Technical Service Bulletins

A/C Compressor
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Prior Approval For A/C Compressor Replacement (TJ26147)
- P3 Ac System, Unusual Noise When Ac Compressor Is Running (TJ 29474)
- Solenoid, "SANDEN" Compressor (TJ29863)
- Ac Cleaning Fluid P/N 1161837 Discontinued (TJ28340)
- Service Campaign 254: A/C Compressor Drain Plug (TJ26609)
- Service Campaign 254: A/C Compressor Drain Plug (SMB87-254)
Accessories & Equipment
- Gloves For High Voltage Battery (33644.1.0)
- Newsletter 73: Mandatory Tools (ST-219)
- VIDA Hardware, Subscription, Infrastructure Requirements (SMB00-261 REV)
- VCT2000 Disposal (SMB00-295)
Accessories Control Systems
- VC App Issues After Renewing Voc Subscription (TJ 35987.3.0)
- Initial Quality Survey (IQS) PDS + (SMB17-026-2022-10-17)
- Parking Assistance System (Pas) Enhanced Troubleshooting (TJ26753.4.0)
- Control Module Swapping (TJ 31946.1.2)
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- Newsletter 75: Mandatory Tools (ST-222)
- SENSUS Downloading Problems. IAM 2.1 System (TJ26525.3.0)
- Engine Remote Start (ERS), Technical Information (TJ26767.1.8)
- "BLIS Service Required" Message In Dim Without DTC (TJ25252.7.0)
- SENSUS Navigation. IAM 2.1 Software Upgrade To Allow Map Upgrade Via USB (TJ31762.1.0)
- Software Download Guide (TJ20278.6.11)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Acc Disabled During Queue Assist (TJ27229)
- Newsletter 59: Mandatory Tools (ST-205)
- Content Of EUPDATES Associated With VIDA 2014B (SPJ28539)
- SENSUS Connected Touch (SCT) Unstable Or No GPS (TJ28137)
- SENSUS, BLUETOOTH Audio Disturbances (TJ28465)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Seat Memory Position 3 Lost Or Changed, Power Seat Module, PSM (TJ23715)
- SENSUS Connected Touch (SCT) ACU Upgrade Procedure (TJ28184)
- SENSUS Connected Touch (SCT); Firmware Upgrade Information And Time Zone Error (TJ28299)
- SENSUS Connected Touch (SCT); Activating IGO Navigation And "Scratch Code" (TJ28266)
- Improved 12 Volt Socket (TJ27466)
- SENSUS, IPHONE & Android Phones Do Not Connect To BLUETOOTH (TJ26145)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS, Unable To Pair Any Phones/Devices Using BLUETOOTH (TJ28056)
- SENSUS Connected Touch (SCT), "GPS Updating" Message (TJ 28019)
- New Logic On Seat Belt Reminder After Software Upgrade (TJ26361)
- Acc, "Radar Blocked See Manual" Message (TJ27239)
- Acc, Slight Speed Reduction Without Any Vehicle Ahead (TJ27177)
- SENSUS, Lost Sound From IPOD Function, IOS 5 And Newer (TJ25478)
- Distance Alert Does Not Keep Settings After Ignition Cycle (TJ27013)
- FSM DTC C1A6754 And C1A6768, Acc (TJ26288)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- VOLVO Accessory Rear Seat Entertainment (SMB39-008)
- Interrupted ICM Upgrade (TJ25318)
- Software Package Content When Ordering SENSUS SW (TJ25359)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
Accessory Drive Belts
- Squealing Noise At Engine Start (TJ26277)
Air Bag, SRS
- R10058/R10125/R10136 Driver Airbag Returns - Shipping Instruction (SMB88-010)
- R10058 Driver Airbag Returns - Shipping Instruction (PB88-010)
- Used Airbag Return/Disposal Pilot Program (SMB88-026)
- Airbag Unit/Steering Wheel, Creaking Noise (TJ 27799)
- Noise From CLOCKSPRING Area (TJ27905)
Anti-Lock Brakes
- Front Brake Pads, Early Or Uneven Wear On Right Side On 16" And 16.5" Brakes (TJ 33250.4.0)
Anti-Theft Systems
- DOORHANDLES Exterior, Not Fully Return (TJ25129.3.0)
- No Or Intermittent Unlocking Function From Door Handles (S60 W/ Keyless Drive) (TJ26520.8.1)
- Keyless Drive Receiver Issues (Short Remote Control Range, Key Messages) (TJ27316.7.2)
