Test requirements
- "Automatic Test Sequence" carried out to establish that any malfunctions stored in Transmission Control Module (TCM) and Engine Control Module (ECM) only affect ABS/ESP.
- Connect VAS5051 tester or VAG1551 scan tool and select the address word 00 (with ignition on). See VAG1551 SCAN TOOL (ST), CONNECTING AND ENTERING ADDRESS WORD .
- After completing electrical testing, check and erase DTC memories of Transmission Control Module (TCM) and Engine Control Module (ECM).
- Multi-pin harness connector for ABS Control Module (w/EDL) -J104- in proper condition, with no bent, broken or corroded terminals. Replace any damaged terminals using VAS1978 wiring repair kit.
Courtesy of AUDI OF AMERICA, INC.
NOTE: The instruction manual for the VAS1978 wiring harness repair kit generally forbids the repair of any lines in the ABS or related systems. This rule only pertains to the shielded lines in these systems. - Ignition and electrical consumers switched off before beginning testing (headlights, lighting, fan, etc.).
- For steps 13 through 16, raise the vehicle until the wheels rotate freely. On vehicles with manual transmission put the gear shift lever in neutral. On vehicles with automatic transmission move the selector lever to position "N."
- Multi-pin harness connector for ABS Control Module (w/EDL) -J104- in proper condition, with no bent, broken or corroded terminals. Replace any damaged terminals using VAS1978 wiring repair kit.
Special tools and equipment required:
- VAS5051 tester or VAG1551 scan tool or VAG1552 scan tool
- VAG1598/20 test box
- Connector test kit VAG1594
- Multimeter (Fluke 83 or equivalent)
- Pressure gauge VAG1310A
Connecting VAG1598/20 test box and checking ESP system
- Switch ignition off.
- Remove ABS Control Module (w/EDL) -J104-.
See ANTILOCK BRAKE SYSTEM .
- Disconnect multi-pin connector from ABS Control Module (w/EDL) -J104-.
- Check multi-pin connector between harness connector and ABS Control Module (w/EDL) -J104-.
The socket designations on the VAG1598/20 test box are identical to the terminal designations on the ABS Control Module (w/EDL) -J104- and on the wiring harness connector.
- Connect VAG1598/20 test box to multi-pin connector of wiring harness.
- For wiring diagrams, see appropriate System Wiring Diagrams article.