LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Chevrolet >> 2013 >> Trax LS, Automatic Trans >> Repair and Diagnosis >> Engine Performance >> Engine Control Systems >> Engine Controls/Fuel - 1.4L (LUV) - Repair Instructions >> Repair Instructions >> Fuel Tank Replacement (AWD) >> Installation Procedure
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Installation Procedure

  1. Install the fuel sender assembly. Refer to Fuel Sender Assembly Replacement (AWD) .
  2. Transfer the fuel tank fuel pump module. Refer to Fuel Tank Fuel Pump Module Replacement (AWD) and Fuel Tank Fuel Pump Module Replacement (FWD) .
  3. Transfer the evaporative emission canister. Refer to Evaporative Emission Canister Replacement (AWD) and Evaporative Emission Canister Replacement (FWD) .
  4. Install the fuel tank to the hydraulic lift.
    5. Fig 1: Fuel Tank Straps And Fasteners
    GM2783760Courtesy of GENERAL MOTORS COMPANY
  5. With the aid of an assistant, position the fuel tank to the vehicle.
    6. CAUTION:

    Refer to Fastener Caution .

  6. Install both fuel tank straps to the fuel tank (2) and tighten the fasteners to 22 (16 lb ft).
  7. Remove the hydraulic lift from the fuel tank.
  8. Connect the EVAP system hoses. Refer to Evaporative Emission System Hose/Pipe Replacement (Fuel Pump Module to Vent Pipe AWD) , Evaporative Emission System Hose/Pipe Replacement (Fuel Pump Module to Canister AWD) , Evaporative Emission System Hose/Pipe Replacement (Canister to Pipe AWD) , Evaporative Emission System Hose/Pipe Replacement (Canister to Pipe FWD) , Evaporative Emission System Hose/Pipe Replacement (LDE) , Evaporative Emission System Hose/Pipe Replacement (Fuel Pump Module to Vent Pipe FWD) and Evaporative Emission System Hose/Pipe Replacement (Fuel Pump Module to Canister FWD) .
  9. Connect the fuel feed pipe. Refer to Fuel Feed Pipe Replacement (At Tank AWD) , Fuel Feed Pipe Replacement (LDE) and Fuel Feed Pipe Replacement (At Tank FWD) .
  10. Connect the fuel tank filler pipe. Refer to Fuel Tank Filler Pipe Replacement .
    11. Fig 2: Fuel Tank Fuel Pump Module Wiring Harness
    GM2781400Courtesy of GENERAL MOTORS COMPANY
  11. Connect the fuel tank fuel pump module wiring harness (1) and clip the fuel tank module wiring harness to the chassis.
  12. Install the propeller shaft. Refer to Two-Piece Propeller Shaft Replacement .
  13. Install the exhaust. Refer to Exhaust Muffler Replacement (2H0, LUV) .
  14. Install the right rear wheelhouse panel liner. Refer to Rear Wheelhouse Liner Replacement .
  15. Lower the vehicle.
scientia non olet · About LEMON Manuals