Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups
Common Specs & Procedures
DTC Index
Electrical Component Locations
Fluids
Technical Bulletins
Tire Fitment
Wiring Diagrams- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Accessories & Equipment
- Anti-Theft Systems
- Security And Locks
- General Description
- Schematic and Routing Diagram
- Repair Instructions
- Front Door Lock Removal and Installation
- Childproof Rear Door Lock Removal and Installation
- Inside Door Handle Removal and Installation
- Outside Door Handle Removal and Installation
- Inside Lock Rod Removal and Installation
- Door Lock Cylinder Removal and Installation
- Door Lock Striker Removal and Installation
- Door Lock Striker Adjustment
- Luggage Compartment Lock Cylinder Removal and Installation
- Luggage Compartment Lock Striker Removal and Installation
- Luggage Compartment Lock Removal and Installation
- Control Module/Receiver Removal and Installation
- Siren Removal and Installation
- Fuel Filler Door Remote Handle and Cable Removal and Installation
- Remote Keyless Entry Transmitter Programming
- Specifications
- Security And Locks
- Cruise Control Systems
- Entertainment Systems
- Audio System
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Stereo Cassette AM / FM Radio Removal and Installation
- Audio Remote Controller Removal and Installation
- CD Changer Removal and Installation (For Notchback Model)
- Door Speakers Removal and Installation
- Tweeter Speakers Removal and Installation
- Glass Antenna Module Removal and Installation
- Windshield Antenna Module Removal and Installation (For Hatchback Model)
- Specifications
- Audio System
- Exterior Lights
- Lighting Systems
- General Description
- Headlamps-on Reminder Chime Description
- Headlamps Description
- Daytime Running Lamps Description
- Parking and Turn Signal Lamps Description
- Sidemarker Lamps Description
- Fog Lamps Description
- Rear Combination Lamps Description
- License Plate Lamp Description
- Interior Courtesy Lamp Description
- Luggage Compartment Lamp Description
- Backup Lamps Description
- Schematic and Routing Diagram
- Backup Lamps Circuit Diagram (For NOTCH BACK/HATCH BACK Model)
- Backup Lamps Circuit Diagram (For STATION WAGON Model)
- Instruments Circuit Diagram
- Front Fog Lamps Circuit Diagram
- Headlamps-ON Reminder Chime Circuit Diagram
- Headlamps Circuit Diagram
- Daytime Running Lamps Circuit Diagram
- Parking, Tail and License Lamps Circuit Diagram
- Stoplamps Circuit Diagram
- Turn and Hazard Lamps Circuit Diagram (For NOTCHBACK Model)
- Turn and Hazard Lamps Circuit Diagram (For HATCHBACK Model)
- Turn and Hazard Lamps Circuit Diagram (For STATION WAGON Model)
- Turn and Hazard Lamps Circuit Diagram (For NOTCHBACK Model, CANADA ONLY)
- Turn and Hazard Lamps Circuit Diagram (For HATCHBACK Model, CANADA ONLY)
- Turn and Hazard Lamps Circuit Diagram (For STATION WAGON Model, CANADA ONLY)
- Interior Courtesy and Luggage Compartment Lamp Circuit Diagram
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For NOTCHBACK Model)
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For HATCHBACK Model)
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For STATION WAGON Model)
- Diagnostic Information and Procedures
- Repair Instructions
- Headlamps / Front Turn Signal Lamps / Parking Lamps Removal and Installation
- Headlamp Aiming
- Daytime Running Lamp Module Removal and Installation
- Front Side Marker Removal and Installation (For Notchback Model)
- Front Fog Lamps Removal and Installation
- Rear Combination Lamps Removal and Installation (For Notchback Model)
- Rear Combination Lamps Removal and Installation (For Hatchback Model)
- Rear Combination Lamps Removal and Installation (For Station Wagon Model)
- Extension Lamps Removal and Installation (For Hatchback Model)
- Center High Mounted Stoplamp Removal and Installation (For Notchback Model)
- Center High Mount Stoplamp Removal and Installation (For Hatchback Model)
- Center High Mount Stoplamp Removal and Installation (For Station Wagon Model)
- Rear Sidemarker Lamps Removal and Installation
- License Plate Lamps Removal and Installation
- Door Contact Switch Removal and Installation
- Center Room Lamp Removal and Installation
- Map Lamp Removal and Installation
- Luggage Compartment Lamp Removal and Installation
- Ashtray and Cigar Lighter Lamp Removal and Installation
- Specifications
- General Description
- Precautions - Accessories & Equipment
- Lighting Systems
- Gauges & Instrument Panels
- Instrumentation/Driver Info./Horn
- General Description
- Horns Description
- Cigar Lighter Description
- Ashtray Description
- Instrument Panel Vents Description
- Glove Box Description
- Digital Clock Description
- Instrument Cluster Description
- Speedometer / Odometer / Trip Odometer Description
- Fuel Gauge Description
- Temperature Gauge Description
- Instrument Cluster Indicator Lamps Description
- Chime Module Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Center Molding Removal and Installation
- Instrument Cluster Trim Panel Removal and Installation
- Garnish Molding Removal and Installation
- Ashtray Removal and Installation
- Cigar Lighter Removal and Installation
- Glove Box Removal and Installation
- Deposit Box Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Hatchback Model)
- Instrument Cluster Removal and Installation
- Instrument Cluster Dimmer Switch Removal and Installation
- Instrument Cluster Indicator Lamps Removal and Installation
- Instrument Panel Removal and Installation
- Chime Module Removal and Installation
- Horns Removal and Installation
- Specifications
- General Description
- Instrumentation/Driver Info./Horn
- Headlights
- Lighting Systems
- General Description
- Headlamps-on Reminder Chime Description
- Headlamps Description
- Daytime Running Lamps Description
- Parking and Turn Signal Lamps Description
- Sidemarker Lamps Description
- Fog Lamps Description
- Rear Combination Lamps Description
- License Plate Lamp Description
- Interior Courtesy Lamp Description
- Luggage Compartment Lamp Description
- Backup Lamps Description
- Schematic and Routing Diagram
- Backup Lamps Circuit Diagram (For NOTCH BACK/HATCH BACK Model)
- Backup Lamps Circuit Diagram (For STATION WAGON Model)
- Instruments Circuit Diagram
- Front Fog Lamps Circuit Diagram
- Headlamps-ON Reminder Chime Circuit Diagram
- Headlamps Circuit Diagram
- Daytime Running Lamps Circuit Diagram
- Parking, Tail and License Lamps Circuit Diagram
- Stoplamps Circuit Diagram
- Turn and Hazard Lamps Circuit Diagram (For NOTCHBACK Model)
- Turn and Hazard Lamps Circuit Diagram (For HATCHBACK Model)
- Turn and Hazard Lamps Circuit Diagram (For STATION WAGON Model)
- Turn and Hazard Lamps Circuit Diagram (For NOTCHBACK Model, CANADA ONLY)
- Turn and Hazard Lamps Circuit Diagram (For HATCHBACK Model, CANADA ONLY)
- Turn and Hazard Lamps Circuit Diagram (For STATION WAGON Model, CANADA ONLY)
- Interior Courtesy and Luggage Compartment Lamp Circuit Diagram
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For NOTCHBACK Model)
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For HATCHBACK Model)
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For STATION WAGON Model)
- Diagnostic Information and Procedures
- Repair Instructions
- Headlamps / Front Turn Signal Lamps / Parking Lamps Removal and Installation
- Headlamp Aiming
- Daytime Running Lamp Module Removal and Installation
- Front Side Marker Removal and Installation (For Notchback Model)
- Front Fog Lamps Removal and Installation
- Rear Combination Lamps Removal and Installation (For Notchback Model)
- Rear Combination Lamps Removal and Installation (For Hatchback Model)
- Rear Combination Lamps Removal and Installation (For Station Wagon Model)
- Extension Lamps Removal and Installation (For Hatchback Model)
- Center High Mounted Stoplamp Removal and Installation (For Notchback Model)
- Center High Mount Stoplamp Removal and Installation (For Hatchback Model)
- Center High Mount Stoplamp Removal and Installation (For Station Wagon Model)
- Rear Sidemarker Lamps Removal and Installation
- License Plate Lamps Removal and Installation
- Door Contact Switch Removal and Installation
- Center Room Lamp Removal and Installation
- Map Lamp Removal and Installation
- Luggage Compartment Lamp Removal and Installation
- Ashtray and Cigar Lighter Lamp Removal and Installation
- Specifications
- General Description
- Lighting Systems
- Horns
- Instrumentation/Driver Info./Horn
- General Description
- Horns Description
- Cigar Lighter Description
- Ashtray Description
- Instrument Panel Vents Description
- Glove Box Description
- Digital Clock Description
- Instrument Cluster Description
- Speedometer / Odometer / Trip Odometer Description
- Fuel Gauge Description
- Temperature Gauge Description
- Instrument Cluster Indicator Lamps Description
- Chime Module Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Center Molding Removal and Installation
- Instrument Cluster Trim Panel Removal and Installation
- Garnish Molding Removal and Installation
- Ashtray Removal and Installation
- Cigar Lighter Removal and Installation
- Glove Box Removal and Installation
- Deposit Box Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Hatchback Model)
- Instrument Cluster Removal and Installation
- Instrument Cluster Dimmer Switch Removal and Installation
- Instrument Cluster Indicator Lamps Removal and Installation
- Instrument Panel Removal and Installation
- Chime Module Removal and Installation
- Horns Removal and Installation
- Specifications
- General Description
- Instrumentation/Driver Info./Horn
- Ignition Switch/Steering Lock
- Steering Wheel And Column
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Headlamp / Turn Signal Switch and Lever Removal and Installation
- Wiper Switch and Lever Removal and Installation
- Steering Wheel Rotation Sensor Removal and Installation
- Steering Wheel Removal and Installation
- Ignition Lock Cylinder and Switch Removal and Installation
- Steering Column Removal and Installation
- Specifications
- Special Tools and Equipment
- Steering Wheel And Column
- Infotainment
- Audio System
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Stereo Cassette AM / FM Radio Removal and Installation
- Audio Remote Controller Removal and Installation
- CD Changer Removal and Installation (For Notchback Model)
- Door Speakers Removal and Installation
- Tweeter Speakers Removal and Installation
- Glass Antenna Module Removal and Installation
- Windshield Antenna Module Removal and Installation (For Hatchback Model)
- Specifications
- Audio System
- Interior/Exterior Trim
- Interior Trim
- General Description
- Repair Instructions
- Front Door Trim Panel Removal and Installation
- Rear Door Trim Panel Removal and Installation
- A-Pillar Trim Panel Removal and Installation
- Upper B-Pillar Trim Panel Removal and Installation
- Lower B-Pillar Trim Panel Removal and Installation
- C-Pillar Trim Panel Removal and Installation