- Remote Control Does Not Work (TJ 28752)
- Handle BOOTLID (Lock Access Missing) (TJ27541)
- No Or Intermittent Unlocking Function From Door Handles (S60 W/Keyless Drive) (TJ26520)
- No Or Intermittent Unlocking Function From Door Handles (S60 W/ Keyless Drive) (TJ26520)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
Automatic Trans
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Rough 2-1 Downshifts, TF80SC (TJ 31210)
- AWD Generation5 DEM-P188971 (TJ29505)
- AWD Gen5 Noise And Vibration (TJ28043)
- Prior Approval No Longer Needed For TF80 Automatic Gearbox (TJ23342)
- VOLVO Service 2.0 (SMB39-013)
- Aw TF80SC: Rough Shifts, 5-4 Downshift, Neutral Control, N-D And/Or DTC P089500 (TJ26840)
- HALDEX Gen 5, No AWD Functionality (TJ29486)
- Aw TF80 SC - Hard 6-5 And/Or 2-1 Downshift Or No Upshift (TJ29050)
- Newsletter 59: Mandatory Tools (ST-205)
- Content Of EUPDATES Associated With VIDA 2014B (SPJ28539)
- Acc Disabled During Queue Assist (TJ27229)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Harsh 1-2 Up Shift TF80SC (TJ28959)
- Transmission And All Wheel Drive (AWD) Lubricants (TJ16773)
- HALDEX Gen5: Sludge On Oil Pump Strainer (TJ28485)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Gear Lever Knob Illumination (TJ27219)
- Differential Electronic Module (DEM) Software (SW) (TJ20756)
- P1 And P2 Can Module Recovery Method For Failed Software Download (TJ27236)
- Propeller (Prop) Shaft Removal And Installation Method (TJ27295)
- New Generation Automatic Transmission TF80, Policy For Transmission Repairs (SMB40-001)
- Gear Whine At 80-110 Kph, 50-70 Mph (TJ25918)
- Automatic Transmission Cooler/Lines Flushing (RTJ 19495)
Auxiliary Emission Control Systems
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
- Parts Return: 31201433 Vacuum Hose (PB52-032)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Leakage Diagnostic Function Improvements (TNN 28-74)
Auxiliary Power Unit
- Improved 12 Volt Socket (TJ27466)
Axle Shafts
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Unusual Noise While Driving From Sealing Ring (TJ 33524.2.0)
- Grease Leaking From Outside Drive Shaft Bellows (Boots) (TJ26943)
- Hub Bearing Splash Shields (TJ25167)
Battery Management Systems
- Proper 12 Volt Battery Handling Summary (SMB31-005)
Body Electrical
- VIN-Unique Wiring Harness Ordering (PB37-008)
- VIN-Unique Wiring Harness Ordering (TJ 35472.1.1)
Body Interior
- VC App Issues After Renewing Voc Subscription (TJ 35987.3.0)
- Control Module Swapping (TJ 31946.1.2)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- "BLIS Service Required" Message In Dim Without DTC (TJ25252.7.0)
- SENSUS Navigation. IAM 2.1 Software Upgrade To Allow Map Upgrade Via USB (TJ31762.1.0)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Workshop System And Guidelines 2015 Version: 1.0 (SMB00-331)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Lost Initialization Door Windows (TJ26054)
Brakes Control Systems
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Pulsation/Vibration While Braking (New Repair Method) (TJ 35833.1.1)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
Charging Systems
- Proper 12 Volt Battery Handling Summary (SMB31-005)
- Voltage Regulator Replacement Recommended Instead Of Alternator Replacement (TJ26897.3.0)
- MIDTRONICS PSC-550S And PSC-700 Vehicle Power Supply (ST-111A)
- Squealing Noise At Engine Start (TJ26277)
- Importance Of Vehicle In Stock Battery Maintenance (SMB17-2013)
Collision/Avoidance
- Parking Assistance System (Pas) Enhanced Troubleshooting (TJ26753.4.0)
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- "BLIS Service Required" Message In Dim Without DTC (TJ25252.7.0)
