Component specifications
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2009 Volvo S60, 2008 Volvo S60, 2007 Volvo S60, 2006 Volvo S60, and 2005 Volvo S60. However, it is still accessible from the selected car via links, so may be relevant.
The component specification gives the value of the component when the connector is disconnected. Where no value is given, it is not possible to measure a relevant value at the component.
The figure within the brackets indicates the terminal pin on the component to which the value refers.
| Designation | Type | Supply voltage | Value | Other |
| Air conditioning (A/C) relay | Mechanical relay | 12V (#1) | Approximately 96 Ω (coil) | |
| A/C pressure sensor | Absolute manifold absolute pressure (MAP) sensor | 5V (#3) | - | |
| Stop lamp switch | Position switch | 12V (#1) | The switch is closed when the pedal is depressed (terminals #1-#5) | |
| Fuel pump (FP) relay | Mechanical relay | - | Approximately 96 Ω (coil) | The relay is controlled by the central electronic module (CEM) |
| Fuel temperature sensor | NTC resistor | 5V (#3) | 5896 Ω at 0°C 3792 Ω at 10°C 2500Ω at 20°C 1707Ω at 30°C 1175 Ω at 40°C (#1-#2) |
Integrated in the fuel pressure sensor |
| Fuel pressure sensor | Piezo resistive pressure sensor | 5V (#3) | - | |
| Engine cooling fan (FC) control module | - | 12V (#2) | - | |
| Canister purge (CP) valve | Electromagnetic valve | 12V (#1) | 17-24 Ω at 20°C (terminals #1-#2) | |
| Accelerator pedal (AP) position sensor | Electronic pedal sensor with two output signals, PWM and a linear analog signal | 12V (terminal #1) 5V (terminal #6) Power supply analog position sensors | - | |
| Throttle unit | Electronic throttle control module with two integrated potentiometers and a damper motor | 5V (#3) | 1.2-3.5 Ω (terminals #1-#4 motor winding). 1000-1500 Ω (terminals #2-#3 Parallel connection of potentiometers 1 and 2). Approximately 820 Ω when the throttle is closed. Approximately 1580 Ω at wide open throttle (terminals #2-#6 potentiometer 1). Approximately 1480 Ω when the throttle is closed. Approximately 500 Ω at wide open throttle (terminals #2-#5 potentiometer 2) |
- |
| Injector | Electromagnetic injector valve | 12V (#1) | Approximately 12 Ω at 20°C (terminal #1-#2) | |
| Camshaft sensor | Magneto-resistive sensor | 5V (#1) | - | |
| Knock sensor (KS) | Piezo electric component | - | Greater than 1 MΩ (terminal #1-#2 front knock sensor (KS)). Greater than 1 MΩ (terminals #3-#4 rear knock sensor (KS)) |
Separate signal ground for the knock sensors (KS) |
| Clutch pedal sensor | Slide potentiometer | 5V (#2) | Unaffected pedal: 1400-2400 Ω Fully depressed pedal: 200-800 Ω (#2-#4) |
|
| Cooling fan for control modules | Fan motor | 12V (#1) | - | The engine cooling fan (FC) is controlled by the engine control module (ECM) |
| Coolant level sensor | Position switch | Connected to ground (terminal #2) | Closed when the engine coolant level is normal | |
| Boost pressure sensor | Absolute manifold absolute pressure (MAP) sensor | 5V (#3) | - | |
| Preheating, front heated oxygen sensor (HO2S) | PTC resistor | 12V (#3) | 2.6-3.4 Ω at 20°C (terminals #3-#4) | |
| Preheating, rear heated oxygen sensor (HO2S) | PTC resistor | 12V (#1) | Approximately 9 Ω at 20°C (terminal #1-#2) | |
| Mass air flow (MAF) sensor | - | 12V (#2) 5V (#4) |
- | |
| Air temperature sensor, intake | NTC resistor | 5V (#3) | 5886 Ω at 0°C 3791 Ω at 10°C 2510 Ω at 20°C 1715 Ω 30°C (#1-#2) |
Integrated in the boost pressure sensor |
| Leak diagnostic unit | Consists of an air pump, an electromagnetic valve and an internal heating element (PTC resistor) | 12V (#4) | Approximately 118 Ω (terminals #1-#4 pump motor winding) 27.9 -34.1 Ω (terminals #3-#4 Valve coil) |
The heating element for heating up the pulsed secondary air injection system (PAIR) pump is controlled by the central electronic module (CEM) |
| Engine coolant temperature (ECT) sensor | NTC resistor | 5V (#1) | 15040 Ω at -20°C 2450 Ω at 20°C 318 Ω at 80°C (#1- #2) |
|
| PTC resistor air preheating | PTC resistor | 12V (#1) | Approximately 10 Ω at 20°C | |
| Oil level sensor | Electronic sensor with PTC resistor and capacitive measurement element | 5V (#3) | - | |
| Oil pressure sensor | Pressure switch (Pressostat) | Grounded in the cylinder block | Closed switch when the oil pressure is low | |
| Camshaft reset valve | Electromagnetic valve | 12V (#1) | 3.7-11.1 Ω (#1-#2) | |
| Flywheel sensor | Engine speed sensor | - | 108.5-142.5 Ω at 20°C (terminals #1-#2) | |
| System relay | Mechanical relay | 12V (#1) | Approximately 80 Ω (coil) | |
| Turbocharger (TC) control valve | Electromagnetic valve (3 way) | 12V (#1) | 21.8-24.2 Ω at 20°C (terminals #1-#2) | |
| Outer temperature sensor | NTC resistor | 5V (#1) | 18702 Ω at -20 °C 6318 Ω at 0°C 2424 Ω at 20°C 1034 Ω at 40°C (#1- #3) |