- C-Pillar Trim Panel Removal and Installation (For Station Wagon Model)
- D-Pillar Trim Panel Removal and Installation (For Station Wagon Model)
- Deck Lid Sill Plate Cover Removal and Installation
- Front Rocker Trim Panel Removal and Installation
- Rear Rocker Trim Panel Removal and Installation
- Front Wheelhouse Trim Removal and Installation
- Rear Wheelhouse Trim Removal and Installation
- Floor Console Removal and Installation
- Floor Carpet Removal and Installation
- Luggage Compartment Rear Low Cover Removal and Installation
- Luggage Compartment Wheelhouse Trim Panel Removal and Installation
- For hatchback model
- For station wagon model
- Driver's Side Knee Bolster Removal and Installation
- Tailgate Lower Garnish Molding Removal and Installation
- Tailgate Upper Garnish Molding Removal and Installation
- Luggage Compartment Rear Trim Panel Removal and Installation (For Hatchback Model)
- Specifications
- Special Tools and Equipment
- Paint/Coatings
- Precautions - Accessories & Equipment
- Interior Trim
- Interior/Illumination Lights
- Lighting Systems
- General Description
- Headlamps-on Reminder Chime Description
- Headlamps Description
- Daytime Running Lamps Description
- Parking and Turn Signal Lamps Description
- Sidemarker Lamps Description
- Fog Lamps Description
- Rear Combination Lamps Description
- License Plate Lamp Description
- Interior Courtesy Lamp Description
- Luggage Compartment Lamp Description
- Backup Lamps Description
- Schematic and Routing Diagram
- Backup Lamps Circuit Diagram (For NOTCH BACK/HATCH BACK Model)
- Backup Lamps Circuit Diagram (For STATION WAGON Model)
- Instruments Circuit Diagram
- Front Fog Lamps Circuit Diagram
- Headlamps-ON Reminder Chime Circuit Diagram
- Headlamps Circuit Diagram
- Daytime Running Lamps Circuit Diagram
- Parking, Tail and License Lamps Circuit Diagram
- Stoplamps Circuit Diagram
- Turn and Hazard Lamps Circuit Diagram (For NOTCHBACK Model)
- Turn and Hazard Lamps Circuit Diagram (For HATCHBACK Model)
- Turn and Hazard Lamps Circuit Diagram (For STATION WAGON Model)
- Turn and Hazard Lamps Circuit Diagram (For NOTCHBACK Model, CANADA ONLY)
- Turn and Hazard Lamps Circuit Diagram (For HATCHBACK Model, CANADA ONLY)
- Turn and Hazard Lamps Circuit Diagram (For STATION WAGON Model, CANADA ONLY)
- Interior Courtesy and Luggage Compartment Lamp Circuit Diagram
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For NOTCHBACK Model)
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For HATCHBACK Model)
- Trunk/Tail Gate Open Switch, Trunk Latch Switch and Trunk Room Lamps Circuit Diagram (For STATION WAGON Model)
- Diagnostic Information and Procedures
- Repair Instructions
- Headlamps / Front Turn Signal Lamps / Parking Lamps Removal and Installation
- Headlamp Aiming
- Daytime Running Lamp Module Removal and Installation
- Front Side Marker Removal and Installation (For Notchback Model)
- Front Fog Lamps Removal and Installation
- Rear Combination Lamps Removal and Installation (For Notchback Model)
- Rear Combination Lamps Removal and Installation (For Hatchback Model)
- Rear Combination Lamps Removal and Installation (For Station Wagon Model)
- Extension Lamps Removal and Installation (For Hatchback Model)
- Center High Mounted Stoplamp Removal and Installation (For Notchback Model)
- Center High Mount Stoplamp Removal and Installation (For Hatchback Model)
- Center High Mount Stoplamp Removal and Installation (For Station Wagon Model)
- Rear Sidemarker Lamps Removal and Installation
- License Plate Lamps Removal and Installation
- Door Contact Switch Removal and Installation
- Center Room Lamp Removal and Installation
- Map Lamp Removal and Installation
- Luggage Compartment Lamp Removal and Installation
- Ashtray and Cigar Lighter Lamp Removal and Installation
- Specifications
- General Description
- Lighting Systems
- Glass/Windows/Mirrors
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Power Window Regulator Removal and Installation
- Waterleak Repair
- Windnoise Repair
- Windshield Removal and Installation
- Rear Window Glass Removal and Installation
- Rear Window Defogger Grid Line Repair
- Rear Window Defogger Braided Lead Wire Repair
- Front Door Glass Removal and Installation
- Rear Door Glass Removal and Installation
- Rear Door Quarter Glass Removal and Installation
- Inside Rearview Mirror Installation
- Outside Rearview Mirrors Removal and Installation
- Specifications
- Special Tools and Equipment
- Seats
- General Description
- Repair Instructions
- Front Bucket Seat Removal and Installation
- Front Seatback Removal and Installation
- Front Seat Cushion Removal and Installation
- Lumbar Support Lever Removal and Installation
- Height Adjustment Knobs Removal and Installation
- Front Seat Trim Removal and Installation
- Head Restraint Removal and Installation
- Rear Seat Cushion Removal and Installation
- Split Rear Seatback Removal and Installation
- Split Rear Seatback Hinge Removal and Installation
- Rear Seat Center Armrest Removal and Installation
- Seat Covers Removal and Installation
- Child Seat Anchorage Removal and Installation For Notchback Model
- For Hatchback Model
- For Station Wagon Model
- Specifications
- Window Motors & Regulators
- Glass/Windows/Mirrors
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Power Window Regulator Removal and Installation
- Waterleak Repair
- Windnoise Repair
- Windshield Removal and Installation
- Rear Window Glass Removal and Installation
- Rear Window Defogger Grid Line Repair
- Rear Window Defogger Braided Lead Wire Repair
- Front Door Glass Removal and Installation
- Rear Door Glass Removal and Installation
- Rear Door Quarter Glass Removal and Installation
- Inside Rearview Mirror Installation
- Outside Rearview Mirrors Removal and Installation
- Specifications
- Special Tools and Equipment
- Glass/Windows/Mirrors
- Wiper/Washer Systems
- Wipers/Washers
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Windshield Wiper Arm Removal and Installation
- Windshield Wiper Motor Removal and Installation
- Windshield Wiper Blade Removal and Installation
- Windshield Wiper Blade Insert Removal and Installation
- Windshield Washer Reservoir Removal and Installation
- Windshield Washer Pump(s) Removal and Installation
- Windshield Washer Nozzles Removal and Installation
- Windshield Washer Hoses Removal and Installation
- Rear Window Wiper Arm Removal and Installation for Hatchback Model
- Rear Window Wiper Arm Removal and Installation for Station Wagon Model
- Rear Window Wiper Motor Removal and Installation for Hatchback Model
- Rear Window Wiper Motor Removal and Installation for Station Wagon Model
- Rear Window Washer Nozzle Removal and Installation for Hatchback Model
- Rear Window Washer Nozzle Removal and Installation for Station Wagon Model
- Specifications
- Wipers/Washers
- Anti-Theft Systems
- Body & Frame
- Door Locks
- Security And Locks
- General Description
- Schematic and Routing Diagram
- Repair Instructions
- Front Door Lock Removal and Installation
- Childproof Rear Door Lock Removal and Installation
- Inside Door Handle Removal and Installation
- Outside Door Handle Removal and Installation
- Inside Lock Rod Removal and Installation
- Door Lock Cylinder Removal and Installation
- Door Lock Striker Removal and Installation
- Door Lock Striker Adjustment
- Luggage Compartment Lock Cylinder Removal and Installation
- Luggage Compartment Lock Striker Removal and Installation
- Luggage Compartment Lock Removal and Installation
- Control Module/Receiver Removal and Installation
- Siren Removal and Installation
- Fuel Filler Door Remote Handle and Cable Removal and Installation
- Remote Keyless Entry Transmitter Programming
- Specifications
- Security And Locks
- Exterior Body Panels
- Body Frame
- Body Structure
- General Description
- Repair Instructions
- Front Bumper Fascia Removal and Installation
- Front Bumper Energy Absorber Removal and Installation
- Front Bumper Impact Bar Removal and Installation
- Rear Bumper Fascia Removal and Installation (For Notchback Model)
- Rear Bumper Fascia Removal and Installation (For Hatchback Model)
- Rear Bumper Impact Bar Removal and Installation
- Specifications
- Exterior Body Panels
- Hood/Fenders/Doors
- Precautions
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Squeak and Rattle Repair
- Outside Channel Molding Removal and Installation
- Front Door Glass Run Removal and Installation
- Door Weatherstrip Removal and Installation
- Rear Door Glass Run Removal and Installation
- Front Door Secondary Weatherstrip Removal and Installation
- Rear Door Secondary Weatherstrip Removal and Installation
- Front Door Opening Weatherstrip Removal and Installation
- Rear Door Opening Weatherstrip Removal and Installation
- Door Seal Trim Removal and Installation
- Door Assembly Removal and Installation
- Door Hinge Removal and Installation
- Door Hold-Open Link Removal and Installation
- Cowl Vent Grille Removal and Installation
- Hood Removal and Installation
- Hood Hinges Removal and Installation
- Hood Prop Rod Removal and Installation
- Hood Secondary Latch Removal and Installation
- Hood Latch Release Cable Removal and Installation
- Radiator Grille Removal and Installation (For Notchback Model)
- Radiator Grille Removal and Installation (For Hatchback Model)
- Front Wheel Well Splash Shield Removal and Installation
- Fender Removal and Installation
- Fuel Filler Door Removal and Installation
- Rear Deck Lid Removal and Installation
- Rear Deck Lid Torque Rods Removal and Installation
- Weatherstrip Removal and Installation
- Hatchback Weatherstrip Removal and Installation (For Station Wagon Model)
- Door Removal and Installation (For Hatchback Model)
- Gas Support Assemblies Removal and Installation
- Hatchback Door Lock Striker Removal and Installation (For Hatchback Model)
- Door Lock Removal and Installation (For Hatchback Model)
- Specifications
- Precautions - Accessories & Equipment
- Exterior/Interior Trim
- Interior Trim
- General Description
- Repair Instructions
- Front Door Trim Panel Removal and Installation
- Rear Door Trim Panel Removal and Installation
- A-Pillar Trim Panel Removal and Installation
- Upper B-Pillar Trim Panel Removal and Installation
- Lower B-Pillar Trim Panel Removal and Installation
- C-Pillar Trim Panel Removal and Installation
- C-Pillar Trim Panel Removal and Installation (For Station Wagon Model)
- D-Pillar Trim Panel Removal and Installation (For Station Wagon Model)
- Deck Lid Sill Plate Cover Removal and Installation
- Front Rocker Trim Panel Removal and Installation
- Rear Rocker Trim Panel Removal and Installation
- Front Wheelhouse Trim Removal and Installation
- Rear Wheelhouse Trim Removal and Installation
- Floor Console Removal and Installation
- Floor Carpet Removal and Installation
- Luggage Compartment Rear Low Cover Removal and Installation
- Luggage Compartment Wheelhouse Trim Panel Removal and Installation
- For hatchback model
- For station wagon model
- Driver's Side Knee Bolster Removal and Installation
