative
- Head Up Display (HUD) Inoperative
- Head Up Display (HUD) Hazard Indicators Inoperative
- Head Up Display (HUD) Image Adjustment Inoperative
- Head Up Display (HUD) Intensity Does Not Vary
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Ambient Air Temperature Gage Sensor Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement
- Electronic Compass Calibration
- Electronic Compass Module Replacement
- Head Up Display Window Cleaning
- Head Up Display Switch Replacement
- Head Up Display Replacement
- Closeout/Insulator Panel Replacement - Right
- Closeout/Insulator Panel Replacement - Left
- Knee Bolster Replacement - Right
- Knee Bolster Replacement - Left
- Trim Plate Replacement - Instrument Panel (I/P)
- Trim Plate Replacement - Instrument Panel (I/P) Accessory
- Trim Panel Replacement - Instrument Panel (I/P) Upper
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Bezel Replacement - Instrument Panel (I/P) Cluster
- Filler Panel Replacement - Outer - Instrument Panel (I/P) Lower Trim
- Instrument Panel (I/P) Outer Trim Cover Replacement - Right
- Instrument Panel (I/P) Outer Trim Cover Replacement - Left
- Compartment Replacement - Instrument Panel (I/P) - Center
- Compartment Replacement - Instrument Panel (I/P)
- Striker Replacement - Instrument Panel (I/P) Compartment
- Latch Replacement - Instrument Panel (I/P) Compartment
- Lock Cylinder Replacement - Instrument Panel (I/P) Compartment Door
- Stop Replacement - I/P Compartment Door
- Dampener Replacement - I/P Compartment
- Trim Pad Replacement - Instrument Panel (I/P)
- Steering Column Filler Replacement
- Driver Information Center Replacement
- Instrument Panel Cluster (IPC) Replacement
- Compartment Replacement - Floor Console - Front
- Console Replacement - Front Floor
- Console Armrest Replacement - Front Floor
- Hinge Replacement - Floor Console Arm Rest
- Trim Plate Replacement - Front Floor Console
- Cup Holder Replacement - Front Floor Console - Rear
- Cover Replacement - Floor Console - Rear
- Description and Operation
- Instrument Panel Cluster (IPC) Description and Operation
- Indicator/Warning Message Description and Operation
- Driver Information Center (DIC) Description and Operation
- Head Up Display (HUD) Description and Operation
- Audible Warnings Description and Operation
- Special Tools and Equipment
- Interior Trim
- Specifications
- Repair Instructions
- Eliminating Unwanted Odors in Vehicles
- Carpet Retainer Replacement - Front
- Floor Carpet Drying
- Carpet Replacement - Front
- Sound Barrier Replacement - Rear Seat Back
- Headliner Replacement
- Assist Handle Replacement - Rear
- Console Replacement - Overhead
- Sunshade Replacement
- Sunshade Anchor Replacement
- Garnish Molding Replacement - Windshield Pillar
- Sail Panel Replacement
- Trim Panel Replacement - Upper Center Pillar
- Trim Panel Replacement - Lower Center Pillar
- Trim Panel Replacement - Rear Quarter Upper
- Trim Panel Replacement - Rear Quarter Lower
- Trim Panel Replacement - Rear Window Shelf
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Frames, Subframes & Crossmembers
- Ignition Switch/Steering Lock
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Turn Signal Cancel Cam and Steering Shaft Upper Bearing Spring Replacement
- Multifunction, Turn Signal Switch Replacement
- Turn Signal Switch Housing Replacement
- Tilt Lever Replacement
- Steering Wheel Cover Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Steering Shaft, Lower Bearing, and Jacket Replacement
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Mirrors
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Ambient Air Temperature Sensor Replacement
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Seats
- Seat System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seat Replacement - Front Bucket
- Seat Cushion Replacement - Front
- Seat Cushion Cover Replacement - Front
- Seat Cushion Frame Replacement - Front
- Seat Back Replacement - Front
- Seat Back Cover Replacement - Front (Fold Flat)
- Seat Back Cover Replacement - Front (Except Fold Flat)
- Seat Back Pad Replacement - Front
- Seat Back Frame Replacement - Front
- Seat Back Recliner Handle Replacement - Front
- Seat Back Panel Replacement - Front
- Lumbar Replacement - Front Seat
- Lumbar Switch Replacement
- Seat Adjuster Replacement - Front (Six-Way Power)
- Seat Adjuster Replacement - Front (Two-Way Manual)
- Seat Adjuster Track Cover Replacement - Front
- Seat Switch Replacement - Power
- Seat Adjuster Phase Adjustment - Power
- Drive Cable Replacement - Horizontal
- Drive Cable Replacement - Vertical
- Relay Replacement - Heated Seats - Front
- Seat Back Heater Element Replacement - Front
- Seat Cushion Heater Element Replacement - Front
- Head Restraint Replacement - Front Seat
- Head Restraint Retainer Replacement - Front Seat
- Trim Panel Replacement - Front Seat
- Seat Cushion Replacement - Rear
- Seat Cushion Cover Replacement - Rear
- Seat Cushion Retainer Replacement - Rear
- Seat Back Replacement - Rear (Folding)
- Seat Back Frame Replacement - Rear (Folding)
- Seat Back Bolster Replacement - Rear Split Folding
- Seat Back Cover Replacement - Rear
- Seat Back Pad Replacement - Rear
- Description and Operation
- Special Tools and Equipment
- Seat System
- Sun Roof/T-Top/Convertible Top
- Sunroof System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Roof
- Symptoms - Roof
- Power Sunroof Inoperative (1 Connector System)
- Power Sunroof Inoperative (2 Connector System)
- Power Sunroof Does Not Close
- Power Sunroof Window is Skewed
- Power Sunroof When Operated from Vent to Close One Side Will Drop Before the Other
- Power Sunroof When Closing from the Vent Position the Window Will Reverse Direction
- Power Sunroof Will Stop at the Wrong Location
- Power Sunroof Will Over Travel the Open Position and Stall the Motor
- Power Sunroof Will Over Travel the Close Position and Stall the Motor
- Repair Instructions
- Sunroof Window Height and Opening Fit Adjustment
- Sunroof Track Timing/Synchronization (PES)
- Sunroof Track Timing/Synchronization (MD4)
- Sunroof Drain Inspection and Cleaning
- Sunroof Sunshade Panel Replacement
- Sunroof Window Replacement
- Sunroof Switch Replacement
- Sunroof Motor/Actuator Replacement (PES)
- Sunroof Motor/Actuator Replacement (MD4)
- Sunroof Motor/Actuator Initilization/Teach Process (New Motor)
- Sunroof Motor/Actuator Initilization/Teach Process (Existing Motor)
- Sunroof Control Module Replacement
- Sunroof Wiring Harness Replacement
- Sunroof Module Assembly Replacement (PES)
- Sunroof Module Assembly Replacement (MD4)
- Sunroof Finishing Lace Replacement
- Sunroof Sunshade Stop Replacement
- Sunroof Opening Position Switch Replacement
- Description and Operation
- Special Tools and Equipment
- Sunroof System
- Windows
- Door System, Mirror System & Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Doors
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Doors
- Power Windows Inoperative - All
- Power Windows Inoperative - Express Down Function
- Power Windows Inoperative - Lockout Function
- Power Window Inoperative - Driver Door
- Power Window Inoperative - Passenger Door
- Door Ajar Indicator Malfunction
- Power Door Locks Inoperative - All Doors and Switches
- Power Door Locks Inoperative - Key Cylinder Switches
- Power Door Lock Inoperative - Driver Door
- Power Door Locks Inoperative - Passenger Door
- Automatic Door Locks Inoperative
- Power Mirrors Inoperative
- Repair Instructions
- Mirror, Window, and Door Lock Switch Replacement
- Bezel Replacement - Front Door Switch
- Bezel Replacement - Rear Door Switch
- Power Window Switch Replacement - Rear Door
- Harness Replacement - Front Side Door Switches
- Handle Bezel Replacement - Inside
- Pull Handle Cover Replacement
- Pull Handle Replacement
- Trim Panel Replacement - Side Front Door
- Trim Panel Replacement - Side Rear Door
- Energy Absorber Pad Replacement - Inner Rear
- Trim Panel Energy Absorber Pad - Rear Door
- Reflector Replacement - Front Door Warning
- Reflector Replacement - Rear Door Warning
- Water Deflector Replacement - Front Door
- Water Deflector Replacement - Rear Door
- Door Adjustment - Front
- Door Replacement - Front
- Door Adjustment - Rear
- Door Replacement - Rear
- Hinge Spring Replacement - Front Door
- Hinge Replacement - Front Door
- Hinge Replacement - Rear Door
- Door Handle Replacement - Front Outside
- Door Handle Replacement - Rear Outside
- Door Handle Rod Adjustment - Front Outside
- Door Handle Rod Replacement - Front Outside
- Door Handle Rod Adjustment - Rear Outside
- Door Handle Replacement - Front Inside
- Door Handle Replacement - Rear Inside
- Front Door Inside Handle Rod Replacement
- Door Handle Rod Replacement - Rear Outside
- Door Handle Rod Replacement - Rear Inside
- Locking Rod Replacement - Front Door
- Lock Replacement - Front Door
- Lock Replacement - Rear Door
- Handle Lock Rod Guide Block Replacement
- Lock Actuator Replacement - Front Door
- Lock Actuator Replacement - Rear Door
- Lock Cylinder Replacement - Door
- Frozen Lock Cylinder Repair
- Lock Striker Adjustment - Door
- Striker Anchor Plate Replacement - Door
- Window Adjustment - Front Door
- Window Adjustment - Rear Door
- Window Regulator Replacement - Front Door
- Window Regulator Replacement - Rear Door
- Window Regulator Motor Replacement - Front Door
- Window Regulator Motor Replacement - Rear Door
- Window Replacement - Front Door
- Window Replacement - Rear Door
- Window Channel Retainer Replacement - Front Door
- Window Channel Retainer Replacement - Rear Door
- Window Run Channel Replacement - Rear Door
- Window Replacement - Rear Door Stationary
- Door Frame Applique/Runchannel Replacement - Front
- Door Frame Applique/Runchannel Replacement - Rear
- Rubber Conduit Replacement - Front Door
- Rubber Conduit Replacement - Rear Door
- Sealing Strip Replacement - Front Door Window Belt Outer
- Sealing Strip Replacement - Rear Door Window Belt Outer
- Sealing Strip Replacement - Front Door Window Belt Inner
- Sealing Strip Replacement - Rear Door Window Belt Inner
- Weatherstrip Replacement - Front Door
- Weatherstrip Replacement - Front Door Window
- Weatherstrip Replacement - Rear Door Window
- Weatherstrip Replacement - Center Pillar Auxiliary
- Weatherstrip Replacement - Rear Door Opening
- Mirror Replacement - Power
- Motor Replacement - Power Mirror
- Mirror Face Replacement
- Description and Operation
- Special Tools and Equipment
- Stationary Window System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Ambient Air Temperature Sensor Replacement
- Stationary Window Reveal Molding Repair
- Windshield Reveal Molding Replacement
- Rear Window Reveal Molding Replacement
- Rearview Mirror Replacement
- Rearview Mirror Support Installation
- Windshield Replacement
- Urethane Adhesive Installation of Stationary Windows
- Rear Window Replacement
- Description and Operation
- Special Tools and Equipment
- Door System, Mirror System & Window System
- Door Locks
- Brakes
- Anti-Lock Brakes
- Antilock Brake System, Traction Control System & Stability Control System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Antilock Brake System
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Test Drive
- Enhanced Diagnostics
- DTC C0035-C0051
- DTC C0060-C0095
- DTC C0110
- DTC C0121
- DTC C0131
- DTC C0132
- DTC C0141-C0156
- DTC C0161
- DTC C0186
- DTC C0187
- DTC C0196
- DTC C0197
- DTC C0236
- DTC C0240
- DTC C0241 or P0856
- DTC C0244 or P1689
- DTC C0245
- DTC C0252
- DTC C0253
- DTC C0710
- DTC C0870
- DTC C0875
- DTC C0896
- DTC U1650
- DTC U1651
- Symptoms - Antilock Brake System
- ABS Indicator Always On
- ABS Indicator Inoperative
- Stability System Disabled Indicator Always On
- Traction Off Indicator Always On
- Traction Off Indicator Inoperative
- Repair Instructions
- ABS Automated Bleed Procedure
- Steering Angle Sensor Centering Procedure
- Electronic Brake Control Module Replacement
- Brake Pressure Modulator Valve (BPMV) Replacement
- Brake Fluid Pressure Sensor Replacement
- Brake Pressure Modulator Valve (BPMV) Bracket Replacement
- Wheel Speed Sensor Replacement - Front
- Wheel Speed Sensor Replacement - Rear
- Traction Control Switch Replacement
- Yaw Rate Sensor/Lateral Accelerometer Replacement
- Description and Operation
- ABS Description and Operation
- Notes
- Initialization Sequence
- Antilock Brake System
- Pressure Hold
- Pressure Decrease
- Pressure Increase
- Dynamic Rear Proportioning (DRP)
- Traction Control System (TCS) (NW7)
- Traction Control System (TCS) (NW9)
- Vehicle Stability Enhancement System (VSES)
- MAGNASTEER
- ABS Indicator
- Service ABS System
- Stability Off Indicator
- Brake Warning Indicator
- Traction Control System Indicator(s)
- Stability Control System Indicator(s)
- ABS Description and Operation
- Special Tools and Equipment
- Antilock Brake System, Traction Control System & Stability Control System
- Mechanical - Hydraulic
- Disc Brake System
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Disc Brakes
- Brake Rotor Thickness Measurement
- Brake Rotor Thickness Variation Measurement
- Brake Rotor Surface and Wear Inspection
- Brake Rotor Assembled Lateral Runout (LRO) Measurement
- Brake Pad Inspection
- Brake Caliper Inspection
- Disc Brake Mounting and Hardware Inspection - Front
- Disc Brake Mounting and Hardware Inspection - Rear
- Repair Instructions
- Brake Pads Replacement - Front (RPO J65. JL9)
- Brake Pads Replacement - Front (RPO Z7U)
- Brake Pads Replacement - Rear (RPO J65, JL9)
- Brake Pads Replacement - Rear (RPO Z7U)
- Burnishing Pads and Rotors
- Brake Caliper Replacement - Front (RPO J65, JL9)
- Brake Caliper Replacement - Front (RPO Z7u)
- Brake Caliper Replacement - Rear (RPO J65, JL9)
- Brake Caliper Replacement - Rear (RPO Z7U)
- Brake Caliper Overhaul - Front
- Brake Caliper Overhaul - Rear
- Disc Brake Hardware Replacement - Front
- Disc Brake Hardware Replacement - Rear
- Brake Caliper Bracket Replacement - Front (RPO J65,JL9)
- Brake Caliper Bracket Replacement - Front (RPO Z7U)
- Brake Caliper Bracket Replacement - Rear (RPO J5, JL9)
- Brake Caliper Bracket Replacement - Rear (RPO Z7U)
- Brake Rotor Replacement - Front (RPO J65, JL9)
- Brake Rotor Replacement - Front (RPO Z7U)
- Brake Rotor Replacement - Rear (RPO J65, JL9)
- Brake Rotor Replacement - Rear (RPO Z7U)
- Disc Brake Backing Plate Replacement - Rear
- Brake Rotor Assembled Lateral Runout (LRO) Correction
- Brake Rotor Assembled Lateral Runout (LRO) Correction - Indexing
- Brake Rotor Assembled Lateral Runout (LRO) Correction - Correction Plates
- Brake Rotor Assembled Lateral Runout (LRO) Correction - On-Vehicle Lathe
- Brake Rotor Refinishing
- Description and Operation
- Special Tools and Equipment
- Hydraulic Brake System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Hydraulic Brakes
- Scan Tool Data List
- Scan Tool Data Definitions
- Symptoms - Hydraulic Brakes
- Brake Warning Indicator Always On
- Brake Warning Indicator Inoperative
- Brake Pulsation
- Brake System Noise
- Braking Action Uneven - Pulls to One Side
- Braking Action Uneven - Front to Rear
- Brake Pedal Excessive Travel
- Brake Pedal Excessive Effort
- Brakes Drag
- Brake System Slow Release
- Brake Fluid Loss
- Disc Brake System Diagnosis
- Hydraulic Brake System Diagnosis
- Brake Assist System Diagnosis
- Brake System Vehicle Road Test
- Brake Pedal Travel Measurement and Inspection
- Brake System Vacuum Source Test
- Brake System External Leak Inspection
- Brake System Internal Leak Test
- Hydraulic Brake Component Operation Visual Inspection
- Brake Pipe and Hose Inspection
- Brake Pedal Pushrod Inspection
- Repair Instructions
- Master Cylinder Reservoir Filling
- Master Cylinder Reservoir Replacement
- Master Cylinder Replacement
- Master Cylinder Overhaul
- Master Cylinder Bench Bleeding
- Master Cylinder Fluid Level Sensor Replacement
- Brake Pedal Assembly Replacement
- Brake Pipe Replacement
- Brake Hose Replacement - Front
- Brake Hose Replacement - Rear
- Hydraulic Brake System Bleeding (Manual)
- Hydraulic Brake System Bleeding (Pressure)
- Hydraulic Brake System Flushing
- Vacuum Brake Booster Replacement (3.8L)
- Vacuum Brake Booster Check Valve and/or Hose Replacement
- Description and Operation
- Special Tools and Equipment
- Disc Brake System
- Parking Brake System
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Park Brake Shoe Replacement
- Park Brake Pedal Assembly Replacement
- Park Brake Warning Lamp Switch Replacement
- Park Brake Cable Replacement - Front
- Park Brake Cable Replacement - Rear (Z7U)
- Park Brake Cable Replacement - Left Rear
- Park Brake Cable Replacement - Right Rear
- Park Brake Cable Equalizer Replacement
- Park Brake Actuator Replacement
- Park Brake Adjustment (L26 and L32)
- Park Brake Adjustment (Z7U)
- Description and Operation
- Special Tools and Equipment
- Antilock Brake System, Traction Control System & Stability Control System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Antilock Brake System
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Test Drive
- Enhanced Diagnostics
- DTC C0035-C0051
- DTC C0060-C0095
- DTC C0110
- DTC C0121
- DTC C0131
- DTC C0132
- DTC C0141-C0156
- DTC C0161
- DTC C0186
- DTC C0187
- DTC C0196
- DTC C0197
- DTC C0236
- DTC C0240
- DTC C0241 or P0856
- DTC C0244 or P1689
- DTC C0245
- DTC C0252
- DTC C0253
- DTC C0710
- DTC C0870
- DTC C0875
- DTC C0896
- DTC U1650
- DTC U1651
- Symptoms - Antilock Brake System
- ABS Indicator Always On
- ABS Indicator Inoperative
- Stability System Disabled Indicator Always On
- Traction Off Indicator Always On
- Traction Off Indicator Inoperative
- Repair Instructions
- ABS Automated Bleed Procedure
- Steering Angle Sensor Centering Procedure
- Electronic Brake Control Module Replacement
- Brake Pressure Modulator Valve (BPMV) Replacement
- Brake Fluid Pressure Sensor Replacement
- Brake Pressure Modulator Valve (BPMV) Bracket Replacement
- Wheel Speed Sensor Replacement - Front
- Wheel Speed Sensor Replacement - Rear
- Traction Control Switch Replacement
- Yaw Rate Sensor/Lateral Accelerometer Replacement
