Section 18 (High Voltage Battery System -- Model 3)
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2023 Tesla Model 3, 2022 Tesla Model 3, 2021 Tesla Model 3, 2020 Tesla Model 3, and 2019 Tesla Model 3. However, it is still accessible from the selected car via links, so may be relevant.
- HV Battery Assembly
- HV Battery Enclosure
- Bracket - Skid Plate - Front - HV Battery - Remove and Replace
- Breathers (HV Battery) - Remove and Replace
- Cover - HV Probe (HV Battery) - Remove and Replace
- Cover - Ancillary Bay - Remove and Replace
- Flood Ports - 2nd Generation - Remove and Replace
- Flood Ports - 2nd Generation - Retrofit
- Seal - Perimeter (HV Battery) - Remove and Replace
- HV Battery Air Leak Test
- NVH Pads (HV Battery) - Install
- Penthouse Air Leak Test
- Platter Enclosure Air Leak Test
- Ski - Center Rail - (HV Battery (RWD)) - Remove and Replace
- Ski - Center Rail - (HV Battery (Dual Motor)) - Remove and Replace
- Skid Plate (HV Battery) - Front - Remove and Replace
- Skid Plate (HV Battery) - Rear - Remove and Replace
- Vent Assembly (HV Battery) - LH - Remove and Replace
- Vent Assembly (HV Battery) - RH - Remove and Replace
- Vent Assembly (HV Battery) - Pair - Remove and Replace
- HV Battery Cooling System
- Coolant (HV Battery) - Drain and Refill
- Penthouse Coolant - Drain and Refill
- Penthouse Coolant Leak Test
- Platter Enclosure Coolant - Drain and Refill
- Platter Enclosure Coolant Leak Test
- Tube - Input - Coolant (Power Conversion System) - Remove and Replace
- Tube - Output - Coolant (Power Conversion System) - Remove and Replace
- HV Battery Electrical Components
- Busbar DC Input to Harness DC Input - Retrofit
- Contactor - Fast Charge (HV Battery) - Remove and Replace
- Contactor - Negative (HV Battery) - Remove and Replace
- Contactor - Positive (HV Battery) - Remove and Replace
- Controller - High Voltage - Backup and Restore
- Controller - High Voltage - Remove and Install
- Controller - High Voltage - Remove and Replace
- DC Input Assembly - (HV Battery (Busbar Type)) - Remove and Replace
- DC Input Assembly - (HV Battery (Harness Type)) - Remove and Replace
- Fuse - A/C Compressor (HV Battery) - Remove and Replace
- Fuse - Cabin Heater (HV Battery) - Remove and Replace
- Fuse - Cabin Heater - (HV Battery (Battery On Table)) - Install
- Fuse - Power Conversion System (HV Battery) - Remove and Replace
- Guide - Probing (HV Battery) - Remove and Replace
- Guide - Probing (HV Battery) - Retrofit
- Harness - AC Inlet (HV Battery) - Remove and Replace
- Harness - Penthouse (HV Battery) - Remove and Replace
- HV Battery Contactor Seize Check
- HV Header - PTC Heater and A/C Compressor (HV Battery) - Remove and Replace
- HV Header - Rear Drive Unit (HV Battery) - Remove and Replace
- Insulators (HV Battery) - Install
- Passthrough - DCDC - 12V (Busbar Type) - Remove and Replace
- Passthrough - DCDC - 12V (Cable Type) - Remove and Replace
- Power Conversion System - Remove and Replace
- Pyrotechnic Battery Disconnect - Remove and Replace
- Resistance Meter (Zero Adjust)
- Seal - Probe Lid (HV Battery) - Remove and Replace
- Shunt (HV Battery) - Remove and Replace