Specifications Index
AVIATOR SPECIFICATIONS INDEX
| System | Specification/Procedure | |||
|---|---|---|---|---|
| Air Conditioning | ||||
| Service | GENERAL SPECIFICATIONS | |||
| Torque | TORQUE SPECIFICATIONS | |||
| Axle Nut/Hub Nut | ||||
| Front | 184 Ft. Lbs. (250 N.m) | |||
| Rear | 203 Ft. Lbs. (275 N.m) | |||
| Battery | 650 CCA 72 amp/hr |
|||
| Brakes | ||||
| Bleeding Sequence | BRAKE SYSTEM BLEEDING | |||
| Disc Brakes | GENERAL SPECIFICATIONS | |||
| Torque | TORQUE SPECIFICATIONS | |||
| Charging | ||||
| Generator | GENERATOR SPECIFICATIONS | |||
| Torque | TORQUE SPECIFICATIONS | |||
| Drive Belts | ||||
| Adjustment | BELT ADJUSTMENT | |||
| Belt Routing | DRIVE BELT ROUTING | |||
| Engine Cooling | ||||
| General Service Specifications | COOLING SYSTEM SPECIFICATIONS | |||
| Radiator Cap Pressure | 13-18 psi (89-124 kPa) | |||
| Thermostat R & I | THERMOSTAT AND THERMOSTAT HOUSING | |||
| Water Pump R & I | WATER PUMP | |||
| Engine Mechanical | ||||
| Compression | COMPRESSION TEST--COMPRESSION GAUGE CHECK | |||
| Oil Pressure | (hot @ 1,500 rpm) 20-45 psi (138-310 kPa) | |||
| Overhaul | GENERAL SPECIFICATIONS | |||
| Torque | TORQUE SPECIFICATIONS | |||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | |||
| Flywheel/Flex Plate Torque | 59 Ft. Lbs. (80 N.m) | |||
| Fuel System | ||||
| Fuel Filter Location | On leading edge of fuel tank on right side, mounted behind fuel filter splash shield. | |||
| Fuel Filter R & I | FUEL LINES AND FUEL FILTER | |||
| Pressure Release Procedure | FUEL SYSTEM PRESSURE RELEASE | |||
| Pressure Specification | FUEL PRESSURE SPECIFICATIONS | |||
| Fuel Pressure Test Procedure | A: No Start STEP A10 CHECK THE FUEL PRESSURE | |||
| Ignition | ||||
| Firing Order & Cylinder Identification | FIRING ORDER & CYLINDER IDENTIFICATION | |||
| Ignition Coil (Cylinder Identification) | Coil on plug | |||
| Ignition Wires (Routing) | Coil on plug | |||
| Spark Plugs | ||||
| Type | Motorcraft AWSF-32EM | |||
| Gap | 0.052-0.056 In. (1.32-1.42 mm) | |||
| Torque | 15 Ft. Lbs. (20 N.m) | |||
| Starting | ||||
| Starter | STARTER MOTOR SPECIFICATIONS | |||
| Torque | TORQUE SPECIFICATIONS | |||
| Wheel Alignment | ||||
| Adjustment Specifications | GENERAL SPECIFICATIONS | |||
| Torque Specifications | TORQUE SPECIFICATIONS | |||
| Wheel & Tire | ||||
| Wheel Lug Nut Torque | 100 Ft. Lbs. (135 N.m) | |||