- Acc Disabled During Queue Assist (TJ27229)
- Mandatory Tool - 9997483 Hole Punch (ST-204)
- No Image From PAC Camera When Engaging Reverse Gear (TJ28309)
- Acc, "Radar Blocked See Manual" Message (TJ27239)
- Acc, Slight Speed Reduction Without Any Vehicle Ahead (TJ27177)
- Distance Alert Does Not Keep Settings After Ignition Cycle (TJ27013)
- FSM DTC C1A6754 And C1A6768, Acc (TJ26288)
- Pedestrian Detection With Full Auto Brake Demonstration (SMB17-014)
Communication Devices
- Remote Connection, BOMGAR Application (TJ 8501.13.0)
- Vehicle/Connectivity Report Checklist (TJ 37175.1.1)
- Control Module Swapping (TJ 31946.1.2)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- Acc Disabled During Queue Assist (TJ27229)
- SENSUS, BLUETOOTH Audio Disturbances (TJ28465)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS, Unable To Pair Any Phones/Devices Using BLUETOOTH (TJ28056)
- SENSUS, Lost Sound From IPOD Function, IOS 5 And Newer (TJ25478)
- SENSUS ICM Display Functionality SW Improvements And Quick Guide (SMB39-011)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- Bpm And Mobile Phone Compatibility. (TJ13753)
- SENSUS, No Sound From IPHONE Media After Start Up (TJ25640)
- Handling Of BLUETOOTH Phone Module (Bpm) Compatibility Questions (RTJ 23691)
- Accessory RSE Headrest Harness Replacement (RTJ 24111)
- VOLVO On Call® New IPHONE® App - Now Available (SMB00-301)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
Cooling System (Mechanical)
- Coolant Filling Equipment Tool (SJ1000167)
- Coolant Filling Equipment (TJ 30971)
- Coolant Discoloration (TJ29984)
Cruise Control Systems
- Acc Disabled During Queue Assist (TJ27229)
- Acc, Slight Speed Reduction Without Any Vehicle Ahead (TJ27177)
- FSM DTC C1A6754 And C1A6768, Acc (TJ26288)
Differentials & Drive Axles
- Unusual Noise While Driving From Sealing Ring (TJ 33524.2.0)
- Newsletter 75: Mandatory Tools (ST-222)
- Vibrations In AWD Vehicle (TJ27227.4.0)
- Propeller (Prop) Shaft Removal And Installation Method (TJ27295)
Driveshaft & Universal Joints
- All Wheel Drive (AWD) Vibrations On Acceleration (TJ29457)
- Propeller (Prop) Shaft Removal And Installation Method (TJ27295)
Engine Control Systems
- SW Part Numbers For Total Upgrade And PDS (TJ 27536.21.1)
- Control Module Swapping (TJ 31946.1.2)
- Engine Remote Start (ERS), Technical Information (TJ26767.1.8)
- VOLVO Service 2.0 (SMB39-013)
- Content Of EUPDATES Associated With VIDA 2014D (SPJ28541)
- Vantage Pro Oscilloscope Update - 14.4 Software Release Supersedes The June 10, 2014 Edition (150A)
- Polestar Calibration Identification (TJ29552)
- Content Of EUPDATES Associated With VIDA 2014B (SPJ28539)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Workshop System And Guidelines 2015 Version: 1.0 (SMB00-331)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- SENSUS Connected Touch (SCT) ACU Upgrade Procedure (TJ28184)
- Incorrect Si6 Crankshaft Position Indicated In VIDA Procedure (TJ27906)
- P1 And P2 Can Module Recovery Method For Failed Software Download (TJ27236)
- My 2013 S60 T5 Transmission Control Module Parameters In VIDA 2012C (TJ26892)
- Leakage Diagnostic Function Improvements (TNN 28-74)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- Suddenly Drained Battery Due To Non Approved Engine SW (RTJ 23952)
Entertainment Systems
- Control Module Swapping (TJ 31946.1.2)
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- SIRIUSXM Tuner Replacement Process (TJ 31535.1.3)
- SIRIUSXM Radio INOP Or No Sound On Sat Source (TJ 34021.1.1)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- SENSUS Downloading Problems. IAM 2.1 System (TJ26525.3.0)
