Engine Controls - Tests W/O Codes: Introduction

Before diagnosing symptoms or intermittent faults, perform steps in BASIC TESTING and TESTS W/CODES articles in this section. See the following list.

F - 1.3L TBI BASIC TESTING
F - 1.6L TBI BASIC TESTING
F - 1.6L MFI BASIC TESTING
F - 1.3L DOHC BASIC TESTING
F - 1.3L SOHC BASIC TESTING
G - 1.3L TBI TESTS W/ CODES
G - 1.6L TBI TESTS W/ CODES
G - 1.6L MFI TESTS W/ CODES
G - 1.3L DOHC TESTS W/ CODES
G - 1.3L SOHC TESTS W/ CODES

Use these articles to diagnose driveability problems existing when a hard trouble code is not present or vehicle is not equipped with a self-diagnostic system.

NOTE: Some driveability problems may have been corrected by manufacturer with a revised computer calibration chip or computer control unit. Check with manufacturer for latest chip or computer application.

Symptom checks can direct the technician to malfunctioning component(s) for further diagnosis. A symptom should lead to a specific component, system test or an adjustment.

Use INTERMITTENT SIMULATION under TEST PROCEDURES to locate driveability problems that DO NOT occur when the vehicle is being tested. These test procedures should also be used if a soft (intermittent) trouble code was present, but no problem was found during self-diagnostic testing.

Most intermittent faults are caused by faulty electrical connections or wiring. Perform careful inspection of suspect circuits for:

Poor mating of coupler halves, or terminals not fully seated in coupler body (backed out).
Terminals damaged or improperly formed. Reform coupler terminals in problem circuit to increase contact tension.
Poor terminal-to-wire connection.
NOTE: For specific testing procedures, see I - SYS/COMP TESTING article. For specifications, see ADJUSTMENTS or SPECIFICATIONS articles in this section. See the following list.
I - 1.3L TBI SYS/COMP TESTS
I - 1.6L TBI SYS/COMP TESTS
I - 1.6L MFI SYS/COMP TESTS
I - 1.3L DOHC SYS/COMP TESTS
I - 1.3L SOHC SYS/COMP TESTS
D - 1.3L TBI ADJUSTMENTS
D - 1.6L TBI ADJUSTMENTS
D - 1.6L MFI ADJUSTMENTS
D - 1.3L DOHC ADJUSTMENTS
D - 1.3L SOHC ADJUSTMENTS
C - 1.3L TBI SPECIFICATIONS
C - 1.6L TBI SPECIFICATIONS
C - 1.6L MFI SPECIFICATIONS
C - 1.3L DOHC SPECIFICATIONS
C - 1.3L SOHC SPECIFICATIONS