- Description and Operation
- ABS Description and Operation
- Notes
- Initialization Sequence
- Antilock Brake System
- Pressure Hold
- Pressure Decrease
- Pressure Increase
- Dynamic Rear Proportioning (DRP)
- Traction Control System (TCS) (NW7)
- Traction Control System (TCS) (NW9)
- Vehicle Stability Enhancement System (VSES)
- MAGNASTEER
- ABS Indicator
- Service ABS System
- Stability Off Indicator
- Brake Warning Indicator
- Traction Control System Indicator(s)
- Stability Control System Indicator(s)
- ABS Description and Operation
- Special Tools and Equipment
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Body Electrical
- Accessory Power Socket
- OEM Connector End Views
- Connector End Views
- Ambient Air Temperature Sensor Connector End View
- Driver Information Center (DIC) Connector End View
- Electronic Compass Module Connector End View
- Engine Oil Level Switch (L26/L32) Connector End View
- Engine Oil Level Switch (LS4) Connector End View
- Engine Oil Pressure (EOP) Switch Connector End View
- Fuel Pump and Sender Assembly Connector End View
- Head Up Display (HUD) (UV6) Connector End View
- Head Up Display (HUD) Switch (UV6) Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Washer Fluid Level Switch Connector End View
- Windshield Wiper/Washer Switch Connector End View
- Windshield Wiper Motor Connector End View
- Sunroof Motor C1 Connector End View (Early Production)
- Sunroof Motor C2 Connector End View (Early Production)
- Sunroof Motor Connector End View (Late Production)
- Sunroof Module C1 Connector End View
- Sunroof Module C2 Connector End View
- Sunroof Switch Connector End View
- Heated Seat Element - Driver Back Connector End View
- Heated Seat Element - Driver Cushion Connector End View
- Heated Seat Element - Front Passenger Back Connector End View
- Heated Seat Element - Front Passenger Cushion Connector End View
- Heated Seat Relay - Driver Connector End View
- Heated Seat Relay - Front Passenger Connector End View
- Seat Adjuster Motor Assembly - Driver Connector End View
- Seat Adjuster Switch - Driver Connector End View
- Seat Horizontal Motor - Driver Connector End View
- Seat Lumbar Switch - Driver Connector End View
- Seat Lumbar Vertical Motor Connector End View
- Door Lock - Driver Connector End View
- Door Lock - Front Passenger Connector End View
- Door Lock - LR Connector End View
- Door Lock - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Front Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver C1 Connector End View
- Window Switch - Driver C2 Connector End View
- Window Switch - Front Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Ambient Light Sensor Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Brake Pedal Position Sensor Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Courtesy/Reading Lamp - Front (TR9, CF5) Connector End View
- Courtesy/Reading Lamp - Left Connector End View
- Courtesy/Reading Lamp - Right Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Headlamp - High Beam - Left Connector End View
- Headlamp - High Beam - Right Connector End View
- Headlamp Low Beam - Left Connector End View
- Headlamp Low Beam - Right Connector End View
- Interior Lamp Switch Connector End View
- I/P Compartment Lamp and Switch Connector End View
- I/P Courtesy Lamp - Left Connector End View
- I/P Courtesy Lamp - Right Connector End View
- License Lamp - Left Connector End View
- License Lamp - Right Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - LR Connector End View
- Marker Lamp - RF Connector End View
- Marker Lamp - RR Connector End View
- Multifunction Turn Signal Lever - C1 Connector End View
- Multifunction Turn Signal Lever - C2 Connector End View
- Multifunction Turn Signal Lever - C3 Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- PRNDL Lamp Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Sunload Sensor Assembly Connector End View
- Tail Lamp - Left Connector End View
- Tail Lamp - Right Connector End View
- Tail/Stop and Turn Signal Lamp - Left Connector End View
- Tail/Stop and Turn Signal Lamp - Right Connector End View
- Vanity Mirror Lamp - Left (CF5) Connector End View
- Vanity Mirror Lamp - Left (TR9) Connector End View
- Vanity Mirror Lamp - Right (CF5) Connector End View
- Vanity Mirror Lamp - Right (TR9) Connector End View
- Accessory Power Outlet - Front Connector End View
- Accessory Power Outlet - Rear Connector End View
- Cooling Fan - Left Connector End View
- Cooling Fan - Right Connector End View
- Audio Amplifier - C1 (U87) Connector End View
- Audio Amplifier - C2 (U87) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio - C1 Connector End View
- Radio - C2 Connector End View
- Radio, C3 (US4) Connector End View
- Speaker - Center Connector End View
- Speaker - LF Door Connector End View
- Speaker - LF Door Tweeter Connector End View
- Speaker - RF Door Connector End View
- Speaker - RF Door Tweeter Connector End View
- Speaker - LR (UW6) Connector End View
- Speaker - LR (U87) Connector End View
- Speaker - RR (UW6) Connector End View
- Speaker - RR (U87) Connector End View
- Steering Wheel Controls - Left Connector End View
- Steering Wheel Controls - Right Connector End View
- Seat Belt Switch Connector End View
- Brake Booster Vacuum Sensor Connector End View (5.3L)
- Crankshaft Position (CKP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 2 Connector End View (5.3L)
- Fuel Injector 7 Connector End View (5.3L)
- Fuel Injector 5 Connector End View (5.3L)
- Fuel Injector 3 Connector End View (5.3L)
- Fuel Injector 1 Connector End View (5.3L)
- Fuel Injector 2 Connector End View (5.3L)
- Fuel Injector 4 Connector End View (5.3L)
- Fuel Injector 6 Connector End View (5.3L)
- Fuel Injector 8 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 2 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 1 Connector End View (5.3L)
- Camshaft Position (CMP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 1 Connector End View (5.3L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (5.3L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Connector End View (5.3L)
- Intake Air Temperature (IAT)/Mass Air Flow (MAF) Sensor Connector End View (5.3L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (5.3L)
- Throttle Actuator Control (TAC) Module Connector End View (5.3L)
- Engine Oil Pressure (EOP) Sensor Connector End View (5.3L)
- Value Lifter Oil Manifold (VLOM) Assembly Connector End View (5.3L)
- Powertrain Control Module (PCM) C1 (NU3) Connector End View
- Powertrain Control Module (PCM) C1 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C2 (NU3) Connector End View
- Powertrain Control Module (PCM) C2 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C3 (NU3) Connector End View
- Powertrain Control Module (PCM) C3 (w/o NU3) Connector End View
- Accelerator Pedal Position (APP) Sensor Connector End View (3.8L)
- Barometric Pressure (BARO) Sensor (L32) Connector End View (3.8L)
- Camshaft Position (CMP) Sensor Connector End View (3.8L)
- Crankshaft Position (CKP) Sensor Connector End View (3.8L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (3.8L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Connector End View (3.8L)
- Evaporative Emissions (EVAP) Canister Vent Solenoid Connector End View (3.8L)
- Exhaust Gas Recirculation (EGR) Valve Connector End View (3.8L)
- Fuel Injector 1 Connector End View (3.8L)
- Fuel Injector 2 Connector End View (3.8L)
- Fuel Injector 3 Connector End View (3.8L)
- Fuel Injector 4 Connector End View (3.8L)
- Fuel Injector 5 Connector End View (3.8L)
- Fuel Injector 6 Connector End View (3.8L)
- Fuel Pump and Sender Assembly Connector End View (3.8L)
- Fuel Tank Pressure (FTP) Sensor Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (w/o NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 2 Connector End View (3.8L)
- Ignition Control Module (ICM) Connector End View (3.8L)
- Knock Sensor (KS) Bank 1 Connector End View (3.8L)
- Knock Sensor (KS) Bank 2 Connector End View (3.8L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (3.8L)
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Connector End View (3.8L)
- Secondary Air Injection (AIR) Control Solenoid Valve/Pressure Sensor Bank 2 Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Relay Connector End View (3.8L)
- Secondary Air Injection (AIR) Valve Relay Connector End View (3.8L)
- Supercharger Boost Control Solenoid (L32) Connector End View (3.8L)
- Throttle Actuator Control (TAC) Module Connector End View (3.8L)
- Horn Assembly Connector End View
- Theft Deterrent Exciter Module Connector End View
- Rear Compartment Lid Ajar Switch Connector End View
- Theft LED Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Brake Fluid Pressure Sensor Connector End View (JL4)
- Brake Fluid Pressure Sensor Connector End View (LS4)
- Electronic Brake Control Module (EBCM) Connector End View
- Steering Angle Sensor Connector End View (JL4)
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Yaw and Lateral Acceleration Sensor Connector End View (JL4)
- Body Control Module (BCM) C1 Connector End View
- Body Control Module (BCM) C2 Connector End View
- Body Control Module (BCM) C3 Connector End View
- Data Link Connector (DLC) Connector End View (L26/L32)
- Data Link Connector (DLC) Connector End View (LS4)
- Splice Pack SP 205 Connector End View
- Rear Window Defogger Grid, C1 Connector End View
- Rear Window Defogger Grid, C2 Connector End View
- Inside Rearview Mirror Connector End Views
- Vehicle Communication Interface Module (VCIM) - C1 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C2 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C3 (US4) Connector End Views
- Rear Compartment Lid Latch Connector End View
- A/C Compressor Clutch Connector End View (L26/L32)
- A/C Compressor Clutch Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (L26/L32)
- Air Temperature Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Control Processor Connector End View
- HVAC Control Module Connector End View
- Mode Actuator Connector End View
- Recirculation Actuator Connector End View
- AT Inline 20-way Connector End View, Engine Side
- AT Inline 20-way Connector End View, Transmission Side
- TAP Shift Switch - Right Connector End View
- TAP Shift Switch - Left Connector End View
- Vehicle Speed Sensor Connector End View, Wiring Harness Side
- 1-2 Shift Solenoid Valve Connector End View, Wiring Harness Side
- 2-3 Shift Solenoid Valve Connector End View, Wiring Harness Side
- Automatic Transmission Fluid Pressure Manual Valve Position Switch Connector End View, Wiring Harness Side
- Input Speed Sensor Connector End View, Wiring Harness Side
- Pressure Control Solenoid Valve Connector End View, Wiring Harness Side
- Torque Converter Clutch Pulse Width Modulated Solenoid Valve Connector End View, Wiring Harness Side
- Transmission Fluid Temperature Sensor Connector End View, Wiring Harness Side
- Transmission Internal Mode Switch Connector End View, Wiring Harness Side
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Air Temperature Actuator - Left Connector End View
- Air Temperature Actuator - Right Connector End View
- Air Temperature Sensor - Inside Connector End View
- Air Temperature Sensor - Lower Left Connector End View
- Air Temperature Sensor - Lower Right Connector End View
- Air Temperature Sensor - Upper Left Connector End View
- Air Temperature Sensor - Upper Right Connector End View
- HVAC Control Module, C1 Connector End View
- HVAC Control Module, C2 Connector End View
- Inflatable Restraint Front End Discriminating Sensor Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Side Impact Sensor - Left Connector End View (AY1)
- Inflatable Restraint Side Impact Sensor - Right Connector End View (AY1)
- Inflatable Restraint Steering Wheel Module Coil C1 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C2 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C3 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (W/O UK3)
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (UK3)
- Inflatable Restraint Steering Wheel Module Coil C5 Connector End View
- Roof Rail Module - Left Connector End View (AY1)
- Roof Rail Module - Right Connector End View (AY1)
- Seat Belt Pretensioner - Left Connector End View
- Seat Belt Pretensioner - Right Connector End View
- Cruise Control Switch Connector End View
- Battery Current Sensor Connector End View
- Generator Connector End View (L26/L32)
- Generator Connector End View (LS4)
- Hood Ajar Switch Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Magnasteer Actuator Connector End View
- Automatic Transmission Related Connector End Views
- Connector End Views
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Special Tools and Equipment
- Charging Systems
- Battery, Charging System And Starting System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B1327
- DTC B1328
- DTC B1516
- DTC P0560
- DTC P0562
- DTC P0563
- DTC P0615
- DTC P0621
- DTC P0622
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Remote Start Does Not Work
- Repair Instructions
- Battery Negative Cable Disconnect/Connect Procedure (RPOs L26/L32)
- Battery Negative Cable Disconnect/Connect Procedure (RPO LS4)
- Battery Current Sensor Replacement (RPOs L26/L32)
- Battery Current Sensor Replacement (RPO LS4)
- Battery Negative Cable Replacement (RPOs L26/L32)
- Battery Negative Cable Replacement (RPO LS4)
- Battery Positive Cable Replacement (RPOs L26/L32)
- Battery Positive Cable Replacement (RPO LS4)
- Battery Replacement (RPOs L26/L32)
- Battery Replacement (RPO LS4)
- Battery Tray Replacement (RPOs L26/L32)
- Battery Tray Replacement (RPO LS4)
- Starter Motor Replacement (RPOs L26/L32)
- Starter Motor Replacement (RPO LS4)
- Generator Bracket Replacement (RPO LS4)
- Generator Brace Replacement (L26)
- Generator Brace Replacement (L32)
- Generator Replacement (RPOs L26/L32)
- Generator Replacement (RPO LS4)
- Description and Operation
- Special Tools and Equipment
- Battery, Charging System And Starting System
- Component Locations
- Diagnostic Connector (DLC) Locations
- Electrical Component Locator
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Special Tools and Equipment
- Fuses & Circuit Breakers
- Instrument Panel System Displays, Gauges And Console
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Instrument Panel, Gages and Console
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0931
- DTC B3619
- DTC B3620
- DTC B3621
- DTC B3634
- DTC P0461
- DTC P0462
- DTC P0463
- DTC P0464
- DTC P0520
- DTC P0521
- DTC P0522
- DTC P0523
- Symptoms - Instrument Panel, Gages and Console
- Fuel Gage Inaccurate or Inoperative
- Instrument Panel Cluster (IPC) Gages Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On (3.8L)
- Engine Oil Pressure Indicator Always On (5.3L)
- Engine Oil Temperature Indicator Always On
- Low Engine Oil Level Indicator Always On
- Low Engine Oil Level Indicator Inoperative
- MPH (Km/h) Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Switch(es) Inoperative
- Head Up Display (HUD) Inoperative
- Head Up Display (HUD) Hazard Indicators Inoperative
- Head Up Display (HUD) Image Adjustment Inoperative
- Head Up Display (HUD) Intensity Does Not Vary
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Ambient Air Temperature Gage Sensor Replacement
- Ignition Switch Lock Cylinder Replacement
- Ignition Switch Replacement
- Electronic Compass Calibration
- Electronic Compass Module Replacement
- Head Up Display Window Cleaning
- Head Up Display Switch Replacement
- Head Up Display Replacement
- Closeout/Insulator Panel Replacement - Right
- Closeout/Insulator Panel Replacement - Left
- Knee Bolster Replacement - Right
- Knee Bolster Replacement - Left
- Trim Plate Replacement - Instrument Panel (I/P)
- Trim Plate Replacement - Instrument Panel (I/P) Accessory
- Trim Panel Replacement - Instrument Panel (I/P) Upper
- Trim Panel Replacement - Instrument Panel (I/P) Cluster
- Bezel Replacement - Instrument Panel (I/P) Cluster
- Filler Panel Replacement - Outer - Instrument Panel (I/P) Lower Trim
- Instrument Panel (I/P) Outer Trim Cover Replacement - Right
- Instrument Panel (I/P) Outer Trim Cover Replacement - Left
- Compartment Replacement - Instrument Panel (I/P) - Center
- Compartment Replacement - Instrument Panel (I/P)
- Striker Replacement - Instrument Panel (I/P) Compartment
- Latch Replacement - Instrument Panel (I/P) Compartment
- Lock Cylinder Replacement - Instrument Panel (I/P) Compartment Door
- Stop Replacement - I/P Compartment Door
- Dampener Replacement - I/P Compartment
- Trim Pad Replacement - Instrument Panel (I/P)
- Steering Column Filler Replacement
- Driver Information Center Replacement
- Instrument Panel Cluster (IPC) Replacement
- Compartment Replacement - Floor Console - Front
- Console Replacement - Front Floor
- Console Armrest Replacement - Front Floor
- Hinge Replacement - Floor Console Arm Rest
- Trim Plate Replacement - Front Floor Console
- Cup Holder Replacement - Front Floor Console - Rear
- Cover Replacement - Floor Console - Rear
- Description and Operation
- Instrument Panel Cluster (IPC) Description and Operation
- Indicator/Warning Message Description and Operation
- Driver Information Center (DIC) Description and Operation
- Head Up Display (HUD) Description and Operation
- Audible Warnings Description and Operation
- Special Tools and Equipment
- Horns
- Horn System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Horn System
- Motors, Switches, Relays
- Accessory Power Socket
- OEM Connector End Views
- Connector End Views
- Ambient Air Temperature Sensor Connector End View
- Driver Information Center (DIC) Connector End View
- Electronic Compass Module Connector End View
- Engine Oil Level Switch (L26/L32) Connector End View
- Engine Oil Level Switch (LS4) Connector End View
- Engine Oil Pressure (EOP) Switch Connector End View
- Fuel Pump and Sender Assembly Connector End View
- Head Up Display (HUD) (UV6) Connector End View
- Head Up Display (HUD) Switch (UV6) Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Washer Fluid Level Switch Connector End View
