Technical Service Bulletins

A/C Compressor
- Alternate Refrigerants And A/C Retrofit (AC003-96)
- Service Hints For Refrigerant Leak Detection - Info (AC95-001)
- Avoiding A/C Compressor Failure: Lube Oil REQTS. (AC93-005)
- A/C Service - Evacuation Procedure Revision (VOL. 10, A/C, NO. 007)
- A/C Not Cooling - REPL A/C Compressor Line O-Rings (VOL. 8, ACC, NO. 003)
- 1.5L Eng INTERMITTANT A/C No Run - New Condenser Fan (VOL. 7, ELC, NO. 009)
- A/C Refrigerant Pressure Conversion Reference Chart (AC92-005)
- Air Conditioner System O-Ring Color Change (AC92-004)
- Air Conditioning System Service Procedure (AC93-003)
Accessories Control Systems
- Battery Maintenance For Vehicles In Storage (EL92-001)
Anti-Theft Systems
- Battery Maintenance For Vehicles In Storage (EL92-001)
- VIN Plates And Certification Labels - Information (VOL. 10, PGI, NO. 015)
- Key Code And Key Cutter Information (VOL. 9, PGI, NO. 022)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
- Intrusion Monitoring System Electrical Connection (VOL. 8, ACC, NO. 001)
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
Automatic Trans
- Transmission Number And Location Information (VOL. 7, TRN, NO. 018)
- Engine Support Bar Improvements (SS95-003)
- A131L/A132L Auto Trans Clutch Changes - Fwd Models (TC95-001)
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
- Torque Converter To FLEXPLATE Mounting Bolt Warnings (VOL. 10, TRN, NO. 036)
- Trans/Cooler Flushing Procedure (VOL. 10, TRN, NO. 006)
- A55 Trans Noise In Neutral - New Rear Eng Mount (VOL. 7, TRN, NO. 012)
Auxiliary Emission Control Systems
- Sulfur Odor From Exhaust (EG003-03)
- Emission Control Label OREDERING Information (PG95-005)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Emission Control Label Part Numbers & Order Form (PG94-002)
Axle Shafts
- Revised Drive Shaft Grease (TC002-99)
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
- Propeller Shaft Tightening Bolt And Nut Modification (VOL. 7, AXL, NO. 006)
Blowers, Superchargers & Turbochargers
- 1.5/1.6L Eng Crankshaft Damper Pulley Improvement (VOL. 7, ENG, NO. 017)
Body Interior
- Air Conditioning Evaporator Odor (AC002-97)
- A/C Evaporator Odor - New Treatment/Part Number (VOL. 8, ELC, NO. 012)
Charging Systems
- MIDTRONICS Battery Tester Software Update (SS002-02)
- 1.5/1.6L Eng Crankshaft Damper Pulley Improvement (VOL. 7, ENG, NO. 017)
Clutch
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
- Clutch Improvement For Reduced Chatter (VOL. 7, TRN, NO. 024)
Communication Devices
- Mobile Communication System Installation:Precautions (AU93-001)
Cooling System (Mechanical)
- Radiator Cap Inspection (EG014-05)
- Recycled Coolants - TOYOTAS Disclaimer (PI91-006)
Cruise Control Systems
- Tercel Cruise Control & Intermittent Wiper Systems (VOL. 8, ELC, NO. 003)
Differentials & Drive Axles
- Revised Drive Shaft Grease (TC002-99)
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
- Propeller Shaft Tightening Bolt And Nut Modification (VOL. 7, AXL, NO. 006)
Driveshaft & Universal Joints
- Revised Drive Shaft Grease (TC002-99)
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
- Propeller Shaft Tightening Bolt And Nut Modification (VOL. 7, AXL, NO. 006)
Engine Control Systems
- Sulfur Odor From Exhaust (EG003-03)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
Entertainment Systems
- Cigarette Lighter Service (EL002-98)
- Cleaning Cassette Tape Heads (AU001-97 REV)
- Am Static Noise On Vehicles With Power Antennas (AU002-96)
- Identification Number On Audio Units - Information (VOL. 10, AUD, NO. 006)
- Radio Antenna Feeder Cable (VOL. 8, ACC, NO. 020)
Exhaust
- Sulfur Odor From Exhaust (EG003-03)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
Exterior Body Panels
- Rivet Nut Tool (SS003-98)
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
- Adjustment Of New Headrests (BO91-010)
Exterior Lights
- Battery Maintenance For Vehicles In Storage (EL92-001)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
Frames, Subframes & Crossmembers
- Paint Repairs On Polyurethane Bumper - Information (PA95-001)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
- Adjustment Of New Headrests (BO91-010)
Front Suspension
- Coil Spring Compressor Tool: Proper Use (SS93-001)
- Steering Rack Bushing And Grease Change - Less Noise (VOL. 7, SUS, NO. 004)
