Section 12 (Engine Control System - Basic Engine Testing - 3.8L): Introduction
WARNING: This page does not describe the selected car, but rather 11 other vehicles, including the 1997 Pontiac Grand Prix, 1997 Pontiac Firebird, 1997 Pontiac Bonneville, 1997 Oldsmobile Regency, and 1997 Oldsmobile LSS. However, it is still accessible from the selected car via links, so may be relevant.
The following diagnostic steps will help prevent overlooking a simple problem. This is also where to begin diagnosis for a no-start condition.
The first step in diagnosing any driveability problem is verifying the customer's complaint with a test drive under the conditions during which the problem reportedly occurred.
Before entering self-diagnostics, perform a careful and complete visual inspection. Most engine control problems result from mechanical breakdowns, poor electrical connections or damaged/misrouted vacuum hoses. Before condemning the computerized system, perform each test listed in this article.
NOTE:
Unless otherwise instructed in test procedures, perform all voltage tests using a Digital Volt-Ohmmeter (DVOM) with a minimum 10-megohm input impedance.
The following table provides the location of commonly used diagnostic information.
GENERAL MOTORS REFERENCE
| System Or Component | Diagnostic Information Location | ||||
|---|---|---|---|---|---|
| Malfunction Indicator Light (MIL) | See ON-BOARD DIAGNOSTIC (OBD) SYSTEM CHECK | ||||
| DLC Diagnosis | See ON-BOARD DIAGNOSTIC (OBD) SYSTEM CHECK | ||||
| No-Start Diagnosis | See NO START - ENGINE CRANKS OKAY | ||||
| No Scan Tool Data | See ON-BOARD DIAGNOSTIC (OBD) SYSTEM CHECK | ||||
| Fuel Pump Relay | See FUEL SYSTEM in SYSTEM/COMPONENT TESTS article | ||||
| Fuel System Diagnosis | See BASIC FUEL SYSTEM CHECKS | ||||
| MAP Sensor | See ENGINE SENSORS & SWITCHES in SYSTEM/COMPONENT TESTS article | ||||
| Power Steering Pressure Switch | See ENGINE SENSORS & SWITCHES in SYSTEM/COMPONENT TESTS article | ||||
| Transmission Range Switch | See ENGINE SENSORS & SWITCHES in SYSTEM/COMPONENT TESTS article | ||||
| Injector Balance Test | See FUEL SYSTEM in SYSTEM/COMPONENT TESTS article | ||||
| Injector Leak Test | See FUEL SYSTEM in SYSTEM/COMPONENT TESTS article | ||||
| IAC Motor | See IDLE CONTROL SYSTEM in SYSTEM/COMPONENT TESTS article | ||||
| Canister Purge System | See EMISSION SYSTEMS & SUB-SYSTEMS in SYSTEM/COMPONENT TESTS article | ||||
| Knock Sensor Check | See IGNITION SYSTEM in SYSTEM/COMPONENT TESTS article | ||||
| Air Injection System | See EMISSION SYSTEMS & SUB-SYSTEMS in SYSTEM/COMPONENT TESTS article | ||||
| EGR System | See EMISSION SYSTEMS & SUB-SYSTEMS in SYSTEM/COMPONENT TESTS article | ||||
| 1-4 Upshift System (Manual Transmission) | See MISCELLANEOUS CONTROLS SYSTEM/COMPONENT TESTS article | ||||
| Torque Converter Clutch | (1) See MISCELLANEOUS CONTROLS in SYSTEM/COMPONENT TESTS article | ||||
| A/C Compressor Clutch Control | (2) See MISCELLANEOUS CONTROLS in SYSTEM/COMPONENT TESTS article | ||||
| Electric Cooling Fan Control | (2) See MISCELLANEOUS CONTROLS in SYSTEM/COMPONENT TESTS article | ||||
| Engine Coolant Level Switch | See ENGINE SENSORS & SWITCHES in SYSTEM/COMPONENT TESTS article | ||||
| Oil Pressure Switch | See ENGINE SENSORS & SWITCHES in SYSTEM/COMPONENT TESTS article | ||||
| Oil Level Sensor | See ENGINE SENSORS & SWITCHES in SYSTEM/COMPONENT TESTS article | ||||
| PCM Controlled Warning Lights | See MISCELLANEOUS CONTROLS in SYSTEM/COMPONENT TESTS article | ||||
| Supercharger Boost Control | See AIR INDUCTION SYSTEMS in SYSTEM/COMPONENT TESTS article | ||||
|
|||||