- SENSUS Navigation. IAM 2.1 Software Upgrade To Allow Map Upgrade Via USB (TJ31762.1.0)
- SENSUS Navigation; Obtaining Map Activation Codes And Converting Maps (TJ 27419)
- SENSUS; Audio Mute Logic (TJ29025)
- SENSUS Connected Touch (SCT), No Media Menu (TJ28580)
- SENSUS, BLUETOOTH Audio Disturbances (TJ28465)
- SENSUS, IPHONE & Android Phones Do Not Connect To BLUETOOTH (TJ26145)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS, Unable To Pair Any Phones/Devices Using BLUETOOTH (TJ28056)
- SENSUS Connected Touch (SCT), "GPS Updating" Message (TJ 28019)
- SENSUS - Map Update Failures During Upgrade (TJ26411)
- SENSUS, Lost Sound From IPOD Function, IOS 5 And Newer (TJ25478)
- RSE Opening Mechanism - Modification (TJ25377)
- SENSUS ICM Display Functionality SW Improvements And Quick Guide (SMB39-011)
- Satellite Radio Tuner & General Fault Tracing For Reception Problems (SIRIUS) (TJ25130)
- SENSUS RTI Map Version Information (TJ26256)
- Stuck CDS In Audio Units (SMB39-004)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- SENSUS System, No Sound Or Button Function Etc. (TJ25549)
- SENSUS, No Sound From IPHONE Media After Start Up (TJ25640)
- Battery Current Consumption And RDAR (TJ25590)
- VOLVO Accessory Rear Seat Entertainment (SMB39-008)
- Interrupted ICM Upgrade (TJ25318)
- Software Package Content When Ordering SENSUS SW (TJ25359)
- SENSUS System With DVD Player, RTI Map Or Video Not Displayed In The ICM (TJ23490)
- Accessory RSE (HEADRESTRAINT DVD) Warranty Coverage And Claim Procedure (SMB39-005)
- Accessory RSE Headrest Harness Replacement (RTJ 24111)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- All New S60: Incorrect Power Supply Connection Causing SWDL Problems (RTJ 23623)
Exhaust
- Oxygen Sensor Thread Repair Method (TJ 35818.1.1)
Exterior Body Panels
- Keyless Drive Receiver Issues (Short Remote Control Range, Key Messages) (TJ27316.7.2)
- Wind Noise, Front And Rear Door Area (TJ28994)
- Rescue Information - My15 (27691)
- Handle BOOTLID (Lock Access Missing) (TJ27541)
- Knocking Noise From The Fuel Tank (TJ28641)
- BAGHOLDER Strap Comes Loose (TJ27442)
- Mechanical Opening Of TRUNKLID In Event Of Electrical Failure (TJ 27551)
- No Or Intermittent Unlocking Function From Door Handles (S60 W/ Keyless Drive) (TJ26520)
- Creaking Noise From Door Striker Area (TJ26867)
- Squeaking Or Creaking Noise From Side Doors (TJ16308)
- Fuel Cap, Broken Strap (TJ24879)
- Corroded License Plate Fasteners (TJ25142)
- Replacement Of Structural Parts On VOLVO Vehicles (SMB00-310)
- Trunk Lid Hard To Open/Close (RTJ 24237)
Exterior Lights
- Left Front Led Flickers After Turning Car Off - Check Outer Position Bulbs (TJ 36584.1.1)
- Headlight Restoration (TJ24584)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
- Exterior Incandescent Bulb Replacement (SMB35-015)
Frames, Subframes & Crossmembers
- Mandatory Tool - 9997483 Hole Punch (ST-204)
Front Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Noise From Ball Joint Front Control Arm (TJ 28204)
Fuel System
- Knocking Noise From The Fuel Tank (TJ28641)
- Parts Return: 31201433 Vacuum Hose (PB52-032)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Leakage Diagnostic Function Improvements (TNN 28-74)
- Fuel Cap, Broken Strap (TJ24879)
- E10 Petrol Fuel Requirements (SMB23-035)
Fuses & Circuit Breakers
- VIN-Unique Wiring Harness Ordering (PB37-008)
- VIN-Unique Wiring Harness Ordering (TJ 35472.1.1)
Gauges & Instrument Panels
- All New S60: Incorrect Power Supply Connection Causing SWDL Problems (RTJ 23623)
General Servicing
- Ac Cleaning Fluid P/N 1161837 Discontinued (TJ28340)
Headlights
- Left Front Led Flickers After Turning Car Off - Check Outer Position Bulbs (TJ 36584.1.1)