Fuel System
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
Fuses & Circuit Breakers
- Wire Harness Repair Kit "B": New Tool (SS94-002)
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Radio Antenna Feeder Cable (VOL. 8, ACC, NO. 020)
- Intrusion Monitoring System Electrical Connection (VOL. 8, ACC, NO. 001)
- Tercel Cruise Control & Intermittent Wiper Systems (VOL. 8, ELC, NO. 003)
Gauges & Instrument Panels
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- VIN Plates And Certification Labels - Information (VOL. 10, PGI, NO. 015)
- Adjustment Of New Headrests (BO91-010)
Headlights
- Battery Maintenance For Vehicles In Storage (EL92-001)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
HVAC Control Systems
- Air Conditioning Evaporator Odor (AC002-97)
- Alternate Refrigerants And A/C Retrofit (AC003-96)
- A/C Compressor Maintenance For Stored Vehicles (AC002-96)
- Service Hints For Refrigerant Leak Detection - Info (AC95-001)
- Avoiding A/C Compressor Failure: Lube Oil REQTS. (AC93-005)
- A/C Service - Evacuation Procedure Revision (VOL. 10, A/C, NO. 007)
- A/C Evaporator Odor - New Treatment/Part Number (VOL. 8, ELC, NO. 012)
- A/C Not Cooling - REPL A/C Compressor Line O-Rings (VOL. 8, ACC, NO. 003)
- A/C O-Ring Kit Available (VOL. 8, ELC, NO. 006)
- 1.5L Eng INTERMITTANT A/C No Run - New Condenser Fan (VOL. 7, ELC, NO. 009)
- A/C Refrigerant Pressure Conversion Reference Chart (AC92-005)
- Air Conditioner System O-Ring Color Change (AC92-004)
- Air Conditioning System Service Procedure (AC93-003)
Identification
- Replacement Certification Labels And VIN Plates (T-SB-0032-20 REV2)
- Replacement VIN Plates (PG009-02)
- Replacement VIN Plates (PG005-97)
- Replacement Certification Labels (PG004-97)
- VIN Plates & Certification Labels: Replacements (PG93-002)
- CALIFORNIA Vehicle Emission Control Info. Labels (PI91-008)
- VIN Plates & Certification Labels - Information (PI91-002)
Ignition Switch/Steering Lock
- Key Code And Key Cutter Information (VOL. 9, PGI, NO. 022)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
Ignition System
- Signal Generator Resistance Specifications (EN91-007)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
Infotainment
- Am Static Noise On Vehicles With Power Antennas (AU002-96)
Interior/Exterior Trim
- Refinishing Replacement Bumper Covers (PA003-02 REV.)
- Rivet Nut Tool (SS003-98)
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- SEATBELT Retractor INOP - Undercoat Application Info (VOL. 9, PGI, NO. 018)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
- Adjustment Of New Headrests (BO91-010)
Interior/Illumination Lights
- Battery Maintenance For Vehicles In Storage (EL92-001)
Locking Hubs
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
Lubrication System
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
Manual Steering
- Steering Rack Bushing And Grease Change - Less Noise (VOL. 7, SUS, NO. 004)
Manual Trans
- Revised Drive Shaft Grease (TC002-99)
- Transmission Number And Location Information (VOL. 7, TRN, NO. 018)
- Engine Support Bar Improvements (SS95-003)
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
- Z52F Trans Shift Lever Bushing Modification (VOL. 7, TRN, NO. 009)
Mechanical
- Engine Support Bar Improvements (SS95-003)
- Standard Bolt Torque Specifications (PG95-006)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- 1.5/2.0L Eng Connecting Rod Standardization (VOL. 7, ENG, NO. 020R)
- 1.5/1.6L Eng Crankshaft Damper Pulley Improvement (VOL. 7, ENG, NO. 017)
- 1.5L Eng New Crankshaft Bearings (VOL. 7, ENG, NO. 014)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
Mechanical - Hydraulic
- Brake Booster Push Rod Gauge (SST) (SS002-97)
- Introduction Of Brake Shim Kit & Brake Fitting Kits (BR95-003)
- Brake Vibration/Pulsation: Corrective Measures (BR94-002)
- Introduction Of New Disc Brake Pad Kit (BR94-004)
- TOYOTA Brake Pads-Proper Balance Of Friction & Force (TSN93-46-3)
- Front Disc Brake Part Standardization (VOL. 7, BRK, NO. 004)
- New Car Pre-Delivery Service (VOL. 7, PGI, NO. 014)
Memory Modules
- Battery Maintenance For Vehicles In Storage (EL92-001)
Mirrors
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
Paint & Coatings
- Paint Repairs On Polyurethane Bumper - Information (PA95-001)