- Windshield Wiper/Washer Switch Connector End View
- Windshield Wiper Motor Connector End View
- Sunroof Motor C1 Connector End View (Early Production)
- Sunroof Motor C2 Connector End View (Early Production)
- Sunroof Motor Connector End View (Late Production)
- Sunroof Module C1 Connector End View
- Sunroof Module C2 Connector End View
- Sunroof Switch Connector End View
- Heated Seat Element - Driver Back Connector End View
- Heated Seat Element - Driver Cushion Connector End View
- Heated Seat Element - Front Passenger Back Connector End View
- Heated Seat Element - Front Passenger Cushion Connector End View
- Heated Seat Relay - Driver Connector End View
- Heated Seat Relay - Front Passenger Connector End View
- Seat Adjuster Motor Assembly - Driver Connector End View
- Seat Adjuster Switch - Driver Connector End View
- Seat Horizontal Motor - Driver Connector End View
- Seat Lumbar Switch - Driver Connector End View
- Seat Lumbar Vertical Motor Connector End View
- Door Lock - Driver Connector End View
- Door Lock - Front Passenger Connector End View
- Door Lock - LR Connector End View
- Door Lock - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Front Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver C1 Connector End View
- Window Switch - Driver C2 Connector End View
- Window Switch - Front Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Ambient Light Sensor Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Brake Pedal Position Sensor Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Courtesy/Reading Lamp - Front (TR9, CF5) Connector End View
- Courtesy/Reading Lamp - Left Connector End View
- Courtesy/Reading Lamp - Right Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Headlamp - High Beam - Left Connector End View
- Headlamp - High Beam - Right Connector End View
- Headlamp Low Beam - Left Connector End View
- Headlamp Low Beam - Right Connector End View
- Interior Lamp Switch Connector End View
- I/P Compartment Lamp and Switch Connector End View
- I/P Courtesy Lamp - Left Connector End View
- I/P Courtesy Lamp - Right Connector End View
- License Lamp - Left Connector End View
- License Lamp - Right Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - LR Connector End View
- Marker Lamp - RF Connector End View
- Marker Lamp - RR Connector End View
- Multifunction Turn Signal Lever - C1 Connector End View
- Multifunction Turn Signal Lever - C2 Connector End View
- Multifunction Turn Signal Lever - C3 Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- PRNDL Lamp Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Sunload Sensor Assembly Connector End View
- Tail Lamp - Left Connector End View
- Tail Lamp - Right Connector End View
- Tail/Stop and Turn Signal Lamp - Left Connector End View
- Tail/Stop and Turn Signal Lamp - Right Connector End View
- Vanity Mirror Lamp - Left (CF5) Connector End View
- Vanity Mirror Lamp - Left (TR9) Connector End View
- Vanity Mirror Lamp - Right (CF5) Connector End View
- Vanity Mirror Lamp - Right (TR9) Connector End View
- Accessory Power Outlet - Front Connector End View
- Accessory Power Outlet - Rear Connector End View
- Cooling Fan - Left Connector End View
- Cooling Fan - Right Connector End View
- Audio Amplifier - C1 (U87) Connector End View
- Audio Amplifier - C2 (U87) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio - C1 Connector End View
- Radio - C2 Connector End View
- Radio, C3 (US4) Connector End View
- Speaker - Center Connector End View
- Speaker - LF Door Connector End View
- Speaker - LF Door Tweeter Connector End View
- Speaker - RF Door Connector End View
- Speaker - RF Door Tweeter Connector End View
- Speaker - LR (UW6) Connector End View
- Speaker - LR (U87) Connector End View
- Speaker - RR (UW6) Connector End View
- Speaker - RR (U87) Connector End View
- Steering Wheel Controls - Left Connector End View
- Steering Wheel Controls - Right Connector End View
- Seat Belt Switch Connector End View
- Brake Booster Vacuum Sensor Connector End View (5.3L)
- Crankshaft Position (CKP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 2 Connector End View (5.3L)
- Fuel Injector 7 Connector End View (5.3L)
- Fuel Injector 5 Connector End View (5.3L)
- Fuel Injector 3 Connector End View (5.3L)
- Fuel Injector 1 Connector End View (5.3L)
- Fuel Injector 2 Connector End View (5.3L)
- Fuel Injector 4 Connector End View (5.3L)
- Fuel Injector 6 Connector End View (5.3L)
- Fuel Injector 8 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 2 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 1 Connector End View (5.3L)
- Camshaft Position (CMP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 1 Connector End View (5.3L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (5.3L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Connector End View (5.3L)
- Intake Air Temperature (IAT)/Mass Air Flow (MAF) Sensor Connector End View (5.3L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (5.3L)
- Throttle Actuator Control (TAC) Module Connector End View (5.3L)
- Engine Oil Pressure (EOP) Sensor Connector End View (5.3L)
- Value Lifter Oil Manifold (VLOM) Assembly Connector End View (5.3L)
- Powertrain Control Module (PCM) C1 (NU3) Connector End View
- Powertrain Control Module (PCM) C1 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C2 (NU3) Connector End View
- Powertrain Control Module (PCM) C2 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C3 (NU3) Connector End View
- Powertrain Control Module (PCM) C3 (w/o NU3) Connector End View
- Accelerator Pedal Position (APP) Sensor Connector End View (3.8L)
- Barometric Pressure (BARO) Sensor (L32) Connector End View (3.8L)
- Camshaft Position (CMP) Sensor Connector End View (3.8L)
- Crankshaft Position (CKP) Sensor Connector End View (3.8L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (3.8L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Connector End View (3.8L)
- Evaporative Emissions (EVAP) Canister Vent Solenoid Connector End View (3.8L)
- Exhaust Gas Recirculation (EGR) Valve Connector End View (3.8L)
- Fuel Injector 1 Connector End View (3.8L)
- Fuel Injector 2 Connector End View (3.8L)
- Fuel Injector 3 Connector End View (3.8L)
- Fuel Injector 4 Connector End View (3.8L)
- Fuel Injector 5 Connector End View (3.8L)
- Fuel Injector 6 Connector End View (3.8L)
- Fuel Pump and Sender Assembly Connector End View (3.8L)
- Fuel Tank Pressure (FTP) Sensor Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (w/o NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 2 Connector End View (3.8L)
- Ignition Control Module (ICM) Connector End View (3.8L)
- Knock Sensor (KS) Bank 1 Connector End View (3.8L)
- Knock Sensor (KS) Bank 2 Connector End View (3.8L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (3.8L)
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Connector End View (3.8L)
- Secondary Air Injection (AIR) Control Solenoid Valve/Pressure Sensor Bank 2 Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Relay Connector End View (3.8L)
- Secondary Air Injection (AIR) Valve Relay Connector End View (3.8L)
- Supercharger Boost Control Solenoid (L32) Connector End View (3.8L)
- Throttle Actuator Control (TAC) Module Connector End View (3.8L)
- Horn Assembly Connector End View
- Theft Deterrent Exciter Module Connector End View
- Rear Compartment Lid Ajar Switch Connector End View
- Theft LED Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Brake Fluid Pressure Sensor Connector End View (JL4)
- Brake Fluid Pressure Sensor Connector End View (LS4)
- Electronic Brake Control Module (EBCM) Connector End View
- Steering Angle Sensor Connector End View (JL4)
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Yaw and Lateral Acceleration Sensor Connector End View (JL4)
- Body Control Module (BCM) C1 Connector End View
- Body Control Module (BCM) C2 Connector End View
- Body Control Module (BCM) C3 Connector End View
- Data Link Connector (DLC) Connector End View (L26/L32)
- Data Link Connector (DLC) Connector End View (LS4)
- Splice Pack SP 205 Connector End View
- Rear Window Defogger Grid, C1 Connector End View
- Rear Window Defogger Grid, C2 Connector End View
- Inside Rearview Mirror Connector End Views
- Vehicle Communication Interface Module (VCIM) - C1 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C2 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C3 (US4) Connector End Views
- Rear Compartment Lid Latch Connector End View
- A/C Compressor Clutch Connector End View (L26/L32)
- A/C Compressor Clutch Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (L26/L32)
- Air Temperature Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Control Processor Connector End View
- HVAC Control Module Connector End View
- Mode Actuator Connector End View
- Recirculation Actuator Connector End View
- AT Inline 20-way Connector End View, Engine Side
- AT Inline 20-way Connector End View, Transmission Side
- TAP Shift Switch - Right Connector End View
- TAP Shift Switch - Left Connector End View
- Vehicle Speed Sensor Connector End View, Wiring Harness Side
- 1-2 Shift Solenoid Valve Connector End View, Wiring Harness Side
- 2-3 Shift Solenoid Valve Connector End View, Wiring Harness Side
- Automatic Transmission Fluid Pressure Manual Valve Position Switch Connector End View, Wiring Harness Side
- Input Speed Sensor Connector End View, Wiring Harness Side
- Pressure Control Solenoid Valve Connector End View, Wiring Harness Side
- Torque Converter Clutch Pulse Width Modulated Solenoid Valve Connector End View, Wiring Harness Side
- Transmission Fluid Temperature Sensor Connector End View, Wiring Harness Side
- Transmission Internal Mode Switch Connector End View, Wiring Harness Side
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Air Temperature Actuator - Left Connector End View
- Air Temperature Actuator - Right Connector End View
- Air Temperature Sensor - Inside Connector End View
- Air Temperature Sensor - Lower Left Connector End View
- Air Temperature Sensor - Lower Right Connector End View
- Air Temperature Sensor - Upper Left Connector End View
- Air Temperature Sensor - Upper Right Connector End View
- HVAC Control Module, C1 Connector End View
- HVAC Control Module, C2 Connector End View
- Inflatable Restraint Front End Discriminating Sensor Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Side Impact Sensor - Left Connector End View (AY1)
- Inflatable Restraint Side Impact Sensor - Right Connector End View (AY1)
- Inflatable Restraint Steering Wheel Module Coil C1 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C2 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C3 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (W/O UK3)
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (UK3)
- Inflatable Restraint Steering Wheel Module Coil C5 Connector End View
- Roof Rail Module - Left Connector End View (AY1)
- Roof Rail Module - Right Connector End View (AY1)
- Seat Belt Pretensioner - Left Connector End View
- Seat Belt Pretensioner - Right Connector End View
- Cruise Control Switch Connector End View
- Battery Current Sensor Connector End View
- Generator Connector End View (L26/L32)
- Generator Connector End View (LS4)
- Hood Ajar Switch Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Magnasteer Actuator Connector End View
- Automatic Transmission Related Connector End Views
- Connector End Views
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Special Tools and Equipment
- Starter
- Battery, Charging System And Starting System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B1327
- DTC B1328
- DTC B1516
- DTC P0560
- DTC P0562
- DTC P0563
- DTC P0615
- DTC P0621
- DTC P0622
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Remote Start Does Not Work
- Repair Instructions
- Battery Negative Cable Disconnect/Connect Procedure (RPOs L26/L32)
- Battery Negative Cable Disconnect/Connect Procedure (RPO LS4)
- Battery Current Sensor Replacement (RPOs L26/L32)
- Battery Current Sensor Replacement (RPO LS4)
- Battery Negative Cable Replacement (RPOs L26/L32)
- Battery Negative Cable Replacement (RPO LS4)
- Battery Positive Cable Replacement (RPOs L26/L32)
- Battery Positive Cable Replacement (RPO LS4)
- Battery Replacement (RPOs L26/L32)
- Battery Replacement (RPO LS4)
- Battery Tray Replacement (RPOs L26/L32)
- Battery Tray Replacement (RPO LS4)
- Starter Motor Replacement (RPOs L26/L32)
- Starter Motor Replacement (RPO LS4)
- Generator Bracket Replacement (RPO LS4)
- Generator Brace Replacement (L26)
- Generator Brace Replacement (L32)
- Generator Replacement (RPOs L26/L32)
- Generator Replacement (RPO LS4)
- Description and Operation
- Special Tools and Equipment
- Battery, Charging System And Starting System
- Wiring Diagrams
- OEM Connector End Views
- Connector End Views
- Ambient Air Temperature Sensor Connector End View
- Driver Information Center (DIC) Connector End View
- Electronic Compass Module Connector End View
- Engine Oil Level Switch (L26/L32) Connector End View
- Engine Oil Level Switch (LS4) Connector End View
- Engine Oil Pressure (EOP) Switch Connector End View
- Fuel Pump and Sender Assembly Connector End View
- Head Up Display (HUD) (UV6) Connector End View
- Head Up Display (HUD) Switch (UV6) Connector End View
- Instrument Panel Cluster (IPC) Connector End View
- Windshield Washer Fluid Pump Connector End View
- Windshield Washer Fluid Level Switch Connector End View
- Windshield Wiper/Washer Switch Connector End View
- Windshield Wiper Motor Connector End View
- Sunroof Motor C1 Connector End View (Early Production)
- Sunroof Motor C2 Connector End View (Early Production)
- Sunroof Motor Connector End View (Late Production)
- Sunroof Module C1 Connector End View
- Sunroof Module C2 Connector End View
- Sunroof Switch Connector End View
- Heated Seat Element - Driver Back Connector End View
- Heated Seat Element - Driver Cushion Connector End View
- Heated Seat Element - Front Passenger Back Connector End View
- Heated Seat Element - Front Passenger Cushion Connector End View
- Heated Seat Relay - Driver Connector End View
- Heated Seat Relay - Front Passenger Connector End View
- Seat Adjuster Motor Assembly - Driver Connector End View
- Seat Adjuster Switch - Driver Connector End View
- Seat Horizontal Motor - Driver Connector End View
- Seat Lumbar Switch - Driver Connector End View
- Seat Lumbar Vertical Motor Connector End View
- Door Lock - Driver Connector End View
- Door Lock - Front Passenger Connector End View
- Door Lock - LR Connector End View
- Door Lock - RR Connector End View
- Door Lock Switch - Driver Connector End View
- Door Lock Switch - Front Passenger Connector End View
- Outside Rearview Mirror - Driver Connector End View
- Outside Rearview Mirror - Passenger Connector End View
- Outside Rearview Mirror Switch Connector End View
- Window Motor - Driver Connector End View
- Window Motor - Front Passenger Connector End View
- Window Motor - LR Connector End View
- Window Motor - RR Connector End View
- Window Switch - Driver C1 Connector End View
- Window Switch - Driver C2 Connector End View
- Window Switch - Front Passenger Connector End View
- Window Switch - LR Connector End View
- Window Switch - RR Connector End View
- Ambient Light Sensor Connector End View
- Backup Lamp - Left Connector End View
- Backup Lamp - Right Connector End View
- Brake Pedal Position Sensor Connector End View
- Center High Mounted Stop Lamp (CHMSL) Connector End View
- Courtesy/Reading Lamp - Front (TR9, CF5) Connector End View
- Courtesy/Reading Lamp - Left Connector End View
- Courtesy/Reading Lamp - Right Connector End View
- Fog Lamp - LF Connector End View
- Fog Lamp - RF Connector End View
- Headlamp - High Beam - Left Connector End View
- Headlamp - High Beam - Right Connector End View
- Headlamp Low Beam - Left Connector End View
- Headlamp Low Beam - Right Connector End View
- Interior Lamp Switch Connector End View
- I/P Compartment Lamp and Switch Connector End View
- I/P Courtesy Lamp - Left Connector End View
- I/P Courtesy Lamp - Right Connector End View
- License Lamp - Left Connector End View
- License Lamp - Right Connector End View
- Marker Lamp - LF Connector End View
- Marker Lamp - LR Connector End View
- Marker Lamp - RF Connector End View
- Marker Lamp - RR Connector End View
- Multifunction Turn Signal Lever - C1 Connector End View
- Multifunction Turn Signal Lever - C2 Connector End View
- Multifunction Turn Signal Lever - C3 Connector End View
- Park/Turn Signal Lamp - LF Connector End View
- Park/Turn Signal Lamp - RF Connector End View
- PRNDL Lamp Connector End View
- Rear Compartment Courtesy Lamp Connector End View
- Sunload Sensor Assembly Connector End View
- Tail Lamp - Left Connector End View
- Tail Lamp - Right Connector End View
- Tail/Stop and Turn Signal Lamp - Left Connector End View
- Tail/Stop and Turn Signal Lamp - Right Connector End View
- Vanity Mirror Lamp - Left (CF5) Connector End View
- Vanity Mirror Lamp - Left (TR9) Connector End View
- Vanity Mirror Lamp - Right (CF5) Connector End View
- Vanity Mirror Lamp - Right (TR9) Connector End View
- Accessory Power Outlet - Front Connector End View
- Accessory Power Outlet - Rear Connector End View
- Cooling Fan - Left Connector End View
- Cooling Fan - Right Connector End View
- Audio Amplifier - C1 (U87) Connector End View
- Audio Amplifier - C2 (U87) Connector End View
- Digital Radio Receiver (U2K) Connector End View
- Radio - C1 Connector End View
- Radio - C2 Connector End View
- Radio, C3 (US4) Connector End View
- Speaker - Center Connector End View
- Speaker - LF Door Connector End View
- Speaker - LF Door Tweeter Connector End View
- Speaker - RF Door Connector End View
- Speaker - RF Door Tweeter Connector End View
- Speaker - LR (UW6) Connector End View
- Speaker - LR (U87) Connector End View
- Speaker - RR (UW6) Connector End View
- Speaker - RR (U87) Connector End View
- Steering Wheel Controls - Left Connector End View
- Steering Wheel Controls - Right Connector End View
- Seat Belt Switch Connector End View
- Brake Booster Vacuum Sensor Connector End View (5.3L)