- Digital Head Light Instrument For L.E.D., Halogen, Xenon Vehicles (32242.3.0)
- Moisture In Headlamp, Leak Test (TJ17076.11.0)
- Headlight Restoration (TJ24584)
HVAC Control Systems
- Animation: Evaporator Climate Unit, Cleaning (SPJ32811.2.0)
- Air Vents, Blisters/Bubbles (TJ19967)
- P3 Ac System, Unusual Noise When Ac Compressor Is Running (TJ 29474)
- Climate Unit, Odor Or Bad Smell (TJ17817)
- Climate Unit Fan Motor, Noise Or Does Not Work (TJ27558)
- Ac Cleaning Fluid P/N 1161837 Discontinued (TJ28340)
- Temperature Dropping During Driving, Climate/Heater Unit (TJ18674)
- Cooling Unit, Fault Tracing Guideline (TJ26262)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
Identification
- Vehicle Type And Platform Identification (TJ19245.1.19)
- Expendable Items Parts List (SMB00-108D)
- New Shipping Address And Label (SMB00-012)
- VIN Plate And VIN Specific Labeling Ordering Procedure (SMB89-005)
- Rescue Information - My15 (27691)
- Battery Analyzer Set-Up Clarification (TJ26090)
Infotainment
- SENSUS/SENSUS Connect Navigation Base Map Versions (TJ 35058.1.4)
- Control Module Swapping (TJ 31946.1.2)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- Map Upgrade Warranty Policy (SMB00-427)
- SENSUS Downloading Problems. IAM 2.1 System (TJ26525.3.0)
- SENSUS Navigation. IAM 2.1 Software Upgrade To Allow Map Upgrade Via USB (TJ31762.1.0)
- SENSUS, Navigation Map Versions (TJ27567)
- Lifetime MAPCARE (TJ 29181)
- SENSUS Navigation; Obtaining Map Activation Codes And Converting Maps (TJ 27419)
- Acc Disabled During Queue Assist (TJ27229)
- SENSUS MAPCARE 2014 Update: Information And Map Loading Instructions (TJ26064)
- Mandatory Tool - 9997483 Hole Punch (ST-204)
- SENSUS Connected Touch (SCT) Unstable Or No GPS (TJ28137)
- SENSUS Connected Touch (SCT); Firmware Upgrade Information And Time Zone Error (TJ28299)
- SENSUS Connected Touch (SCT); Activating IGO Navigation And "Scratch Code" (TJ28266)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS Connected Touch (SCT), "GPS Updating" Message (TJ 28019)
- Acc, "Radar Blocked See Manual" Message (TJ27239)
- Acc, Slight Speed Reduction Without Any Vehicle Ahead (TJ27177)
- SENSUS, Navigation Displays "Navigation Please Wait..." Message At Startup (TJ 27568)
- SENSUS - Map Update Failures During Upgrade (TJ26411)
- SENSUS ICM Display Functionality SW Improvements And Quick Guide (SMB39-011)
- HOMELINK, No Function (TJ25609)
- SENSUS RTI Map Version Information (TJ26256)
- SENSUS: Map Care 2012 Update (SMB39-010)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- SENSUS System, No Sound Or Button Function Etc. (TJ25549)
- RTI System Identification Guide (TJ17424)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
- SENSUS System With DVD Player, RTI Map Or Video Not Displayed In The ICM (TJ23490)
- Accessory RSE Headrest Harness Replacement (RTJ 24111)
- New SW Upgrade Disc For RTI, Mmm, Mmm+ And Mmm2 Available (TJ15493)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
Interior/Exterior Trim
- Service Action S89833 Replace Headliner Clip (S89833)
- Extended Warranty P89405, VOLVO Emblem On Radiator Grille Iron Mark Logo (TJ25957.3.6)
- Air Vents, Blisters/Bubbles (TJ19967)
- Center Console, Creaking Noise (TJ 29264)
- Extended Warranty P89405: VOLVO Emblem On Radiator Grille Iron Mark Logo Model Year 2010 - 2013 S80, S60, V70, XC70, XC60, XC90, S40, V50, C30, C70 (P89405)
- Rear Door B-Pillar Seal, Creaking Noise (TJ29705)
- Wind Noise Around The A-Pillar Area (TJ28361)
- No Or Intermittent Unlocking Function From Door Handles (S60 W/Keyless Drive) (TJ26520)
- BAGHOLDER Strap Comes Loose (TJ27442)
- HOMELINK, No Function (TJ25609)
