HVAC Torque Specifications
HVAC TORQUE SPECIFICATIONS
| Application | Ft. Lbs. (N.m) |
|---|---|
| Battery Box-To-Body Bolt | 11 (15) |
| Compressor Clutch Nut | 14 (19) |
| Compressor Hose Assembly-To-Compressor Bolt | 20 (27) |
| Compressor Hose Assembly-To-Condenser Nut | 12 (16) |
| Compressor Hose Assembly-To-TXV Nut (2.2L) | 12 (16) |
| Compressor-To-Engine Block Bolt | 16 (22) |
| Discharge Line Nut | 12 (16) |
| Evaporator Outlet Hose-To-Compressor Hose Nut (3.5L) | 12 (16) |
| Evaporator Outlet Hose-To-TXV Nut (3.5L) | 12 (16) |
| Liquid Line-To-TXV Nut | 12 (16) |
| Liquid Line-To-Receiver Dehydrator Nut | 12 (16) |
| Receiver Dehydrator-To-Condenser Nut | 12 (16) |
| INCH Lbs. (N.m) | |
| Actuator-To-HVAC Case Screw | 9 (1) |
| Air Inlet Assembly Screw | 9 (1) |
| Air Outlet Duct Screw | 9 (1) |
| Blower Motor Resistor Screw | 9 (1) |
| Blower Motor Screw | 9 (1) |
| Compressor Hose Assembly-To-Battery Box Nut (2.2L) | 71 (8) |
| Compressor Pressure Relief Valve | 89 (10) |
| Compressor Thermal Protection Switch Retainer Bolt | 53 (6) |
| CRFM Bracket Bolt | 89 (10) |
| Defrost Actuator-To-Evaporator Case Screw | 9 (1) |
| Defroster Duct -To-HVAC Module Nut | 22 (2.5) |
| Evaporator Case Assembly-To-Blower Case Assembly Screw | 9 (1) |
| Evaporator Cover Screw | 9 (1) |
| Evaporator Outlet Hose-To-Air Cleaner Bracket Bolt (3.5L) | 62 (7) |
| Evaporator Outlet Hose-To-Cowl Nut (3.5L) | 71 (8) |
| Evaporator Pipe Cover Screw | 9 (1) |
| Floor Actuator-To-Evaporator Case Screw | 9 (1) |
| Front Of Dash-To-HVAC Module Seal Nut | 70 (8) |
| Heater Core Cover Screw | 9 (1) |
| Heater Core Pipe Cover Screw | 9 (1) |
| Heater Core Screw | 9 (1) |
| Heater Duct-To-Heater Core Cover Screw | 18 (2) |
| Hold Down Bracket & Bolt | 53 (6) |
| HVAC Controller-To-Radio Bezel Screw | 22 (2.5) |
| HVAC Module-To-Cross Car Beam Nut/Bolt | 70 (8) |
| Intermediate Duct Fastener | 22 (2.5) |
| Liquid Line-To-Strut Tower Nut (2.2L) | 44 (5) |
| Liquid Line-To-Strut Tower Nut (3.5L) | 89 (10) |
| Metal Bracket-To-HVAC Module Screws | 18 (2) |
| Panel Actuator-To-Evaporator Case Screw | 9 (1) |
| Passenger Compartment Air Filter Housing Nut | 80 (9) |
| Receiver Dehydrator Bracket Bolt-To-Body | 89 (10) |
| Recirc Assembly Screw | 9 (1) |
| Refrigerant Low Temperature Sensor Bolt-To-TXV | 45 (5) |
| Refrigerant Pressure Sensor-To-Compressor Hose Assembly | 89 (10) |
| Temperature Cable Screw | 9 (1) |
| TXV Backing Plate Bolt | 80 (9) |