- Crankshaft Position (CKP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 2 Connector End View (5.3L)
- Fuel Injector 7 Connector End View (5.3L)
- Fuel Injector 5 Connector End View (5.3L)
- Fuel Injector 3 Connector End View (5.3L)
- Fuel Injector 1 Connector End View (5.3L)
- Fuel Injector 2 Connector End View (5.3L)
- Fuel Injector 4 Connector End View (5.3L)
- Fuel Injector 6 Connector End View (5.3L)
- Fuel Injector 8 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 2 Connector End View (5.3L)
- Heated Oxygen Sensor (HO2S) 1 Connector End View (5.3L)
- Camshaft Position (CMP) Sensor Connector End View (5.3L)
- Knock Sensor (KS) 1 Connector End View (5.3L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (5.3L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Connector End View (5.3L)
- Intake Air Temperature (IAT)/Mass Air Flow (MAF) Sensor Connector End View (5.3L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (5.3L)
- Throttle Actuator Control (TAC) Module Connector End View (5.3L)
- Engine Oil Pressure (EOP) Sensor Connector End View (5.3L)
- Value Lifter Oil Manifold (VLOM) Assembly Connector End View (5.3L)
- Powertrain Control Module (PCM) C1 (NU3) Connector End View
- Powertrain Control Module (PCM) C1 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C2 (NU3) Connector End View
- Powertrain Control Module (PCM) C2 (w/o NU3) Connector End View
- Powertrain Control Module (PCM) C3 (NU3) Connector End View
- Powertrain Control Module (PCM) C3 (w/o NU3) Connector End View
- Accelerator Pedal Position (APP) Sensor Connector End View (3.8L)
- Barometric Pressure (BARO) Sensor (L32) Connector End View (3.8L)
- Camshaft Position (CMP) Sensor Connector End View (3.8L)
- Crankshaft Position (CKP) Sensor Connector End View (3.8L)
- Engine Coolant Temperature (ECT) Sensor Connector End View (3.8L)
- Evaporative Emission (EVAP) Canister Purge Solenoid Connector End View (3.8L)
- Evaporative Emissions (EVAP) Canister Vent Solenoid Connector End View (3.8L)
- Exhaust Gas Recirculation (EGR) Valve Connector End View (3.8L)
- Fuel Injector 1 Connector End View (3.8L)
- Fuel Injector 2 Connector End View (3.8L)
- Fuel Injector 3 Connector End View (3.8L)
- Fuel Injector 4 Connector End View (3.8L)
- Fuel Injector 5 Connector End View (3.8L)
- Fuel Injector 6 Connector End View (3.8L)
- Fuel Pump and Sender Assembly Connector End View (3.8L)
- Fuel Tank Pressure (FTP) Sensor Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 1 (w/o NU3) Connector End View (3.8L)
- Heated Oxygen Sensor (HO2S) Sensor 2 Connector End View (3.8L)
- Ignition Control Module (ICM) Connector End View (3.8L)
- Knock Sensor (KS) Bank 1 Connector End View (3.8L)
- Knock Sensor (KS) Bank 2 Connector End View (3.8L)
- Manifold Absolute Pressure (MAP) Sensor Connector End View (3.8L)
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Connector End View (3.8L)
- Secondary Air Injection (AIR) Control Solenoid Valve/Pressure Sensor Bank 2 Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Connector End View (3.8L)
- Secondary Air Injection (AIR) Pump Relay Connector End View (3.8L)
- Secondary Air Injection (AIR) Valve Relay Connector End View (3.8L)
- Supercharger Boost Control Solenoid (L32) Connector End View (3.8L)
- Throttle Actuator Control (TAC) Module Connector End View (3.8L)
- Horn Assembly Connector End View
- Theft Deterrent Exciter Module Connector End View
- Rear Compartment Lid Ajar Switch Connector End View
- Theft LED Connector End View
- Brake Fluid Level Switch Connector End View
- Park Brake Switch Connector End View
- Brake Fluid Pressure Sensor Connector End View (JL4)
- Brake Fluid Pressure Sensor Connector End View (LS4)
- Electronic Brake Control Module (EBCM) Connector End View
- Steering Angle Sensor Connector End View (JL4)
- Traction Control Switch Connector End View
- Wheel Speed Sensor (WSS) - LF Connector End View
- Wheel Speed Sensor (WSS) - LR Connector End View
- Wheel Speed Sensor (WSS) - RF Connector End View
- Wheel Speed Sensor (WSS) - RR Connector End View
- Yaw and Lateral Acceleration Sensor Connector End View (JL4)
- Body Control Module (BCM) C1 Connector End View
- Body Control Module (BCM) C2 Connector End View
- Body Control Module (BCM) C3 Connector End View
- Data Link Connector (DLC) Connector End View (L26/L32)
- Data Link Connector (DLC) Connector End View (LS4)
- Splice Pack SP 205 Connector End View
- Rear Window Defogger Grid, C1 Connector End View
- Rear Window Defogger Grid, C2 Connector End View
- Inside Rearview Mirror Connector End Views
- Vehicle Communication Interface Module (VCIM) - C1 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C2 Connector End Views
- Vehicle Communication Interface Module (VCIM) - C3 (US4) Connector End Views
- Rear Compartment Lid Latch Connector End View
- A/C Compressor Clutch Connector End View (L26/L32)
- A/C Compressor Clutch Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (LS4)
- A/C Refrigerant Pressure Sensor Connector End View (L26/L32)
- Air Temperature Actuator Connector End View
- Blower Motor Connector End View
- Blower Motor Control Processor Connector End View
- HVAC Control Module Connector End View
- Mode Actuator Connector End View
- Recirculation Actuator Connector End View
- AT Inline 20-way Connector End View, Engine Side
- AT Inline 20-way Connector End View, Transmission Side
- TAP Shift Switch - Right Connector End View
- TAP Shift Switch - Left Connector End View
- Vehicle Speed Sensor Connector End View, Wiring Harness Side
- 1-2 Shift Solenoid Valve Connector End View, Wiring Harness Side
- 2-3 Shift Solenoid Valve Connector End View, Wiring Harness Side
- Automatic Transmission Fluid Pressure Manual Valve Position Switch Connector End View, Wiring Harness Side
- Input Speed Sensor Connector End View, Wiring Harness Side
- Pressure Control Solenoid Valve Connector End View, Wiring Harness Side
- Torque Converter Clutch Pulse Width Modulated Solenoid Valve Connector End View, Wiring Harness Side
- Transmission Fluid Temperature Sensor Connector End View, Wiring Harness Side
- Transmission Internal Mode Switch Connector End View, Wiring Harness Side
- Ignition Switch, C1 Connector End View
- Ignition Switch, C2 Connector End View
- Remote Control Door Lock Receiver (RCDLR) Connector End View
- Air Temperature Actuator - Left Connector End View
- Air Temperature Actuator - Right Connector End View
- Air Temperature Sensor - Inside Connector End View
- Air Temperature Sensor - Lower Left Connector End View
- Air Temperature Sensor - Lower Right Connector End View
- Air Temperature Sensor - Upper Left Connector End View
- Air Temperature Sensor - Upper Right Connector End View
- HVAC Control Module, C1 Connector End View
- HVAC Control Module, C2 Connector End View
- Inflatable Restraint Front End Discriminating Sensor Connector End View
- Inflatable Restraint I/P Module Connector End View
- Inflatable Restraint Sensing and Diagnostic Module (SDM) Connector End View
- Inflatable Restraint Side Impact Sensor - Left Connector End View (AY1)
- Inflatable Restraint Side Impact Sensor - Right Connector End View (AY1)
- Inflatable Restraint Steering Wheel Module Coil C1 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C2 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C3 Connector End View
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (W/O UK3)
- Inflatable Restraint Steering Wheel Module Coil C4 Connector End View (UK3)
- Inflatable Restraint Steering Wheel Module Coil C5 Connector End View
- Roof Rail Module - Left Connector End View (AY1)
- Roof Rail Module - Right Connector End View (AY1)
- Seat Belt Pretensioner - Left Connector End View
- Seat Belt Pretensioner - Right Connector End View
- Cruise Control Switch Connector End View
- Battery Current Sensor Connector End View
- Generator Connector End View (L26/L32)
- Generator Connector End View (LS4)
- Hood Ajar Switch Connector End View
- A/T Shift Lock Control Solenoid Connector End View
- Magnasteer Actuator Connector End View
- Automatic Transmission Related Connector End Views
- Connector End Views
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Body Control Modules
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Seats
- Power Top/Sunroof
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- Wiring Systems & Electrical Power Management
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- Flat Wire Repairs
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- Push to Seat Connectors
- Pull to Seat Connectors
- Weather Pack Connectors
- Micro-Pack 100W Connectors
- Micro .64 Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Repairing Connector Terminals
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Special Tools and Equipment
- OEM Connector End Views
- Body Electrical
- Engine Mechanical
- Cooling System (Mechanical)
- Engine Cooling System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Cooling
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC P0480 or P0481
- DTC P1258
- Symptoms - Engine Cooling
- Engine Coolant Temperature Indicator Always On
- Cooling Fan Always On
- Cooling Fan Inoperative
- Engine Overheating
- Loss of Coolant
- Thermostat Diagnosis (Overheating)
- Thermostat Diagnosis (Slow to Heat)
- Coolant Heater Inoperative
- Engine Fails To Reach Normal Operating Temperature
- Pressure Cap Testing
- Coolant Leak Testing
- Repair Instructions
- Draining and Filling Cooling System (L26 and L32)
- Draining and Filling Cooling System (LS4)
- Flushing
- Radiator Cleaning
- Coolant Recovery Reservoir Replacement (L26 L32)
- Coolant Recovery Reservoir Replacement (LS4)
- Radiator Hose Replacement - Inlet (L26 L32)
- Radiator Hose Replacement - Inlet (LS4)
- Radiator Hose Replacement - Outlet (L26 L32)
- Radiator Hose Replacement - Outlet (LS4)
- Cooling Fan Motor Replacement - Electric (L26 L32)
- Cooling Fan Motor Replacement - Electric (LS4)
- Thermostat Housing Replacement (RPOs L26/L32)
- Thermostat Housing Replacement (RPO LS4)
- Thermostat Replacement (RPOs L26/L32)
- Thermostat Replacement (RPO LS4)
- Coolant Air Bleed Pipe Assembly Replacement (RPO LS4)
- Coolant Air Bleed Hose Replacement (RPO LS4)
- Water Pump Replacement (RPOs L26/L32)
- Water Pump Replacement (RPO LS4)
- Coolant Pump Manifold Replacement (RPO LS4)
- Drain Cock Replacement
- Fan Shroud Replacement (L26 L32)
- Fan Shroud Replacement (LS4)
- Radiator Replacement
- Radiator Air Baffle and Deflector Replacement - Lower
- Radiator Air Baffle and Deflector Replacement - Upper
- Coolant Heater Replacement (RPOs L26/L32)
- Coolant Heater Replacement (RPO LS4)
- Coolant Heater Cord Replacement (L26/L32)
- Coolant Heater Cord Replacement (LS4)
- Description and Operation
- Special Tools and Equipment
- Engine Cooling System
- Engine Exhaust System
- Specifications
- Diagnostic Information and Procedures
- Repair Instructions
- Exhaust Manifold Replacement - Left (RPOs L26/L32)
- Exhaust Manifold Replacement - Left (RPO LS4)
- Exhaust Manifold Replacement - Right (RPOs L26/L32)
- Exhaust Manifold Replacement - Right (RPO LS4)
- Exhaust Crossover Pipe Replacement (L26/L32)
- Exhaust Crossover Pipe Replacement (LS4)
- Exhaust Seal Replacement
- Catalytic Converter Replacement (RPOs L26/L32)
- Catalytic Converter Replacement (RPO LS4)
- Exhaust Hanger Replacement
- Exhaust Hanger Mounting Bracket Replacement
- Muffler Replacement (Single Outlet)
- Muffler Replacement (Dual Outlet)
- Tail Pipe Replacement (With RPO Z03)
- Tail Pipe Replacement (Without RPO Z03)
- Converter Hanger Assembly Replacement
- Catalytic Converter Heat Shield Replacement
- Description and Operation
- Special Tools and Equipment
- Lubrication System
- Engine Mechanical - 3.8L
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Mechanical
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Coolant in Combustion Chamber
- Coolant in Engine Oil
- Engine Compression Test
- Cylinder Leakage Test
- Oil Consumption Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Drive Belt Chirping Diagnosis
- Drive Belt Squeal Diagnosis
- Drive Belt Whine Diagnosis
- Drive Belt Rumbling Diagnosis
- Drive Belt Vibration Diagnosis
- Drive Belt Falls Off Diagnosis
- Drive Belt Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- Repair Instructions
- On-Vehicle Repair Instructions
- Fuel Injector Sight Shield Replacement (L26)
- Fuel Injector Sight Shield Replacement (L32)
- Drive Belt Replacement (L26)
- Drive Belt Replacement (L32)
- Drive Belt Tensioner Replacement
- Drive Belt Tensioner Replacement - Supercharger
- Drive Belt Idler Pulley Replacement - Upper
- Drive Belt Idler Pulley Replacement - Lower
- Drive Belt Idler Pulley Bracket Replacement
- Engine Support Fixture
- Engine Mount Inspection
- Engine Mount Replacement - Right
- Engine Mount Bracket Replacement - Right
- Engine Mount Strut Replacement - Right
- Engine Mount Strut Replacement - Left
- Engine Mount Strut Bracket Replacement - Left
- Engine Mount Strut Bracket Replacement - Right
- Engine Mount Strut Bracket Replacement - Upper Radiator Support
- Positive Crankcase Ventilation (PCV) Valve Replacement (L26)
- Positive Crankcase Ventilation (PCV) Valve Replacement (L32)
- Oil Level Indicator and Tube Replacement
- Supercharger Oil Level Inspection
- Supercharger Replacement
- Intake Manifold Replacement - Upper
- Intake Manifold Replacement - Lower (L26)
- Intake Manifold Replacement - Lower (L32)
- Valve Rocker Arm Cover Replacement - Left
- Valve Rocker Arm Cover Replacement - Right
- Valve Rocker Arm and Push Rod Replacement
- Valve Stem Oil Seal and Valve Spring Replacement
- Valve Lifter Replacement
- Crankshaft Balancer Replacement
- Crankshaft Front Oil Seal Replacement
- Engine Front Cover Replacement
- Oil Pump Cover and Gear Set Replacement
- Oil Filter Adapter and Bypass Valve Assembly Replacement
- Timing Chain and Sprockets Replacement
- Cylinder Head Replacement - Left
- Cylinder Head Replacement - Right
- Oil Pan Replacement
- Engine Oil Pressure Sensor and/or Switch Replacement
- Engine Oil Level Sensor and/or Switch Replacement
- Oil Pump Pipe and Screen Assembly Replacement
- Connecting Rod Bearing Replacement
- Engine Flywheel Replacement
- Crankshaft Rear Oil Seal and Housing Replacement
- Engine Replacement
- Engine Oil and Oil Filter Replacement
- Off-Vehicle Repair Instructions
- Rotating the Engine for Service Access
- Draining Fluids and Oil Filter Removal
- Crankshaft Balancer Removal
- Engine Flywheel Removal
- Drive Belt Tensioner Removal - Supercharger
- Drive Belt Tensioner Removal
- Drive Belt Idler Pulley Removal
- Drive Belt Idler Pulley Bracket Removal
- Oil Level Indicator and Tube Removal
- Water Outlet and Thermostat Removal (L26)
- Water Outlet and Thermostat Removal (L32)
- Water Pump Removal
- Supercharger Removal
- Intake Manifold Removal - Upper
- Exhaust Gas Recirculation (EGR) and EGR Pipe Removal
- Intake Manifold Removal - Lower (L26)
- Intake Manifold Removal - Lower (L32)
- Exhaust Manifold Removal - Left
- Exhaust Manifold Removal - Right (Without Secondary Air Injection-SAI)
- Exhaust Manifold Removal - Right (With Secondary Air Injection-SAI)
- Valve Rocker Arm Cover Removal - Left
- Valve Rocker Arm Cover Removal - Right
- Valve Rocker Arm and Push Rod Removal
- Cylinder Head Removal - Left
- Cylinder Head Removal - Right
- Valve Lifter Removal
- Oil Pan Removal
- Oil Pump Pipe and Screen Assembly Removal
- Crankshaft Front Oil Seal Removal
- Engine Front Cover Removal
- Oil Filter Adapter Removal
- Timing Chain and Sprockets Removal (L26)
- Timing Chain and Sprockets Removal (L32)
- Balance Shaft Removal
- Camshaft Removal
- Crankshaft Rear Oil Seal and Housing Removal
- Piston, Connecting Rod, and Bearing Removal
- Crankshaft and Bearings Removal
- Engine Block Plug Removal
- Camshaft Bearing Removal
- Balance Shaft Bearing and/or Bushing Removal
- Engine Block Cleaning and Inspection
- Cylinder Boring and Honing
- Crankshaft and Bearings Cleaning and Inspection
- Crankshaft Balancer Cleaning and Inspection
- Engine Flywheel Cleaning and Inspection
- Piston and Connecting Rod Disassemble
- Piston, Connecting Rod, and Bearings Cleaning and Inspection
- Piston and Connecting Rod Assemble
- Camshaft and Bearings Cleaning and Inspection
- Timing Chain and Sprockets Cleaning and Inspection (L26)
- Timing Chain and Sprockets Cleaning and Inspection (L32)
- Valve Rocker Arm and Push Rods Cleaning and Inspection
- Valve Lifters and Guides Cleaning and Inspection
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Valve Guide Reaming/Valve and Seat Grinding
- Cylinder Head Assemble
- Oil Pump Disassemble
- Oil Pump Cleaning and Inspection
- Engine Front Cover Cleaning and Inspection
- Oil Pump Assemble
- Valve Rocker Arm Cover Cleaning and Inspection
- Oil Pan Cleaning and Inspection
- Supercharger Cleaning and Inspection
- Intake Manifold Cleaning and Inspection - Upper
- Intake Manifold Cleaning and Inspection - Lower (L26)
- Intake Manifold Cleaning and Inspection - Lower (L32)
- Exhaust Manifold Cleaning and Inspection
- Water Pump Cleaning and Inspection
- Balance Shaft Cleaning and Inspection
- Thread Repair
- Service Prior to Assembly
- Balance Shaft Bearing and/or Bushing Installation
- Camshaft Bearing Installation
- Engine Block Plug Installation
- Crankshaft and Bearings Installation
- Piston, Connecting Rod, and Bearing Installation
- Crankshaft Rear Oil Seal and Housing Installation
- Camshaft Installation
- Balance Shaft Installation
- Timing Chain and Sprockets Installation (L26)
- Timing Chain and Sprockets Installation (L32)
- Engine Front Cover Installation
- Crankshaft Front Oil Seal Installation
- Oil Filter Adapter Installation
- Oil Pump Pipe and Screen Assembly Installation
- Oil Pan Installation
- Valve Lifter Installation
- Cylinder Head Installation - Right
- Cylinder Head Installation - Left
- Valve Rocker Arm and Push Rod Installation
- Valve Rocker Arm Cover Installation - Right
- Valve Rocker Arm Cover Installation - Left
- Exhaust Manifold Installation - Right (Without A.I.R.)
- Exhaust Manifold Installation - Right (With A.I.R.)
