Technical Service Bulletins

A/C Compressor
- A/C System Diagnosis After Component Failure (T-SB-0083-13 REV1)
- Drive Belt Squeal Noise On Cold Start (T-SB-0012-15)
- Long Term Vehicle Storage Guidelines (T-SB-0025-11)
Accessories & Equipment
- RAPGARD Protective Film Removal (T-SB-0061-23 REV2)
- Immobilizer And Smart Key Reset (T-SB-0057-18 REV2)
- Odor Remediation After Water Intrusion (T-SB-0094-21 REV2)
- Use Of Genuine Parts - Crib # 180 (S-CRIB-180 REV2)
Accessories Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- Remote Keyless Entry Transmitter Inoperative (TSB-15-005)
Accessory Drive Belts
- Drive Belt Squeal Noise On Cold Start (T-SB-0012-15)
Air Bag, SRS
- Seat Cover Replacement For Side Airbag Equipped Vehicles (T-SB-0122-11 REV1)
- SRS Component Disposal As Hazardous Material Treatment (T-SB-0218-17 REV1)
- Passenger "Airbag Off" Light Illuminates Intermittently (T-SB-0092-12)
Anti-Theft Systems
- Immobilizer And Smart Key Reset (T-SB-0057-18 REV2)
- Remote Keyless Entry Transmitter Inoperative (TSB-15-005)
Automatic Trans
- Automatic/Continuously Variable Transmission Replacement Precautions (T-SB-0024-18)
- Remanufactured Automatic Transmission Serial Number Location (TC013-06)
- World Standard Automatic Transmission Fluid (TC010-07)
- Automatic Transmission Serial Number Location (TC012-06)
- Rattle Noise From Automatic Transmission Control Cable Assembly In Reverse (TC005-07)
Auxiliary Emission Control Systems
- Ca/Fed/50 State Certified Emission Control UNDERHOOD Labels (T-SB-0054-13)
Body Electrical
- Scanning For Electrical System Faults - Crib # 191 (S-CRIB-191)
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Interior Electrical Component Precautions (T-SB-0182-17)
- SRS & HV Wiring Repairs (T-CRIB-156)
Body Interior
- Scanning For Electrical System Faults - Crib # 191 (S-CRIB-191)
Brakes Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
Charging Systems
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Battery Maintenance For In-Stock Vehicles & Pre-Delivery (PG017-02 REV.)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Engine Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- Scanning For Electrical System Faults - Crib # 191 (S-CRIB-191)
Entertainment Systems
- Prevention Of Metal Contamination In Speakers - Crib # 197 (T-CRIB-197)
Exterior Body Panels
- Corrosion Prevention For Collision Repair - Crib # 186 (S-CRIB-186)
- Approved Collision Repair Methods - Crib # 176 (S-CRIB-176)
- Use Of Genuine Parts - Crib # 180 (S-CRIB-180 REV2)
- Front/Rear Door Outer Panel Installation Substitution - Crib # 199 (S-CRIB-199)
- PINCHWELD And Frame Clamping - Crib # 57 (T-CRIB-57)
- GMAW/Mig Welding Specifications - Crib # 196 (T-CRIB-196)
- Welded Outer Panel Replacement - Crib # 194 (T-CRIB-194)
- Frame Repair & Component Replacement - Crib # 193 (T-CRIB-193)
- PAINTLESS Dent Repair - Crib # 146 (T-CRIB-146)
- Sealing Hem-Flanges & Body Seams - Crib # 163 (T-CRIB-163)
Frames, Subframes & Crossmembers
- Use Of Genuine Parts - Crib # 180 (S-CRIB-180 REV2)
- PINCHWELD And Frame Clamping - Crib # 57 (T-CRIB-57)
- GMAW/Mig Welding Specifications - Crib # 196 (T-CRIB-196)
- Welded Outer Panel Replacement - Crib # 194 (T-CRIB-194)
- Frame Repair & Component Replacement - Crib # 193 (T-CRIB-193)
- Sealing Hem-Flanges & Body Seams - Crib # 163 (T-CRIB-163)
Front Suspension
- Steering And Suspension Analysis And Repair - Crib # 187 (L-CRIB-187)
- Clunk Noise From Front Suspension (T-SB-0078-12)
- Shock Absorber Replacement Criteria (T-SB-0145-11)
