Section 98 (Differential Assembly)
WARNING: This page is about a different car, the 2011 Suzuki SX4. However, it is still accessible from the selected car via links, so may be relevant.
- Precautions
- General Description
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- 4WD Control System Check
- Notes
- Detail of 4WD Control System Check
- Step 1. Customer complaint analysis
- Step 2. DTC check, record and clearance
- Step 3 and 4. Visual inspection
- Step 5. Trouble symptom confirmation
- Step 6 and 7. Rechecking and record of DTC
- Step 8. 4WD control symptom diagnosis
- Step 9. Troubleshooting for DTC
- Step 10. Check for intermittent problem
- Step 11. Final confirmation test
- 4WD Position Indicator Operation Check
- 4WD Control System Operation Inspection
- Visual Inspection
- DTC Check
- DTC Clearance
- DTC Table
- Fail-Safe Table
- Scan Tool Data
- Rear Differential Symptom Diagnosis
- 4WD Control Symptom Diagnosis
- 4WD Position Indicator Does Not Come ON at Ignition Switch ON but Engine Stops
- 4WD Position Indicator Remains ON Steady at Ignition Switch ON
- DTC C1240: 4WD Control Module Power Supply Circuit Malfunction
- DTC C1243: Internal Circuit Malfunction of 4WD Control Module
- DTC C1250: Coupling Air Temperature Sensor Circuit Open
- DTC C1251: Coupling Air Temperature Sensor Circuit Short
- DTC C1252: Coupling Assembly Circuit Open
- DTC C1253: Coupling Assembly Circuit Short
- DTC C1254: 2WD/4WD Switch Malfunction
- DTC U0073: Control Module Communication Bus Off
- DTC U0100: Lost Communication with ECM
- DTC U0101: Lost Communication with TCM
- DTC U0121: Lost Communication with ABS/ESP® Control Module
- DTC U0155: Lost Communication with Instrument Panel Cluster (IPC) Control Module
- Inspection of 4WD Control Module and Its Circuits
- 4WD Control System Check
- Repair Instructions
- Rear Differential Oil Level Check
- Rear Differential Oil Change
- 2WD/4WD Switch Removal and Installation
- 2WD/4WD Switch Inspection
- 4WD Control Module Removal and Installation
- Coupling Air Temperature Sensor Removal and Installation
- Coupling Air Temperature Sensor Inspection
- Coupling Assembly Inspection
- Rear Differential Mountings Components
- Front Mounting Arm and/or Rear Mounting Bracket Assembly Removal and Installation
- Rear Mounting Bracket Assembly Disassembly and Reassembly
- Rear Differential Dismounting and Remounting
- Rear Differential Components
- Rear Differential Disassembly and Reassembly
- Rear Differential Inspection
- Specifications
- Special Tools and Equipment