Problem Symptoms Table
Use the table below to help you determine the cause of the problem. The numbers in the column of "Suspect Area" indicate the possibility of the problem in descending order. Therefore, check the areas in this order. If necessary, replace or exchange these parts.
PROBLEM SYMPTOMS TABLE
| Symptom | Suspect Area | Proceed To |
|---|---|---|
| Noise | 1. Oil (Level low) | MANUAL TRANSAXLE OIL |
| 2. Oil (Wrong) | MANUAL TRANSAXLE OIL | |
| 3. Gear (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| 4. Bearing (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| Oil leakage | 1. Oil (Level too high) | MANUAL TRANSAXLE OIL |
| 2. Gasket (Damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| 3. Oil seal (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| 4. O-Ring (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| Hard to shift or will not shift | 1. Control cable (Faulty) | FLOOR SHIFT CABLE TRANSMISSION CONTROL SHIFT |
| FLOOR SHIFT CABLE TRANSMISSION CONTROL SELECT | ||
| 2. Synchronizer ring (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| 3. Shift key spring (Damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| Jumps out of gear | 1. Locking ball spring (Damaged) | MANUAL TRANSAXLE ASSY (E351) |
| 2. Shift fork (Worn) | MANUAL TRANSAXLE ASSY (E351) | |
| 3. Gear (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) | |
| 4. Bearing (Worn or damaged) | MANUAL TRANSAXLE ASSY (E351) |