Common Specifications & Procedures
LEGACY & OUTBACK COMMON SPECIFICATIONS & PROCEDURES
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SPECIFICATION | ||
| Torque | See Torque Specifications in applicable text under COMPONENT . | ||
| Axle Shaft Nut (Front) | 162 Ft. Lbs. (220 N.m) | ||
| Axle Shaft Nut (Rear) | 177 Ft. Lbs. (240 N.m) | ||
| Battery | |||
| H4SO, H4DOTC & H6DO | |||
| Brakes | |||
| Bleeding Sequence | RR, LR, RF, LF AIR BLEEDING |
||
| Disc Brakes | |||
| Front | FRONT DISC BRAKE ASSEMBLY | ||
| Rear | REAR DISC BRAKE ASSEMBLY | ||
| Torque | See Torque Specifications in text under COMPONENT . | ||
| Charging | |||
| Generator | |||
| H4DOTC, H4SO & H6DO | GENERATOR | ||
| Torque | |||
| H4DOTC, H4SO & H6DO | See Torque Specifications in text under INSTALLATION . | ||
| Pulley | 80 Ft. Lbs. (108 N.m) | ||
| Drive Belts | |||
| Adjustment | |||
| H4DOTC | INSPECTION | ||
| H6DO | INSPECTION | ||
| Belt Routing | |||
| H4DOTC | V-BELT | ||
| H6DO | V-BELT | ||
| Engine Cooling | |||
| General Service Specifications | |||
| H4DOTC | SPECIFICATION | ||
| H6DO | SPECIFICATION | ||
| Radiator Cap Pressure | 14-18 psi (.95-1.25 kg/cm2 ) | ||
| Thermostat R & I | |||
| H4DOTC | THERMOSTAT | ||
| H6DO | THERMOSTAT | ||
| Water Pump R & I | |||
| H4DOTC | WATER PUMP | ||
| H6DO | WATER PUMP | ||
| Engine Mechanical | |||
| Compression | |||
| H4DOTC | 142-171 psi (981-1, 177 kPa (10-12 kg/cm>2 ) | ||
| H6DO | 185-213 psi (1, 275-1, 471 kPa (13.0-15.0 kgf/cm2 ) | ||
| Oil Pressure | |||
| At Idle Speed | H4DOTC 14 psi (1.0 kg/cm2 ) H6DO 23 psi (3.0 kg/cm2 ) |
||
| At 5, 000 RPM | H4DOTC 43 psi (3.0 kg/cm2 ) H6DO 85 psi (6.0 kg/cm2 ) |
||
| Overhaul | |||
| H4DOTC | SPECIFICATION | ||
| H6DO | SPECIFICATION | ||
| Torque | |||
| H4DOTC | See Torque Specifications in text for appropriate items under COMPONENT . | ||
| H6DO | See Torque Specifications in text for appropriate items under COMPONENT . | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. | ||
| Flywheel/Flex Plate (Drive Plate) Torque | |||
| 4 Cylinder | 53 Ft. Lbs. (72 N.m) | ||
| 6 Cylinder | 60 Ft. Lbs. (81 N.m) | ||
| Fuel System | |||
| Fuel Pressure Test Procedure | |||
| H4DOTC | FUEL PRESSURE | ||
| H6DO | FUEL PRESSURE | ||
| Fuel Filter Location | Fuel filter is attached to Fuel Pump Unit located fuel tank. | ||
| Ignition | |||
| Firing Order & Cylinder Identification | |||
| H4DOTC | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| H6DO | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | |||
| H4DOTC | Engine is equipped with Coil-On-Plug ignition. | ||
| H4SO | Engine is equipped with Coil-On-Plug ignition. | ||
| H6DO | Engine is equipped with Coil-On-Plug ignition. | ||
| Ignition Wires (Routing) | Engines are equipped with Coil-On-Plug ignition. | ||
| Spark Plug | |||
| H4DOTC | SPARK PLUG | ||
| H6DO | SPARK PLUG | ||
| Starting | |||
| Starter | |||
| H4DOTC & H6DO | STARTER | ||
| Torque | 37 Ft. Lbs. (50 N.m) | ||
| Wheel Alignment | |||
| Adjustment Specifications | |||
| Front | SPECIFICATION | ||
| Rear | SPECIFICATION | ||
| Torque | |||
| Front | See Torque Specifications in text in WHEEL ALIGNMENT . | ||
| Rear | See Torque Specifications in text under WHEEL ALIGNMENT . | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 88.5 Ft. Lbs. (120 N.m) | ||