| Air Conditioning |
| Service |
AIR CONDITIONING TECHNICAL DATA |
| Torque |
HEATING AND AIR CONDITIONING -- TIGHTENING TORQUES |
| Axle Nut/Hub Nut (Collar Nut) |
| Front |
FRONT AXLE -- TIGHTENING TORQUES |
| Rear |
REAR AXLE -- TIGHTENING TORQUES |
| Battery |
12V VEHICLE BATTERY |
| Brakes |
| Bleeding Sequence |
RR, LR, RF, LF |
| Disc Brakes |
FRONT BRAKES
REAR BRAKES |
| Torque |
BRAKES -- TIGHTENING TORQUES |
| Charging |
| Generator |
REMOVING AND INSTALLING/REPLACING ALTERNATOR (Z4 sDrive30i)
REMOVING AND INSTALLING/REPLACING ALTERNATOR (Z4 M40i) |
| Torque |
ALTERNATOR -- TIGHTENING TORQUES |
| Drive Belts |
| Adjustment |
N/A |
| Belt Routing |
REPLACING DRIVE BELT FOR ALTERNATOR (Z4 sDrive30i
REPLACING DRIVE BELT FOR ALTERNATOR (Z4 M40i) |
| Engine Cooling |
| Coolant, Cooling System Test |
COOLING SYSTEM TECHNICAL DATA |
| Radiator Cap Pressure |
COOLING SYSTEM TECHNICAL DATA |
| Thermostat R & I |
REMOVING AND INSTALLING/REPLACING HEAT MANAGEMENT MODULE (Z4 sDrive30i)
REMOVING AND INSTALLING/REPLACING HEAT MANAGEMENT MODULE (Z4 M40i) |
| Water Pump R & I |
REMOVING AND INSTALLING/REPLACING THE COOLANT PUMP (Z4 sDrive30i)
REMOVING AND INSTALLING/REPLACING THE COOLANT PUMP (Z4 M40i) |
| Engine Mechanical |
| Compression |
CHECKING COMPRESSION OF ALL CYLINDERS (Z4 sDrive30i)
CHECKING COMPRESSION OF ALL CYLINDERS (Z4 M40i) |
| Oil pressure |
CHECKING ENGINE OIL PRESSURE (Z4 sDrive30i)
CHECKING ENGINE OIL PRESSURE (Z4 M40i) |
| Overhaul |
ENGINE TECHNICAL DATA |
| Torque |
ENGINE -- TIGHTENING TORQUES |
| Fluid Specifications |
See "Fluid Capacities" tab for the selected vehicle. |
| Flywheel/Flex Plate Torque |
FLYWHEEL -- TIGHTENING TORQUE |
| Fuel System |
| Fuel Filter Location |
In fuel tank |
| Fuel Filter R & I |
REMOVE AND INSTALL/REPLACE FUEL PUMP (Z4 sDrive30i)
REMOVE AND INSTALL/REPLACE FUEL PUMP (Z4 M40i) |
| Pressure Release Procedure |
N/A |
| Pressure Specification |
N/A |
| Fuel Pressure Test Procedure |
N/A |
| Ignition |
| Firing Order |
N/A |
| Ignition Wires (Routing) |
Coil on plug |
| Spark Plug |
| Type |
BMW 12122455258 (NGK SILZKGR8E8S / 96206) |
| Gap |
N/A |
| Torque |
23 Nm |
| Starting |
| Starter |
REMOVING AND INSTALLING/REPLACING STARTER MOTOR (Z4 sDrive30i)
REMOVING AND INSTALLING/REPLACING STARTER MOTOR (Z4 M40i) |
| Torque |
STARTER MOTOR -- TIGHTENING TORQUES |
| Wheel Alignment |
| Adjustment Specifications |
WHEEL ALIGNMENT TECHNICAL DATA |
| Torque |
FRONT AXLE -- TIGHTENING TORQUES
REAR AXLE -- TIGHTENING TORQUES |
| Wheel & Tire |
| Wheel Lug Nut Torque |
103 Ft. Lbs. (140 Nm) |