- Tailgate Lower Garnish Molding Removal and Installation
- Tailgate Upper Garnish Molding Removal and Installation
- Luggage Compartment Rear Trim Panel Removal and Installation (For Hatchback Model)
- Specifications
- Special Tools and Equipment
- Paint/Coatings
- Precautions - Accessories & Equipment
- Interior Trim
- Ignition Switch/Steering Lock
- Steering Wheel And Column
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Headlamp / Turn Signal Switch and Lever Removal and Installation
- Wiper Switch and Lever Removal and Installation
- Steering Wheel Rotation Sensor Removal and Installation
- Steering Wheel Removal and Installation
- Ignition Lock Cylinder and Switch Removal and Installation
- Steering Column Removal and Installation
- Specifications
- Special Tools and Equipment
- Steering Wheel And Column
- Glass/Windows/Mirrors
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Power Window Regulator Removal and Installation
- Waterleak Repair
- Windnoise Repair
- Windshield Removal and Installation
- Rear Window Glass Removal and Installation
- Rear Window Defogger Grid Line Repair
- Rear Window Defogger Braided Lead Wire Repair
- Front Door Glass Removal and Installation
- Rear Door Glass Removal and Installation
- Rear Door Quarter Glass Removal and Installation
- Inside Rearview Mirror Installation
- Outside Rearview Mirrors Removal and Installation
- Specifications
- Special Tools and Equipment
- Seats
- General Description
- Repair Instructions
- Front Bucket Seat Removal and Installation
- Front Seatback Removal and Installation
- Front Seat Cushion Removal and Installation
- Lumbar Support Lever Removal and Installation
- Height Adjustment Knobs Removal and Installation
- Front Seat Trim Removal and Installation
- Head Restraint Removal and Installation
- Rear Seat Cushion Removal and Installation
- Split Rear Seatback Removal and Installation
- Split Rear Seatback Hinge Removal and Installation
- Rear Seat Center Armrest Removal and Installation
- Seat Covers Removal and Installation
- Child Seat Anchorage Removal and Installation For Notchback Model
- For Hatchback Model
- For Station Wagon Model
- Specifications
- Sun Roof/T-Top/Convertible Top
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Power Sunroof Removal and Installation
- Sun Shade Removal and Installation
- Sunroof Glass Removal and Installation
- Formed Headliner Removal and Installation
- Sun Visors with Vanity Mirror Removal and Installation
- Passenger Assist Handles Removal and Installation
- Power Sunroof Control Switch Removal and Installation
- Specifications
- Special Tools and Equipment
- Glass/Windows/Mirrors (2)
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Power Window Regulator Removal and Installation
- Waterleak Repair
- Windnoise Repair
- Windshield Removal and Installation
- Rear Window Glass Removal and Installation
- Rear Window Defogger Grid Line Repair
- Rear Window Defogger Braided Lead Wire Repair
- Front Door Glass Removal and Installation
- Rear Door Glass Removal and Installation
- Rear Door Quarter Glass Removal and Installation
- Inside Rearview Mirror Installation
- Outside Rearview Mirrors Removal and Installation
- Specifications
- Special Tools and Equipment
- Door Locks
- Brakes
- Anti-Lock Brakes
- Brakes - Abs
- Precautions
- General Description
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Notes
- Diagnostic Circuit Check
- ABS Indicator Lamp Inoperative
- Power Supply to Control Module, No DTCs Stored
- ABS Indicator Lamp Illuminated Continuously, No DTCs Stored
- Electronic Brake-Force Distribution (EBD) System Indicator Lamp Inoperative
- Self-Diagnostics
- Displaying DTCs
- Clearing DTCs
- Intermittents and Poor Connections
- DTC C0035: Left Front Wheel Speed Sensor Circuit Malfunction
- DTC C0040: Right Front Wheel Speed Sensor Circuit Malfunction
- DTC C0045: Left Rear Wheel Speed Sensor Circuit Malfunction
- DTC C0050: Right Rear Wheel Speed Sensor Circuit Malfunction
- DTC C0060/C0065: Left Front Inlet and Outlet Valve Solenoid Fault
- DTC C0070/C0075: Right Front Inlet and Outlet Valve Solenoid Fault
- DTC C0080/C0085: Left Rear Inlet and Outlet Valve Solenoid Fault
- DTC C0090/C0095: Right Rear Inlet and Outlet Valve Solenoid Fault
- DTC C0110: Pump Motor Circuit Malfunction
- DTC C0121: Valve Relay Circuit Malfunction
- DTC C0161: ABS Brake Switch Circuit Malfunction
- DTC C0245: Wheel Speed Sensor Frequency Error
- DTC C0550: ABS Control Module Internal Fault
- DTC C0800: Low Voltage Fault
- DTC C0931: Overheated
- Repair Instructions
- Specifications
- Brakes - Abs
- Mechanical - Hydraulic
- Brakes - Front
- Brakes - Mechanical
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Manual Bleeding the Brakes
- Pressure Bleeding the Brakes
- Brake Hose (Front) Removal and Installation
- Brake Hose (Rear) Removal and Installation
- Stoplamp Switch Removal and Installation
- Brake Pedal Removal and Installation
- Brake Hose Inspection
- Master Cylinder Assembly Removal and Installation
- Brake Fluid Reservoir Removal and Installation
- Master Cylinder Disassembly and Assembly
- Vacuum Hose Removal and Installation
- Power Booster Assembly Removal and Installation
- Specifications
- Brakes - Rear
- Precautions - Brakes
- Parking Brake System
- Traction Control
- Brakes - Abs
- Precautions
- General Description
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Notes
- Diagnostic Circuit Check
- ABS Indicator Lamp Inoperative
- Power Supply to Control Module, No DTCs Stored
- ABS Indicator Lamp Illuminated Continuously, No DTCs Stored
- Electronic Brake-Force Distribution (EBD) System Indicator Lamp Inoperative
- Self-Diagnostics
- Displaying DTCs
- Clearing DTCs
- Intermittents and Poor Connections
- DTC C0035: Left Front Wheel Speed Sensor Circuit Malfunction
- DTC C0040: Right Front Wheel Speed Sensor Circuit Malfunction
- DTC C0045: Left Rear Wheel Speed Sensor Circuit Malfunction
- DTC C0050: Right Rear Wheel Speed Sensor Circuit Malfunction
- DTC C0060/C0065: Left Front Inlet and Outlet Valve Solenoid Fault
- DTC C0070/C0075: Right Front Inlet and Outlet Valve Solenoid Fault
- DTC C0080/C0085: Left Rear Inlet and Outlet Valve Solenoid Fault
- DTC C0090/C0095: Right Rear Inlet and Outlet Valve Solenoid Fault
- DTC C0110: Pump Motor Circuit Malfunction
- DTC C0121: Valve Relay Circuit Malfunction
- DTC C0161: ABS Brake Switch Circuit Malfunction
- DTC C0245: Wheel Speed Sensor Frequency Error
- DTC C0550: ABS Control Module Internal Fault
- DTC C0800: Low Voltage Fault
- DTC C0931: Overheated
- Repair Instructions
- Specifications
- Brakes - Abs
- Anti-Lock Brakes
- Drivelines & Axles
- Axle Shafts
- Drive Shafts
- For Automatic Transaxle
- For Manual Transaxle
- Drive Shafts
- Axle Shafts
- Electrical
- Charging Systems
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Instrumentation/Driver Info./Horn
- General Description
- Horns Description
- Cigar Lighter Description
- Ashtray Description
- Instrument Panel Vents Description
- Glove Box Description
- Digital Clock Description
- Instrument Cluster Description
- Speedometer / Odometer / Trip Odometer Description
- Fuel Gauge Description
- Temperature Gauge Description
- Instrument Cluster Indicator Lamps Description
- Chime Module Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Center Molding Removal and Installation
- Instrument Cluster Trim Panel Removal and Installation
- Garnish Molding Removal and Installation
- Ashtray Removal and Installation
- Cigar Lighter Removal and Installation
- Glove Box Removal and Installation
- Deposit Box Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Hatchback Model)
- Instrument Cluster Removal and Installation
- Instrument Cluster Dimmer Switch Removal and Installation
- Instrument Cluster Indicator Lamps Removal and Installation
- Instrument Panel Removal and Installation
- Chime Module Removal and Installation
- Horns Removal and Installation
- Specifications
- General Description
- Instrumentation/Driver Info./Horn
- Horns
- Instrumentation/Driver Info./Horn
- General Description
- Horns Description
- Cigar Lighter Description
- Ashtray Description
- Instrument Panel Vents Description
- Glove Box Description
- Digital Clock Description
- Instrument Cluster Description
- Speedometer / Odometer / Trip Odometer Description
- Fuel Gauge Description
- Temperature Gauge Description
- Instrument Cluster Indicator Lamps Description
- Chime Module Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Center Molding Removal and Installation
- Instrument Cluster Trim Panel Removal and Installation
- Garnish Molding Removal and Installation
- Ashtray Removal and Installation
- Cigar Lighter Removal and Installation
- Glove Box Removal and Installation
- Deposit Box Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Notchback Model)
- Digital Clock Removal and Installation (For Hatchback Model)
- Instrument Cluster Removal and Installation
- Instrument Cluster Dimmer Switch Removal and Installation
- Instrument Cluster Indicator Lamps Removal and Installation
- Instrument Panel Removal and Installation
- Chime Module Removal and Installation
- Horns Removal and Installation
- Specifications
- General Description
- Instrumentation/Driver Info./Horn
- Starter
- Wiring Diagrams
- System Wiring Diagrams
- Using lemon2025'S Wiring Diagrams
- Air Conditioning
- Anti-Lock Brakes
- Anti-Theft
- Computer Data Lines
- Cooling Fan
- Cruise Control
- Defoggers
- Electronic Power Steering
- Engine Performance
- Exterior Lights
- Ground Distribution
- Headlights
- Horn
- Instrument Cluster
- Interior Lights
- Power Distribution
- Power Door Locks
- Power Mirrors
- Power Windows
- Radio
- Shift Interlock
- Starting/Charging
- Supplemental Restraints
- Transmission
- Trunk, Tailgate, Fuel Door
- Warning Systems
- Wiper/Washer
- Using lemon2025'S System Wiring Diagrams
- System Wiring Diagrams
- Engine Mechanical
- Auxiliary Emission Control Systems
- Aux. Emission Control Devices
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Front Heated Oxygen Sensor (HO2S1) Removal and Installation
- Rear Heated Oxygen Sensor (HO2S2) Removal and Installation
- Exhaust Gas Recirculation Valve Removal and Installation
- Evaporative Emission Canister Removal and Installation
- Evaporative Emission Canister Purge Solenoid Valve Removal and Installation
- Specifications
- Aux. Emission Control Devices
- Cooling System (Mechanical)
- Engine Cooling System
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Specifications
- Special Tools and Equipment
- Engine Cooling System
- Exhaust System
- Fuel System
- Lubrication System
- Engine Lubrication System
- Maintenance And Lubrication
- Scheduled Maintenance
- Maintenance and Lubrication (Normal Vehicle Use)
- Explanation of Scheduled Maintenance Services
- Maintenance Recommended under Normal Driving Conditions
- Maintenance Recommended under Severe Driving Conditions
- Owner Inspections and Services
- Specifications
- Scheduled Maintenance
- Engine Mechanical
