Section 3154 (Steering And Wheel Alignment - Repair - E91)
WARNING: This page is about a different car, the 2012 BMW 328i, 2011 BMW 328i, 2010 BMW 328i, and 2009 BMW 328i. However, it is still accessible from the selected car via links, so may be relevant.
- 3200 Electronic Chassis Alignment
- 32 00 620 Adjusting rear axle
- 32 00 610 Adjusting toe-in and camber on front axle
- 32 10 005 Adjustment for active front steering
- 61 31 996 Carrying out steering angle sensor adjustment
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 31 00... Front axle + steering: wheel/chassis alignment check after specified work
- 32 00... General chassis and suspension definitions
- 32 00... General information and definitions
- 32 00... Identification of suspension without label
- 32 00... Identifying suspension from label on front axle
- 32 00... Information on replacing steering gear after accident damage
- 32 00 155 KDS chassis/wheel alignment check with ride height measurement without vehicle load
- 32 00 150 KDS chassis/wheel alignment check with vehicle load up to design position
- 32 00... Moving vehicle into design position
- 32 00... Moving vehicle into normal position
- 32... Overview of steering
- 32...... Overview of steering wheel/casing components
- 32 00... Performing rim runout compensation
- 00...... Raising vehicle with trolley jack
- 33 00... Rear axle: wheel/chassis alignment check must be carried out after the following work
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00 Safety instructions for handling oil
- 32 00... Test conditions for chassis/wheel alignment check
- 3211 Mechanical Steering Gear
- 32 00... Information on replacing steering gear after accident damage
- 32 11... Notes on checking steering backlash on vehicles with rack-and-pinion steering (with front axle raised)
- 32 11... Replacing gaiter for electric steering gear (EPS) on left or right
- 32 11 100 Replacing gaiter for steering gear on left or right
- 3213 Steering Gear With Servo Unit
- 32 13 006 Bleeding power steering unit
- 32 00... Information on replacing steering gear after accident damage
- 32 13 070 Removing and installing (replacing) electric steering gear (EPS)
- 32 13 065 Removing and installing/replacing active front steering power steering gear
- 32 13 060 Removing and installing/replacing power steering gear
- 32 11... Replacing gaiter for electric steering gear (EPS) on left or right
- 3221 Steering Arms, Tie Rods, Steering Damper
- 3231 Steering Column
- 32 31 020 Removing and installing/replacing lower section of steering column trim
- 32 31 070 Removing and installing/replacing lower section of steering shaft
- 32 31 082 Removing and installing/replacing steering angle sensor
- 32 31 090 Removing and installing/replacing steering column
- 32 31 003 Removing and installing/replacing upper section of steering column trim
- 32 31 241 Replacing adjusting lever for steering column
- 32 31 102 Replacing steering shaft sleeve
- 3233 Steering Wheel
- 3234 Steering Wheel For Airbag
- 65 77... Notes on scrapping BMW vehicles with gas generators (central airbag control unit, airbag system)
- Notes
- Gas generators that have not fired constitute a hazard (also to the environment)!
- Firing failure
- The components of an airbag system must always be disposed of. Such components must not be sold on as used parts
- 1. Vehicles with central airbag control unit (all airbags, seat belt tensioners, battery safety terminal)
- 72 12... Procedure after airbag triggering as result of an accident
- 32 34 020 Removing and installing/replacing airbag unit
- 32 34 030 Removing and installing/replacing airbag unit (sport steering wheel)
- 72 00... Safety regulations for handling components with gas generators
- 65 77... Notes on scrapping BMW vehicles with gas generators (central airbag control unit, airbag system)
- 3241 Pump And Oil Supply
- 32 13 006 Bleeding power steering unit
- 32 41... Instructions for removing and installing ear clips
- 32 41... Instructions for using special tool 32 4 000
- 32 41... Notes on hydraulic line with quick-connect coupling
- 32 41 033 Removing and installing (replacing) power steering pump for power steering gear with active front steering
- 32 41 253 Removing and installing/replacing fluid reservoir for power steering with active front steering
- 32 41 060 Removing and installing or replacing hydraulic steering vane pump (N51, N52, N53)
- 32 41 100 Removing and installing/replacing belt pulley on vane pump for power steering
- 32 41 250 Removing and installing/replacing fluid reservoir for power steering
- 32 41 341 Replacing cooler return line for power steering
- 32 41 332 Replacing delivery line for power steering (N51, N52, N53)
- 32 41 311 Replacing intake line for power steering (N51, N52, N53)
- 32 41 332 Replacing pressure line for power steering (N51, N52, N53 AWD)
- 32 41 351 Replacing return line for power steering (N51, N52, N53)
- 3243 Electronic Power Steering