LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Toyota >> 2005 >> RAV4 Base, FWD, Standard >> Repair and Diagnosis >> Transmission >> Manual Trans >> Manual Transmission >> Troubleshooting >> Problem Symptoms Table
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Problem Symptoms Table

Use the table below to help you find the cause of a problem. The numbers indicate the priority of the likely cause of the problem. Check each part in order. If necessary, replace parts.

PROBLEM SYMPTOMS TABLE - MANUAL TRANSAXLE

Symptom Suspect Area
Noise
  1. Oil (Level low) 2WD 4WD Transfer
  2. Oil (Wrong)) 2WD 4WD Transfer
  3. Gear (Worn or damaged)
  4. Bearing (Worn or damaged)
Oil leakage
  1. Oil (Level too high) 2WD 4WD Transfer
  2. Gasket (Damaged)
  3. Oil seal (Worn or damaged)
  4. O-Ring (Worn or damaged)
Hard to shift or will not shift
  1. Control cable (Faulty)
  2. Synchronizer ring (Worn or damaged)
  3. Shift key spring (Damaged)
Jumps out of gear
  1. Locking ball spring (Damaged)
  2. Shift fork (Worn)
  3. Gear (Worn or damaged)
  4. Bearing (Worn or damaged)
Tight corner braking
  1. Differential, Center differential (Faulty)
scientia non olet · About LEMON Manuals