Fastener Specifications
WARNING: This page is about a different car, the 2017 Chevrolet Spark. However, it is still accessible from the selected car via links, so may be relevant.
Single Use Non-Threaded Fasteners/Components
| Application |
|---|
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal.
|
| Engine Coolant Thermostat Housing Gasket |
| Water Outlet Gasket |
| Radiator Mounting Pin |
| Thermostat Bypass Pipe Gasket |
| Engine Coolant Thermostat Housing Gasket |
| Water Pump Housing Gasket |
Reusable Threaded Fastener Tightening Specifications
| Application | Specification |
|---|---|
| Metric (English) | |
|
NOTE:
All fasteners listed in this table can be reused after removal.
|
|
| Air Conditioning Compressor and Condenser Under Pipe Nut | 11 N.m (96 lb in) |
| Air Conditioning Condenser Bolt | 8 N.m (71 lb in) |
| Air Conditioner Evaporator Hose Assembly Nut | 22 N.m (16 lb ft) |
| Block Heater Connecting Plug Holder Bolt | 8 N.m (71 lb in) |
| Catalytic Converter Heat Shield Cover Bolt | 9 N.m (80 lb in) |
| Engine Coolant Fan Bolt | 3 N.m (27 lb in) |
| Engine Coolant Fan Shroud Bolt | 6 N.m (53 lb in) |
| Engine Coolant Heater | 60 N.m (44 lb ft) |
| Engine Coolant Thermostat Bolt | 10 N.m (89 lb in) |
| Engine Coolant Thermostat Housing Bolt | 10 N.m (89 lb in) |
| Intake Manifold Rear Bracket Bolt - Down | 58 N.m (42 lb ft) |
| Intake Manifold Rear Bracket Bolt - Up | 22 N.m (16 lb ft) |
| Oxygen Sensor Connector Bracket Bolt | 15 N.m (11 lb ft) |
| Radiator Drain Cock | 2 N.m (18 lb in) |
| Radiator Lower Bracket Bolt | 22 N.m (16 lb ft) |
| Radiator Overflow Hose Bracket Nut | 9 N.m (80 lb in) |
| Radiator Support Bracket Bolt | 22 N.m (16 lb ft) |
| Radiator Support Mounting Bolt | 22 N.m (16 lb ft) |
| Radiator Surge Tank Mounting Bolt | 5 N.m (44 lb in) |
| Upper Tie Bar To Front Compartment Side Rail Retaining Nut - Left Side | 9 N.m (80 lb in) |
| Upper Tie Bar To Front Compartment Side Rail Retaining Nut - Right Side | 9 N.m (80 lb in) |
| Upper Tie Bar To Impact Bar Retaining Bolts - Left Side | 10 N.m (89 lb in) |
| Upper Tie Bar To Impact Bar Retaining Bolts - Right Side | 10 N.m (89 lb in) |
| Water Outlet Bolt | 12 N.m (106 lb in) |
| Water Pump Bolt | 25 N.m (18 lb ft) |
| Water Pump Pulley Bolt | 10 N.m (89 lb in) |