LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Saturn >> 2005 >> Vue Red Line, AWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 2 (Engine Controls - 2.2L (L61) Introduction) >> Repair Instructions >> Fuel Level Sensor Replacement (Primary) >> Removal Procedure
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
    IMPORTANT: There are 2 fuel level sender unit and float assemblies in the fuel tank. There is 1 located on each fuel pump module. The fuel level sender unit and float is NOT the same for each of the fuel pump modules.
  1. Remove the fuel tank. Refer to Fuel Tank Replacement .
  2. Remove the fuel pump module. Refer to Fuel Tank Module Replacement - Primary .
  3. Disconnect the fuel level sender unit and float electrical connector from the underside of the top of the pump module.
  4. Release the retaining tabs (1, 2) and remove the level sensor by sliding up.
    Fig 1: View Of Fuel Level Sensor
    GM1226418Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals