Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- New PAG Oil Released (02-01-39-004B)
- Information On Serpentine Belt Wear (04-06-01-013)
- Procedures Involving Thermal Expansion Valve Connect (99-T-42)
- Changes To Oil Charge For R134A A/C Compressors (98-T-23)
- EXPERTEC TSB (95-T-21)
- EXPERTEC TSB (95-I-02)
- Accessories & Equipment
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Essential Service Tool Update # 2 (U.S. Retailers Only) (08-00-89-020)
- Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
- Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Disconnect/Reconnect Procedure For Driver And Passenger Sir Modules (97-T-33A)
- Frontal Supplemental Inflatable Restraint Switch Kit (98-T-28)
- SSS Software Update - Version 44.50 (SSS - 44.50)
- Air Bag Disconnect/Reconnect Procedure (97-T-33)
- Sir Telltale Lamp On - DTC 24 & 71 - Inspect Coil (96-T-57B)
- Air Bag Warning Label Replacement (97-I-01)
- EXPERTEC TSB (95-T-19)
- Anti-Lock Brakes
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Service Information Regarding Anti-Lock Brakes (Abs) DTCS 47, 48, And 51 Diagnostic Chart (01-T-60)
- SSS Software Update - Version 44.50 (SSS - 44.50)
- Abs Telltale On In Vehicles With Or Without Abs (96-T-49)
- EXPERTEC TSB (95-T-13)
- Anti-Theft Systems
- Inoperative Or Intermittent Operation Of Various Electrical Functions (99-T-58)
- Information/Installation Of Trap Resistant Trunk Kit (99-T-08)
- New 1ST Design Lock Cylinders & Changed Service Kit (99-PA-01)
- New Remote Keyless Entry/SATURN Sec. System Module (97-T-44)
- Sunroof Binds When Opened/Closed - Replace Locators (97-T-11)
- Water Leak At Front Upper Door Frame - Apply Sealer (94-T-52B)
- Service Information On Lock Cylinder Coding (94-T-50)
- Automatic Trans
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Info - Remanufactured Transmission And Remanufactured Valve Body Information Requirements (04-07-30-026)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Service Information Regarding Service Applications For Automatic Transaxle Shift Solenoids (00-T-74)
- VALVEBODY Cover Gasket Information (95-T-25A)
- Service Information Regarding New Design Automatic Transaxle Solenoids (00-T-74)
- Service Info Regarding Auto Trans Air Check Process (99-T-56)
- Mp6/Mp7 Trans Design Change To Sprag Clutch Assembly (99-T-07)
- Design Changes To Differential Pinion Shaft & Gear (99-T-12)
- Vehicle Vibration Between 48 & 54 Mph - Damper Kit (96-T-52A)
- Design Changes To ATX Control Solenoid Valve (97-T-41A)
- SSS Software Update - Version 45.50A (SSS - 45.50A)
- Mil On "No Gear" DTC'S After Transaxle Repair (98-T-37)
- Delay/Harsh Engagement Into Reverse Or No Reverse (96-T-38A)
- Differential End Play Checking - Manual Update (97-T-19)
- Changes To Valve Body Cover Gasket, Cover & Case (96-T-42B)
- SMU - A/T Oil Pump Output & Line Pressure Tests (96-T-64)
- Changes - Torque CONV. Housing & Oil Pump Wear Plate (96-T-41)
- Automatic Transaxle Clutch Material Changes (95-T-43B)
- EXPERTEC Technical Service Bulletins (95-T-35)
- EXPERTEC TSB (95-T-09A)
- EXPERTEC TSB (94-T-51)
- EXPERTEC TSB (95-C-02)
- EXPERTEC TSB (94-T-46)
- Information On Transaxle Fluid (94-I-12)
- Auxiliary Emission Control Systems
- Ignition Coil Available As A Service Part (99-T-14)
- Year 2000 Effects On On-Board Vehicle Computers (99-I-05)
- SSS Software Update - Version 45.50A (SSS - 45.50A)
- Pcm & Abs EEPROM Information (96-T-46B)
- Pcm/EC DTC 45 Or P0172 - Replace O2 Sensor Wire (96-T-32A)
- Vehicle Runs Out Of Fuel With 1/8-1/4 Tank Indicated (96-T-44)
- Manual Update - Pcm/EC DTCS 26/32 & Info. Flag 27 (96-T-08)
- EXPERTEC TSB (95-T-01A)
- EXPERTEC TSB (95-T-26)
- Axle Shafts
- Body Electrical
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Body Interior
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Information On Serpentine Belt Wear (04-06-01-013)
- Battery Charger For Critical Image Equipment Program (99-I-07)
- Starter/Charging System Tester Repair/Loaner Program (98-I-16)
- Service Info. On Battery & Generator Diagnostics (97-T-28)
- Generator & Engine Wiring Harness Design Changes (97-T-22)
- EXPERTEC TSB (94-T-60)
- Clutch
- Improved Clutch Components/Flywheel Inspection (95-T-37A)
- Vehicle Vibration Between 48 & 54 Mph - Damper Kit (96-T-52A)
- Differential End Play Checking - Manual Update (97-T-19)
- Changes To Clutch Pressure Plate Cover & Driven Disc (96-T-16)
- Rattle Noise In 2ND Gear During Left Hand Turns (96-T-06)
- EXPERTEC TSB (95-T-37)
- Communication Devices
- Cooling System (Mechanical)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- Information On Serpentine Belt Wear (04-06-01-013)
- Objectionable Engine Vibration At Idle (Check Engine Mount, Cooling Module Mounts, Engine Strut Cradle Bracket, Muffler Hanger And Strap, A/C Suction Hose, And Adjust Or Replace As Required) (95-T-36A)
- Engine Coolant Recovery Reservoir Discoloration Due To Engine Cooling System Sealer (97-T-04A)
- Engine Cooling System Sealer Usage (97-T-40A)
- Engine Coolant Temperature Sensor Diagnostic Trouble Code(S) &/Or The Following Conditions: Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low &/Or Leaking Coolant, &/Or Service Engine Soon Lamp Illuminated (01-T-07)
- Information On New Exhaust Manifold Gasket (97-T-07)
- Cruise Control Systems
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SSS Software Update - Version 45.50A (SSS - 45.50A)
- SSS Software Update - Version 44.50 (SSS - 44.50)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- EXPERTEC TSB (94-T-49)
- EXPERTEC TSB (94-PA-08)
- Differentials & Drive Axles
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Squeak Or Squeal Noise From Intermediate Axle Shaft Bearing (01-T-11)
- EXPERTEC TSB (95-T-06)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM, and TCM) for All Models and All Model Years (05-06-04-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Intermittent No Start, Intermittent Stall After Start-Up &/Or Loss Of Radio Presets (Replace Instrument Panel Junction Block-IPJB And/Or Terminal) (03-08-45-001)
- Engine Coolant Temperature Sensor Diagnostic Trouble Code(S) &/Or The Following Conditions: Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low &/Or Leaking Coolant, &/Or Service Engine Soon Lamp Illuminated (01-T-07)
- Ignition Coil Available As A Service Part (99-T-14)
- Year 2000 Effects On On-Board Vehicle Computers (99-I-05)
- SSS Software Update - Version 1.01 Update 1.01A (SSS - 1.01A)
- SSS Software Update - Version 45.50A (SSS - 45.50A)
- Pcm & Abs EEPROM Information (96-T-46B)
- Pcm/EC DTC 45 Or P0172 - Replace O2 Sensor Wire (96-T-32A)
- No Start, Surge Or Stall During Light Throttle (96-T-58)
- Manual Update - Pcm/EC DTCS 26/32 & Info. Flag 27 (96-T-08)
- EXPERTEC TSB (95-T-34)
- EXPERTEC TSB (95-T-30)
- EXPERTEC TSB (95-I-08)
- EXPERTEC TSB (92-T-47B)
- EXPERTEC TSB (95-T-10)
- Entertainment Systems
- Information On Procedure To Unlock DELCO Radio With THEFTLOCK (PIC4696E)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Intermittent No Start, Intermittent Stall After Start-Up &/Or Loss Of Radio Presets (Replace Instrument Panel Junction Block-IPJB And/Or Terminal) (03-08-45-001)
- Am Band Radio Noise - Install Engine To Chassis GRND (98-T-43A)
- Inoperative Or Intermittent Operation Of Various Electrical Functions (99-T-58)
- After Market Cassette-Type Portable Cd Adapters (95-T-08C)
- Aftermarket Cassette Type Portable Cd Adapter Info (95-T-08C)
- Info On Aftermarket CASSETE-Type Portable Cd Adapter (95-T-08B)
- Audio Complaint Codes Table (97-T-38)
- Ignition Noise Or Interference Through Speakers (95-T-28A)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Info. On Aftermarket Cassette-Type Portable Cd Adapt (95-T-08A)
- EXPERTEC TSB (95-PA-06)
- EXPERTEC TSB (95-T-08)
- Cassette Tape Player Head Cleaning Procedure (94-T-47)
- Exhaust
- Objectionable Engine Vibration At Idle (Check Engine Mount, Cooling Module Mounts, Engine Strut Cradle Bracket, Muffler Hanger And Strap, A/C Suction Hose, And Adjust Or Replace As Required) (95-T-36A)
- 'HOOT' Or 'MOAN' Noise During Steady Throttle (97-T-46)
- Service Information On New Exhaust Manifold Gasket (97-T-07A)
- Information On New Exhaust Manifold Gasket (97-T-07)
- Exterior Body Panels
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- GM Training - Changes to Saturn Service Training Standards (STS) Requirements for 2009 and 2010 (U.S. Dealers) (09-00-89-021)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Stripped/Detached Front Seat To Floor Attachments (99-T-21)
- Front Side Marker Lamp Rubs Paint From Lower Fascia (96-T-45)
- Vehicle Runs Out Of Fuel With 1/8-1/4 Tank Indicated (96-T-44)
- Fuel Tank Fill Cap Holder Retainer Installation (96-T-05)
- EXPERTEC TSB (94-T-52)
- EXPERTEC TSB (93-T-21A)
- Exterior Lights
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Dome Lamp Falls Out Of Headliner - Install Screw (96-T-28)
- EXPERTEC TSB (95-T-39)
- Frames, Subframes & Crossmembers
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Stripped/Detached Front Seat To Floor Attachments (99-T-21)
- EXPERTEC TSB (94-T-25C)
- EXPERTEC TSB (94-T-04)
- Front Suspension
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Rattle Noise In 2ND Gear During Left Hand Turns (96-T-06)
- EXPERTEC TSB (95-T-07)
- Fuel System
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Pcm & Abs EEPROM Information (96-T-46B)
- Harsh Shift To Reverse/Start Then Stall - DTC 43 (96-T-20)
- Choke Cleaner And Brake Cleaner (94-I-13)
- EXPERTEC TSB (94-I-13)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Intermittent No Start, Intermittent Stall After Start-Up &/Or Loss Of Radio Presets (Replace Instrument Panel Junction Block-IPJB And/Or Terminal) (03-08-45-001)
- Aftermarket Cassette Type Portable Cd Adapter Info (95-T-08C)
- EXPERTEC TSB (95-T-39)
- Gauges & Instrument Panels
- Verifying Odometer Accuracy (PIC3100G)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Rattle Noise From Front Of Dash Area (00-T-39)
- Rattle Noise From Front Of Dash Area - Install Foam Shim (00-T-39)
- Squeaks & Rattles Coming From Upper Instrument Panel - New Molding (96-T-11)
- Inoperative Or Intermittent Operation Of Various Electrical Functions (99-T-58)
- SSS Software Update - Version 44.50 (SSS - 44.50)
- Clicking Or Ticking Noise From Odometer - Replace (95-T-27B)
- Rattle From Instrument Cluster ASSY - Insulate (96-T-63)
- Abs Telltale On In Vehicles With Or Without Abs (96-T-49)
- Vehicle Runs Out Of Fuel With 1/8-1/4 Tank Indicated (96-T-44)
- Squeaks & Rattles Coming From Top Or Corners Of Instrument Panel (96-T-33)
- Tapping Noise Coming From Dash/Cowl Area (96-T-14)
- EXPERTEC TSB (95-T-27)
- EXPERTEC TSB (95-PA-07)
- EXPERTEC TSB (95-T-11)
- Removal Of I/P Upper Trim Panel Assembly (95-T-02)
- EXPERTEC TSB (94-T-39)
- Hazy Or Fogged Instrument Cluster Assembly Lens (94-T-39)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- Rattle Noise From Front Of Dash Area (00-T-39)
- Rattle Noise From Front Of Dash Area - Install Foam Shim (00-T-39)
- Windows Fog Up (Open Front Of Dash Drains And Replace Air Inlet Screen If Required) (01-T-27)
- Odor From A/C At Vehicle Start-Up (Remove Debris From Evaporator Case, Disinfect Cooling Coil Coating, And Install Delayed Blower Motor Control Module) (96-T-34A)
- Sizzling/Hissing Noise After A/C Use - New CONTROLER (99-T-65)
- Procedures Involving Thermal Expansion Valve Connect (99-T-42)
- Service Info On Liquid/Suction Line TVX Connector (99-T-42)
- Changes To Oil Charge For R134A A/C Compressors (98-T-23)
- Loss Of Airflow From A/C Outlets - Extended Driving (98-T-10A)
- Removal & Installation Of Windshield Defroster Duct (96-T-53)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- A/C Odor At Vehicle Start-Up - Install Blower Delay (96-T-35)
- EXPERTEC TSB (95-I-06)
- EXPERTEC TSB (95-I-02)
- I/P Center Air Outlet Closes When Blower Is On High (94-T-54)
- EXPERTEC TSB (94-T-54)
- Ignition Switch/Steering Lock
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Ignition Lock Cylinder Updated Coding Procedure (99-T-01)
- New 1ST Design Lock Cylinders & Changed Service Kit (99-PA-01)
- Electrical Accessories Intermittently Inoperative (96-T-50A)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Service Information On Lock Cylinder Coding (94-T-50)
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Rattle Noise From Front Of Dash Area (00-T-39)
- Squeaks & Rattles Coming From Upper Instrument Panel - New Molding (96-T-11)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Stripped/Detached Front Seat To Floor Attachments (99-T-21)
- New Torque Spec For Front Seat Adjuster To VEH Bolts (98-T-39)
- Water Leaks Into Front FOOTWELL From Front Of Dash (94-T-32A)
- Squeaks & Rattles From Top Or Top Corners Of I/P (96-T-33)
- Dome Lamp Falls Out Of Headliner - Install Screw (96-T-28)
- Dome Light Falls Out Of Headliner - Install Screw To Fix Lamp To Headliner (96-T-28)
- Squeaks & Rattles Coming From Upper I/P Area (96-T-11)
- Water Leak At Front Upper Door Frame - Apply Sealer (94-T-52B)
- EXPERTEC TSB (95-T-23)
- EXPERTEC TSB (94-T-58)
- EXPERTEC TSB (94-T-52)
- Interior/Illumination Lights
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Front Side Marker Lamp Rubs Paint From Lower Fascia (96-T-45)
- Dome Lamp Falls Out Of Headliner - Install Screw (96-T-28)
- Dome Light Falls Out Of Headliner - Install Screw To Fix Lamp To Headliner (96-T-28)
- Locking Hubs
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Internal Engine Cleaning Products (99-I-08)
- Information On New Exhaust Manifold Gasket (97-T-07)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Power Steering System Noise and/or Leak Diagnosis (02-T-46)
- Information On Serpentine Belt Wear (04-06-01-013)
- Design Changes To Strut Assemblies/Dust Boots (99-T-16)
- Power Steering Pump Drive Shaft Seal Leak (98-T-32)
- EXPERTEC TSB (95-T-07)
- EXPERTEC TSB (95-C-01)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Design Changes To Differential Pinion Shaft & Gear (99-T-12)
- Vehicle Vibration Between 48 & 54 Mph - Damper Kit (96-T-52A)
- Tool J43270 - Quill Bearing Seal Protector (98-T-17)
- Differential End Play Checking - Manual Update (97-T-19)
- Rattle Noise In 2ND Gear During Left Hand Turns (96-T-06)
- EXPERTEC Technical Service Bulletins (95-T-35)
- EXPERTEC TSB (95-T-09A)
- Information On Transaxle Fluid (94-I-12)
- Mechanical
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Essential Service Tool Update #4 (U.S. Retailers Only) (08-00-89-025)
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
- Essential Service Tool Update #8 (U.S. Retailers Only) (06-00-89-049)
- Objectionable Engine Vibration At Idle (Check Engine Mount, Cooling Module Mounts, Engine Strut Cradle Bracket, Muffler Hanger And Strap, A/C Suction Hose, And Adjust Or Replace As Required) (95-T-36A)
- Engine Cooling System Sealer Usage (97-T-40A)
- Service Information Regarding Upper Engine Mount Assembly (01-T-30A)
- Mobile Engine Lift Table (99-I-11)
- Internal Engine Cleaning Products (99-I-08)
- Engine Runs Hot &/Or Oil Mixed W/Coolant (96-T-65B)
- Vehicle Vibration Between 48 & 54 Mph - Damper Kit (96-T-52A)
- SMU - Piston Installation (99-T-02)
- Service Information On New Special Tools (98-T-50)
- Remanufactured Cylinder Head Assemblies (98-T-44)
- New Oil Pump Cover - Pump/Timing Chain Install Kits (97-T-15A)
- Information On New Exhaust Manifold Gasket (97-T-07)
- New Design Upper Engine Mount Assembly (96-T-48)
- EXPERTEC Technical Service Bulletins (95-T-35)
- EXPERTEC TSB (95-T-01A)
- EXPERTEC TSB (95-T-03)
- EXPERTEC TSB (94-T-59)
- EXPERTEC TSB (94-T-57)
- EXPERTEC TSB (94-T-48A)
- EXPERTEC TSB (94-T-56A)
- Choke Cleaner And Brake Cleaner (94-I-13)
- Mechanical - Hydraulic
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- Brake Pedal Pulsation And/Or Vehicle Vibration During Brake Application (Diagnosis/Service Procedures) (95-T-15)
- Rear Disc Brake Noise And/Or Pulsation (Replace With New Rear Disc Brake Pads) (98-T-15)
- Buzzing Noise Coming From Instrument Panel (95-T-31B)
- Noise From Instrument Panel During Slow Speed (95-T-31A)
- Bolt Torque Retention Compound For Brake Calipers (96-T-47)
- Front Brake Noise/Pulsation (New Front Disc Pads) (96-T-40A)
- EXPERTEC TSB (95-I-11)
- EXPERTEC TSB (95-T-31)
- EXPERTEC TSB (95-T-22)
- EXPERTEC TSB (95-T-16)
- Choke Cleaner And Brake Cleaner (94-I-13)
- EXPERTEC TSB (94-I-13)
- Mirrors
- Information On Curb Park Assist And Memory Related Issues On Outside Rearview Mirrors (07-08-64-022B)
- Electrical Accessories Intermittently Inoperative (96-T-50A)
- Sunroof Binds When Opened/Closed - Replace Locators (97-T-11)
- Removal & Installation Of Sunroof Switch Assembly (96-T-54)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Overdrive Unit
- Paint & Coatings
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004A)
- Info - Pinstripe/Vinyl Graphic Installation Tips And Techniques (04-08-51-004)
- Bumps or Iron Dust on Paint Surface (Apply Buffered Oxalic Acid Spray or a Clay Type Non-Acid Based Product Using Manufacturer's Recommendations) (99-08-51-006C)
- Bumps Or Rust Colored Spots In The Paint Due To Rail Or Iron Dust (94-T-09B)
- Front Side Marker Lamp Rubs Paint From Lower Fascia (96-T-45)
- Water Leak At Front Upper Door Frame - Apply Sealer (94-T-52B)
- Fuel Tank Fill Cap Holder Retainer Installation (96-T-05)
- Right FOOTWELL Water Leak - Sealer At Strut Tower (94-T-44)
- EXPERTEC TSB (94-I-08A)
- Parking Brake System
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Disconnect/Reconnect Procedure For Driver And Passenger Sir Modules (97-T-33A)
- Year 2000 Effects On On-Board Vehicle Computers (99-I-05)
- SSS Software Update - Version 44.50 (SSS - 44.50)
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Disconnect/Reconnect Procedure For Driver And Passenger Sir Modules (97-T-33A)
- Stripped/Detached Front Seat To Floor Attachments (99-T-21)
- New Torque Spec For Front Seat Adjuster To VEH Bolts (98-T-39)
- Top Tether Hardware Package For Child Restraint Seat (97-T-47A)
- Electrical Accessories Intermittently Inoperative (96-T-50A)
- Sunroof Binds When Opened/Closed - Replace Locators (97-T-11)
- Removal & Installation Of Sunroof Switch Assembly (96-T-54)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Tapping Noise Coming From Dash/Cowl Area (96-T-14)
- EXPERTEC TSB (95-T-33)
- EXPERTEC TSB (95-T-14)
- Starter
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- Battery Charger For Critical Image Equipment Program (99-I-07)
- Starter/Charging System Tester Repair/Loaner Program (98-I-16)
- Service Info. On Battery & Generator Diagnostics (97-T-28)
- EXPERTEC TSB (95-T-05)
- Steering Column
- Essential Service Tool Update # 8 (U.S. Retailers Only) (07-00-89-061)
- Power Steering System Noise and/or Leak Diagnosis (02-T-46)
- Clunk/Rattle Noise From Front Of Vehicle (98-T-08)
- STEEING Wheel Hub Seized To Steering Column (96-T-36)
- Rattle Noise In 2ND Gear During Left Hand Turns (96-T-06)
- EXPERTEC TSB (95-T-33)
- EXPERTEC TSB (95-T-14)
- EXPERTEC TSB (95-T-07)
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Sunroof Binds When Opened Or Closed - REPL Sunroof Locator Assemblies (97-T-11)
- Sunroof Binds When Opened/Closed - Replace Locators (97-T-11)
- Tapping Noise Coming From Dash/Cowl Area (96-T-14)
- EXPERTEC TSB (95-T-24)
- EXPERTEC TSB (93-T-21A)
- Suspension Control Systems
- System
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM, and TCM) for All Models and All Model Years (05-06-04-013)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In August, 2004 (04-00-89-037)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In June And July 2004 (04-00-89-031)
- Intermittent No Start, Intermittent Stall After Start-Up &/Or Loss Of Radio Presets (Replace Instrument Panel Junction Block-IPJB And/Or Terminal) (03-08-45-001)
- Engine Coolant Temperature Sensor Diagnostic Trouble Code(S) &/Or The Following Conditions: Hard Start, Erratic Idle, Rough Running, Engine Overheating, Low &/Or Leaking Coolant, &/Or Service Engine Soon Lamp Illuminated (01-T-07)
- Ignition Coil Available As A Service Part (99-T-14)
- Year 2000 Effects On On-Board Vehicle Computers (99-I-05)
- SSS Software Update - Version 1.01 Update 1.01A (SSS - 1.01A)
- SSS Software Update - Version 45.50A (SSS - 45.50A)
- Pcm & Abs EEPROM Information (96-T-46B)
- Pcm/EC DTC 45 Or P0172 - Replace O2 Sensor Wire (96-T-32A)
- Information On New Exhaust Manifold Gasket (97-T-07)
- No Start, Surge Or Stall During Light Throttle (96-T-58)
- Vehicle Runs Out Of Fuel With 1/8-1/4 Tank Indicated (96-T-44)
- Harsh Shift To Reverse/Start Then Stall - DTC 43 (96-T-20)
- Manual Update - Pcm/EC DTCS 26/32 & Info. Flag 27 (96-T-08)
- EXPERTEC TSB (95-T-01A)
- EXPERTEC TSB (95-T-34)
- EXPERTEC TSB (95-T-30)
- EXPERTEC TSB (95-I-08)
- EXPERTEC TSB (92-T-47B)
- EXPERTEC TSB (95-T-10)
- EXPERTEC TSB (95-T-03)
- EXPERTEC TSB (94-T-57)
- Towing
- Transfer Case
- Transmission Control Systems
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In November 2004 (04-00-89-058)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In October, 2004 (04-00-89-048)
- SATURN Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information And Technical Bulletins Released In January, February And March 2004 (04-00-89-012)
- Service Information Regarding Service Applications For Automatic Transaxle Shift Solenoids (00-T-74)
- Harsh Shifts, No Shifts &/Or No TCC Operation With Transaxle Related DTCS Set (Replace Transaxle Connector & Harness) (01-T-09)
- Service Information Regarding New Design Automatic Transaxle Solenoids (00-T-74)
- Year 2000 Effects On On-Board Vehicle Computers (99-I-05)
- SSS Software Update - Version 1.01 Update 1.01A (SSS - 1.01A)
- SSS Software Update - Version 45.50A (SSS - 45.50A)
- SSS Software Update - Version 44.50 (SSS - 44.50)
- Harsh Shift To Reverse/Start Then Stall - DTC 43 (96-T-20)
- SMU - Transaxle Actuator Voltage Supply Circuit 458 (95-T-50)
- EXPERTEC TSB (94-T-42)
- EXPERTEC TSB (94-T-43)
- Wheel Alignment
- Wheels & Tire System
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Vehicle Vibration Between 48 & 54 Mph - Damper Kit (96-T-52A)
- CALIF. VEH. Code Requirements Regarding Tire Chains (98-I-17)
- Scraping/Clunking Noise From Front When In Motion (96-T-18)
- EXPERTEC TSB (95-I-13)
- EXPERTEC Technical Service Bulletins (95-T-35)
- EXPERTEC TSB (95-T-07)
- EXPERTEC TSB (94-T-45)
- EXPERTEC TSB (94-T-40)
- EXPERTEC TSB (94-F-02)
- Window Motors & Regulators
- Saturn Field Product Reminder - Vehicle "Fix It Right the First Time" Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- WATERLEAK(S) At Left &/Or Right FOOTWELL Area (94-T-32C)
- Electrical Accessories Intermittently Inoperative (96-T-50A)
- Sunroof Binds When Opened/Closed - Replace Locators (97-T-11)
- Removal & Installation Of Sunroof Switch Assembly (96-T-54)
- Access. Inoperative, Mil On, DTC'S Set Or Key Binds (96-T-50)
- Tapping Noise Coming From Dash/Cowl Area (96-T-14)
- Water Leak At Front Upper Door Frame - Apply Sealer (94-T-52B)
- EXPERTEC TSB (94-T-25C)
- EXPERTEC TSB (94-T-53)
- EXPERTEC TSB (94-T-04)
- EXPERTEC TSB (93-T-21A)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Intermittent No Start, Intermittent Stall After Start-Up &/Or Loss Of Radio Presets (Replace Instrument Panel Junction Block-IPJB And/Or Terminal) (03-08-45-001)
- Aftermarket Cassette Type Portable Cd Adapter Info (95-T-08C)
- No Start, Surge Or Stall During Light Throttle (96-T-58)
- EXPERTEC TSB (95-T-18)