- Retail Car Delivery Process All My 2013 (SMB17-2013)
- Corroded License Plate Fasteners (TJ25142)
Lubrication System
- Extended Warranty P10183: 15T Oil Consumption Replace; Model Year 2013-2016 S60, 2015-2016 V60, V60CC And XC60, 2016 XC70, S60CC And S60L (P10206)
- Extended Warranty P10206: I5T Oil Consumption Test; Model Year 2013-2016 S60, 2015-2016 V60, V60CC And XC60, 2016 XC70, S60CC And S60L (P10206)
- High Oil Consumption. Engine 61 (TJ 34588.4.1)
- Expendable Items Parts List (SMB00-108D)
- Engine Oil Consumption Test FAQ (SMB22-006)
- 4 Cylinder VEP Engine: CASTROL Edge Professional V 0W-20 Synthetic Oil (TJ 34740.1.4)
- Expendable Items Reimbursement - Oil (SMB22-206)
- Prior Approval: Oil Consumption, "Low Oil Level" Or "Oil Level Low" In Dim (TJ24643)
- Prior Approval: Si6/Si6T ULEV/T Engine Code 95/90 Excessive Oil Consumption (TJ30021)
- Engine Oil Leak From Oil Duct Plug (TJ17714)
- Oil Volume Correction (SMB22-002)
- Required Engine Oils (12,000 Km Intervals) (SMB22-003C)
- Required Engine Oils (Synthetic) (SMB22-001C)
- Required Engine Oils (7,500 Miles/12,000 Km Intervals) (SMB22-003)
- Oil Consumption, Low Or Uneven Idle, "Low Oil Level" Or "Oil Level Low" In Dim (RTJ 24643)
Manual Steering
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
Manual Trans
- Transmission And All Wheel Drive (AWD) Lubricants (TJ16773)
Mechanical
- High Oil Consumption. Engine 61 (TJ 34588.4.1)
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Newsletter 112: Mandatory Tools (ST-255)
- VOLVO Engine Oil Consumption (SMB22-007)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Prior Approval: Oil Consumption, "Low Oil Level" Or "Oil Level Low" In Dim (TJ24643)
- Prior Approval: Si6/Si6T ULEV/T Engine Code 95/90 Excessive Oil Consumption (TJ30021)
- Engine Oil Leak From Oil Duct Plug (TJ17714)
- Timing Belt Replacement Interval For Model Years 1999 And Up (SMB21-14)
- Oil Volume Correction (SMB22-002)
- Cam Cover (Valve Cover) Reseal Procedure, Additional Information (TJ28312)
- Oil Leak From Unused Bolt Hole (TJ26765)
- Camshaft Timing Belt TENSIONER (TJ27234)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Squealing Noise At Engine Start (TJ26277)
- Required Engine Oils (12,000 Km Intervals) (SMB22-003C)
- Required Engine Oils (Synthetic) (SMB22-001C)
- Required Engine Oils (7,500 Miles/12,000 Km Intervals) (SMB22-003)
- Oil Consumption, Low Or Uneven Idle, "Low Oil Level" Or "Oil Level Low" In Dim (RTJ 24643)
Mechanical - Hydraulic
- Pulsation/Vibration While Braking (New Repair Method) (TJ 35833.1.1)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Front Brake Pads, Early Or Uneven Wear On Right Side On 16" And 16.5" Brakes (TJ 33250.4.0)
- Front Brake Caliper - Moan Noise (TJ30393.5.0)
- Front Brake Caliper - Noise (TJ 30393)
- Front Brake Caliper - Noise (TJ30393)
- Specification Change, Rear Ventilated Brake Disc Thickness (TJ29045)
- Front Brakes 16" (FN3) Squealing Noise While Reversing In Low Speed (TJ26889)
Memory Modules
- Control Module Swapping (TJ 31946.1.2)
Mirrors
- Outer Rear View Mirror, Play In Mirror (TJ30619)
- Outer Rear View Mirrors, Folding/Noise Issue (TJ 30914)
- Outer Rear View Mirrors, Folding/Noise Issue (TJ30914)
Parking Brake System
- Parking Brake (EPB), Not Possible To Get Brake Caliper In Service Position (TJ27500)
Passive Restraints
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Seat Belt Extender - 850, 900, S90, V90, V90CC, S/V40, V50, S/V60, V60CC, S/V70, XC70, C30, C70, S80, XC40, XC60, XC90 (SMB88-001A)
Procedures
- Vehicle/Connectivity Report Checklist (TJ 37175.1.1)
- Data Requests From Lea (Police) And/Or Customers (TJ 28941.5.0)