- Acid Rain Damage - Condition/Cause/Inspection/Repair (VOL. 10, BOD, NO. 043R)
- New Vehicle Washing Schedule For Paint Protection (BO91-019)
- Iron Particle Contamination Repair (VOL. 10, BOD, NO. 045)
- Pearl Mica Paint Care/Scratch Removal (VOL. 9, BOD, NO. 015)
- Fixed Glass Installation: Urethane Adhesive Sealant (VOL. 9, BOD, NO. 009)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
- Urethane Adhesive Sealant For Fixed Glass Install (VOL. 8, BOD, NO. 032)
- Paint Codes For All 1984 Models (VOL. 7, PNT, NO. 003)
Passive Restraints
- Seat Belt Tongue Plate Stopper Replacement (T-SB-0258-08)
- Child Restraint Seat Top Strap Bracket Installation (BO010-02)
Rear Suspension
- Coil Spring Compressor Tool: Proper Use (SS93-001)
- Steering Rack Bushing And Grease Change - Less Noise (VOL. 7, SUS, NO. 004)
Schedule
- Battery Maintenance For In-Stock Vehicles - Info (EL95-001)
Seats
- Child Restraint Seat Top Strap Bracket Installation (BO010-02)
- Seat Belt Extenders - Information And Order Process (BO92-003)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Seat Belt Extender - Information (VOL. 10, BOD, NO. 017)
- SEATBELT Retractor INOP - Undercoat Application Info (VOL. 9, PGI, NO. 018)
- Seat Belt Extender Description/Ordering Info (VOL. 8, BOD, NO. 044)
- Original TOYOTA Seat Cover Material (VOL. 8, BOD, NO. 042)
- Seat Belt Replacement Guide (VOL. 8, BOD, NO. 002)
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
- Adjustment Of New Headrests (BO91-010)
- Rear Seat 3-Point Belts - Availability/Installation (VOL. 9, BOD, NO. 011)
- Seat Belt Extenders Availability (BO93-006)
Solar Ventilation
- Avoiding A/C Compressor Failure: Lube Oil REQTS. (AC93-005)
- A/C Service - Evacuation Procedure Revision (VOL. 10, A/C, NO. 007)
- A/C Not Cooling - REPL A/C Compressor Line O-Rings (VOL. 8, ACC, NO. 003)
- 1.5L Eng INTERMITTANT A/C No Run - New Condenser Fan (VOL. 7, ELC, NO. 009)
Starter
- MIDTRONICS Battery Tester Software Update (SS002-02)
- Battery Maintenance For In-Stock Vehicles - Info (EL95-001)
Steering Gear
- Steering Rack Bushing And Grease Change - Less Noise (VOL. 7, SUS, NO. 004)
Steering Linkage
- Steering Rack Bushing And Grease Change - Less Noise (VOL. 7, SUS, NO. 004)
Sun Roof/T-Top/Convertible Top
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Corrosion Resistant Back Door Lock CYL. Availability (VOL. 9, BOD, NO. 004)
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
- Adjustment Of New Headrests (BO91-010)
System
- Sulfur Odor From Exhaust (EG003-03)
- Emission Control Label OREDERING Information (PG95-005)
- Signal Generator Resistance Specifications (EN91-007)
- Converter Odor Reduction Procedure (VOL. 8, EMM, NO. 001)
- 1.5/1.6L Carb Eng Catalytic Converter Odor (VOL. 8, ENG, NO. 001)
- Emission Control Label Part Numbers & Order Form (PG94-002)
Towing
- Emergency Tow Procedures - All Models (VOL. 10, PGI, NO. 035)
Transfer Case
- Revised Drive Shaft Grease (TC002-99)
- New SADS Equipment Driveshaft Reduces Knocking Noise (EN91-008)
Transmission Control Systems
- Torque Converter To FLEXPLATE Mounting Bolt Warnings (VOL. 10, TRN, NO. 036)
Wheels & Tire System
- Wheel Balance Adapter Kit (SU002-96 REV)
- Aluminum Disc Wheel Clear Coating (VOL. 7, AXL, NO. 004)
Window Motors & Regulators
- Wind Noise Repair Kit Parts Information Table (BO003-97)
- Squeak & Rattle Repair Kit (Revised) (VOL. 10, BOD, NO. 046R)
- Fixed Glass Installation: Urethane Adhesive Sealant (VOL. 9, BOD, NO. 009)
- Urethane Adhesive Sealant For Fixed Glass Install (VOL. 8, BOD, NO. 032)
- Roof Rack - 5MM Jack Nut Collapsing Tool Kit (VOL. 7, ACC, NO. 010)
- Adjustment Of New Headrests (BO91-010)
Wiper/Washer Systems
- Wiper Linkage Improvement - New Ball Socket Joint (VOL. 9, BOD, NO. 001)
- Tercel Cruise Control & Intermittent Wiper Systems (VOL. 8, ELC, NO. 003)
- Windshield Wiper Blade New Supplier Part Info Table (BO026-97)
- Wiper Performance - New Wiper Arm & Blade (VOL. 7, ELC, NO. 011)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wire Harness Repair Kit "B": New Tool (SS94-002)
- Battery Maintenance For Vehicles In Storage (EL92-001)
- Radio Antenna Feeder Cable (VOL. 8, ACC, NO. 020)
- Intrusion Monitoring System Electrical Connection (VOL. 8, ACC, NO. 001)
- Tercel Cruise Control & Intermittent Wiper Systems (VOL. 8, ELC, NO. 003)