- Exhaust Manifold Installation - Left
- Intake Manifold Installation - Lower (L26)
- Intake Manifold Installation - Lower (L32)
- Exhaust Gas Recirculation (EGR) and EGR Pipe Installation
- Intake Manifold Installation - Upper
- Supercharger Installation
- Water Pump Installation
- Water Outlet and Thermostat Installation (L26)
- Water Outlet and Thermostat Installation (L32)
- Oil Level Indicator and Tube Installation
- Drive Belt Idler Pulley Bracket Installation
- Drive Belt Idler Pulley Installation
- Drive Belt Tensioner Installation
- Drive Belt Tensioner Installation - Supercharger
- Engine Flywheel Installation
- Crankshaft Balancer Installation
- Engine Prelubing
- On-Vehicle Repair Instructions
- Description And Operation
- Crankcase Ventilation System Description
- Drive Belt System Description
- Engine Component Description
- Supercharger Description And Operation
- New Product Information
- Lubrication Description
- Cleanliness And Care
- Separating Parts
- Replacing Engine Gaskets
- Use of Room Temperature Vulcanizing (RTV) And Anaerobic Sealer
- Tools And Equipment
- Special Tools And Equipment
- Starter
- Battery, Charging System And Starting System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Electrical
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B1327
- DTC B1328
- DTC B1516
- DTC P0560
- DTC P0562
- DTC P0563
- DTC P0615
- DTC P0621
- DTC P0622
- Symptoms - Engine Electrical
- Battery Inspection/Test
- Battery Charging
- Battery Electrical Drain/Parasitic Load Test
- Battery Common Causes of Failure
- Jump Starting in Case of Emergency
- Charging System Test
- Charge Indicator Always On
- Charge Indicator Inoperative
- Generator Noise Diagnosis
- Starter Solenoid Does Not Click
- Starter Solenoid Clicks, Engine Does Not Crank
- Engine Cranks Slowly
- Starter Motor Noise Diagnosis
- Remote Start Does Not Work
- Repair Instructions
- Battery Negative Cable Disconnect/Connect Procedure (RPOs L26/L32)
- Battery Negative Cable Disconnect/Connect Procedure (RPO LS4)
- Battery Current Sensor Replacement (RPOs L26/L32)
- Battery Current Sensor Replacement (RPO LS4)
- Battery Negative Cable Replacement (RPOs L26/L32)
- Battery Negative Cable Replacement (RPO LS4)
- Battery Positive Cable Replacement (RPOs L26/L32)
- Battery Positive Cable Replacement (RPO LS4)
- Battery Replacement (RPOs L26/L32)
- Battery Replacement (RPO LS4)
- Battery Tray Replacement (RPOs L26/L32)
- Battery Tray Replacement (RPO LS4)
- Starter Motor Replacement (RPOs L26/L32)
- Starter Motor Replacement (RPO LS4)
- Generator Bracket Replacement (RPO LS4)
- Generator Brace Replacement (L26)
- Generator Brace Replacement (L32)
- Generator Replacement (RPOs L26/L32)
- Generator Replacement (RPO LS4)
- Description and Operation
- Special Tools and Equipment
- Battery, Charging System And Starting System
- Cooling System (Mechanical)
- Engine Performance
- Emissions
- EGR Function Testing - General Motors Cars
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Mode 6 - PONTIAC
- Specifications
- System
- Engine Controls - 3.8L - Introduction
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement (L26)
- Manifold Absolute Pressure (MAP) Sensor Replacement (L32)
- Barometric Pressure (BARO) Sensor Replacement
- Heated Oxygen Sensor Replacement - Position 1
- Heated Oxygen Sensor Replacement - Position 2
- Accelerator Pedal Position (APP) Sensor Replacement
- Throttle Body Assembly Replacement (L26)
- Throttle Body Assembly Replacement (L32)
- Throttle Body Cleaning Procedure
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Tank Draining Procedure
- Fuel Tank Replacement
- Fuel Tank Pressure Sensor Replacement
- Fuel Level Sensor Replacement
- Filler Tube Replacement
- Fuel Sender Assembly Replacement
- Fuel Hose/Pipes Assembly Replacement
- Fuel System Cleaning
- Fuel Rail Assembly Replacement (L26)
- Fuel Rail Assembly Replacement (L32)
- Fuel Injector Cleaning Procedure (L26 Only)
- Fuel Injector Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine/Chassis
- Evaporative Emission (EVAP) Canister Replacement
- Ignition Coil(s) Replacement
- Ignition Control Module Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) 1 Replacement
- Knock Sensor (KS) 2 Replacement
- Secondary Air Injection (AIR) Pump Replacement
- Secondary Air Injection (AIR) Shut-Off Valve Outlet Pipe/Hose Replacement
- Secondary Air Injection (AIR) Shut-Off Valve Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Inlet Pipe Replacement
- Exhaust Gas Recirculation (EGR) Outlet Pipe Replacement
- Exhaust Gas Recirculation (EGR) System Cleaning
- Boost Control Solenoid Replacement
- Bypass Valve Actuator Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Air Cleaner Intake Duct Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Notes
- PCM Function
- EEPROM
- Data Link Connector (DLC)
- Malfunction Indicator Lamp (MIL) Operation
- PCM Service Precautions
- Emissions Diagnosis For State I/M Programs
- Aftermarket (Add-On) Electrical And Vacuum Equipment
- Electrostatic Discharge (ESD) Damage
- Emissions Control Information Label
- Underhood Inspection
- Basic Knowledge Required
- Throttle Actuator Control (TAC) System Description
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Secondary Air Injection (AIR) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Boost Control System Description
- Powertrain Control Module (PCM) Description
- Special Tools and Equipment
- Engine Controls - 3.8L - Diagnostic Starting Point
- Engine Controls - 3.8L - DTC P0016 To DTC P0135
- Engine Controls - 3.8L - DTC P0137 To DTC P0405
- Engine Controls - 3.8L - DTC P0406 To DTC P1111
- DTC Table
- DTC P0406: Exhaust Gas Recirculation (EGR) Position Sensor Circuit High Voltage
- DTC P0411 (L26, NU3): Secondary Air Injection (AIR) System Insufficient Flow
- DTC P0412 (L26, NU3): Secondary Air Injection (AIR) Solenoid Relay Control Circuit
- DTC P0418 (L26, NU3): Secondary Air Injection (AIR) Pump Control Circuit
- DTC P0420: Catalyst System Low Efficiency Bank 1
- DTC P0442: Evaporative Emission (EVAP) System Small Leak Detected
- DTC P0443: Evaporative Emission (EVAP) Purge Solenoid Control Circuit
- DTC P0446: Evaporative Emission Vent System Performance
- DTC P0449: Evaporative Emission Vent Solenoid Control Circuit
- DTC P0451: Fuel Tank Pressure (FTP) Sensor Performance
- DTC P0452: Fuel Tank Pressure Sensor Circuit Low Voltage
- DTC P0453: Fuel Tank Pressure Sensor Circuit High Voltage
- DTC P0454: Fuel Tank Pressure (FTP) Sensor Circuit Intermittent
- DTC P0455: Evaporative Emission System Large Leak Diagnostic
- DTC P0496: Evaporative Emission System Flow During Non-Purge
- DTC P0506: Idle Speed Low
- DTC P0507: Idle Speed High
- DTC P0601, P0602, P0603, P0604, P0605, P0606, P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610: Control Module Malfunction(s)
- DTC P0641: 5-Volt Reference 1 Circuit
- DTC P0650: Malfunction Indicator Lamp (MIL) Control Circuit
- DTC P0651: 5-Volt Reference 2 Circuit
- DTC P0685: Engine Controls Ignition Relay Control Circuit
- DTC P1106: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent High Voltage
- DTC P1107: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent Low Voltage
- DTC P1111: Intake Air Temperature (IAT) Sensor Circuit Intermittent High Voltage
- Engine Controls - 3.8L - DTC P1112 To DTC P2431
- DTC Table
- DTC P1112: Intake Air Temperature (IAT) Sensor Circuit Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent High Voltage
- DTC P1125: Accelerator Pedal Position (APP) System
- DTC P1133: HO2S Insufficient Switching Bank 1 Sensor 1
- DTC P1134: HO2S Transition Time Ratio Bank 1 Sensor 1
- DTC P1350: Ignition Bypass Circuit
- DTC P1404: Exhaust Gas Recirculation (EGR) Closed Position Performance
- DTC P1516: Throttle Actuator Control (TAC) Module Throttle Actuator Position Performance
- DTC P1640: Control Module Output A Circuit
- DTC P1650: Control Module Output B Circuit
- DTC P1660: Control Module Output C Circuit
- DTC P2101: Control Module Throttle Actuator Position Performance
- DTC P2107: Throttle Actuator Control (TAC) Module Internal Circuit
- DTC P2108: Throttle Actuator Control (TAC) Module Performance
- DTC P2119: Throttle Closed Position Performance
- DTC P2120: Accelerator Pedal Position (APP) Sensor 1 Circuit
- DTC P2125: Accelerator Pedal Position (APP) Sensor 2 Circuit
- DTC P2135: Throttle Position (TP) Sensor 1-2 Correlation
- DTC P2138: Accelerator Pedal Position (APP) Sensor 1-2 Correlation
- DTC P2227: Barometric Pressure (BARO) Sensor Performance
- DTC P2228: Barometric Pressure (BARO) Sensor Circuit Low Voltage
- DTC P2229: Barometric Pressure (BARO) Sensor Circuit High voltage
- DTC P2430 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Stuck in Range
- DTC P2431 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Performance
- ENGINE CONTROLS - 3.8L - DTC P2432 To DTC U0107
- DTC Table
- DTC P2432 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Circuit Low Voltage
- DTC P2433 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Circuit High Voltage
- DTC P2440 (L26, NU3): Secondary Air Injection (AIR) Control/Shut-Off Valve Stuck Open
- DTC P2444 (L26, NU3): Secondary Air Injection (AIR) System Pump Stuck On
- DTC P2A00: HO2S Circuit Closed Loop (CL) Performance Bank 1 Sensor 1
- DTC P2A01: HO2S Circuit Closed Loop (CL) Performance Bank 1 Sensor 2
- DTC U0107: Throttle Actuator Control (TAC) Module Serial Data Circuit
- Engine Controls - 3.8L - Troubleshooting & Diagnosis
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run
- Powertrain Relay Diagnosis
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Injector Balance Test with Tech 2
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (With Special Tool)
- Manifold Absolute Pressure (MAP) Sensor Diagnosis
- Boost Control System Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Crankshaft Position Sensor (CKP) System Diagnosis
- Inspection/Maintenance (I/M) System Check
- Inspection/Maintenance (I/M) Complete System Set Procedure
- Inspection/Maintenance (I/M) System DTC Table
- Inspection/Maintenance (I/M) AIR System Set Procedure
- Inspection/Maintenance (I/M) Catalyst System Set Procedure
- Inspection/Maintenance (I/M) Exhaust Gas Recirculation (EGR) System Set Procedure
- Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor/Oxygen Sensor (HO2S/O2S) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor (HO2S) Heater System Set Procedure
- Service Bay Test
- Engine Controls - 3.8L - Introduction
- Testing & Diagnosis
- Engine Controls - 3.8L - Introduction
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement (L26)
- Manifold Absolute Pressure (MAP) Sensor Replacement (L32)
- Barometric Pressure (BARO) Sensor Replacement
- Heated Oxygen Sensor Replacement - Position 1
- Heated Oxygen Sensor Replacement - Position 2
- Accelerator Pedal Position (APP) Sensor Replacement
- Throttle Body Assembly Replacement (L26)
- Throttle Body Assembly Replacement (L32)
- Throttle Body Cleaning Procedure
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Tank Draining Procedure
- Fuel Tank Replacement
- Fuel Tank Pressure Sensor Replacement
- Fuel Level Sensor Replacement
- Filler Tube Replacement
- Fuel Sender Assembly Replacement
- Fuel Hose/Pipes Assembly Replacement
- Fuel System Cleaning
- Fuel Rail Assembly Replacement (L26)
- Fuel Rail Assembly Replacement (L32)
- Fuel Injector Cleaning Procedure (L26 Only)
- Fuel Injector Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine/Chassis
- Evaporative Emission (EVAP) Canister Replacement
- Ignition Coil(s) Replacement
- Ignition Control Module Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) 1 Replacement
- Knock Sensor (KS) 2 Replacement
- Secondary Air Injection (AIR) Pump Replacement
- Secondary Air Injection (AIR) Shut-Off Valve Outlet Pipe/Hose Replacement
- Secondary Air Injection (AIR) Shut-Off Valve Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Inlet Pipe Replacement
- Exhaust Gas Recirculation (EGR) Outlet Pipe Replacement
- Exhaust Gas Recirculation (EGR) System Cleaning
- Boost Control Solenoid Replacement
- Bypass Valve Actuator Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Air Cleaner Intake Duct Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Notes
- PCM Function
- EEPROM
- Data Link Connector (DLC)
- Malfunction Indicator Lamp (MIL) Operation
- PCM Service Precautions
- Emissions Diagnosis For State I/M Programs
- Aftermarket (Add-On) Electrical And Vacuum Equipment
- Electrostatic Discharge (ESD) Damage
- Emissions Control Information Label
- Underhood Inspection
- Basic Knowledge Required
- Throttle Actuator Control (TAC) System Description
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Secondary Air Injection (AIR) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Boost Control System Description
- Powertrain Control Module (PCM) Description
- Special Tools and Equipment
- Engine Controls - 3.8L - Diagnostic Starting Point
- Engine Controls - 3.8L - DTC P0016 To DTC P0135
- Engine Controls - 3.8L - DTC P0137 To DTC P0405
- Engine Controls - 3.8L - DTC P0406 To DTC P1111
- DTC Table
- DTC P0406: Exhaust Gas Recirculation (EGR) Position Sensor Circuit High Voltage
- DTC P0411 (L26, NU3): Secondary Air Injection (AIR) System Insufficient Flow
- DTC P0412 (L26, NU3): Secondary Air Injection (AIR) Solenoid Relay Control Circuit
- DTC P0418 (L26, NU3): Secondary Air Injection (AIR) Pump Control Circuit
- DTC P0420: Catalyst System Low Efficiency Bank 1
- DTC P0442: Evaporative Emission (EVAP) System Small Leak Detected
- DTC P0443: Evaporative Emission (EVAP) Purge Solenoid Control Circuit
- DTC P0446: Evaporative Emission Vent System Performance
- DTC P0449: Evaporative Emission Vent Solenoid Control Circuit
- DTC P0451: Fuel Tank Pressure (FTP) Sensor Performance
- DTC P0452: Fuel Tank Pressure Sensor Circuit Low Voltage
- DTC P0453: Fuel Tank Pressure Sensor Circuit High Voltage
- DTC P0454: Fuel Tank Pressure (FTP) Sensor Circuit Intermittent
- DTC P0455: Evaporative Emission System Large Leak Diagnostic
- DTC P0496: Evaporative Emission System Flow During Non-Purge
- DTC P0506: Idle Speed Low
- DTC P0507: Idle Speed High
- DTC P0601, P0602, P0603, P0604, P0605, P0606, P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610: Control Module Malfunction(s)
- DTC P0641: 5-Volt Reference 1 Circuit
- DTC P0650: Malfunction Indicator Lamp (MIL) Control Circuit
- DTC P0651: 5-Volt Reference 2 Circuit
- DTC P0685: Engine Controls Ignition Relay Control Circuit
- DTC P1106: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent High Voltage
- DTC P1107: Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent Low Voltage
- DTC P1111: Intake Air Temperature (IAT) Sensor Circuit Intermittent High Voltage
- Engine Controls - 3.8L - DTC P1112 To DTC P2431
- DTC Table
- DTC P1112: Intake Air Temperature (IAT) Sensor Circuit Intermittent Low Voltage
- DTC P1114: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent Low Voltage
- DTC P1115: Engine Coolant Temperature (ECT) Sensor Circuit Intermittent High Voltage
- DTC P1125: Accelerator Pedal Position (APP) System
- DTC P1133: HO2S Insufficient Switching Bank 1 Sensor 1
- DTC P1134: HO2S Transition Time Ratio Bank 1 Sensor 1
- DTC P1350: Ignition Bypass Circuit
- DTC P1404: Exhaust Gas Recirculation (EGR) Closed Position Performance
- DTC P1516: Throttle Actuator Control (TAC) Module Throttle Actuator Position Performance
- DTC P1640: Control Module Output A Circuit
- DTC P1650: Control Module Output B Circuit
- DTC P1660: Control Module Output C Circuit
- DTC P2101: Control Module Throttle Actuator Position Performance
- DTC P2107: Throttle Actuator Control (TAC) Module Internal Circuit
- DTC P2108: Throttle Actuator Control (TAC) Module Performance
- DTC P2119: Throttle Closed Position Performance
- DTC P2120: Accelerator Pedal Position (APP) Sensor 1 Circuit
- DTC P2125: Accelerator Pedal Position (APP) Sensor 2 Circuit
- DTC P2135: Throttle Position (TP) Sensor 1-2 Correlation
- DTC P2138: Accelerator Pedal Position (APP) Sensor 1-2 Correlation
- DTC P2227: Barometric Pressure (BARO) Sensor Performance
- DTC P2228: Barometric Pressure (BARO) Sensor Circuit Low Voltage
- DTC P2229: Barometric Pressure (BARO) Sensor Circuit High voltage
- DTC P2430 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Stuck in Range
- DTC P2431 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Performance
- ENGINE CONTROLS - 3.8L - DTC P2432 To DTC U0107
- DTC Table
- DTC P2432 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Circuit Low Voltage
- DTC P2433 (L26, NU3): Secondary Air Injection (AIR) System Pressure Sensor Circuit High Voltage
- DTC P2440 (L26, NU3): Secondary Air Injection (AIR) Control/Shut-Off Valve Stuck Open
- DTC P2444 (L26, NU3): Secondary Air Injection (AIR) System Pump Stuck On
- DTC P2A00: HO2S Circuit Closed Loop (CL) Performance Bank 1 Sensor 1
- DTC P2A01: HO2S Circuit Closed Loop (CL) Performance Bank 1 Sensor 2
- DTC U0107: Throttle Actuator Control (TAC) Module Serial Data Circuit
- Engine Controls - 3.8L - Troubleshooting & Diagnosis
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Malfunction Indicator Lamp (MIL) Inoperative
- Malfunction Indicator Lamp (MIL) Always On
- Engine Cranks but Does Not Run
- Powertrain Relay Diagnosis
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Injector Balance Test with Tech 2
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis (With Special Tool)
- Manifold Absolute Pressure (MAP) Sensor Diagnosis
- Boost Control System Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Crankshaft Position Sensor (CKP) System Diagnosis