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Camshaft Cover Removal and Installation
- Cylinder Head and Gasket Removal and Installation
- Cylinder Head and Gasket Cleaning
- Camshafts Removal and Installation
- Timing Belt Check and Adjust
- Timing Belt Removal and Installation
- Engine Mount Removal and Installation
- Intake Manifold Removal and Installation
- Camshaft Gears Removal and Installation
- Rear Timing Belt Cover Removal and Installation
- Engine Removal and Installation
- Pistons and Rods Removal and Installation
- Pistons and Rods Inspection
- Cylinder Head and Valve Train Components Disassembly and Assembly
- Cylinder Head Inspection
- Valve Inspection
- Cylinder Head and Valve Train Components Cleaning
- Cylinder Head Overhaul
- Crankshaft Disassembly and Assembly
- Crankshaft Bearings and Connecting Rod Bearings - Gauging Plastic Inspection
- Specifications
- Special Tools and Equipment
- Starter
- Auxiliary Emission Control Systems
- Engine Performance
- Emissions
- EGR Function Testing - SUZUKI
- Emission Applications
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Engine Control Systems
- Engine General Information And Diagnosis
- Precautions
- General Description
- Cleanliness and Care
- Idle Air System Operation
- OBD II Serviceability Issues
- Serial Data Communications
- On-Board Diagnostic (OBD II) Description
- Comprehensive Component Monitor Diagnostic Operation
- Common OBD II Terms Diagnostic
- When used as a noun, the word diagnostic refers to any on-board test run by the vehicle's Diagnostic Management System. A diagnostic is simply a test run on a system or component to determine if the system or component is operating according to specification. There are many diagnostics, shown in the following list:
- Enable Criteria
- Trip
- Diagnostic Information
- Malfunction Indicator Lamp (MIL)
- Extinguishing the MIL
- Data Link Connector (DLC)
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Strategy-Based Diagnostics
- Strategy-Based Diagnostics
- No Trouble Found
- Verifying Vehicle Repair
- Reading Diagnostic Trouble Codes
- DTC Modes
- DTC Information Mode
- DTC Status
- Fail This Ign. (Fail This Ignition)
- History
- Last Test Fail
- MIL Request
- Not Run SCC (Not Run Since Code Clear)
- Test Fail SCC (Test Failed Since Code Clear)
- Specific DTC Mode
- Failed Last Test
- Failed Since Clear
- Failed This Ig. (Failed This Ignition)
- MIL Requested
- Not Run Since Cl (Not Run Since Cleared)
- Not Run This Ig. (Not Run This Ignition)
- Test Ran and Passed
- Primary System-Based Diagnostics
- Diagnostic Aids
- Idle Learn Procedure
- TEC (Tooth Error Correction) Learn Procedure
- On-Board Diagnostic (OBD II) System Check
- Engine Data Display Tables
- Engine Data Display Table Definitions
- ECM Data Description
- A/C Clutch
- A/C Pressure
- A/C Request
- Air Fuel Ratio
- BARO
- Base Injection PWM
- Calculated Air Flow
- Desired Idle
- Engine Coolant Temperature
- EGR Desired Position
- Engine Load
- Engine Run Time
- Engine Speed
- Fan
- Fuel Level Sensor
- Fuel System Status
- IAC Position
- Ignition 1 (Voltage)
- Intake Air Temperature
- Knock Present
- Long Term Ft
- Map
- Misfire History #1-4
- Oxygen Sensor Bank 1 Sensor 1
- Oxygen Sensor Bank 1 Sensor 2
- Short Term Ft
- Spark Advance
- TCC Engaged
- Total Misfire Current Counter
- TP Sensor
- Vehicle Speed
- Symptom Diagnosis Table
- Intermittents
- Hard Start
- Surges or Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation / Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle, Stalling
- Excessive Exhaust Emissions or Odors
- Dieseling, Run-On
- Backfire
- Multiple ECM Information Sensor DTCs Set
- Engine Cranks But Will Not Run
- No Malfunction Indicator Lamp
- Malfunction Indicator Lamp ON Steady
- Data Link Connector Diagnosis
- Clearing Trouble Codes
- DTC Table
- DTC P0106 Manifold Absolute Pressure Rationality
- DTC P0107 Manifold Absolute Pressure Low Voltage
- DTC P0108 Manifold Absolute Pressure High Voltage
- DTC P0110 Intake Air Temperature (IAT) Sensor Stuck Rationality
- DTC P0111 Intake Air Temperature (IAT) Sensor Skewed Rationality
- DTC P0112 Intake Air Temperature Low Voltage
- DTC P0113 Intake Air Temperature High Voltage
- DTC P0115 Stuck Coolant Temperature Sensor
- DTC P0117 Engine Coolant Temperature Low Voltage
- DTC P0118 Engine Coolant Temperature High Voltage
- DTC P0122 Throttle Position Sensor Low Voltage
- DTC P0123 Throttle Position Sensor High Voltage
- DTC P0125 Insufficient Coolant Temperature for Stable Operation
- DTC P0128 Coolant Temperature below Thermostat Regulating Temperature
- DTC P0131 Oxygen Sensor 1 (O2S1) Low Voltage
- DTC P0132 Oxygen Sensor 1 (O2S1) High Voltage
- DTC P0133 Oxygen Sensor 1 (O2S1) Slow Response
- DTC P0134 Oxygen Sensor 1 (O2S1) No Activity or Open
- DTC P0135 Oxygen Sensor 1 (O2S1) Heater Circuit Not Functioning
- DTC P0137 Oxygen Sensor 2 (O2S2) Low Voltage
- DTC P0138 Oxygen Sensor 2 (O2S2) High Voltage
- DTC P0140 Oxygen Sensor 2 (O2S2) No Activity or Open
- DTC P0141 Oxygen Sensor 2 (O2S2) Heater Circuit Not Functioning
- DTC P0171 Fuel Trim System Too Lean
- DTC P0172 Fuel Trim System Too Rich
- DTC P0201 Injector 1 Circuit Fault
- DTC P0202 Injector 2 Circuit Fault
- DTC P0203 Injector 3 Circuit Fault
- DTC P0204 Injector 4 Circuit Fault
- DTC P0217 Engine Coolant Over Temperature Condition
- DTC P0300 Multiple Cylinder Misfire Detected
- DTC P0315 58X Crank Position Tooth Error Not Learned
- DTC P0317 Rough Road Sensor Source Not Detected
- DTC P0324 Knock Sensor Internal Malfunction
- DTC P0327 Knock Sensor Circuit Fault
- DTC P0336 58X Crank Position Sensor Extra/Missing Pulses
- DTC P0337 58X Crank Position Sensor No Signal
- DTC P0341 Camshaft Position Sensor Rationality
- DTC P0342 Camshaft Position Sensor No Signal
- DTC P0351 Ignition Control Circuit A Fault (Cylinder 1 and 4)
- DTC P0352 Ignition Control Circuit B Fault (Cylinder 2 and 3)
- DTC P0401 Exhaust Gas Recirculation Insufficient Flow
- DTC P0402 Exhaust Gas Recirculation Excessive Flow
- DTC P0404 Exhaust Gas Recirculation Open Valve Position Error
- DTC P0405 Exhaust Gas Recirculation Pintle Position Low Voltage
- DTC P0406 Exhaust Gas Recirculation Pintle Position High Voltage
- DTC P0420 Catalyst Oxygen Sensor Low Efficiency
- DTC P0442 Evaporative Emission System Small Leak
- DTC P0443 Evaporative Emission System Purge Solenoid Control Circuit
- DTC P0446 Evaporative Emission System Vent Control Malfunction
- DTC P0449 Evaporative Emission System Vent Solenoid Circuit Fault
- DTC P0452 Fuel Tank Pressure Sensor Low Voltage
- DTC P0453 Fuel Tank Pressure Sensor High Voltage
- DTC P0455 Evaporative Emission System Leak Detected (Gross Leak)
- DTC P0456 Evaporative Emission System Very Small Leak
- DTC P0461 Fuel Level Stuck
- DTC P0462 Fuel Level Low Voltage
- DTC P0463 Fuel Level High Voltage
- DTC P0464 Fuel Level Intermittent Noisy
- DTC P0488 Exhaust Gas Recirculation Closed Valve Pintle Error
- DTC P0496 Evaporative Emission System Continuous Purge Flow
- DTC P0502 Vehicle Speed Sensor No Signal (Engine Side)
- DTC P0506 Idle Speed RPM Lower than Desired Idle Speed
- DTC P0507 Idle Speed RPM Higher than Desired Idle Speed
- DTC P0532 A/C Pressure Sensor Low Voltage
- DTC P0533 A/C Pressure Sensor High Voltage
- DTC P0562 System Voltage Too Low (Engine Side)
- DTC P0563 System Voltage Too High (Engine Side)
- DTC P0601 ECM Checksum Error (Engine Side)
- DTC P0602 ECM Reprogram Error
- DTC P0606 SPI Communication between Error with SIDM Chip
- DTC P0606 SPI Communication between Error with PSVI Chip
- DTC P0645 A/C Clutch Output Circuit Fault
- DTC P1106 Manifold Absolute Pressure Intermittent High Voltage
- DTC P1107 Manifold Absolute Pressure Intermittent Low Voltage
- DTC P1111 Intake Air Temperature Intermittent High Voltage
- DTC P1112 Intake Air Temperature Intermittent Low Voltage
- DTC P1114 Engine Coolant Temperature Intermittent Low Voltage
- DTC P1115 Engine Coolant Temperature Intermittent High Voltage
- DTC P1121 Throttle Position Sensor Intermittent High Voltage
- DTC P1122 Throttle Position Sensor Intermittent Low Voltage
- DTC P1391 G Sensor Rough Road Rationality
- DTC P1392 G Sensor Rough Road Low Voltage
- DTC P1393 G Sensor Rough Road High Voltage
- DTC P1396 WSSD Rough Road System Fault
- DTC P1397 WSSD Rough Road
- DTC P2195 Fuel Supply System Lean during Power Enrichment
- DTC P2196 Oxygen Sensor 1 (O2S1) Rich in Decel Fuel Cutoff (DFCO)
- DTC P2279 Intake Air System Leak
- DTC P2610 Lower Power Counter Error
- DTC P2610 Lower Power Counter Reset
- DTC P0700 Transaxle Control Module (TCM) Malfunction
- DTC U0101 SPI Communications between ECM and TCM
- Fuel Pump Relay Circuit Check
- Manifold Absolute Pressure Check
- Idle Air Control System Check
- Engine Cooling Fan Circuit Check - Dual Fan
- Strategy-Based Diagnostics
- Specifications
- Engine General Information And Diagnosis
- Fuel Delivery
- Ignition System
- Mode 6 - 2004-2006
- Specifications
- System
- Aux. Emission Control Devices
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Front Heated Oxygen Sensor (HO2S1) Removal and Installation
- Rear Heated Oxygen Sensor (HO2S2) Removal and Installation
- Exhaust Gas Recirculation Valve Removal and Installation
- Evaporative Emission Canister Removal and Installation
- Evaporative Emission Canister Purge Solenoid Valve Removal and Installation
- Specifications
- Engine Electrical Devices
- General Description
- Engine Coolant Temperature Sensor Description
- Throttle Position Sensor Description
- Intake Air Temperature Sensor Description
- Idle Air Control Valve Description
- Manifold Absolute Pressure Sensor Description
- Engine Control Module Description
- Knock Sensor Description
- Crankshaft Position Sensor
- Camshaft Position Sensor
- G Sensor Description
- Repair Instructions
- Engine Coolant Temperature Sensor Removal and Installation
- Throttle Position Sensor Removal and Installation
- Throttle Body Removal and Installation
- Intake Air Temperature Sensor Removal and Installation
- Idle Air Control Valve Removal and Installation
- Manifold Absolute Pressure Sensor Removal and Installation
- Knock Sensor Removal and Installation
- Crankshaft Position (CKP) Sensor Removal and Installation
- Camshaft Position Sensor Removal and Installation
- Engine Control Module Removal and Installation
- VIN Registration
- Specifications
- General Description
- Engine General Information And Diagnosis
- Precautions
- General Description
- Cleanliness and Care
- Idle Air System Operation
- OBD II Serviceability Issues
- Serial Data Communications
- On-Board Diagnostic (OBD II) Description
- Comprehensive Component Monitor Diagnostic Operation
- Common OBD II Terms Diagnostic
- When used as a noun, the word diagnostic refers to any on-board test run by the vehicle's Diagnostic Management System. A diagnostic is simply a test run on a system or component to determine if the system or component is operating according to specification. There are many diagnostics, shown in the following list:
- Enable Criteria
- Trip
- Diagnostic Information
- Malfunction Indicator Lamp (MIL)
- Extinguishing the MIL
- Data Link Connector (DLC)
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Strategy-Based Diagnostics
- Strategy-Based Diagnostics
- No Trouble Found
- Verifying Vehicle Repair
- Reading Diagnostic Trouble Codes
- DTC Modes
- DTC Information Mode
- DTC Status
- Fail This Ign. (Fail This Ignition)
- History
- Last Test Fail
- MIL Request
- Not Run SCC (Not Run Since Code Clear)
- Test Fail SCC (Test Failed Since Code Clear)
- Specific DTC Mode
- Failed Last Test
- Failed Since Clear
- Failed This Ig. (Failed This Ignition)
- MIL Requested
- Not Run Since Cl (Not Run Since Cleared)
- Not Run This Ig. (Not Run This Ignition)
- Test Ran and Passed
- Primary System-Based Diagnostics
- Diagnostic Aids
- Idle Learn Procedure
- TEC (Tooth Error Correction) Learn Procedure
- On-Board Diagnostic (OBD II) System Check
- Engine Data Display Tables
- Engine Data Display Table Definitions
- ECM Data Description
- A/C Clutch
- A/C Pressure
- A/C Request
- Air Fuel Ratio
- BARO
- Base Injection PWM
- Calculated Air Flow
- Desired Idle
- Engine Coolant Temperature
- EGR Desired Position
- Engine Load
- Engine Run Time
- Engine Speed
- Fan
- Fuel Level Sensor
- Fuel System Status
- IAC Position
- Ignition 1 (Voltage)
- Intake Air Temperature
- Knock Present
- Long Term Ft
- Map
- Misfire History #1-4
- Oxygen Sensor Bank 1 Sensor 1
- Oxygen Sensor Bank 1 Sensor 2
- Short Term Ft
- Spark Advance
- TCC Engaged
- Total Misfire Current Counter
- TP Sensor
- Vehicle Speed
- Symptom Diagnosis Table
- Intermittents
- Hard Start
- Surges or Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation / Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle, Stalling
- Excessive Exhaust Emissions or Odors
- Dieseling, Run-On
- Backfire
- Multiple ECM Information Sensor DTCs Set
- Engine Cranks But Will Not Run
- No Malfunction Indicator Lamp
- Malfunction Indicator Lamp ON Steady
- Data Link Connector Diagnosis
- Clearing Trouble Codes
- DTC Table
- DTC P0106 Manifold Absolute Pressure Rationality
- DTC P0107 Manifold Absolute Pressure Low Voltage
- DTC P0108 Manifold Absolute Pressure High Voltage
- DTC P0110 Intake Air Temperature (IAT) Sensor Stuck Rationality
- DTC P0111 Intake Air Temperature (IAT) Sensor Skewed Rationality
- DTC P0112 Intake Air Temperature Low Voltage
- DTC P0113 Intake Air Temperature High Voltage
- DTC P0115 Stuck Coolant Temperature Sensor
- DTC P0117 Engine Coolant Temperature Low Voltage
- DTC P0118 Engine Coolant Temperature High Voltage
- DTC P0122 Throttle Position Sensor Low Voltage
- DTC P0123 Throttle Position Sensor High Voltage
- DTC P0125 Insufficient Coolant Temperature for Stable Operation
- DTC P0128 Coolant Temperature below Thermostat Regulating Temperature
- DTC P0131 Oxygen Sensor 1 (O2S1) Low Voltage
- DTC P0132 Oxygen Sensor 1 (O2S1) High Voltage
- DTC P0133 Oxygen Sensor 1 (O2S1) Slow Response
- DTC P0134 Oxygen Sensor 1 (O2S1) No Activity or Open
- DTC P0135 Oxygen Sensor 1 (O2S1) Heater Circuit Not Functioning
- DTC P0137 Oxygen Sensor 2 (O2S2) Low Voltage
- DTC P0138 Oxygen Sensor 2 (O2S2) High Voltage
- DTC P0140 Oxygen Sensor 2 (O2S2) No Activity or Open
- DTC P0141 Oxygen Sensor 2 (O2S2) Heater Circuit Not Functioning
- DTC P0171 Fuel Trim System Too Lean
- DTC P0172 Fuel Trim System Too Rich
- DTC P0201 Injector 1 Circuit Fault
- DTC P0202 Injector 2 Circuit Fault
- DTC P0203 Injector 3 Circuit Fault
- DTC P0204 Injector 4 Circuit Fault
- DTC P0217 Engine Coolant Over Temperature Condition
- DTC P0300 Multiple Cylinder Misfire Detected
- DTC P0315 58X Crank Position Tooth Error Not Learned
- DTC P0317 Rough Road Sensor Source Not Detected
- DTC P0324 Knock Sensor Internal Malfunction
- DTC P0327 Knock Sensor Circuit Fault
- DTC P0336 58X Crank Position Sensor Extra/Missing Pulses
- DTC P0337 58X Crank Position Sensor No Signal
- DTC P0341 Camshaft Position Sensor Rationality
- DTC P0342 Camshaft Position Sensor No Signal
- DTC P0351 Ignition Control Circuit A Fault (Cylinder 1 and 4)
- DTC P0352 Ignition Control Circuit B Fault (Cylinder 2 and 3)
- DTC P0401 Exhaust Gas Recirculation Insufficient Flow
- DTC P0402 Exhaust Gas Recirculation Excessive Flow
- DTC P0404 Exhaust Gas Recirculation Open Valve Position Error
- DTC P0405 Exhaust Gas Recirculation Pintle Position Low Voltage
- DTC P0406 Exhaust Gas Recirculation Pintle Position High Voltage
- DTC P0420 Catalyst Oxygen Sensor Low Efficiency
- DTC P0442 Evaporative Emission System Small Leak
- DTC P0443 Evaporative Emission System Purge Solenoid Control Circuit
- DTC P0446 Evaporative Emission System Vent Control Malfunction
- DTC P0449 Evaporative Emission System Vent Solenoid Circuit Fault
- DTC P0452 Fuel Tank Pressure Sensor Low Voltage
- DTC P0453 Fuel Tank Pressure Sensor High Voltage
- DTC P0455 Evaporative Emission System Leak Detected (Gross Leak)
- DTC P0456 Evaporative Emission System Very Small Leak
- DTC P0461 Fuel Level Stuck
- DTC P0462 Fuel Level Low Voltage
- DTC P0463 Fuel Level High Voltage
- DTC P0464 Fuel Level Intermittent Noisy
- DTC P0488 Exhaust Gas Recirculation Closed Valve Pintle Error
- DTC P0496 Evaporative Emission System Continuous Purge Flow
- DTC P0502 Vehicle Speed Sensor No Signal (Engine Side)
- DTC P0506 Idle Speed RPM Lower than Desired Idle Speed
- DTC P0507 Idle Speed RPM Higher than Desired Idle Speed
- DTC P0532 A/C Pressure Sensor Low Voltage
- DTC P0533 A/C Pressure Sensor High Voltage
- DTC P0562 System Voltage Too Low (Engine Side)
- DTC P0563 System Voltage Too High (Engine Side)
- DTC P0601 ECM Checksum Error (Engine Side)
- DTC P0602 ECM Reprogram Error
- DTC P0606 SPI Communication between Error with SIDM Chip
- DTC P0606 SPI Communication between Error with PSVI Chip
- DTC P0645 A/C Clutch Output Circuit Fault
- DTC P1106 Manifold Absolute Pressure Intermittent High Voltage
- DTC P1107 Manifold Absolute Pressure Intermittent Low Voltage
- DTC P1111 Intake Air Temperature Intermittent High Voltage
- DTC P1112 Intake Air Temperature Intermittent Low Voltage
- DTC P1114 Engine Coolant Temperature Intermittent Low Voltage
- DTC P1115 Engine Coolant Temperature Intermittent High Voltage
- DTC P1121 Throttle Position Sensor Intermittent High Voltage
- DTC P1122 Throttle Position Sensor Intermittent Low Voltage
- DTC P1391 G Sensor Rough Road Rationality
- DTC P1392 G Sensor Rough Road Low Voltage
- DTC P1393 G Sensor Rough Road High Voltage
- DTC P1396 WSSD Rough Road System Fault
- DTC P1397 WSSD Rough Road
- DTC P2195 Fuel Supply System Lean during Power Enrichment
- DTC P2196 Oxygen Sensor 1 (O2S1) Rich in Decel Fuel Cutoff (DFCO)
- DTC P2279 Intake Air System Leak
- DTC P2610 Lower Power Counter Error
- DTC P2610 Lower Power Counter Reset
- DTC P0700 Transaxle Control Module (TCM) Malfunction
- DTC U0101 SPI Communications between ECM and TCM
- Fuel Pump Relay Circuit Check
- Manifold Absolute Pressure Check
- Idle Air Control System Check
- Engine Cooling Fan Circuit Check - Dual Fan
- Strategy-Based Diagnostics
- Specifications
- Precautions - Engine
- Aux. Emission Control Devices
- Testing & Diagnosis
- Aux. Emission Control Devices
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Front Heated Oxygen Sensor (HO2S1) Removal and Installation
- Rear Heated Oxygen Sensor (HO2S2) Removal and Installation
- Exhaust Gas Recirculation Valve Removal and Installation
- Evaporative Emission Canister Removal and Installation
- Evaporative Emission Canister Purge Solenoid Valve Removal and Installation
- Specifications
- Engine Electrical Devices
- General Description
- Engine Coolant Temperature Sensor Description
- Throttle Position Sensor Description
- Intake Air Temperature Sensor Description
- Idle Air Control Valve Description
- Manifold Absolute Pressure Sensor Description
- Engine Control Module Description
- Knock Sensor Description
- Crankshaft Position Sensor
- Camshaft Position Sensor
- G Sensor Description
- Repair Instructions
- Engine Coolant Temperature Sensor Removal and Installation
- Throttle Position Sensor Removal and Installation
- Throttle Body Removal and Installation
- Intake Air Temperature Sensor Removal and Installation
- Idle Air Control Valve Removal and Installation
- Manifold Absolute Pressure Sensor Removal and Installation
- Knock Sensor Removal and Installation
- Crankshaft Position (CKP) Sensor Removal and Installation
- Camshaft Position Sensor Removal and Installation
- Engine Control Module Removal and Installation
- VIN Registration
- Specifications
- General Description
- Engine General Information And Diagnosis
- Precautions
- General Description
- Cleanliness and Care
- Idle Air System Operation
- OBD II Serviceability Issues
- Serial Data Communications
- On-Board Diagnostic (OBD II) Description
- Comprehensive Component Monitor Diagnostic Operation
- Common OBD II Terms Diagnostic
- When used as a noun, the word diagnostic refers to any on-board test run by the vehicle's Diagnostic Management System. A diagnostic is simply a test run on a system or component to determine if the system or component is operating according to specification. There are many diagnostics, shown in the following list:
- Enable Criteria
- Trip
- Diagnostic Information
- Malfunction Indicator Lamp (MIL)
- Extinguishing the MIL
- Data Link Connector (DLC)
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Strategy-Based Diagnostics
- Strategy-Based Diagnostics
- No Trouble Found
- Verifying Vehicle Repair
- Reading Diagnostic Trouble Codes
- DTC Modes
- DTC Information Mode
- DTC Status
- Fail This Ign. (Fail This Ignition)
- History
- Last Test Fail
- MIL Request
- Not Run SCC (Not Run Since Code Clear)
- Test Fail SCC (Test Failed Since Code Clear)
- Specific DTC Mode
- Failed Last Test
- Failed Since Clear
- Failed This Ig. (Failed This Ignition)
- MIL Requested
- Not Run Since Cl (Not Run Since Cleared)
- Not Run This Ig. (Not Run This Ignition)
- Test Ran and Passed
- Primary System-Based Diagnostics
- Diagnostic Aids
- Idle Learn Procedure
- TEC (Tooth Error Correction) Learn Procedure
- On-Board Diagnostic (OBD II) System Check
- Engine Data Display Tables
- Engine Data Display Table Definitions
- ECM Data Description
- A/C Clutch
- A/C Pressure
- A/C Request
- Air Fuel Ratio
- BARO
- Base Injection PWM
- Calculated Air Flow
- Desired Idle
- Engine Coolant Temperature
- EGR Desired Position
- Engine Load
- Engine Run Time
- Engine Speed
- Fan
- Fuel Level Sensor
- Fuel System Status
- IAC Position
- Ignition 1 (Voltage)
- Intake Air Temperature
- Knock Present
- Long Term Ft
- Map
- Misfire History #1-4
- Oxygen Sensor Bank 1 Sensor 1
- Oxygen Sensor Bank 1 Sensor 2
- Short Term Ft
- Spark Advance
- TCC Engaged
- Total Misfire Current Counter
- TP Sensor
- Vehicle Speed
- Symptom Diagnosis Table
- Intermittents
- Hard Start
- Surges or Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation / Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Rough, Unstable, or Incorrect Idle, Stalling
- Excessive Exhaust Emissions or Odors