Fuel System
- Accelerator Pedal Sensor Assembly Service Precaution (T-SB-0087-12)
Fuses & Circuit Breakers
- Interior Electrical Component Precautions (T-SB-0182-17)
General Servicing
- HVAC Odor Maintenance (T-SB-0010-20)
Hazardous Waste Material
- SRS Component Disposal As Hazardous Material Treatment (T-SB-0218-17 REV1)
HVAC Control Systems
- HVAC Evaporator Drain Hose Clogged Due To Insect Intrusion (T-SB-0080-19 REV1)
- A/C System Diagnosis After Component Failure (T-SB-0083-13 REV1)
Identification
- Replacement Certification Labels And VIN Plates (T-SB-0032-20 REV2)
- Replacement VIN Plates (PG005-97)
- Remanufactured Automatic Transmission Serial Number Location (TC013-06)
- Automatic Transmission Serial Number Location (TC012-06)
- Ca/Fed/50 State Certified Emission Control UNDERHOOD Labels (T-SB-0054-13)
Infotainment
- Reception Diagnosis Using Antenna Test Kit (T-SB-0014-15)
Interior/Exterior Trim
- Prevention And Repair Of Acid Rain Damage (T-SB-091-020)
- Odor Remediation Process (Dealer Performed) (T-SB-0055-24 REV1)
- Carpet Floor Retainer Serviceability (T-SB-0014-22)
- Loose Windshield Dam At Lower Right Corner Of Windshield (T-SB-0077-13)
- Floor Mat Installation During PDS (T-SB-0040-11 REV2)
- 2012 My YARIS Pre-Delivery Service (PDS) (T-SB-0046-11)
Lubrication System
- Oil Leak Diagnosis And Repair (T-SB-0008-20)
Manual Steering
- Drive Belt Squeal Noise On Cold Start (T-SB-0012-15)
Mechanical
- Oil Leak Diagnosis And Repair (T-SB-0008-20)
- Drive Belt Squeal Noise On Cold Start (T-SB-0012-15)
- Torque Converter Bolt Installation (T-SB-0014-11 REV1)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
Mechanical - Hydraulic
- Wheel Film For Brake Rotor Rust Prevention (T-SB-0038-24 REV2)
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Brake Pedal Force Gauge SST For Parking Brake (T-SB-0141-13)
- Long Term Vehicle Storage Guidelines (T-SB-0025-11)
Procedures
- Odor Remediation After Water Intrusion (T-SB-0094-21 REV2)
- Welding Specifications & Substitutions - Crib # 181 (S-CRIB-181)
Rear Suspension
- Steering And Suspension Analysis And Repair - Crib # 187 (L-CRIB-187)
- Shock Absorber Replacement Criteria (T-SB-0145-11)
Restraints Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
- SRS & HV Wiring Repairs (T-CRIB-156)
- Passenger "Airbag Off" Light Illuminates Intermittently (T-SB-0092-12)
Seats
- Seat Cover Replacement For Side Airbag Equipped Vehicles (T-SB-0122-11 REV1)
Starter
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- 2012 My YARIS Pre-Delivery Service (PDS) (T-SB-0046-11)
- Long Term Vehicle Storage Guidelines (T-SB-0025-11)
Steering Linkage
- Steering And Suspension Analysis And Repair - Crib # 187 (L-CRIB-187)
Suspension Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
Transmission Control Systems
- GTS+ Ecu Flash Reprogramming Procedure (T-SB-0134-16 REV2)
Wheels & Tire System
- Tire Repair Resources (T-SB-0187-12 REV2)
- Flood Damaged Vehicle Inspection & Handling (T-SB-0229-12 REV1)
- Tire Inflation Pressure Compensation And Adjustment (T-SB-0020-11 REV2)
- Tire Positioning Before New Vehicle Delivery (T-SB-0021-11 REV2)
- Long Term Vehicle Storage Guidelines (T-SB-0025-11)
Window Motors & Regulators
- Loose Windshield Dam At Lower Right Corner Of Windshield (T-SB-0077-13)
Wiper/Washer Systems
- Wiper Blade Maintenance And Cleaning (T-SB-0185-13)
Wiring Diagrams
- Wire Harness Repair Or Replacement Guide (T-SB-0003-22)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Interior Electrical Component Precautions (T-SB-0182-17)