- Inspection/Maintenance (I/M) System Check
- Inspection/Maintenance (I/M) Complete System Set Procedure
- Inspection/Maintenance (I/M) System DTC Table
- Inspection/Maintenance (I/M) AIR System Set Procedure
- Inspection/Maintenance (I/M) Catalyst System Set Procedure
- Inspection/Maintenance (I/M) Exhaust Gas Recirculation (EGR) System Set Procedure
- Inspection/Maintenance (I/M) Evaporative Emission (EVAP) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor/Oxygen Sensor (HO2S/O2S) System Set Procedure
- Inspection/Maintenance (I/M) Heated Oxygen Sensor (HO2S) Heater System Set Procedure
- Service Bay Test
- Engine Controls - 3.8L - Introduction
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles - 3.8L
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- General Information
- Introduction
- Conversion - English/Metric
- Equivalents - Decimal and Metric
- Arrows and Symbols
- Special Tools Ordering Information
- Diagnostic Work Sheets
- Training
- Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage
- Label - Vehicle Certification, Tire Place Card, Anti-Theft and Service Parts ID
- RPO Code Description
- Fasteners
- Thread Inserts
- Abbreviations and Meanings
- Registered and Non-Registered Trademarks
- Key and Lock Cylinder Coding
- Lifting and Jacking the Vehicle
- Strategy Based Diagnosis
- Introduction
- General Information
- Identification
- Metric Conversions
- OEM General Information
- Automatic Stop/Start Disable
- Cautions And Notices
- Introduction
- Definition of Caution, Notice, and Important
- ABS Component Handling Caution
- Approved Equipment for Collision Repair Caution
- Assistant Driving Caution
- Automatic Transaxle Range Selector Cable Caution
- Batteries Produce Explosive Gases Caution
- Battery Disconnect Caution
- Brake Dust Caution
- Brake Fluid Irritant Caution
- Breathing R-134a Caution
- Cleaning Solvent Caution
- Electric Coolant Fan Caution
- Express Window Down Caution
- Eye Protection Caution
- Failure to Prep Primer Caution
- Foam Sound Deadeners Caution
- Fuel and EVAP Pipe Caution
- Fuel Gage Leak Caution
- Fuel Pipe Fitting Caution
- Fuel Rail Stop Bracket Installation Caution
- Fuel Storage Caution
- Fuel Vapors in Evaporative Emission (EVAP) Components Caution
- Gasoline/Gasoline Vapors Caution
- Glass and Sheet Metal Handling Caution
- Halogen Bulb Caution
- Hot Exhaust System Caution
- Lower O-Ring Removal Caution
- Moving Parts and Hot Surfaces Caution
- Park Brake Cable to Caliper Caution
- Radiator Cap Removal Caution
- Relieving Fuel Pressure Caution
- Road Test Caution
- Safety Glasses Caution
- Safety Glasses and Compressed Air Caution
- Safety Goggles and Fuel Caution
- SIR Caution
- SIR Deployed Inflator Modules Are Hot Caution
- SIR Inflator Module Coil Caution
- SIR Inflatable Module Deployment Outside Vehicle Caution
- SIR Inflator Module Disposal Caution
- SIR Inflator Module Handling and Storage Caution
- SIR Special Tool Caution
- Vehicle Lifting Caution
- Window Retention Caution
- Work Stall Test Caution
- Air in the Power Steering System Notice
- Anti-Corrosion Materials Notice
- Avoid Chipping or Scratching the Coating Notice
- Ball Stud Removal Notice
- Belt Dressing Notice
- Brake Caliper Notice
- Brake Fluid Effects on Paint and Electrical Components Notice
- Catalytic Converter Movement Notice
- Clean, Dry, Low Pressure Gas Source Notice
- Clearcoat/Ultraviolet Screeners Notice
- Component Fastener Tightening Notice
- Connector Test Adapter Kit J 35616-A Notice
- Constant Velocity Joint Seal Damage Notice
- Continuous Operation of the AIR Pump Notice
- Cover and Plug Openings Notice
- Disengaging Connectors Notice
- Emission Modification Notice
- Engine Emission Notice
- Excessive Force and Oxygen Sensor Notice
- Exterior Trim Emblem Removal Notice
- Fastener Notice
- Fuel and Evaporative Emission (EVAP) Hose/Pipe Connection Cleaning Notice
- Fuel Pressure Notice
- Fuel Rail Notice
- Fuel System Ground Notice
- Fuel Tank Strap Fastener Notice
- Handling ESD Sensitive Parts Notice
- Handling IAC Valve Notice
- Heated Oxygen and Oxygen Sensor Notice
- Heated Oxygen Sensor (HO2S) Resistance Learn Reset Notice
- Ignition OFF When Disconnecting Battery Notice
- Installing Hoses without Twists or Bends Notice
- Liftgate Assist Rod Notice
- Nylon Fuel Lines Notice
- Nylon Pipes Notice
- OBD II Symbol Description Notice
- Oxygen Sensor Notice
- Paint Damage Notice
- PCM and ESD Notice
- Pipe Wrench Positioning Notice
- Power Steering Hose Disconnected Notice
- Propeller Shaft Notice
- Raising the Hood Notice
- Sealant Notice
- Service Programming System (SPS) Notice
- Silicon Contamination of Heated Oxygen Sensors Notice
- Single Cylinder Flooding Notice
- Special Fastener Notice
- Steering Wheel in the Full Turn Position Notice
- Steering Wheel Straight and Column Locked Notice
- Tape Corners of Panel Notice
- Test Probe Notice
- Three-Way Catalytic Converter Damage Notice
- Transmission Overfill Notice
- Using Proper Power Steering Fluid Notice
- Window Edge Damage Notice
- Windshield Installation Notice
- Introduction
- General Information
- Introduction
- Conversion - English/Metric
- Equivalents - Decimal and Metric
- Arrows and Symbols
- Special Tools Ordering Information
- Diagnostic Work Sheets
- Training
- Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage
- Label - Vehicle Certification, Tire Place Card, Anti-Theft and Service Parts ID
- RPO Code Description
- Fasteners
- Thread Inserts
- Abbreviations and Meanings
- Registered and Non-Registered Trademarks
- Key and Lock Cylinder Coding
- Lifting and Jacking the Vehicle
- Strategy Based Diagnosis
- Introduction
- Vehicle DTC Information
- Vibration Symptoms Diagnosis And Correction
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Vibration Diagnosis and Correction
- Vibration Analysis - Road Testing
- Component Rotational Speed Calculation
- Vibration Analysis - Tire and Wheel
- Vibration Analysis - Hub and/or Axle Input
- Vibration Analysis - Engine
- Engine Order Classification
- Vibration Analysis - Engine/Accessory Isolation
- Vibration Analysis - Engine Balance
- Vibration Diagnostic Aids
- Vibration Diagnostic Aids - Vibration Intermittent or Not Duplicated
- Vibration Diagnostic Aids - Vibration Duplicated, Component Not Identified
- Vibration Diagnostic Aids - Vibration Duplicated, Difficult to Isolate/Balance Component
- Vibration Diagnostic Aids - Vibration Duplicated, Appears to Be Potential Operating Characteristic
- Symptoms - Vibration Diagnosis and Correction
- Vehicle-to-Vehicle Diagnostic Comparison
- Tire and Wheel Inspection
- Tire and Wheel Assembly Runout Measurement - On-Vehicle
- Tire and Wheel Assembly Runout Measurement - Off-Vehicle
- Brake Rotor/Drum Balance Inspection
- Hub/Axle Flange and Wheel Stud Runout Inspection
- Tire and Wheel Assembly Isolation Test
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Reset Procedures
- BARTEC TPMS Reset Procedure
- Maintenance And Lubrication
- Maintenance Reminder Light (Reset Procedures)
- Engine Oil Replacement Reminder
- Notes
- Engine Oil Replacement Reminder Reset - Procedure 01
- Engine Oil Replacement Reminder Reset - Procedure 02
- Engine Oil Replacement Reminder Reset - Procedure 03
- Engine Oil Replacement Reminder Reset - Procedure 04
- Engine Oil Replacement Reminder Reset - Procedure 05
- Engine Oil Replacement Reminder Reset - Procedure 06
- Engine Oil Replacement Reminder Reset - Procedure 07
- Engine Oil Replacement Reminder Reset - Procedure 08
- Engine Oil Replacement Reminder Reset - Procedure 09
- Engine Oil Replacement Reminder Reset - Procedure 10
- Engine Oil Replacement Reminder Reset - Procedure 11
- Engine Oil Replacement Reminder Reset - Procedure 12
- Engine Oil Replacement Reminder Reset - Procedure 13
- Engine Oil Replacement Reminder Reset - Procedure 14
- Engine Oil Replacement Reminder Reset - Procedure 15
- Engine Oil Replacement Reminder Reset - Procedure 16
- Engine Oil Replacement Reminder Reset - Procedure 17
- Engine Oil Replacement Reminder Reset - Procedure 18
- Engine Oil Replacement Reminder Reset - Procedure 19
- Engine Oil Replacement Reminder Reset - Procedure 20
- Engine Oil Replacement Reminder Reset - Procedure 21
- Engine Oil Replacement Reminder Reset - Procedure 22
- Engine Oil Replacement Reminder Reset - Procedure 23
- Engine Oil Replacement Reminder Reset - Procedure 24
- Engine Oil Replacement Reminder Reset - Procedure 25
- Engine Oil Replacement Reminder Reset - Procedure 26
- Engine Oil Replacement Reminder Reset - Procedure 27
- Engine Oil Replacement Reminder Reset - Procedure 28
- Engine Oil Replacement Reminder Reset - Procedure 29
- Engine Oil Replacement Reminder Reset - Procedure 30
- Engine Oil Replacement Reminder Reset - Procedure 31
- Engine Oil Replacement Reminder Reset - Procedure 32
- Engine Oil Replacement Reminder Reset - Procedure 33
- Engine Oil Replacement Reminder Reset - Procedure 34
- Engine Oil Replacement Reminder Reset - Procedure 35
- Engine Oil Replacement Reminder Reset - Procedure 36
- Engine Oil Replacement Reminder Reset - Procedure 37
- Emissions Maintenance Reminder (Reminder Flag)
- Emissions Maintenance Reminder (Warning Light)
- Emissions Maintenance Reminder (Check Engine Light)
- Diesel Fuel Filter Replacement Reminder
- Maintenance Service Reminder
- Timing Belt Replacement Reminder
- Transmission Fluid Replacement Reminder
- Tire Pressure Monitor System Reminder
- Notes
- TPMS Reminder Reset - Procedure 01
- TPMS Reminder Reset - Procedure 02
- TPMS Reminder Reset - Procedure 03
- TPMS Reminder Reset - Procedure 04
- TPMS Reminder Reset - Procedure 05
- TPMS Reminder Reset - Procedure 06
- TPMS Reminder Reset - Procedure 07
- TPMS Reminder Reset - Procedure 08
- TPMS Reminder Reset - Procedure 09
- TPMS Reminder Reset - Procedure 10
- TPMS Reminder Reset - Procedure 11
- TPMS Reminder Reset - Procedure 12
- TPMS Reminder Reset - Procedure 13
- TPMS Reminder Reset - Procedure 14
- TPMS Reminder Reset - Procedure 15
- TPMS Reminder Reset - Procedure 16
- TPMS Reminder Reset - Procedure 17
- TPMS Reminder Reset - Procedure 18
- TPMS Reminder Reset - Procedure 19
- TPMS Reminder Reset - Procedure 20
- TPMS Reminder Reset - Procedure 21
- TPMS Reminder Reset - Procedure 22
- TPMS Reminder Reset - Procedure 23
- TPMS Reminder Reset - Procedure 24
- TPMS Reminder Reset - Procedure 25
- TPMS Reminder Reset - Procedure 26
- TPMS Reminder Reset - Procedure 27
- TPMS Reminder Reset - Procedure 28
- TPMS Reminder Reset - Procedure 29
- TPMS Reminder Reset - Procedure 30
- TPMS Reminder Reset - Procedure 31
- TPMS Reminder Reset - Procedure 32
- TPMS Reminder Reset - Procedure 33
- TPMS Reminder Reset - Procedure 34
- TPMS Reminder Reset - Procedure 35
- TPMS Reminder Reset - Procedure 36
- TPMS Reminder Reset - Procedure 37
- Engine Oil Replacement Reminder
- Tire Pressure Monitor Systems
- RPO Codes
- General Information
- Introduction
- Conversion - English/Metric
- Equivalents - Decimal and Metric
- Arrows and Symbols
- Special Tools Ordering Information
- Diagnostic Work Sheets
- Training
- Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage
- Label - Vehicle Certification, Tire Place Card, Anti-Theft and Service Parts ID
- RPO Code Description
- Fasteners
- Thread Inserts
- Abbreviations and Meanings
- Registered and Non-Registered Trademarks
- Key and Lock Cylinder Coding
- Lifting and Jacking the Vehicle
- Strategy Based Diagnosis
- Introduction
- General Information
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- Heating, Ventilation & Air Conditioning
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Heating, Ventilation and Air Conditioning
- Leak Testing
- Air Conditioning (A/C) System Performance Test
- Air Conditioning (A/C) Diagnostics - Pressure Zone A (L26, L32)
- Air Conditioning (A/C) Diagnostics - Pressure Zone A (LS4)
- Air Conditioning (A/C) Diagnostics - Pressure Zone B
- Air Conditioning (A/C) Diagnostics - Pressure Zone C
- Air Conditioning (A/C) Diagnostics - Pressure Zone D
- Heating Performance Diagnostic
- Defrosting Insufficient
- Noise Diagnosis - Blower Motor
- Noise Diagnosis - Air Conditioning (A/C) System
- Noise Diagnosis - HVAC Module
- Odor Diagnosis
- Repair Instructions
- Odor Correction
- Refrigerant Recovery and Recharging
- Flushing
- Compressor Oil Balancing
- Compressor Replacement (L26 L32)
- Compressor Replacement (LS4)
- Compressor Clutch Assembly Replacement
- Compressor Pressure Relief Valve Replacement
- Sealing Washer Replacement
- O-Ring Replacement
- A/C Line/Tube Connector Removal/Replacement
- Compressor Hose Assembly Replacement
- Evaporator Tube Replacement
- Air Conditioning (A/C) Refrigerant Filter Replacement
- Compressor Relay Replacement
- Service Ports Replacement
- Receiver Dehydrator Replacement
- Thermal Expansion Valve Replacement
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement
- Condenser Replacement (L26 L32)
- Condenser Replacement (LS4)
- Blower Control Module Replacement
- HVAC Module Assembly Replacement
- Evaporator Core Replacement
- Heater Hose Replacement - Inlet (L26, L32)
- Heater Hose Replacement - Inlet (LS4)
- Heater Pipes Replacement
- Heater Hose Replacement - Outlet (L26, L32)
- Heater Hose Replacement - Outlet (LS4)
- Heater Pipe Adapter Replacement - Inlet
- Heater Pipe Adapter Replacement - Outlet
- Passenger Compartment Air Filter Replacement
- Blower Motor Replacement
- Air Distributor Duct Replacement
- Air Outlet Replacement - Side Window (Right)
- Air Outlet Replacement - Side Window (Left)
- Air Outlet Replacement - Instrument Panel - Left
- Air Outlet Replacement - Instrument Panel - Center
- Air Outlet Replacement - Instrument Panel - Right
- Air Outlet Replacement - Defroster
- Air Outlet Replacement - Rear Floor
- Air Temperature Door Replacement
- Mode Valve Assembly Replacement
- Recirculation Door Replacement
- Heater Core Cover Replacement
- Heater Core Replacement
- Special Tools and Equipment
- HVAC System - Automatic
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0159, B0164, B0174, B0179, B0510, or B0515
- DTC B0184 or B0189
- DTC B0249, B0269, B0409, or B0419
- DTC B0414, B0424, B3748, or B3749
- DTC P0530
- DTC P0645
- Symptoms - HVAC Systems - Automatic
- HVAC Compressor Clutch Does Not Engage
- HVAC Compressor Clutch Does Not Disengage
- Blower Motor Always On
- Blower Motor Inoperative
- Blower Motor Malfunction
- Too Hot in Vehicle
- Too Cold in Vehicle
- Air Delivery Improper
- Air Recirculation Malfunction
- Re-Calibrating Actuators
- Repair Instructions
- HVAC Control Module Replacement
- Recirculation Actuator Replacement
- Mode Actuator Replacement
- Air Temperature Actuator Replacement - Right
- Air Temperature Actuator Replacement - Left
- Air Temperature Sensor Replacement - Upper Right
- Air Temperature Sensor Replacement - Upper Left
- Air Temperature Sensor Replacement - Lower Left
- Air Temperature Sensor Replacement - Lower Right
- Ambient Air Temperature Sensor Replacement
- Inside Air Temperature Sensor Replacement
- Sun Load Sensor Replacement
- Description and Operation
- Special Tools and Equipment
- HVAC Systems - Manual
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0248, B0268, or B0418
- DTC B0249, B0269, or B0419
- DTC B0424, B3748, or B3749
- DTC P0530
- DTC P0645
- Symptoms - HVAC Systems - Manual
- HVAC Compressor Clutch Does Not Engage
- HVAC Compressor Clutch Does Not Disengage
- Blower Motor Always On
- Blower Motor Inoperative
- Blower Motor Malfunction
- Too Hot in Vehicle
- Too Cold in Vehicle
- Air Delivery Improper
- Re-Calibrating Actuators
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Heating, Ventilation & Air Conditioning
- Maintenance
- Restraints
- Air Bag, SRS
- Supplemental Inflatable Restraint System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - SIR
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B0012, B0013, B0014, B0016, B0017, or B0018
- DTC B0022, B0024, B0026, B0042, B0043, or B0044
- DTC B0028, B0029, or B0030
- DTC B0040, B0041, or B0045
- DTC B0051
- DTC B0053
- DTC B0057, B0058, or B0059
- DTC B0064, B0065, or B0066
- DTC B0077, B0078, B0079, B0080, B0081, or B0082
- DTC B0103, B0104, or B0105
- DTC B1001
- Symptoms - SIR
- Air Bag Indicator Circuit Malfunction
- SIR Disabling and Enabling Zones
- Repair Instructions
- SIR Service Precautions
- SIR Disabling and Enabling Zone 1
- SIR Disabling and Enabling Zone 2
- SIR Disabling and Enabling Zone 3
- SIR Disabling and Enabling Zone 5
- SIR Disabling and Enabling Zone 6
- SIR Disabling and Enabling Zone 7
- SIR Disabling and Enabling Zone 9
- Inflatable Restraint Front End Sensor Replacement
- Inflatable Restraint Side Impact Sensor Replacement
- Inflatable Restraint Sensing and Diagnostic Module Replacement
- Inflatable Restraint Steering Wheel Module Replacement
- Inflatable Restraint Steering Wheel Module Coil Replacement (Coil)
- Inflatable Restraint Instrument Panel Module Replacement
- Inflatable Restraint Roof Rail Module Replacement - Left
- Inflatable Restraint Roof Rail Module Replacement - Right
- Seat Belt Buckle Pretensioner Replacement
- Repairs and Inspections Required After a Collision
- Inflator Module Handling and Scrapping
- Pretensioner Handling and Scrapping
- Description and Operation
- SIR System Description and Operation
- SIR System Overview
- Frontal SIR System Description
- Inflatable Restraint Sensing and Diagnostic Module (SDM)
- AIR BAG Indicator
- Dual Stage Inflator Modules
- Inflatable Restraint Steering Wheel Module Coil
- Steering Wheel and Column
- Inflatable Restraint Front End Sensor
- Inflatable Restraint Seat Belt Pretensioner
- Inflatable Restraint Wiring Harness