- Dieseling, Run-On
- Backfire
- Multiple ECM Information Sensor DTCs Set
- Engine Cranks But Will Not Run
- No Malfunction Indicator Lamp
- Malfunction Indicator Lamp ON Steady
- Data Link Connector Diagnosis
- Clearing Trouble Codes
- DTC Table
- DTC P0106 Manifold Absolute Pressure Rationality
- DTC P0107 Manifold Absolute Pressure Low Voltage
- DTC P0108 Manifold Absolute Pressure High Voltage
- DTC P0110 Intake Air Temperature (IAT) Sensor Stuck Rationality
- DTC P0111 Intake Air Temperature (IAT) Sensor Skewed Rationality
- DTC P0112 Intake Air Temperature Low Voltage
- DTC P0113 Intake Air Temperature High Voltage
- DTC P0115 Stuck Coolant Temperature Sensor
- DTC P0117 Engine Coolant Temperature Low Voltage
- DTC P0118 Engine Coolant Temperature High Voltage
- DTC P0122 Throttle Position Sensor Low Voltage
- DTC P0123 Throttle Position Sensor High Voltage
- DTC P0125 Insufficient Coolant Temperature for Stable Operation
- DTC P0128 Coolant Temperature below Thermostat Regulating Temperature
- DTC P0131 Oxygen Sensor 1 (O2S1) Low Voltage
- DTC P0132 Oxygen Sensor 1 (O2S1) High Voltage
- DTC P0133 Oxygen Sensor 1 (O2S1) Slow Response
- DTC P0134 Oxygen Sensor 1 (O2S1) No Activity or Open
- DTC P0135 Oxygen Sensor 1 (O2S1) Heater Circuit Not Functioning
- DTC P0137 Oxygen Sensor 2 (O2S2) Low Voltage
- DTC P0138 Oxygen Sensor 2 (O2S2) High Voltage
- DTC P0140 Oxygen Sensor 2 (O2S2) No Activity or Open
- DTC P0141 Oxygen Sensor 2 (O2S2) Heater Circuit Not Functioning
- DTC P0171 Fuel Trim System Too Lean
- DTC P0172 Fuel Trim System Too Rich
- DTC P0201 Injector 1 Circuit Fault
- DTC P0202 Injector 2 Circuit Fault
- DTC P0203 Injector 3 Circuit Fault
- DTC P0204 Injector 4 Circuit Fault
- DTC P0217 Engine Coolant Over Temperature Condition
- DTC P0300 Multiple Cylinder Misfire Detected
- DTC P0315 58X Crank Position Tooth Error Not Learned
- DTC P0317 Rough Road Sensor Source Not Detected
- DTC P0324 Knock Sensor Internal Malfunction
- DTC P0327 Knock Sensor Circuit Fault
- DTC P0336 58X Crank Position Sensor Extra/Missing Pulses
- DTC P0337 58X Crank Position Sensor No Signal
- DTC P0341 Camshaft Position Sensor Rationality
- DTC P0342 Camshaft Position Sensor No Signal
- DTC P0351 Ignition Control Circuit A Fault (Cylinder 1 and 4)
- DTC P0352 Ignition Control Circuit B Fault (Cylinder 2 and 3)
- DTC P0401 Exhaust Gas Recirculation Insufficient Flow
- DTC P0402 Exhaust Gas Recirculation Excessive Flow
- DTC P0404 Exhaust Gas Recirculation Open Valve Position Error
- DTC P0405 Exhaust Gas Recirculation Pintle Position Low Voltage
- DTC P0406 Exhaust Gas Recirculation Pintle Position High Voltage
- DTC P0420 Catalyst Oxygen Sensor Low Efficiency
- DTC P0442 Evaporative Emission System Small Leak
- DTC P0443 Evaporative Emission System Purge Solenoid Control Circuit
- DTC P0446 Evaporative Emission System Vent Control Malfunction
- DTC P0449 Evaporative Emission System Vent Solenoid Circuit Fault
- DTC P0452 Fuel Tank Pressure Sensor Low Voltage
- DTC P0453 Fuel Tank Pressure Sensor High Voltage
- DTC P0455 Evaporative Emission System Leak Detected (Gross Leak)
- DTC P0456 Evaporative Emission System Very Small Leak
- DTC P0461 Fuel Level Stuck
- DTC P0462 Fuel Level Low Voltage
- DTC P0463 Fuel Level High Voltage
- DTC P0464 Fuel Level Intermittent Noisy
- DTC P0488 Exhaust Gas Recirculation Closed Valve Pintle Error
- DTC P0496 Evaporative Emission System Continuous Purge Flow
- DTC P0502 Vehicle Speed Sensor No Signal (Engine Side)
- DTC P0506 Idle Speed RPM Lower than Desired Idle Speed
- DTC P0507 Idle Speed RPM Higher than Desired Idle Speed
- DTC P0532 A/C Pressure Sensor Low Voltage
- DTC P0533 A/C Pressure Sensor High Voltage
- DTC P0562 System Voltage Too Low (Engine Side)
- DTC P0563 System Voltage Too High (Engine Side)
- DTC P0601 ECM Checksum Error (Engine Side)
- DTC P0602 ECM Reprogram Error
- DTC P0606 SPI Communication between Error with SIDM Chip
- DTC P0606 SPI Communication between Error with PSVI Chip
- DTC P0645 A/C Clutch Output Circuit Fault
- DTC P1106 Manifold Absolute Pressure Intermittent High Voltage
- DTC P1107 Manifold Absolute Pressure Intermittent Low Voltage
- DTC P1111 Intake Air Temperature Intermittent High Voltage
- DTC P1112 Intake Air Temperature Intermittent Low Voltage
- DTC P1114 Engine Coolant Temperature Intermittent Low Voltage
- DTC P1115 Engine Coolant Temperature Intermittent High Voltage
- DTC P1121 Throttle Position Sensor Intermittent High Voltage
- DTC P1122 Throttle Position Sensor Intermittent Low Voltage
- DTC P1391 G Sensor Rough Road Rationality
- DTC P1392 G Sensor Rough Road Low Voltage
- DTC P1393 G Sensor Rough Road High Voltage
- DTC P1396 WSSD Rough Road System Fault
- DTC P1397 WSSD Rough Road
- DTC P2195 Fuel Supply System Lean during Power Enrichment
- DTC P2196 Oxygen Sensor 1 (O2S1) Rich in Decel Fuel Cutoff (DFCO)
- DTC P2279 Intake Air System Leak
- DTC P2610 Lower Power Counter Error
- DTC P2610 Lower Power Counter Reset
- DTC P0700 Transaxle Control Module (TCM) Malfunction
- DTC U0101 SPI Communications between ECM and TCM
- Fuel Pump Relay Circuit Check
- Manifold Absolute Pressure Check
- Idle Air Control System Check
- Engine Cooling Fan Circuit Check - Dual Fan
- Strategy-Based Diagnostics
- Specifications
- Precautions - Engine
- Aux. Emission Control Devices
- Tune-Up
- Emissions
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- OBD-II Drive Cycles
- * Please Read This First *
- Drive Cycles
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- DTC Index
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Hoist/Jack
- General Information
- General Description
- General Information
- Identification
- Metric Conversions
- OEM General Information
- General Information
- General Description
- Precautions - Gen Info
- General Information
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (Check Engine Light)
- Emissions Maintenance Reminder (Oxygen Sensor)
- Engine Oil Replacement Reminder
- Tire Pressure Monitor System Reminder
- Specifications Index
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Traction Control Disable Procedures
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- HVAC Control Systems
- Air Conditioning System
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- O-Ring Replacement
- Handling Refrigerant
- Handling of Refrigerant Lines and Fittings
- Maintaining Chemical Stability in Refrigeration System
- Discharging, Adding Oil, Evacuating, and Charging Procedures for A/C System
- A/C System Oil Charge Replenishing
- Components Used in Non-A/C Systems
- A/C Pressure Transducer Removal and Installation
- A/C Compressor Relay Removal and Installation
- Air Filter Removal and Installation
- A/C Expansion Valve Removal and Installation
- A/C High-Pressure Pipe Line Removal and Installation
- Evaporator Core Removal and Installation
- A/C Suction Hose Assembly Removal and Installation
- A/C Discharge Hose-Compressor to Condenser Removal and Installation
- Receiver-Dryer Removal and Installation
- Condenser Removal and Installation
- Compressor Removal and Installation
- V5 Compressor Components
- Clutch Plate and Hub Assembly Disassembly and Assembly
- Clutch Rotor and Bearing Disassembly and Installation
- Clutch Coil Removal and Installation
- Shaft Seal Replacement
- Control Valve Assembly Removal and Installation
- Rear Head, Gasket, Valve Plate, Reed Plate, and O-Ring Removal and Installation
- Cylinder-to-Front Head O-Ring Removal and Installation
- Leak Testing (External)
- Specifications
- Special Tools and Equipment
- Heater And Ventilation
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Temperature Cable Adjustment
- Temperature Control Cable Removal and Installation
- Control Assembly Removal and Installation
- Control Assembly Knob Lighting Removal and Installation
- Heater / Air Distributor Case Assembly Removal and Installation
- Blower Motor Removal and Installation
- Blower Resistor Removal and Installation
- Heater Hoses Removal and Installation
- Heater Core Removal and Installation
- Specifications
- Precautions - HVAC
- Air Conditioning System
- Maintenance
- Procedures
- Maintenance And Lubrication
- Scheduled Maintenance
- Maintenance and Lubrication (Normal Vehicle Use)
- Explanation of Scheduled Maintenance Services
- Maintenance Recommended under Normal Driving Conditions
- Maintenance Recommended under Severe Driving Conditions
- Owner Inspections and Services
- Specifications
- Scheduled Maintenance
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (Check Engine Light)
- Emissions Maintenance Reminder (Oxygen Sensor)
- Engine Oil Replacement Reminder
- Tire Pressure Monitor System Reminder
- Maintenance And Lubrication
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag System
- Precautions
- General Description
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Diagnostic Trouble Codes Table
- Scan Tool Diagnostics
- SIR Diagnostic System Check
- Sensing and Diagnostic Module (SDM) Integrity Check
- DTC B1101: Battery Voltage High
- DTC B1102: Battery Voltage Low
- DTC B1103: Communication Voltage Too Low
- DTC B1104: OC Passenger Out of Voltage Range
- DTC B1326: Early Crash Sensor Driver (LH) Short to Ground (GND)
- DTC B1327: Early Crash Sensor Driver (LH) Short to Power (BATTERY)
- DTC B1328: Early Crash Sensor Driver (LH) Defect
- DTC B1329: Early Crash Sensor Driver (LH) Communication Error
- DTC B1330: Early Crash Sensor Driver (LH) Wrong ID
- DTC B1331: Early Crash Sensor Passenger (RH) Short to Ground (GND)
- DTC B1332: Early Crash Sensor Passenger (RH) Short to Power (BATTERY)
- DTC B1333: Early Crash Sensor Passenger (RH) Defect
- DTC B1334: Early Crash Sensor Passenger (RH) Communication Error
- DTC B1335: Early Crash Sensor Passenger (RH) Wrong ID
- DTC B1346: 1st Stage Driver Airbag Resistance Too High
- DTC B1347: 1st Stage Driver Airbag Resistance Too Low
- DTC B1348: 1st Stage Driver Airbag Short to Ground
- DTC B1349: 1st Stage Driver Airbag Short to Power
- DTC B1352: 1st Stage Passenger Airbag Resistance Too Low
- DTC B1353: 1st Stage Passenger Airbag Resistance Too High
- DTC B1354: 1st Stage Passenger Airbag Short to Ground
- DTC B1355: 1st Stage Passenger Airbag Short to Power
- DTC B1361: Driver Belt Pretensioner Resistance Too High
- DTC B1362: Driver Belt Pretensioner Resistance Too Low
- DTC B1363: Driver Belt Pretensioner Short to Ground
- DTC B1364: Driver Belt Pretensioner Short to Power
- DTC B1367: Passenger Belt Pretensioner Resistance Too High
- DTC B1368: Passenger Belt Pretensioner Resistance Too Low
- DTC B1369: Passenger Belt Pretensioner Short to Ground
- DTC B1370: Passenger Belt Pretensioner Short to Power
- DTC B1378: Driver Side Airbag Resistance Too High
- DTC B1379: Driver Side Airbag Resistance Too Low
- DTC B1380: Driver Side Airbag Short to Ground
- DTC B1381: Driver Side Airbag Short to Power
- DTC B1382: Passenger Side Airbag Resistance Too High
- DTC B1383: Passenger Side Airbag Resistance Too Low
- DTC B1384: Passenger Side Airbag Short to Ground