- Newsletter 112: Mandatory Tools (ST-255)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- High Voltage (HV) Module Balancer Cart (ST-251)
- VIDA Updated Graphical Plotter Functionality Applications - VIDA (SJ1000785)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Method For Interior Cleaning (Information Only) (TJ 35475.1.2)
- Newsletter 105: Mandatory Tools (ST-237)
- Recall Compliance Clearance Letter Requests (SMB00-440)
- GDPR - Information Notice (SPJ34864.2.0)
- Not Possible To Left Click Ecus In The Network Image For Non-Spa Cars (US34753.1.0 EN-US)
- VOLVO Complimentary Factory Scheduled Maintenance 'FSM330' My2013 And Later (SMB00-321)
- Software Installation Policy (SMB00-006C)
- Configuration Test Software (TJ 33057.1.1)
- P3 Software Download Guide (TJ32688.1.1)
- The VOLVO Carefree Coverage Plan My2013 Vehicles (SMB00-324)
Rear Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Knocking/Rumbling Noise From Rear Suspension, Upper Spring Seat To Body (TJ20251)
Restraints Control Systems
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Noise From CLOCKSPRING Area (TJ27905)
- New Logic On Seat Belt Reminder After Software Upgrade (TJ26361)
Schedule
- VOLVO Complimentary Factory Scheduled Maintenance 'FSM330' My2013 And Later (SMB00-321)
- VOLVO FSM Upgrade Program (SMB00-320)
- VOLVO Protection Plus+ Factory Scheduled Maintenance (SMB00-317)
- VIDA Service Maintenance Schedules Reference (SMB00-294)
Seats
- Interior Seat Protection Kit (SMB85-002)
- Seat Belt Catch, Foreign Objects (TJ19383.8.0)
- Allocation For Seat Belt Recall (PB88-R10029)
- P3 Front Seat Backrest, Too Much Play (TJ 32509.1.0)
- Knocking/Rumbling Noise From Rear Suspension, Upper Spring Seat To Body (TJ20251)
- Seat Memory Position 3 Lost Or Changed, Power Seat Module, PSM (TJ23715)
- VOLVO Accessory Rear Seat Entertainment (SMB39-008)
- Accessory RSE (HEADRESTRAINT DVD) Warranty Coverage And Claim Procedure (SMB39-005)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
Starter
- Proper 12 Volt Battery Handling Summary (SMB31-005)
- Engine Remote Start (ERS), Technical Information (TJ26767.1.8)
- Importance Of Vehicle In Stock Battery Maintenance (SMB17-2013)
- Battery Analyzer Set-Up Clarification (TJ26090)
- Spare Part Battery Date Codes (SMB31-003)
- Spare Part Battery Date Codes (TJ25935)
- Battery Current Consumption And RDAR (TJ25590)
- Safety Precautions When Working With Lead Acid Batteries (RTJ 24188)
- Suddenly Drained Battery Due To Non Approved Engine SW (RTJ 23952)
- All New S60: Incorrect Power Supply Connection Causing SWDL Problems (RTJ 23623)
Steering Column
- Interior Seat Protection Kit (SMB85-002)
- Steering Wheel, Clicking Noise (TJ 36170.1.0)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- VOLVO Logo On Steering Wheel, Replacement (TJ31750.3.0)
- Airbag Unit/Steering Wheel, Creaking Noise (TJ 27799)
- Noise From CLOCKSPRING Area (TJ27905)
Steering Control Systems
- Control Module Swapping (TJ 31946.1.2)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
Steering Gear
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Oil Leakage Into The Bellows, Standard Steering Gear (TJ15636)
- O-Rings Available As Spare Parts; Steering Gear (TJ30813)
Suspension Control Systems
- Control Module Swapping (TJ 31946.1.2)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
System
- SW Part Numbers For Total Upgrade And PDS (TJ 27536.21.1)
- Control Module Swapping (TJ 31946.1.2)
- Engine Remote Start (ERS), Technical Information (TJ26767.1.8)
- VOLVO Service 2.0 (SMB39-013)
- Content Of EUPDATES Associated With VIDA 2014D (SPJ28541)
- Polestar Calibration Identification (TJ29552)