- Knee Bolster
- Side SIR System Description
- Inflatable Restraint Side Impact Sensor (SIS)
- SIR System Description and Operation
- Special Tools and Equipment
- Supplemental Inflatable Restraint System
- Restraints Control Systems
- Seat Belt System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Seat Belt System
- Seat Belts
- Seat Belt System
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Description and Operation
- Special Tools and Equipment
- Seat Belt System
- Air Bag, SRS
- Steering
- Electronic Steering System - Variable Effort Steering
- Manual Steering
- Power Steering System
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Power Steering System (w/o Electrohydraulic Steering)
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle, Clunk, or Shudder Noise from the Power Steering System
- Whine or Growl Noise from the Power Steering System
- Steering Effort Hard or Too Easy in One or Both Directions
- Steering Effort Hard in One or Both Directions
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Flushing the Power Steering System
- Remote Power Steering Fluid Reservoir Replacement
- Power Steering Pulley Replacement (3.8L V-6)
- Power Steering Pulley Replacement (5.3L V-8)
- Power Steering Pump Replacement (3.8L V-6)
- Power Steering Pump Replacement (5.3L V-8)
- Power Steering Reservoir Replacement - Off Vehicle (CB Series)
- Power Steering Pump Flow Control Valve Replacement - Off Vehicle (CB Series)
- Power Steering Pump Drive Shaft Seal Replacement (CB)
- Rack and Pinion Outer Tie Rod End Replacement
- Rack and Pinion Boot Replacement
- Rack and Pinion Boot Replacement - On Vehicle
- Power Steering Cooler Pipe/Hose Replacement
- Power Steering Pressure Pipe/Hose Replacement (L26 and L32)
- Power Steering Pressure Pipe/Hose Replacement (LS4)
- Power Steering Return Hose Replacement
- Power Steering Gear Replacement
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle (MAGNASTEER)
- Rack and Pinion Boot and Breather Tube Replacement - Off Vehicle
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Magnasteer)
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - Off Vehicle (MAGNASTEER)
- Description and Operation
- Special Tools and Equipment
- Power Steering System
- Power Steering System
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Power Steering System (w/o Electrohydraulic Steering)
- Symptoms - Power Steering System
- Power Steering System Test Procedure
- Power Steering Fluid Leaks
- Rattle, Clunk, or Shudder Noise from the Power Steering System
- Whine or Growl Noise from the Power Steering System
- Steering Effort Hard or Too Easy in One or Both Directions
- Steering Effort Hard in One or Both Directions
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Power Steering Fluid
- Flushing the Power Steering System
- Remote Power Steering Fluid Reservoir Replacement
- Power Steering Pulley Replacement (3.8L V-6)
- Power Steering Pulley Replacement (5.3L V-8)
- Power Steering Pump Replacement (3.8L V-6)
- Power Steering Pump Replacement (5.3L V-8)
- Power Steering Reservoir Replacement - Off Vehicle (CB Series)
- Power Steering Pump Flow Control Valve Replacement - Off Vehicle (CB Series)
- Power Steering Pump Drive Shaft Seal Replacement (CB)
- Rack and Pinion Outer Tie Rod End Replacement
- Rack and Pinion Boot Replacement
- Rack and Pinion Boot Replacement - On Vehicle
- Power Steering Cooler Pipe/Hose Replacement
- Power Steering Pressure Pipe/Hose Replacement (L26 and L32)
- Power Steering Pressure Pipe/Hose Replacement (LS4)
- Power Steering Return Hose Replacement
- Power Steering Gear Replacement
- Rack and Pinion Gear Rack Bearing Preload Adjustment - Off Vehicle (MAGNASTEER)
- Rack and Pinion Boot and Breather Tube Replacement - Off Vehicle
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Magnasteer)
- Rack and Pinion Inner Tie Rod Replacement - Off Vehicle (Quiet Valve)
- Steering Gear Cylinder Pipe Assemblies/O-Ring Seals Replacement - Off Vehicle (MAGNASTEER)
- Description and Operation
- Special Tools and Equipment
- Steering Wheel & Steering Column
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Repair Instructions
- Seal Replacement - Intermediate Steering Shaft
- Intermediate Steering Shaft Replacement
- Steering Column Accident Damage Inspection
- Steering Column Trim Covers Replacement
- Turn Signal Cancel Cam and Steering Shaft Upper Bearing Spring Replacement
- Multifunction, Turn Signal Switch Replacement
- Turn Signal Switch Housing Replacement
- Tilt Lever Replacement
- Steering Wheel Cover Replacement
- Steering Wheel Control Switch Assembly Replacement
- Steering Wheel Replacement
- Tilt Spring Replacement
- Steering Column Tilt Head Replacement
- Steering Column Replacement
- Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement
- Steering Wheel Position Sensor Centering
- Steering Shaft, Lower Bearing, and Jacket Replacement
- Inflatable Restraint Steering Wheel Module Coil Centering
- Description and Operation
- Special Tools and Equipment
- Suspension
- Front Suspension
- Front Suspension System
- Specifications
- Repair Instructions
- Stabilizer Shaft Replacement
- Stabilizer Shaft Link Replacement
- Stabilizer Shaft Insulator Replacement
- Lower Ball Joint Replacement
- Wheel Bearing/Hub Replacement - Front
- Steering Knuckle Replacement
- Lower Control Arm Replacement
- Lower Control Arm Bushings Replacement (Vertical)
- Wheel Stud Replacement
- Strut Assembly Replacement
- Suspension Shock/Strut Disposal
- Strut, Strut Component and/or Spring Replacement
- Description and Operation
- Special Tools and Equipment
- Suspension General Diagnosis
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Suspension General Diagnosis
- Symptoms - Suspension General Diagnosis
- Ride Diagnosis
- Vehicle Leads/Pulls
- Body Leans or Sways in Corners
- Suspension Bottoms
- Torque Steer
- Memory Steer
- Poor Directional Stability
- Noise Diagnosis - Front Suspension
- Noise Diagnosis - Rear Suspension
- Ball Joint Inspection
- Struts or Shock Absorbers On-Vehicle Testing
- Wheel Bearings Diagnosis
- Trim Height Inspection Procedure
- Special Tools and Equipment
- Front Suspension System
- Rear Suspension
- Rear Suspension System
- Specifications
- Repair Instructions
- Wheel Bearing/Hub Replacement - Rear
- Support Replacement
- Knuckle Replacement
- Stabilizer Shaft Replacement
- Stabilizer Shaft Insulator Replacement
- Stabilizer Shaft Link Replacement
- Trailing Arm Replacement
- Spindle Rod Replacement
- Strut Assembly Replacement
- Suspension Shock/Strut Disposal
- Strut, Strut Component and/or Spring Replacement
- Wheel Stud Replacement
- Description and Operation
- Special Tools and Equipment
- Suspension General Diagnosis
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Suspension General Diagnosis
- Symptoms - Suspension General Diagnosis
- Ride Diagnosis
- Vehicle Leads/Pulls
- Body Leans or Sways in Corners
- Suspension Bottoms
- Torque Steer
- Memory Steer
- Poor Directional Stability
- Noise Diagnosis - Front Suspension
- Noise Diagnosis - Rear Suspension
- Ball Joint Inspection
- Struts or Shock Absorbers On-Vehicle Testing
- Wheel Bearings Diagnosis
- Trim Height Inspection Procedure
- Special Tools and Equipment
- Rear Suspension System
- Wheel Alignment System
- Wheels & Tire System
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transaxle - Introduction (Diagnostic Information & Procedures)
- Automatic Transaxle - Introduction & Repair Instructions
- Specifications
- Transmission Fluid Temperature (TFT) Sensor Specifications
- Fastener Tightening Specifications
- Transmission General Specifications
- Fluid Capacity Specifications
- Range Reference (Without Touch Activated Power)
- Range Reference (With Touch Activated Power)
- Shift Solenoid Valve State and Gear Ratio
- Shift Speed
- Transmission Internal Mode Switch Logic
- Line Pressure
- Component Resistance
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Automatic Transmission Range Selector Cable Replacement
- Automatic Transmission Range Selector Cable Adjustment
- Switch Replacement - Automatic Transmission Manual Shift Auxiliary Position - Steering Wheel
- Park Lock Cable Replacement
- Park Lock Cable Adjustment
- Fluid Filler Tube Replacement
- Vehicle Speed Sensor (VSS) Replacement
- Reverse Servo Replacement
- Forward Servo Replacement
- Front Wheel Drive Shaft Oil Seal Replacement - Left
- Front Wheel Drive Shaft Oil Seal Replacement - Right
- Oil Pressure Test Plug Replacement
- Transmission Vent Replacement
- Oil Pan Replacement
- Oil Filter and Seal Replacement
- Accumulator and 2-1 Manual Servo Replacement
- Thermo Element Replacement
- Wiring Harness Replacement
- Case Side Cover Replacement
- Torque Converter Clutch (TCC) Solenoid Replacement
- Fluid Temperature Sensor Replacement
- Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid Replacement
- 1-2 Shift Solenoid Valve Replacement
- 2-3 Shift Solenoid Valve Replacement
- Input Speed Sensor Replacement
- Pressure Control Solenoid (PCS) Replacement
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Replacement
- Oil Pump Replacement
- Control Valve Body Replacement
- Oil Weir Replacement
- Case Extension Housing Replacement
- Final Drive Replacement
- Output Shaft Replacement
- Automatic Transmission Oil Cooler Hose Replacement
- Transmission Fluid Cooler Line Quick Connect Fitting
- Transmission Fluid Cooler Connector Replacement
- Automatic Transmission Radiator Oil Cooler Connector Replacement
- Transmission Mount Inspection
- Automatic Transmission Brace Replacement
- Transmission Mount Replacement - Left
- Transmission Mount Bracket Replacement - Left
- Torque Converter Cover Replacement
- Flywheel to Torque Converter Bolt Replacement
- Transmission Replacement
- Description and Operation
- Transmission General Information
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Transmission Adaptive Functions
- TAP Shift Operation
- Electronic Component Description
- Vehicle Speed Sensor
- Automatic Transmission Input Speed Sensor
- 1-2 and 2-3 Shift Solenoid Valves
- Pressure Control Solenoid Valve
- Torque Converter Clutch Pulse Width Modulation Solenoid Valve
- Automatic Transmission Fluid Pressure Manual Valve Position Switch
- Lever Assembly-Manual Shaft Detent with Internal Mode Switch
- Automatic Transmission Fluid Temperature Sensor
- TAP Shift Switches
- Automatic Transmission Inline 20-Way Connector Description
- Special Tools and Equipment
- Specifications
- Automatic Transaxle - Hydraulic Diagrams - 4T65-E
- Automatic Transaxle - Overhaul - 4T65-E
- Specifications
- Component Locator
- Repair Instructions
- Torque Converter Assembly Removal
- Transmission Support Fixture Assemble
- Transfer Case Removal
- Reverse Servo Removal
- Forward Servo Removal
- Pan and Filter Assembly Removal
- Oil Filter Inspection
- Accumulator Assembly and 2-1 Band Servo Removal
- Control Valve Body Cover and Gaskets Disassemble
- Wiring Harness Removal
- Oil Pump Removal
- Control Valve Body Assembly Removal
- Oil Pump Drive Shaft Removal
- Vehicle Speed Sensor (VSS) Removal
- Output Shaft Removal
- Front Differential Carrier End Play Check (FWD Only)
- Manual Valve Link and Oil Dam Removal
- Drive Axle Oil Seal Removal - Left
- Case Cover Removal
- Fourth Clutch Components Removal
- Drive Link Stretch Check
- Drive Sprocket, Driven Sprocket, and Drive Link Removal
- Driven Sprocket Support Assembly Removal
- Second Clutch and Input Clutch Removal
- Reverse Band Removal
- Reverse Reaction Drum Removal
- Case Extension Assembly Removal
- Differential Carrier and Components Removal
- Input and Reaction Carrier Removal
- Reaction Sun Gear and Manual 2-1 Band Removal
- 1-2 Support Drum and Forward Band Removal
- Differential Carrier Internal Gear Removal
- Manual Shift Shaft Position (Internal Mode) Switch and Parking System Components Removal
- Case Assembly Inspection
- Case Components Disassemble
- Case Components Assemble
- Torque Converter Oil Seal Removal
- Drive Sprocket Support Removal
- Drive Sprocket Support Assemble
- Torque Converter Oil Seal Assemble
- Manual Shift Shaft Position (Internal Mode) Switch and Parking System Components Installation
- Differential Carrier Internal Gear Assemble
- Differential Carrier Inspection (FWD Only)
- Differential Carrier Disassemble (FWD Only)
- Differential Carrier Assemble (FWD Only)
- Vehicle Speed Sensor (VSS) Reluctor Wheel Disassemble (FWD Only)
- Vehicle Speed Sensor (VSS) Reluctor Wheel Assemble (FWD Only)
- Differential Carrier Components Assemble (FWD Only)
- Case Extension Assemble (FWD Only)
- Forward Band Assemble
- 1-2 Support Roller Clutch Disassemble
- 1-2 Support Roller Clutch Assemble
- 1-2 Support Roller Clutch Functional Check
- 1-2 Support Drum Assemble
- 2-1 Manual Band Assemble
- Reaction Sun Gear and Drum Assemble
- Input and Reaction Carrier Pinion End Play Check
- Input and Reaction Carrier Assemble
- Reverse Reaction Drum Assemble
- Input and Third Sprag Clutches Disassemble
- Input and Third Sprag Clutches Assemble
- Input and Third Sprag Clutches Functional Check
- Input Clutch and Third Clutch Disassemble
- Input Clutch Housing Assembly Inspection
- Input Clutch Housing Ball Check Valve Disassemble
- Input Clutch Housing Ball Check Valve Assemble
- Input Clutch and Third Clutch Assemble
- Input Clutch and Third Clutch Functional Air Check
- Input Clutch Housing Oil Seal Rings Assemble
- Input Clutch Housing and Sprag Clutches Assemble
- Input Clutch Housing End Play Check (FWD Only)
- Input Clutch Housing End Play Check (F4WD Only)
- Second Clutch Disassemble
- Second Clutch Housing Assembly Inspection
- Second Clutch Housing Ball Check Valve Disassemble
- Second Clutch Housing Ball Check Valve Assemble
- Second Clutch Assemble
- Reverse Band Assemble
- Driven Sprocket Support Components Disassemble
- Driven Sprocket Support Components Inspection
- Driven Sprocket Support Bearing Disassemble
- Driven Sprocket Support Bearing Assemble
- Driven Sprocket Support Components Assemble
- Fourth and Second Clutch Functional Air Check
- Second, Input, Third and Sprag Clutches Assemble
- Driven Sprocket Support Assemble
- Drive Sprocket and Turbine Shaft Disassemble
- Drive Sprocket and Turbine Shaft Assemble
- Drive and Driven Sprocket Components Assemble
- Fourth Clutch Components Assemble
- Case Cover Components Disassemble (Without Touch Activated Power)
- Case Cover Components Disassemble (With Touch Activated Power)
- Case Cover Components Inspection (Without Touch Activated Power)
- Case Cover Components Inspection (With Touch Activated Power)
- Case Cover Bearing Disassemble
- Case Cover Bearing Assemble
- Drive Shaft Oil Seal Assemble - Left
- Case Cover Components Assemble (Without Touch Activated Power)
- Case Cover Components Assemble (With Touch Activated Power)
- Case Cover and Gaskets Assemble
- Manual Valve Link and Oil Dam Assemble
- Differential Carrier End Play Check (FWD Only)
- Drive Shaft Oil Seal Disassemble - Right (FWD Only)
- Drive Shaft Oil Seal Assemble - Right (FWD Only)
- Vehicle Speed Sensor (VSS) Assemble (FWD Only)
- Control Valve Body Clean
- Control Valve Body Inspection
- Control Valve Body Disassemble (Without Touch Activated Power)
- Control Valve Body Disassemble (With Touch Activated Power)
- Control Valve Body Assemble (Without Touch Activated Power)
- Control Valve Body Assemble (With Touch Activated Power)
- Oil Pump Drive Shaft Assemble
- Control Valve Body and Spacer Plate Assemble
- Oil Pump Components Disassemble
- Oil Pump Components Assemble
- Wiring Harness Assemble
- Control Valve Body Cover and Gasket Assemble
- Thermo Element Adjustment
- 2-1 Manual Band Servo Disassemble
- 2-1 Manual Band Servo Assemble
- Accumulator Components Disassemble
- Accumulator Components Assemble
- Accumulator Assembly, 2-1 Band Servo Assemble
- Oil Pan and Filter Assemble
- Forward Band Servo Components Disassemble
- Forward Band Servo Assemble
- Reverse Band Servo Components Disassemble
- Reverse Band Servo Assemble
- Transmission to Transfer Case End Play Check (F4WD Only)
- Transfer Case Installation
- Output Shaft Assemble
- Transmission Holding Fixture Disassemble
- Torque Converter Inspection
- Torque Converter Assemble
- Description and Operation
- Automatic Transmission Hydraulic Diagrams
- Park or Neutral - Engine Running (Park - Without Touch Activated Power)
- Notes
- Pressure Regulator Valve (313)
- Actuator Feed Limit Valve (414)
- Pressure Control (PC) Solenoid Valve (322)
- Torque Signal Regulator Valve (321)
- Line Pressure Relief Valve (324)
- Manual Valve (404)
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Assembly (34)
- 1-2, 3-4 Shift Solenoid Valve (315A)
- 2-3 Shift Solenoid Valve (315B)
- 1-2 Shift Valve (318)
- 2-3 Shift Valve (357)
- 1-2, 2-3 and 3-4 Accumulator Valves (350, 344, 341)
- 1-2, 2-3 and 3-4 Accumulator Assemblies
- Pressure Regulator Valve (313) (Torque Converter/Cooler and Lube Circuits)
- TCC Control Valve (335)
- Park or Neutral - Engine Running (Park - With Touch Activated Power)
- Notes
- Pressure Regulator Valve (313)
- Actuator Feed Limit Valve (414)
- Pressure Control (PC) Solenoid Valve (322)
- Torque Signal Regulator Valve (321)
- Line Pressure Relief Valve (324)
- Manual Valve (404)
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Assembly (34)
- 1-2, 3-4 Shift Solenoid Valve (315A)
- 2-3 Shift Solenoid Valve (315B)
- 1-2 Shift Valve (318)
- 2-3 Shift Valve (357)
- 1-2, 2-3 and 3-4 Accumulator Valves (350, 344, 341)
- 1-2, 2-3 and 3-4 Accumulator Assemblies
- Pressure Regulator Valve (313) (Torque Converter/Cooler and Lube Circuits)
- TCC Control Valve (335)