- DTC B1385: Passenger Side Airbag Short to Power
- Troubleshooting
- DTC B1395: Firing Loops Interconnection Fault
- DTC B1400: Driver Side Airbag Sensor Defect
- DTC B1401: Driver Side Airbag Sensor Short to Ground
- DTC B1402: Driver Side Airbag Sensor Short to Power
- DTC B1403: Passenger Side Airbag Sensor Defect
- DTC B1404: Passenger Side Airbag Sensor Short to Ground
- DTC B1405: Passenger Side Airbag Sensor Short to Power
- DTC B1409: Driver Side Airbag Sensor Communication Error
- DTC B1410: Passenger Side Airbag Sensor Communication Error
- DTC B1414: Driver Side Airbag Sensor Wrong ID
- DTC B1415: Passenger Side Airbag Sensor Wrong ID
- DTC B1440: OC Passenger Short to Ground (GND)
- DTC B1446: OC Passenger Short to Power (Battery) or No Response
- DTC B1447: OC Passenger (System) Defect
- DTC B1448: OC Passenger Sensor Mat Defect
- DTC B1449: OC Passenger Communication Error
- DTC B1450: OC Passenger Wrong ID
- DTC B1481: 2nd Stage Driver Airbag Resistance Too High
- DTC B1482: 2nd Stage Driver Airbag Resistance Too Low
- DTC B1483: 2nd Stage Driver Airbag Short to Ground
- DTC B1484: 2nd Stage Driver Airbag Short to Power
- DTC B1485: 2nd Stage Passenger Airbag Resistance Too High
- DTC B1486: 2nd Stage Passenger Airbag Resistance Too Low
- DTC B1487: 2nd Stage Passenger Airbag Short to Ground
- DTC B1488: 2nd Stage Passenger Airbag Short to Power
- DTC B1620: Internal SDM Fault
- DTC B1650: Crash Recorded in 1st Stage Frontal Airbag
- DTC B1651: Crash Recorded in Driver Side Airbag
- DTC B1652: Crash Recorded in Passenger Side Airbag
- DTC B1657: Crash Recorded in Belt Pretensioner
- DTC B1670: Crash Recorded in 2nd Stage Frontal Airbag
- DTC B2500: Airbag Warning Lamp Failure
- DTC B2502: Passenger Airbag "OFF" Indicator Failure
- Disabling the Supplemental Inflatable Restraints (SIR)
- Enabling the Supplemental Inflatable Restraints (SIR)
- Handling, Installation and Diagnosis
- Repairs and Inspections Required after an Accident
- Accident with Deployment Components Replacements
- Accident without Deployment Component Inspection
- Sensing and Diagnostic Module (SDM) Removal and Installation
- Driver Airbag Module Removal and Installation
- Clock Spring Removal and Installation
- Clock Spring Alignment
- Passenger Airbag Module Removal and Installation
- Side Airbag Sensor Removal and Installation
- Front Seat Belt Pretensioner
- Airbag Module Deployment (Inside of Vehicle)
- Airbag Module Deployment (Outside of Vehicle)
- Deployed Airbag Module Disposal Procedure
- SIR Wiring Repair
- Specifications
- Precautions - Restraints
- Air Bag System
- Passive Restraints
- Air Bag System
- Precautions
- General Description
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- Diagnostic Trouble Codes Table
- Scan Tool Diagnostics
- SIR Diagnostic System Check
- Sensing and Diagnostic Module (SDM) Integrity Check
- DTC B1101: Battery Voltage High
- DTC B1102: Battery Voltage Low
- DTC B1103: Communication Voltage Too Low
- DTC B1104: OC Passenger Out of Voltage Range
- DTC B1326: Early Crash Sensor Driver (LH) Short to Ground (GND)
- DTC B1327: Early Crash Sensor Driver (LH) Short to Power (BATTERY)
- DTC B1328: Early Crash Sensor Driver (LH) Defect
- DTC B1329: Early Crash Sensor Driver (LH) Communication Error
- DTC B1330: Early Crash Sensor Driver (LH) Wrong ID
- DTC B1331: Early Crash Sensor Passenger (RH) Short to Ground (GND)
- DTC B1332: Early Crash Sensor Passenger (RH) Short to Power (BATTERY)
- DTC B1333: Early Crash Sensor Passenger (RH) Defect
- DTC B1334: Early Crash Sensor Passenger (RH) Communication Error
- DTC B1335: Early Crash Sensor Passenger (RH) Wrong ID
- DTC B1346: 1st Stage Driver Airbag Resistance Too High
- DTC B1347: 1st Stage Driver Airbag Resistance Too Low
- DTC B1348: 1st Stage Driver Airbag Short to Ground
- DTC B1349: 1st Stage Driver Airbag Short to Power
- DTC B1352: 1st Stage Passenger Airbag Resistance Too Low
- DTC B1353: 1st Stage Passenger Airbag Resistance Too High
- DTC B1354: 1st Stage Passenger Airbag Short to Ground
- DTC B1355: 1st Stage Passenger Airbag Short to Power
- DTC B1361: Driver Belt Pretensioner Resistance Too High
- DTC B1362: Driver Belt Pretensioner Resistance Too Low
- DTC B1363: Driver Belt Pretensioner Short to Ground
- DTC B1364: Driver Belt Pretensioner Short to Power
- DTC B1367: Passenger Belt Pretensioner Resistance Too High
- DTC B1368: Passenger Belt Pretensioner Resistance Too Low
- DTC B1369: Passenger Belt Pretensioner Short to Ground
- DTC B1370: Passenger Belt Pretensioner Short to Power
- DTC B1378: Driver Side Airbag Resistance Too High
- DTC B1379: Driver Side Airbag Resistance Too Low
- DTC B1380: Driver Side Airbag Short to Ground
- DTC B1381: Driver Side Airbag Short to Power
- DTC B1382: Passenger Side Airbag Resistance Too High
- DTC B1383: Passenger Side Airbag Resistance Too Low
- DTC B1384: Passenger Side Airbag Short to Ground
- DTC B1385: Passenger Side Airbag Short to Power
- Troubleshooting
- DTC B1395: Firing Loops Interconnection Fault
- DTC B1400: Driver Side Airbag Sensor Defect
- DTC B1401: Driver Side Airbag Sensor Short to Ground
- DTC B1402: Driver Side Airbag Sensor Short to Power
- DTC B1403: Passenger Side Airbag Sensor Defect
- DTC B1404: Passenger Side Airbag Sensor Short to Ground
- DTC B1405: Passenger Side Airbag Sensor Short to Power
- DTC B1409: Driver Side Airbag Sensor Communication Error
- DTC B1410: Passenger Side Airbag Sensor Communication Error
- DTC B1414: Driver Side Airbag Sensor Wrong ID
- DTC B1415: Passenger Side Airbag Sensor Wrong ID
- DTC B1440: OC Passenger Short to Ground (GND)
- DTC B1446: OC Passenger Short to Power (Battery) or No Response
- DTC B1447: OC Passenger (System) Defect
- DTC B1448: OC Passenger Sensor Mat Defect
- DTC B1449: OC Passenger Communication Error
- DTC B1450: OC Passenger Wrong ID
- DTC B1481: 2nd Stage Driver Airbag Resistance Too High
- DTC B1482: 2nd Stage Driver Airbag Resistance Too Low
- DTC B1483: 2nd Stage Driver Airbag Short to Ground
- DTC B1484: 2nd Stage Driver Airbag Short to Power
- DTC B1485: 2nd Stage Passenger Airbag Resistance Too High
- DTC B1486: 2nd Stage Passenger Airbag Resistance Too Low
- DTC B1487: 2nd Stage Passenger Airbag Short to Ground
- DTC B1488: 2nd Stage Passenger Airbag Short to Power
- DTC B1620: Internal SDM Fault
- DTC B1650: Crash Recorded in 1st Stage Frontal Airbag
- DTC B1651: Crash Recorded in Driver Side Airbag
- DTC B1652: Crash Recorded in Passenger Side Airbag
- DTC B1657: Crash Recorded in Belt Pretensioner
- DTC B1670: Crash Recorded in 2nd Stage Frontal Airbag
- DTC B2500: Airbag Warning Lamp Failure
- DTC B2502: Passenger Airbag "OFF" Indicator Failure
- Disabling the Supplemental Inflatable Restraints (SIR)
- Enabling the Supplemental Inflatable Restraints (SIR)
- Handling, Installation and Diagnosis
- Repairs and Inspections Required after an Accident
- Accident with Deployment Components Replacements
- Accident without Deployment Component Inspection
- Sensing and Diagnostic Module (SDM) Removal and Installation
- Driver Airbag Module Removal and Installation
- Clock Spring Removal and Installation
- Clock Spring Alignment
- Passenger Airbag Module Removal and Installation
- Side Airbag Sensor Removal and Installation
- Front Seat Belt Pretensioner
- Airbag Module Deployment (Inside of Vehicle)
- Airbag Module Deployment (Outside of Vehicle)
- Deployed Airbag Module Disposal Procedure
- SIR Wiring Repair
- Specifications
- Seat Belts
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- Specifications
- Air Bag System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Assisted Steering System
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Notes
- Power Rack and Pinion Steering Gear Diagnosis
- Hissing Noise
- Rattling Noise in Steering Gear
- Poor Return of Steering Wheel to Center
- Momentary Increase in Effort When Turning the Wheel Quickly
- Steering Surges or Jerks When Turning with Engine Running
- Steering Vibrates during Low Speed or Static Steering
- Excessive Wheel Kickback or Loose Steering
- Hard Steering or Lack of Assist (Especially during Parking)
- Power Rack and Pinion Steering Gear Bench Testing
- Speed Sensitive Power Steering System Operating Diagnosis
- SSPS System Self-Diagnosis
- Diagnostic System Check-Variable Effort Steering
- DTC 01: Actuator Circuit Open
- DTC 02: Actuator Hi to Lo Short
- DTC 03: Actuator Circuit Short to B+
- DTC 04: Actuator Hi Short to Ground
- DTC 05: Actuator Lo Short to Ground
- DTC 06: Steering Wheel Speed Sensor Open
- DTC 07: Steering Wheel Speed Sensor Short to 5V
- DTC 08: Battery Voltage Out of Range (9-16V)
- Power Steering System Pressure Test
- Power Steering System Leak Test
- Power Steering Pump Diagnosis
- Straight-Ahead Check
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Fluid
- Rack and Pinion Assembly Removal and Installation
- Outer Tie Rod Removal and Installation
- Dust Boot Removal and Installation
- Intermediate Shaft and Dash Seal Removal and Installation
- Hydraulic Cylinder Lines Removal and Installation
- Speed Sensitive Power Steering Control Module Removal and Installation
- Rack and Pinion Disassembly and Assembly
- Stub Shaft Seals and Upper and Lower Bearing Disassembly and Assembly
- Rack Bearing Disassembly and Assembly
- Rack Bearing Preload Adjustment
- Valve and Pinion Disassembly and Assembly
- Fluid Reservoir Removal and Installation
- Hoses and Pipes Removal and Installation
- Serpentine Accessory Drive Belt Removal and Installation
- Pump Assembly Removal and Installation
- Specifications
- Special Tools and Equipment
- Precautions - Steering
- Steering General Diagnosis
- Power Assisted Steering System
- Power Steering
- Power Assisted Steering System
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Notes
- Power Rack and Pinion Steering Gear Diagnosis
- Hissing Noise
- Rattling Noise in Steering Gear
- Poor Return of Steering Wheel to Center
- Momentary Increase in Effort When Turning the Wheel Quickly
- Steering Surges or Jerks When Turning with Engine Running
- Steering Vibrates during Low Speed or Static Steering
- Excessive Wheel Kickback or Loose Steering
- Hard Steering or Lack of Assist (Especially during Parking)
- Power Rack and Pinion Steering Gear Bench Testing
- Speed Sensitive Power Steering System Operating Diagnosis
- SSPS System Self-Diagnosis
- Diagnostic System Check-Variable Effort Steering
- DTC 01: Actuator Circuit Open
- DTC 02: Actuator Hi to Lo Short
- DTC 03: Actuator Circuit Short to B+
- DTC 04: Actuator Hi Short to Ground
- DTC 05: Actuator Lo Short to Ground
- DTC 06: Steering Wheel Speed Sensor Open
- DTC 07: Steering Wheel Speed Sensor Short to 5V
- DTC 08: Battery Voltage Out of Range (9-16V)
- Power Steering System Pressure Test
- Power Steering System Leak Test
- Power Steering Pump Diagnosis
- Straight-Ahead Check
- Repair Instructions
- Bleeding the Power Steering System
- Checking and Adding Fluid
- Rack and Pinion Assembly Removal and Installation
- Outer Tie Rod Removal and Installation
