Fastener Specifications
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Camshaft Position Actuator Solenoid Valve Seal |
| Crankshaft Position Sensor O-ring |
| Evaporative Emission Canister Air Inlet Hose Tie Strap |
| Evaporative Emission Canister Purge Hose Tie Strap |
| Fuel Pump Gasket |
| Fuel Pump O-ring |
| Fuel Tank Filler Evaporative Emission Hose Tie Strap |
| Fuel Tank Filler Pipe Tie Strap |
| Fuel Tank Fuel Pump Module O-ring |
| Throttle Body Gasket |
| Vacuum Pump Pipe Seal |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Fuel Feed Intermediate Pipe/Fitting | 28 N.m (21 lb ft) |
| Fuel Pump Bolt | 25 N.m (18 lb ft) |
| Fuel Injection Fuel Rail Fuel Pressure Sensor | 33 N.m (24 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Accelerator Pedal Position Sensor Fastener | 3.5 N.m (31 lb in) |
| Air Cleaner Assembly Fastener | 9 N.m (80 lb in) |
| Air Cleaner Bracket Bolt | 22 N.m (16 lb ft) |
| Air Cleaner Bracket Nut | 22 N.m (16 lb ft) |
| Air Cleaner Outlet Duct Clamp | 4 N.m (35 lb in) |
| Air Cleaner Resonator Bolt | 9 N.m (80 lb in) |
| Air Cleaner Upper Housing Bolt | 4 N.m (35 lb in) |
| Camshaft Position Actuator Locating Pin Control Valve Bolt | 10 N.m (89 lb in) |
| Camshaft Position Actuator Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Camshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Chassis Control Module Bracket Nut | 9 N.m (80 lb in) |
| Crankshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Engine Control Module Bracket Bolt | 9 N.m (80 lb in) |
| Engine Coolant Temperature Sensor | 9 N.m (80 lb in) |
| Evaporative Emission Canister Purge Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Fuel Injection Fuel Rail Fastener | 25 N.m (18 lb ft) |
| Fuel Pump Power Control Module Fastener | 9 N.m (80 lb in) |
| Fuel Tank Filler Hose Clamp | 3.5 N.m (31 lb in) |
| Fuel Tank Filler Pipe Bolt @ Fuel Filler Door | 10 N.m (89 lb in) |
| Fuel Tank Filler Pipe Bolt @ Wheel Well | 9 N.m (80 lb in) |
| Fuel Tank Strap Bolt | 27 N.m (20 lb ft) |
| Heated Oxygen Sensor | 42 N.m (31 lb ft) |
| Ignition Coil Bolt | 10 N.m (89 lb in) |
| Intake Air Duct Bolt | 9 N.m (80 lb in) |
| Knock Sensor Bolt | 25 N.m (18 lb ft) |
| Knock Sensor Heat Shield Bolt | 9 N.m (80 lb in) |
| Manifold Absolute Pressure Sensor Fastener | 7 N.m (62 lb in) |
| Mass Airflow Sensor Bolt | 1.4 N.m (12 lb in) |
| Oil Pump Flow Control Solenoid Valve Harness Bolt | 15 N.m (11 lb ft) |
| Oil Pump Flow Control Valve Fastener | 5 N.m (44 lb in) |
| Positive Crankcase Ventilation Tube Clamp | 4 N.m (35 lb in) |
| Spark Plug | 18 N.m (13 lb ft) |
| Throttle Body Bolt | 10 N.m (89 lb in) |
| Vacuum Pump Pipe Bolt | 9 N.m (80 lb in) |
| Valve Rocker Arm Oil Control Valve Bolt | 10 N.m (89 lb in) |