- Park or Neutral - Engine Running (Neutral-Without Touch Activated Power)
- Park or Neutral - Engine Running (Neutral - With Touch Activated Power)
- Reverse (Without Touch Activated Power)
- Reverse (With Touch Activated Power)
- Overdrive Range, First Gear (Without Touch Activated Power)
- Overdrive Range, First Gear (With Touch Activated Power)
- Overdrive Range, Second Gear (Without Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315A)
- 1-2 Shift Valve (318)
- Number 2 Ball Check Valve (372)
- Second Clutch
- Input Clutch
- Input Sprag Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 1-2 Accumulator
- 1-2 Accumulator Valve
- TCC Control Pulse Width Modulated (PWM) Solenoid Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Second Gear (With Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315A)
- 1-2 Shift Valve (318)
- Number 2 Ball Check Valve (372)
- Second Clutch
- Input Clutch
- Input Sprag Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 1-2 Accumulator
- 1-2 Accumulator Valve
- TCC Control Pulse Width Modulated (PWM) Solenoid Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (Without Touch Activated Power)
- Notes
- 2-3 Shift Solenoid (SS) Valve (315)
- Number 9 Ball Check Valve (372)
- Number 4 Ball Check Valve (372)
- 2-3 Shift Valve (357)
- Third Clutch
- Third Roller Clutch
- Input Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 2-3 Accumulator
- 2-3 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (With Touch Activated Power)
- Notes
- 2-3 Shift Solenoid (SS) Valve (315)
- Number 9 Ball Check Valve (372)
- Number 4 Ball Check Valve (372)
- 2-3 Shift Valve (357)
- Third Clutch
- Third Roller Clutch
- Input Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 2-3 Accumulator
- 2-3 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Not Applied (Without Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315)
- 1-2 Shift Valve (318)
- 3-4 Shift Valve (362)
- Fourth Clutch
- Third Clutch
- Third Roller Clutch
- Second Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 3-4 Accumulator
- 3-4 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Not Applied (With Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315)
- 1-2 Shift Valve (318)
- 3-4 Shift Valve (362)
- Fourth Clutch
- Third Clutch
- Third Roller Clutch
- Second Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 3-4 Accumulator
- 3-4 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (Without Touch Activated Power)
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (With Touch Activated Power)
- Overdrive Range, 4-3 Downshift - Torque Converter Clutch (TCC) Not Applied (Without Touch Activated Power)
- Overdrive Range, 4-3 Downshift - Torque Converter Clutch (TCC) Not Applied (With Touch Activated Power)
- Drive Range, Manual Third (from Overdrive Range) (Without Touch Activated Power)
- Manual Third Gear (With Touch Activated Power)
- Drive Range, Manual Second (from Drive, Manual Third) (Without Touch Activated Power)
- Manual Second Gear (With Touch Activated Power)
- Drive Range, Manual First (from Drive, Manual Second) (Without Touch Activated Power)
- Manual First Gear (With Touch Activated Power)
- Park or Neutral - Engine Running (Park - Without Touch Activated Power)
- Fluid Passages
- Automatic Transmission Hydraulic Diagrams
- Special Tools and Equipment
- Automatic Transaxle - Service, Diagnosis & Troubleshooting
- Symptoms - Automatic Transmission
- TAP Shift Circuit Performance
- Range Selector Displays Incorrect Range (3.8L)
- Range Selector Displays Incorrect Range (5.3L)
- Transmission Fluid Checking Procedure
- Line Pressure Check Procedure
- Road Test Procedure
- Torque Converter Diagnosis Procedure
- Torque Converter Replacement Guide
- Flexplate/Torque Converter Vibration Test
- Noise and Vibration Analysis
- Clutch Plate Diagnosis
- Engine Coolant/Water in Transmission
- Fluid Leak Diagnosis
- Case Porosity Repair
- Shift Solenoid Leak Test
- Automatic Transmission Oil Cooler Flushing and Flow Test (J45096)
- Automatic Transmission Oil Cooler Flushing and Flow Test (J35944-A)
- Automatic Transmission Fluid Leaks
- Incorrect Line Pressure
- Delayed Park to Reverse/Drive Engagement
- Harsh Park to Reverse/Drive Engagement
- Slips in Drive or No Drive
- Slips in Reverse or No Reverse
- Locked Up in Drive/Reverse
- No Park Range
- Harsh or Soft 1-2 Shift Feel
- Harsh or Soft 2-3/3-2 Shift Feel
- Harsh or Soft 3-4/4-3 Shift Feel
- High or Low Upshift or Downshift Speed
- First and Second Gear Only (2-3 Solenoid Stuck On)
- First and Fourth Gear Only (1-2 Solenoid Stuck On)
- Second and Third Gear Only (1-2 Solenoid Stuck Off)
- Third and Fourth Gear Only (2-3 Solenoid Stuck Off)
- First Gear Only
- Second Gear Only
- Third Gear Only
- Fourth Gear Only
- Slipping or No First Gear
- Slipping or No Second Gear
- Slipping or No Third Gear
- Slipping or No Fourth Gear
- No Engine Braking in Manual Ranges (Touch Activated Power)
- Whine Noise Varying with RPM or Fluid Pressure
- Popping Noise
- Buzz Noise or High Frequency Rattle Sound
- Whine/Growl Noise That Changes with Vehicle Speed
- Final Drive Noise or Hum Noise
- Noise in First, Second, Third, or Fourth
- Noise in Random Ranges
- Abnormal Noise in Park or Neutral Range
- Converter Clutch Stuck On in All Gears
- Converter Clutch Stuck On in Second, Third and Fourth Gear
- Harsh Torque Converter Clutch (TCC) Apply or Release
- Converter Clutch Apply Rough, Slips, or Shudders
- No Torque Converter Clutch (TCC) Apply
- Automatic Transaxle (DTC P0218 To DTC P0751)
- DTC P0218 (3.8L)
- DTC P0218 (5.3L)
- DTC P0502 (3.8L)
- DTC P0503 (3.8L)
- DTC P0562 (5.3L)
- DTC P0563 (5.3L)
- DTC P0601, P0602, P0603, or P0604 (5.3L)
- DTC P0711 (3.8L)
- DTC P0711 (5.3L)
- DTC P0712 (3.8L)
- DTC P0712 (5.3L)
- DTC P0713 (3.8L)
- DTC P0713 (5.3L)
- DTC P0716 (3.8L)
- DTC P0716 (5.3L)
- DTC P0717 (3.8L)
- DTC P0717 (5.3L)
- DTC P0722 (5.3L)
- DTC P0723 (5.3L)
- DTC P0741 (3.8L)
- DTC P0741 (5.3L)
- DTC P0742 (3.8L)
- DTC P0742 (5.3L)
- DTC P0748 (3.8L)
- DTC P0751 (3.8L)
- Automatic Transaxle (DTC P0751 To DTC P1819)
- DTC P0751 (5.3L)
- DTC P0752 (3.8L)
- DTC P0752 (5.3L)
- DTC P0753 (3.8L)
- DTC P0756 (3.8L)
- DTC P0756 (5.3L)
- DTC P0757 (3.8L)
- DTC P0757 (5.3L)
- DTC P0758 (3.8L)
- DTC P0815 (3.8L)
- DTC P0816 (3.8L)
- DTC P0826 (3.8L)
- DTC P0842 (5.3L)
- DTC P0843 (5.3L)
- DTC P0850 (5.3L)
- DTC P0961 (5.3L)
- DTC P0973 (5.3L)
- DTC P0974 (5.3L)
- DTC P0976 (5.3L)
- DTC P0977 (5.3L)
- DTC P1621 (5.3L)
- DTC P1750 (3.8L)
- DTC P1811 (3.8L)
- DTC P1811 (5.3L)
- DTC P1819 (3.8L)
- Automatic Transaxle (DTC P1820 To DTC P2764)
- Shift Interlock System
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Automatic Transmission Shift Lock Control
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- DTC B2705
- Symptoms - Automatic Transmission Shift Lock Control
- Shift Lever Does Not Move with Brake Pedal Depressed
- Shift Lever Can Be Moved without Brake Pedal Depressed
- Repair Instructions
- Description and Operation
- Hydraulic Diagrams
- Automatic Transaxle - Hydraulic Diagrams - 4T65-E
- Automatic Transaxle - Overhaul - 4T65-E
- Specifications
- Component Locator
- Repair Instructions
- Torque Converter Assembly Removal
- Transmission Support Fixture Assemble
- Transfer Case Removal
- Reverse Servo Removal
- Forward Servo Removal
- Pan and Filter Assembly Removal
- Oil Filter Inspection
- Accumulator Assembly and 2-1 Band Servo Removal
- Control Valve Body Cover and Gaskets Disassemble
- Wiring Harness Removal
- Oil Pump Removal
- Control Valve Body Assembly Removal
- Oil Pump Drive Shaft Removal
- Vehicle Speed Sensor (VSS) Removal
- Output Shaft Removal
- Front Differential Carrier End Play Check (FWD Only)
- Manual Valve Link and Oil Dam Removal
- Drive Axle Oil Seal Removal - Left
- Case Cover Removal
- Fourth Clutch Components Removal
- Drive Link Stretch Check
- Drive Sprocket, Driven Sprocket, and Drive Link Removal
- Driven Sprocket Support Assembly Removal
- Second Clutch and Input Clutch Removal
- Reverse Band Removal
- Reverse Reaction Drum Removal
- Case Extension Assembly Removal
- Differential Carrier and Components Removal
- Input and Reaction Carrier Removal
- Reaction Sun Gear and Manual 2-1 Band Removal
- 1-2 Support Drum and Forward Band Removal
- Differential Carrier Internal Gear Removal
- Manual Shift Shaft Position (Internal Mode) Switch and Parking System Components Removal
- Case Assembly Inspection
- Case Components Disassemble
- Case Components Assemble
- Torque Converter Oil Seal Removal
- Drive Sprocket Support Removal
- Drive Sprocket Support Assemble
- Torque Converter Oil Seal Assemble
- Manual Shift Shaft Position (Internal Mode) Switch and Parking System Components Installation
- Differential Carrier Internal Gear Assemble
- Differential Carrier Inspection (FWD Only)
- Differential Carrier Disassemble (FWD Only)
- Differential Carrier Assemble (FWD Only)
- Vehicle Speed Sensor (VSS) Reluctor Wheel Disassemble (FWD Only)
- Vehicle Speed Sensor (VSS) Reluctor Wheel Assemble (FWD Only)
- Differential Carrier Components Assemble (FWD Only)
- Case Extension Assemble (FWD Only)
- Forward Band Assemble
- 1-2 Support Roller Clutch Disassemble
- 1-2 Support Roller Clutch Assemble
- 1-2 Support Roller Clutch Functional Check
- 1-2 Support Drum Assemble
- 2-1 Manual Band Assemble
- Reaction Sun Gear and Drum Assemble
- Input and Reaction Carrier Pinion End Play Check
- Input and Reaction Carrier Assemble
- Reverse Reaction Drum Assemble
- Input and Third Sprag Clutches Disassemble
- Input and Third Sprag Clutches Assemble
- Input and Third Sprag Clutches Functional Check
- Input Clutch and Third Clutch Disassemble
- Input Clutch Housing Assembly Inspection
- Input Clutch Housing Ball Check Valve Disassemble
- Input Clutch Housing Ball Check Valve Assemble
- Input Clutch and Third Clutch Assemble
- Input Clutch and Third Clutch Functional Air Check
- Input Clutch Housing Oil Seal Rings Assemble
- Input Clutch Housing and Sprag Clutches Assemble
- Input Clutch Housing End Play Check (FWD Only)
- Input Clutch Housing End Play Check (F4WD Only)
- Second Clutch Disassemble
- Second Clutch Housing Assembly Inspection
- Second Clutch Housing Ball Check Valve Disassemble
- Second Clutch Housing Ball Check Valve Assemble
- Second Clutch Assemble
- Reverse Band Assemble
- Driven Sprocket Support Components Disassemble
- Driven Sprocket Support Components Inspection
- Driven Sprocket Support Bearing Disassemble
- Driven Sprocket Support Bearing Assemble
- Driven Sprocket Support Components Assemble
- Fourth and Second Clutch Functional Air Check
- Second, Input, Third and Sprag Clutches Assemble
- Driven Sprocket Support Assemble
- Drive Sprocket and Turbine Shaft Disassemble
- Drive Sprocket and Turbine Shaft Assemble
- Drive and Driven Sprocket Components Assemble
- Fourth Clutch Components Assemble
- Case Cover Components Disassemble (Without Touch Activated Power)
- Case Cover Components Disassemble (With Touch Activated Power)
- Case Cover Components Inspection (Without Touch Activated Power)
- Case Cover Components Inspection (With Touch Activated Power)
- Case Cover Bearing Disassemble
- Case Cover Bearing Assemble
- Drive Shaft Oil Seal Assemble - Left
- Case Cover Components Assemble (Without Touch Activated Power)
- Case Cover Components Assemble (With Touch Activated Power)
- Case Cover and Gaskets Assemble
- Manual Valve Link and Oil Dam Assemble
- Differential Carrier End Play Check (FWD Only)
- Drive Shaft Oil Seal Disassemble - Right (FWD Only)
- Drive Shaft Oil Seal Assemble - Right (FWD Only)
- Vehicle Speed Sensor (VSS) Assemble (FWD Only)
- Control Valve Body Clean
- Control Valve Body Inspection
- Control Valve Body Disassemble (Without Touch Activated Power)
- Control Valve Body Disassemble (With Touch Activated Power)
- Control Valve Body Assemble (Without Touch Activated Power)
- Control Valve Body Assemble (With Touch Activated Power)
- Oil Pump Drive Shaft Assemble
- Control Valve Body and Spacer Plate Assemble
- Oil Pump Components Disassemble
- Oil Pump Components Assemble
- Wiring Harness Assemble
- Control Valve Body Cover and Gasket Assemble
- Thermo Element Adjustment
- 2-1 Manual Band Servo Disassemble
- 2-1 Manual Band Servo Assemble
- Accumulator Components Disassemble
- Accumulator Components Assemble
- Accumulator Assembly, 2-1 Band Servo Assemble
- Oil Pan and Filter Assemble
- Forward Band Servo Components Disassemble
- Forward Band Servo Assemble
- Reverse Band Servo Components Disassemble
- Reverse Band Servo Assemble
- Transmission to Transfer Case End Play Check (F4WD Only)
- Transfer Case Installation
- Output Shaft Assemble
- Transmission Holding Fixture Disassemble
- Torque Converter Inspection
- Torque Converter Assemble
- Description and Operation
- Automatic Transmission Hydraulic Diagrams
- Park or Neutral - Engine Running (Park - Without Touch Activated Power)
- Notes
- Pressure Regulator Valve (313)
- Actuator Feed Limit Valve (414)
- Pressure Control (PC) Solenoid Valve (322)
- Torque Signal Regulator Valve (321)
- Line Pressure Relief Valve (324)
- Manual Valve (404)
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Assembly (34)
- 1-2, 3-4 Shift Solenoid Valve (315A)
- 2-3 Shift Solenoid Valve (315B)
- 1-2 Shift Valve (318)
- 2-3 Shift Valve (357)
- 1-2, 2-3 and 3-4 Accumulator Valves (350, 344, 341)
- 1-2, 2-3 and 3-4 Accumulator Assemblies
- Pressure Regulator Valve (313) (Torque Converter/Cooler and Lube Circuits)
- TCC Control Valve (335)
- Park or Neutral - Engine Running (Park - With Touch Activated Power)
- Notes
- Pressure Regulator Valve (313)
- Actuator Feed Limit Valve (414)
- Pressure Control (PC) Solenoid Valve (322)
- Torque Signal Regulator Valve (321)
- Line Pressure Relief Valve (324)
- Manual Valve (404)
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Assembly (34)
- 1-2, 3-4 Shift Solenoid Valve (315A)
- 2-3 Shift Solenoid Valve (315B)
- 1-2 Shift Valve (318)
- 2-3 Shift Valve (357)
- 1-2, 2-3 and 3-4 Accumulator Valves (350, 344, 341)
- 1-2, 2-3 and 3-4 Accumulator Assemblies
- Pressure Regulator Valve (313) (Torque Converter/Cooler and Lube Circuits)
- TCC Control Valve (335)
- Park or Neutral - Engine Running (Neutral-Without Touch Activated Power)
- Park or Neutral - Engine Running (Neutral - With Touch Activated Power)
- Reverse (Without Touch Activated Power)
- Reverse (With Touch Activated Power)
- Overdrive Range, First Gear (Without Touch Activated Power)
- Overdrive Range, First Gear (With Touch Activated Power)
- Overdrive Range, Second Gear (Without Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315A)
- 1-2 Shift Valve (318)
- Number 2 Ball Check Valve (372)
- Second Clutch
- Input Clutch
- Input Sprag Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 1-2 Accumulator
- 1-2 Accumulator Valve
- TCC Control Pulse Width Modulated (PWM) Solenoid Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Second Gear (With Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315A)
- 1-2 Shift Valve (318)
- Number 2 Ball Check Valve (372)
- Second Clutch
- Input Clutch
- Input Sprag Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 1-2 Accumulator
- 1-2 Accumulator Valve
- TCC Control Pulse Width Modulated (PWM) Solenoid Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (Without Touch Activated Power)
- Notes
- 2-3 Shift Solenoid (SS) Valve (315)
- Number 9 Ball Check Valve (372)
- Number 4 Ball Check Valve (372)
- 2-3 Shift Valve (357)
- Third Clutch
- Third Roller Clutch
- Input Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 2-3 Accumulator
- 2-3 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Third Gear - Torque Converter Clutch (TCC) Not Applied (With Touch Activated Power)
- Notes
- 2-3 Shift Solenoid (SS) Valve (315)
- Number 9 Ball Check Valve (372)
- Number 4 Ball Check Valve (372)
- 2-3 Shift Valve (357)
- Third Clutch
- Third Roller Clutch
- Input Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 2-3 Accumulator
- 2-3 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Not Applied (Without Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315)
- 1-2 Shift Valve (318)
- 3-4 Shift Valve (362)
- Fourth Clutch
- Third Clutch
- Third Roller Clutch
- Second Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 3-4 Accumulator
- 3-4 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Not Applied (With Touch Activated Power)
- Notes
- 1-2, 3-4 Shift Solenoid (SS) Valve (315)
- 1-2 Shift Valve (318)
- 3-4 Shift Valve (362)
- Fourth Clutch
- Third Clutch
- Third Roller Clutch
- Second Clutch
- Forward Band
- 1-2 Support Roller Clutch
- 3-4 Accumulator
- 3-4 Accumulator Valve
- Torque Converter Clutch
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (Without Touch Activated Power)
- Overdrive Range, Fourth Gear - Torque Converter Clutch (TCC) Applied (With Touch Activated Power)
- Overdrive Range, 4-3 Downshift - Torque Converter Clutch (TCC) Not Applied (Without Touch Activated Power)
- Overdrive Range, 4-3 Downshift - Torque Converter Clutch (TCC) Not Applied (With Touch Activated Power)
- Drive Range, Manual Third (from Overdrive Range) (Without Touch Activated Power)
- Manual Third Gear (With Touch Activated Power)
- Drive Range, Manual Second (from Drive, Manual Third) (Without Touch Activated Power)
- Manual Second Gear (With Touch Activated Power)
- Drive Range, Manual First (from Drive, Manual Second) (Without Touch Activated Power)
- Manual First Gear (With Touch Activated Power)
- Park or Neutral - Engine Running (Park - Without Touch Activated Power)
- Fluid Passages
- Automatic Transmission Hydraulic Diagrams
- Special Tools and Equipment
- Automatic Trans
- External Pages