Specification Index
(Discovery Sport) SPECIFICATIONS INDEX
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SPECIFICATIONS | ||
| Torque | SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Front | Front halfshaft to hub nut: Stage 1 300 Nm, 221 LB-FT Stage 2 Loosen 90° Stage 3 80 Nm, 59 LB-FT Stage 4 60° |
||
| Rear | Halfshaft nut: Stage 1 300 Nm, 221 LB-FT Stage 2 Loosen 90° Stage 3 80 Nm, 59 LB-FT Stage 4 60° |
||
| Battery | SPECIFICATIONS - WITH PHEV , SPECIFICATIONS - NON ELECTRICAL | ||
| Brakes | |||
| Bleeding Sequence | BRAKE SYSTEM BLEEDING - VEHICLES WITH: MHEV/NON-ELECTRIC VEHICLES (G1889732)
, BRAKE SYSTEM PRESSURE BLEEDING - VEHICLES WITH: PHEV (G2408607) |
||
| Disc Brakes | GENERAL SPECIFICATIONS FRONT DISC BRAKE (G2360343) REAR DISC BRAKE (G2360344) |
||
| Torque | |||
| Front Disc Brakes | SPECIFICATIONS | ||
| Rear Disc Brakes | SPECIFICATIONS | ||
| Charging | |||
| 2.0L Petrol | |||
| Generator | GENERATOR AND REGULATOR - INGENIUM I4 2.0L PETROL | ||
| Torque | SPECIFICATIONS | ||
| Drive Belts | |||
| 2.0L Petrol | |||
| Adjustment | ACCESSORY DRIVE BELT TENSIONER - VEHICLES WITH: NON-ELECTRIC VEHICLES | ||
| Belt Routing | ACCESSORY DRIVE BELT - VEHICLES WITH: NON-ELECTRIC VEHICLES | ||
| Engine Cooling | |||
| 2.0L Petrol | |||
| General Service Specifications | SPECIFICATIONS | ||
| Radiator Cap Pressure | 140 kPa, 20.3 PSI | ||
| Thermostat R & I | |||
| 2.0L Petrol | THERMOSTAT | ||
| Water Pump R & I | |||
| 2.0L Petrol | COOLANT PUMP - [+] MHEV (G2360810) , COOLANT PUMP - VEHICLES WITH: NON-ELECTRIC VEHICLES (G2110294) , COOLANT PUMP - CHARGE AIR COOLER (G2110298) | ||
| Engine Mechanical | |||
| 2.0L Petrol | |||
| Compression | CYLINDER COMPRESSION TEST - INGENIUM I4 2.0L PETROL (G2110208) | ||
| Oil Pressure | |||
| Overhaul | ENGINE - INGENIUM I4 2.0L PETROL | ||
| Torque | SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate/Drive Plate Torque | |||
| 2.0L Petrol | Stage 1 30 Nm, 22 LB-FT Stage 2 120° |
||
| Fuel System | |||
| 2.0L Petrol | |||
| Pressure Specification | 4.5 bar - 65.3 lbf/in2 | ||
| Fuel Pressure Test Procedure | |||
| Fuel Filter Location | Located in the fuel tank | ||
| Fuel Filter R & I | Refer to the appropriate Fuel Filter article. | ||
| Ignition | |||
| 2.0L Petrol | |||
| Firing Order & Cylinder Identification | 1, 3, 4, 2 No. 1 from the accessory drive end |
||
| Ignition Wires (Resistance) | Coil On Plug | ||
| Ignition Wires (Routing) | Coil On Plug | ||
| Spark Plug | |||
| 2.0L Petrol | |||
| Gap | 0.6 - 0.65mm (0.024 - 0.026 inches) | ||
| Torque | SPECIFICATIONS | ||
| Starting | |||
| 2.0L Petrol | |||
| Starter | STARTER MOTOR | ||
| Torque | SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | SPECIFICATIONS | ||
| Torque | |||
| Front | SPECIFICATIONS | ||
| Rear | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | Stage 1 4 Nm, 3 LB-FT Stage 2 70 Nm, 52 LB-FT Stage 3 133 Nm, 98 LB-FT |
||