Fastener Specifications
WARNING: This page is about a different car, the 2018 Chevrolet Trax and 2018 Buick Encore. However, it is still accessible from the selected car via links, so may be relevant.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Engine Oil Cooler Gasket |
| Thermostat Bypass Pipe Gasket |
| Thermostat Housing Gasket |
| Turbocharger Coolant Feed Pipe Copper Washer |
| Turbocharger Coolant Feed Pipe Gasket |
| Turbocharger Coolant Feed Pipe Seal Ring |
| Turbocharger Coolant Return Pipe Clamp |
| Turbocharger Coolant Return Pipe Copper Washer |
| Water Outlet Seal |
| Water Pump Gasket |
| Water Pump Inlet Pipe Seal |
| Water Pump Seal |
| Engine Coolant Thermostat Housing Seal |
| Engine Oil Cooler Seals |
| Turbocharger Feed Pipe Retainer |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Rear Transmission Mount Through Bolt | 80 N.m (59 lb ft) Plus 45 to 60 Degrees |
| Transmission Bolt (LE2) | 75 N.m (55 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Drain Plug | 2 N.m (18 lb in) |
| Engine Coolant Fan Bolt | 5 N.m (44 lb in) |
| Engine Coolant Fan Bolt (LE2) | 6 N.m (53 lb in) |
| Engine Coolant Fan Shroud Bolt (LE2) | 6 N.m (53 lb in) |
| Engine Coolant Fan Retaining Bolt (LUV) | 10 N.m (89 lb in) |
| Engine Coolant Thermostat (2H0) | 10 N.m (89 lb in) |
| Engine Coolant Thermostat Housing Bolt (2H0) | 8 N.m (71 lb in) |
| Engine Coolant Thermostat Housing Bracket Nut (2H0) | 6 N.m (53 lb in) |
| Engine Coolant Thermostat Housing Bolt (LE2) | 10 N.m (89 lb in) |
| Engine Oil Cooler Assembly Bolt (2H0) | 25 N.m (18 lb ft) |
| Engine Oil Cooler Bolt (LUV) - large | 22 N.m (16 lb ft) |
| Engine Oil Cooler Bolt (LUV) - small | 10 N.m (89 lb in) |
| Engine Oil Cooler Housing Bolt (LUV) | 25 N.m (18 lb ft) |
| Engine Oil Cooler Inlet Pipe Bolt (LUV) | 10 N.m (89 lb in) |
| Engine Oil Cooler Inlet Pipe Bracket Bolt (LUV) | 20 N.m (15 lb ft) |
| Engine Oil Cooler Large Bolt (LE2) | 25 N.m (18 lb ft) |
| Engine Oil Cooler Outlet Pipe Bolt (2H0) | 8 N.m (71 lb in) |
| Engine Oil Cooler Outlet Pipe Bolt (LUV) | 10 N.m (89 lb in) |
| Engine Oil Cooler Pipe Bolt (2H0) | 8 N.m (71 lb in) |
| Engine Oil Cooler Small Bolt (LE2) | 10 N.m (89 lb in) |
| Radiator Bolt (LE2) | 6 N.m (53 lb in) |
| Radiator Mounting Pin Bolt | 5 N.m (44 lb in) |
| Radiator Surge Tank Bolt (LE2) | 5 N.m (44 lb in) |
| Radiator Upper Bracket Bolt (2H0, LUV) | 18 N.m (13 lb ft) |
| Radiator Upper Mount Bracket Bolt (LE2) | 18 N.m (13 lb ft) |
| Thermostat Bypass Pipe Bolt (LE2) | 10 N.m (89 lb in) |
| Turbocharger Coolant Feed Pipe Bolt (LUV) | 10 N.m (89 lb in) |
| Turbocharger Coolant Feed Pipe Hollow Bolt (LE2) | 35 N.m (26 lb ft) |
| Turbocharger Coolant Feed Pipe Quick Connect (LUV) | 20 N.m (15 lb ft) |
| Turbocharger Coolant Return Pipe Bracket Bolt (LE2, LUV) | 10 N.m (89 lb in) |
| Turbocharger Coolant Return Pipe Hollow Bolt (LE2) | 35 N.m (26 lb ft) |
| Turbocharger Coolant Return Pipe Quick Connect (LUV) | 20 N.m (15 lb ft) |
| Vent Screw | 1.9 N.m (17 lb in) |
| Water Inlet Pipe Bolt (LUV) | 9 N.m (80 lb in) |
| Water Outlet Bolt (LE2) | 10 N.m (89 lb in) |
| Water Outlet Bolt (LUV) | 8 N.m (71 lb in) |
| Water Pump Bolt (2H0) | 8 N.m (71 lb in) |
| Water Pump Bolt (LE2) | 10 N.m (89 lb in) |
| Water Pump Bolt (LUV) | |
|
8 N.m (71 lb in) |
|
NOTE:
Does not apply to all bolts. Review repair procedure.
|
Plus 30 Degrees |
| Water Pump Housing Bolt (LE2) | 25 N.m (18 lb ft) |
| Water Pump Pulley Bolt (2H0) | 20 N.m (15 lb ft) |
| Water Pump Pulley Bolt (LUV) | 22 N.m (16 lb ft) |
| Wiring Harness Bracket Nut (2H0) | 10 N.m (89 lb in) |