- Dust Boot Removal and Installation
- Intermediate Shaft and Dash Seal Removal and Installation
- Hydraulic Cylinder Lines Removal and Installation
- Speed Sensitive Power Steering Control Module Removal and Installation
- Rack and Pinion Disassembly and Assembly
- Stub Shaft Seals and Upper and Lower Bearing Disassembly and Assembly
- Rack Bearing Disassembly and Assembly
- Rack Bearing Preload Adjustment
- Valve and Pinion Disassembly and Assembly
- Fluid Reservoir Removal and Installation
- Hoses and Pipes Removal and Installation
- Serpentine Accessory Drive Belt Removal and Installation
- Pump Assembly Removal and Installation
- Specifications
- Special Tools and Equipment
- Precautions - Steering
- Steering General Diagnosis
- Power Assisted Steering System
- Steering Column
- Precautions - Steering
- Steering Wheel And Column
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Headlamp / Turn Signal Switch and Lever Removal and Installation
- Wiper Switch and Lever Removal and Installation
- Steering Wheel Rotation Sensor Removal and Installation
- Steering Wheel Removal and Installation
- Ignition Lock Cylinder and Switch Removal and Installation
- Steering Column Removal and Installation
- Specifications
- Special Tools and Equipment
- Manual Steering
- Suspension
- Front Suspension
- Front Suspension
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Front Camber and Caster Check
- Front Toe Adjustment
- Stabilizer Shaft and Insulators Removal and Installation
- Stabilizer Link Removal and Installation
- Knuckle Assembly Removal and Installation
- Hub and Bearing Removal and Installation
- Control Arm Removal and Installation
- Strut Assembly Removal and Installation
- Crossmember Assembly Removal and Installation
- Ball Joint Disassembly and Assembly
- Control Arm Bushings Disassembly and Assembly
- Front Strut Assembly Disassembly and Assembly
- Knuckle Disassembly and Assembly
- Specifications
- Special Tools and Equipment
- Precautions - Suspension
- Suspension General Diagnosis
- Front Suspension
- Rear Suspension
- Precautions - Suspension
- Rear Suspension
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Rear Camber Check
- Rear Toe Adjustment
- Strut Assembly Removal and Installation
- Knuckle Assembly Removal and Installation
- Trailing Link Removal and Installation
- Trailing Link Bracket Removal and Installation
- Front Parallel Link Removal and Installation
- Rear Parallel Link Removal and Installation
- Stabilizer Shaft Removal and Installation
- Stabilizer Link Removal and Installation
- Crossmember Removal and Installation
- Hub and Bearing Assembly Removal and Installation
- Springs and Insulators Disassembly and Assembly
- Knuckle Disassembly and Assembly
- Specifications
- Special Tools and Equipment
- Suspension General Diagnosis
- Wheel Alignment
- Front Suspension
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Front Camber and Caster Check
- Front Toe Adjustment
- Stabilizer Shaft and Insulators Removal and Installation
- Stabilizer Link Removal and Installation
- Knuckle Assembly Removal and Installation
- Hub and Bearing Removal and Installation
- Control Arm Removal and Installation
- Strut Assembly Removal and Installation
- Crossmember Assembly Removal and Installation
- Ball Joint Disassembly and Assembly
- Control Arm Bushings Disassembly and Assembly
- Front Strut Assembly Disassembly and Assembly
- Knuckle Disassembly and Assembly
- Specifications
- Special Tools and Equipment
- Rear Suspension
- General Description
- Component Location
- Diagnostic Information and Procedures
- Repair Instructions
- Rear Camber Check
- Rear Toe Adjustment
- Strut Assembly Removal and Installation
- Knuckle Assembly Removal and Installation
- Trailing Link Removal and Installation
- Trailing Link Bracket Removal and Installation
- Front Parallel Link Removal and Installation
- Rear Parallel Link Removal and Installation
- Stabilizer Shaft Removal and Installation
- Stabilizer Link Removal and Installation
- Crossmember Removal and Installation
- Hub and Bearing Assembly Removal and Installation
- Springs and Insulators Disassembly and Assembly
- Knuckle Disassembly and Assembly
- Specifications
- Special Tools and Equipment
- SUZUKI Wheel Alignment Specifications
- Front Suspension
- Wheels & Tire System
- Precautions - Suspension
- Suspension General Diagnosis
- Wheel And Tires
- General Description
- Diagnostic Information and Procedures
- Repair Instructions
- Specifications
- Front Suspension
- Transmission
- Automatic Trans
- Automatic Transmission
- General Description
- ZF 4HP 16 Automatic Transaxle Introduction
- ZF 4HP 16 Automatic Transaxle Description
- Mechanical Components Description
- Electronic Components Description
- Selector Lever/Program Switch
- Park/Neutral Position Switch
- Signal Combination
- Automatic Transaxle Output Speed Sensor (A/T OSS)
- Automatic Transaxle Input Speed Sensor (A/T ISS)
- Shift Solenoid Valve: Solenoid 1, 2
- Pressure Control Solenoid Valve (EDS VALVE 3, 4, 5, 6)
- Transaxle Fluid Temperature (TFT) Sensor
- Transaxle Electrical Connector
- Transaxle Control Module (TCM)
- Data Link Connector (DLC)
- TCM Inputs That Affect the 4HP 16 Transaxle
- Automatic Transaxle Output (Shaft) Speed Sensor
- Automatic Transaxle Input (Shaft) Speed Sensor
- Engine Coolant Temperature Sensor
- Engine Speed
- Stoplamp Switch
- Transmission Fluid Temperature (TFT) Sensor
- Transaxle Identification Information
- Shift Mode Diagram
- Power Flow Diagram
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Basic Knowledge Required
- Functional Check
- Line Pressure Check
- Clutch Plate Diagnosis
- Cooler Flushing and Flow Test
- Transaxle Fluid Level Service
- Electrical/Garage Shift Test
- Road Test
- Torque Converter Lock-Up Clutch (TCC) Diagnosis
- TCM Initialization Procedure
- Shift Speed Chart
- Internal Wiring Harness Check
- Transaxle Wiring Harness Connector
- Symptom Diagnosis
- Shift Lever Diagnosis
- Diagnostic Trouble Code (DTC) Identification
- DTC P0562 System Voltage Low
- DTC P0563 System Voltage High
- DTC P0601 Internal Control Module Memory Checksum Error
- DTC P0603 Internal Control Module Keep Alive Memory (KAM) Error
- DTC P0604 Internal Control Module Random Access Memory (RAM) Error
- DTC P0606 Transaxle Control Module Processor Fault
- DTC P0703 Brake Switch Circuit Malfunction
- DTC P0705 Transmission Range Sensor Circuit Malfunction (PRNDL Input)
- DTC P0710 Transmission Fluid Temperature Sensor Circuit Malfunction
- DTC P0711 Transmission Fluid Temperature Sensor Circuit Range/Performance
- DTC P0712 Transmission Fluid Temperature Sensor Circuit Shorted to Ground
- DTC P0713 Transmission Fluid Temperature Sensor Circuit Shorted to Power and Open
- DTC P0715 Input Speed Sensor (ISS) Circuit Malfunction
- DTC P0716 Input Speed Sensor (ISS) Circuit Range/Performance
- DTC P0717 Input Speed Sensor (ISS) Circuit No Signal
- DTC P0720 Output Speed Sensor (OSS) Circuit Malfunction
- DTC P0721 Output Speed Sensor (OSS) Circuit Range/Performance
- DTC P0722 Output Speed Sensor (OSS) Circuit No Signal
- DTC P0725 Engine Speed Input Circuit Malfunction
- DTC P0726 Engine Speed Input Circuit Range/Performance
- DTC P0727 Engine Speed Input Circuit No Signal
- DTC P0731 Gear 1 Incorrect Ratio
- DTC P0732 Gear 2 Incorrect Ratio
- DTC P0733 Gear 3 Incorrect Ratio
- DTC P0734 Gear 4 Incorrect Ratio
- DTC P0741 TCC (Torque Converter Clutch) Circuit Stuck OFF
- DTC P0742 TCC (Torque Converter Clutch) Circuit Stuck ON
- DTC P0781 1-2 Shift Malfunction
- DTC P0782 2-3 Shift Malfunction
- DTC P0783 3-4 Shift Malfunction
- DTC P1604 Data Check of Internal & Extended RAM Failed
- DTC P1606 Failure of External Watchdog
- DTC P1779 Engine Torque Input Signal Malfunction
- DTC P1791 Throttle Position Input Signal Circuit Malfunction
- DTC P1839 EDS 3 Output Shorted to Ground
- DTC P1840 EDS 3 Output Shorted to Power
- DTC P1841 EDS 3 Output Open
- DTC P1850 Solenoid 1 Output Shorted to Ground
- DTC P1851 Solenoid 1 Output Shorted to Power
- DTC P1852 Solenoid 1 Output Open
- DTC P1853 Solenoid 2 Output Shorted to Ground
- DTC P1854 Solenoid 2 Output Shorted to Power
- DTC P1855 Solenoid 2 Output Open
- DTC P1861 EDS 4 Output Shorted to Ground
- DTC P1862 EDS 4 Output Shorted to Power
- DTC P1863 EDS 4 Output Open
- DTC P1864 EDS 5 Output Shorted to Ground
- DTC P1865 EDS 5 Output Shorted to Power
- DTC P1866 EDS 5 Output Open
- DTC P1867 EDS 6 Output Shorted to Ground
- DTC P1868 EDS 6 Output Shorted to Power
- DTC P1869 EDS 6 Output Open
- DTC P1871 EDS Valve Power Supply Circuit Shorted to Power
- DTC P1874 Solenoid Valve Power Supply Circuit Shorted to Power
- DTC P1881 2-1 Shift Malfunction
- DTC P1883 3-2 Shift Malfunction
- DTC P1884 4-3 Shift Malfunction
- DTC P1885 3-1 Shift Malfunction
- DTC U0073 CAN Bus OFF Failure
- DTC U0100 CAN Receive ECM Message Failure
- DTC U0101 CAN Transmit Message Failure
- Repair Instructions
- Transaxle Fluid Level Checking Procedure
- Changing the Fluid
- Fluid Level Set after Service
- Repairing Fluid Leaks
- Case Porosity Repair
- Torque Converter Components
- Transaxle Housing Components
- Oil Pump Components
- Rear Cover & Oil Pan Cover Components
- Parking Lever Components
- Input Shaft & Shift Gear Components
- Valve Body Components
- Gear Shift Control Components
- Shift Control Lever Assembly Removal and Installation
- Shift Control Cable Removal and Installation
- Shift Control Cable Adjustment
- Transmission Control Module (TCM) Removal and Installation
- Park/Neutral Start Switch Removal and Installation
- Oil Cooler Pipes/Hoses Removal and Installation
- Drive Axle Oil Seal Removal and Installation
- Oil Pan, Oil Pan Gasket Removal and Installation
- Control Valve Body Assembly Removal and Installation
- Left Transaxle Mounting Bracket Removal and Installation
- Transaxle Assembly Removal and Installation
- Torque Converter Disassembly and Assembly
- Transaxle Holding Fixture Assembly
- Valve Body Disassembly and Assembly
- Rear Cover Disassembly and Assembly
- Clutch B/E Disassembly and Assembly
- Clutch B/E Measurement
- Measuring Installation Space, Clutch E (EE)
- Determining Adjusting Disc B (PB)
- Determining Adjusting Disc E (PE)
- Planetary Gear Set Disassembly and Assembly
- Brake C/D Disassembly and Assembly
- Differential Disassembly and Assembly
- Brake F, Slotted Nut Disassembly and Assembly and Installation
- Measuring Installation Space F
- Torque Converter Housing Disassembly and Assembly
- Shift Mechanism Disassembly and Assembly
- Parking Lock System Disassembly and Assembly
- Bearing Plate (with Spur Gear) Assembly Disassembly and Assembly
- Side Shaft Disassembly and Assembly
- Oil Pump Assembly Disassembly and Assembly
- Differential / Side Shaft Outer Race, Bearing Shim Disassembly and Assembly
- Important Measurement / Adjustment
- Specifications
- Special Tools and Equipment
- General Description
- Precautions - Automatic Transmission
- Automatic Transmission
- Automatic Trans
- External Pages