- Content Of EUPDATES Associated With VIDA 2014B (SPJ28539)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Incorrect Si6 Crankshaft Position Indicated In VIDA Procedure (TJ27906)
- P1 And P2 Can Module Recovery Method For Failed Software Download (TJ27236)
- My 2013 S60 T5 Transmission Control Module Parameters In VIDA 2012C (TJ26892)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
Towing
- Tow Damage Claims (SMB00-040)
- VOLVO Roadside Assistance On Call® On Call® Advantage (SMB00-056)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
Towing Systems
- Tow Damage Claims (SMB00-040)
Transfer Case
- DEM-P188918 And AWD Disabled Message In Dim (TJ31292)
- Vibrations In AWD Vehicle (TJ27227.4.0)
- AWD Generation5 DEM-P188971 (TJ29505)
- HALDEX Gen 5, No AWD Functionality (TJ29486)
- Transmission And All Wheel Drive (AWD) Lubricants (TJ16773)
- DEM-P188918, Changed Fault-Tracing (TJ28879)
- HALDEX Gen5: Sludge On Oil Pump Strainer (TJ28485)
Transmission Control Systems
- Control Module Swapping (TJ 31946.1.2)
- TF80/Rough Shift N-D And/Or 5-4 (TJ32169.9.0)
- TF80 Rough Or Jerky Shift In N-D (TJ 33901.4.0)
- DEM-P188918 And AWD Disabled Message In Dim (TJ31292)
- AWD Gen5 Noise And Vibration (TJ28043)
- VOLVO Service 2.0 (SMB39-013)
- Aw TF80SC: Rough Shifts, 5-4 Downshift, Neutral Control, N-D And/Or DTC P089500 (TJ26840)
- HALDEX Gen 5, No AWD Functionality (TJ29486)
- Gearshift Service Required (TJ29426)
- Aw TF80 SC - Hard 6-5 And/Or 2-1 Downshift Or No Upshift (TJ29050)
- Newsletter 59: Mandatory Tools (ST-205)
- Content Of EUPDATES Associated With VIDA 2014B (SPJ28539)
- Acc Disabled During Queue Assist (TJ27229)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Harsh 1-2 Up Shift TF80SC (TJ28959)
- DEM-P188918, Changed Fault-Tracing (TJ28879)
- Workshop System And Guidelines 2015 Version: 1.0 (SMB00-331)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- SENSUS Connected Touch (SCT) ACU Upgrade Procedure (TJ28184)
- Differential Electronic Module (DEM) Software (SW) (TJ20756)
- P1 And P2 Can Module Recovery Method For Failed Software Download (TJ27236)
- New Generation Automatic Transmission TF80, Policy For Transmission Repairs (SMB40-001)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
Warning Systems
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- No Image From PAC Camera When Engaging Reverse Gear (TJ28309)
- New Logic On Seat Belt Reminder After Software Upgrade (TJ26361)
- Pedestrian Detection With Full Auto Brake Demonstration (SMB17-014)
Wheel Alignment
- Wheel Alignment Data (TJ19674)
- Alignments: 'BEFORE' And 'AFTER' Measurements Required (RTJ 16704)
Wheel Hubs
- Hub Bearing Splash Shields (TJ25167)
Wheels & Tire System
- Center Wheel Caps, Removal Instruction (TJ 28739.3.0)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- Winter Wheel Applications (PB77-006)
- Brake Vibrations Due To Lockable Wheel Screws (TJ 33239.1.0)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Wheel Cross Reference (PB77-017)
- VOLVO Recommended Winter Tires (77-013)
- CONTIPROCONTACT 235/40 R18 All Season Tire (TJ26438)
- Retail Car Delivery Process All My 2013 (SMB17-2013)
- Tire Rotation (SMB77-007)
Window Motors & Regulators
- Windshield Cleaning (SMB00-444)
- Windshield POWERCURE Dispenser And Adhesive (SMB84-001)
- Wind Noise, Front And Rear Door Area (TJ28994)
- Lost Initialization Door Windows (TJ26054)
- Retail Car Delivery Process All My 2013 (SMB17-2013)
Wiper/Washer Systems
- Washer System Layout For Identifying Leakage Points (TJ25153.7.3)
- VOLVO Wiper Blade Warranty Replacement Policy (SMB00-425)
- Retail Car Delivery Process All My 2013 (SMB17-2013)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Improved 12 Volt Socket (TJ27466)