Service Program B
| Program point: | Km x 1000: | 132 | 144 | 156 | 168 | 180 | 192 | 204 | 216 | 228 | 240 |
|---|---|---|---|---|---|---|---|---|---|---|---|
| - | Year: | 11 | 12 | 13 | 14 | 15 | 16 | 17 | 18 | 19 | 20 |
| - | Miles x 1000: | 82.5 | 90 | 97.5 | 105 | 112.5 | 120 | 127.5 | 135 | 142.5 | 150 |
| Parking brake -check/adjust |
Should be checked when the car is driven into the workshop. Adjust on raised car. |
x | x | x | x | x | x | x | x | x | x |
| Exterior lighting -check function |
Should be checked when the car is driven into the workshop. | x | x | x | x | x | x | x | x | x | x |
| Washer/wipers for windshields and headlamps -check function/signs of wear |
- | x | x | x | x | x | x | x | x | x | x |
| Crankcase ventilation -clean |
Clean nipples and hoses. | - | x | - | - | - | x | - | - | - | x |
| Automatic transmission -check oil level |
x | x | x | x | x | x | x | x | x | x | - |
| Raise car | |||||||||||
| Engine oil Oil filter -drain the oil -replace the oil filter Reset the service reminder indicator (SRI). |
- | x | x | x | x | x | x | x | x | x | x |
| Automatic transmission The oil does not normally need changing. Oil change must be carried if instructed in the display information text. |
NOTE:
Cars used as taxis or primarily used for towing: Change oil every: 84,000 km/52,500 miles. See Reset the counter. |
- | - | - | x | - | - | - | - | - | - |
| Wheels and tires -check |
Check condition, signs of wear and pressure. | x | x | x | x | x | x | x | x | x | x |
| Drive shafts joints -check play |
x | x | x | x | x | x | x | x | x | x | - |
| -check rubber bellows | x | x | x | x | x | x | x | x | x | x | - |
| Brake pads/ rotors -check |
Minimum brake pad thickness: Front......3 mm/0.12 inches Rear......2 mm/0.08 inches. To measure front pad thickness see Service information: Section 5. Check brake disc thickness and condition when replacing brake pads. |
x | x | x | x | x | x | x | x | x | x |
| Brake and fuel lines -check for leakage/damage |
Including fuel filter and brake pipes. | - | x | - | - | - | x | - | - | - | x |
| Fuel filter -replace |
Service interval for replacing fuel filter: 168,000 km/105,000 miles. |
- | - | - | x | - | - | - | - | - | - |
| Exhaust system -check |
Check: condition, sealing/mounting. | x | x | x | x | x | x | x | x | x | x |
| Raise the front wheels | |||||||||||
| Front suspension and steering | - | - | - | - | - | - | - | - | - | - | - |
| -check for signs of wear | Including shock absorber. | x | x | x | x | x | x | x | x | x | x |
| Rear suspension | |||||||||||
| -check for signs of wear | Including shock absorber. Cars with detachable tow bar: Lubricate. |
x | x | x | x | x | x | x | x | x | x |
| Lower the car | |||||||||||
| Air filter cartridge -replace |
- | - | x | - | - | - | x | - | - | - | x |
| Spark plugs -replace |
See specification: | - | x | - | - | - | x | - | - | - | x |
| Fill engine oil | See specification: | x | x | x | x | x | x | x | x | x | x |
| Automatic transmission -check and adjust fluid level |
See specification: | - | x | - | x | - | x | - | x | - | x |
| Fluid levels - engine compartment -check/adjust See schedule. |
Brake, clutch and steering servo reservoirs and windshield washer fluid. | x | x | x | x | x | x | x | x | x | x |
| Coolant -check/adjust |
Anti-freeze rating/anti-corrosion agent. | x | x | x | x | x | x | x | x | x | x |
| Battery -check: poles, electrolyte level/installation |
See specification: | x | x | x | x | x | x | x | x | x | x |
| Auxiliary equipment, drive belt | - | - | - | - | - | - | - | - | - | - | - |
| -replace belt every 120,000 km/75,000 miles or: |
When replacing the decal must always be applied with date marking and mileage. | - | - | - | - | - | - | - | - | - | x |
| -replace the belt at 6 year intervals | Check decal after latest replacement. | x | - | x | - | - | - | - | - | - | - |
| Timing belt -replace belt every 168,000 km/105,000 miles or: |
When replacing the decal must always be applied with date marking and mileage. | - | - | - | x | - | - | - | - | - | - |
| -replace the belt at 10 year intervals | Check decal after latest replacement. | - | x | - | - | - | - | - | - | - | - |
| Belt tensioner -replace belt tensioner at every: 168,000 km/105,000 miles |
Applies to engines with mechanical belt tensioner. | - | - | - | x | - | - | - | - | - | - |
| Thermostat -replace thermostat every 168,000 km/105,000 miles |
Applies to six-cylinder engines. | - | x | - | - | - | - | - | - | - | - |
| Doors, hood -lubricate |
- | x | x | x | x | x | x | x | x | x | x |
| Brake fluid -replace See note on schedule. |
Replace every year 48,000 km/30,000 miles. | - | x | - | - | - | x | - | - | - | x |
|
NOTE:
If car is driven in mountainous areas or in humid climates the break fluid should be replaced every year.
|
x | x | x | x | x | x | x | x | x | x | - |