Common Specs & Procedures Index
ESCALADE, SUBURBAN, TAHOE & YUKON COMMON SPECS & PROCEDURES
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | APPROXIMATE FLUID CAPACITIES | ||
| Torque | Automatic - FASTENER SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Front | 255 N.m (188 lb ft) | ||
| Battery | N/A | ||
| Brakes | |||
| Bleeding Sequence | RIGHT REAR, LEFT REAR, RIGHT FRONT, LEFT FRONT HYDRAULIC BRAKE SYSTEM BLEEDING (PRESSURE) HYDRAULIC BRAKE SYSTEM BLEEDING (MANUAL) |
||
| Disc Brakes | |||
| Service Specifications | DISC BRAKE COMPONENT SPECIFICATIONS | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Charging | |||
| Generator | N/A | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | Non-Adjustable Serpentine Belt | ||
| Drive Belt Routing | Please see figure under drive belt DRIVE BELT REPLACEMENT - ACCESSORY for 5.3L, 6.2L | ||
| Engine Cooling | |||
| General Service Specifications | N/A | ||
| Radiator Cap Pressure | Pressure Stamped On Cap | ||
| Thermostat R & I | |||
| 5.3L, 6.2L | ENGINE COOLANT THERMOSTAT HOUSING REPLACEMENT | ||
| Water Pump R & I | |||
| 5.3L, 6.2L | WATER PUMP REPLACEMENT | ||
| Engine Mechanical | |||
| 5.3L, 6.2L | |||
| Compression | ENGINE COMPRESSION TEST | ||
| Oil Pressure | Minimum - Hot - @ 1,000 RPM - 152 kPa (22 psig) @ 2,000 RPM - 207 kPa (30 psig) @ 3,000 RPM - 228 kPa (33 psig) |
||
| Overhaul | ENGINE MECHANICAL SPECIFICATIONS (L83) ENGINE MECHANICAL SPECIFICATIONS (L86) |
||
| Torque | FASTENER SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE/FLUIDS tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate/Drive Plate Torque | 5.3L, 6.2L Automatic - First Pass - 15 N.m (11 lb ft) Second Pass - 30 N.m (22 lb ft) Final Pass - 45 Degrees |
||
| Fuel System | |||
| Pressure Specification | 5.3L, 6.2L (FPCM) - Ignition ON, engine OFF, 345-690 kPa (50-100 psi) ± 5 percent | ||
| Fuel Pressure Test Procedure | 5.3L, 6,2L - CIRCUIT/SYSTEM VERIFICATION | ||
| Fuel Filter Location | Fuel Filter Is Part of the Fuel Tank Fuel Pump Module | ||
| Fuel Filter R & I | 5.3L, 6.2L - FUEL TANK FUEL PUMP MODULE REPLACEMENT (SWB) FUEL TANK FUEL PUMP MODULE REPLACEMENT (LWB) |
||
| Ignition | |||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | Individual Ignition Coil/Module Assemblies | ||
| Ignition Wires (Routing) | |||
| 5.3L, 6.2L | Coil on Plug | ||
| Spark Plug | |||
| 5.3L, 6.2L - Type - See parts catalog | |||
| Gap | 0.95-1.10 mm (0.037-0.043 in) | ||
| Torque | 20 N.m (15 lb ft) | ||
| Starting | |||
| Starter | N/A | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | WHEEL ALIGNMENT SPECIFICATIONS | ||
| Torque | FASTENER SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 190 N.m (140 lb ft) For lug nut Tightening Sequence, please see figure under INSTALLATION PROCEDURE |
||