Engine Controls - Self-Diagnostics
- Introduction
- Self-Diagnostic System
- Powertrain Control Module Location
- Programming
- Summary
- Fuel System Pressure Release
- Diagnostic Trouble Code Definitions
- Connector Identification
- Notes
- Battery Temperature Sensor Connector End View
- Brake Switch Connector End View
- Camshaft Position Sensor Connector End View
- Coil On Plug Connector End View (4.7L)
- Controller Anti-Lock Brake (CAB) Module Connector C1 End View
- Crankshaft Position Sensor Connector End View
- Data Link Connector End View
- Engine Coolant Temperature Sensor Connector End View (2.5L)
- Engine Coolant Temperature Sensor Connector End View (3.9L & 5.9L)
- Engine Coolant Temperature Sensor Connector End View (4.7L)
- Engine Oil Pressure Sensor Connector End View
- EVAP Purge Solenoid Connector End View
- Fuel Injector Connector End View (2.5L)
- Fuel Injector Connector End View (3.9L, 4.7L & 5.9L)
- Fuel Pump Module Connector End View
- Idle Air Control Motor Connector End View
- Ignition Coil Connector End View (2.5L, 3.9L & 5.9L)
- Intake Air Temperature Sensor
- Leak Detection Pump Connector End View
- Manifold Absolute Pressure Sensor Connector End View (2.5L, 3.9L & 5.9L)
- Manifold Absolute Pressure Sensor Connector End View (4.7L)
- Oxygen Sensor Wiring Harness Side Connector End View
- Park/Neutral Switch Connector End View (3.9L & 5.9L)
- Power Steering Pressure Switch Connector End View (4.7L)
- Powertrain Control Module Connectors End View
- Throttle Position Sensor Connector End View
- Transmission Control Module Connector End View (4.7L)
- Transmission Solenoid Assembly Connector End View (3.9L & 5.9L)
- Transmission Solenoid Assembly Connector End View (4.7L)
- Diagnostic Tests
- Notes
- DTC P0107: Map Sensor Voltage Too Low
- DTC P0108: Map Sensor Voltage Too High
- DTC P0112: Intake Air Temp Sensor Voltage Low
- DTC P0113: Intake Air Temp Sensor Voltage High
- DTC P0117: ECT Sensor Voltage Too Low
- DTC P0118: ECT Sensor Voltage Too High
- DTC P0121: TPS Voltage Does Not Agree With Map
- DTC P0122: Throttle Position Sensor Voltage Low
- DTC P0123: Throttle Position Sensor Voltage High
- DTC P0125: Closed Loop Temp Not Reached
- DTC P0130: 1/1 O2 Sensor Heater Circuit Malfunction
- DTC P0131: 1/1 O2 Sensor Shorted To Ground
- DTC P0132: 1/1 O2 Sensor Shorted To Voltage
- DTC P0133: 1/1 O2 Sensor Slow Response
- DTC P0135: 1/1 O2 Sensor Heater Failure
- DTC P0136: 1/2 O2 Sensor Heater Circuit Malfunction
- DTC P0137 1/2 O2 Sensor Shorted To Ground
- DTC P0138: 1/2 O2 Sensor Shorted To Voltage
- DTC P0139: 1/2 O2 Sensor Slow Response
- DTC P0141: 1/2 O2 Sensor Heater Failure
- DTC P0151: 2/1 O2 Sensor Shorted To Ground
- DTC P0152: 2/1 O2 Sensor Shorted To Voltage
- DTC P0153: 2/1 O2 Sensor Slow Response
- DTC P0155: 2/1 O2 Sensor Heater Failure
- DTC P0157: 2/2 O2 Sensor Shorted To Ground
- DTC P0158: 2/2 O2 Sensor Shorted To Voltage
- DTC P0159: 2/2 O2 Sensor Slow Response
- DTC P0161: 2/2 O2 Sensor Heater Failure
- DTC P0171 & DTC P0174: Fuel System Lean
- DTC P0172 & DTC P0175: Fuel System Rich
- DTC P0201: Injector #1 Control Circuit
- DTC P0202: Injector #2 Control Circuit
- DTC P0203: Injector #3 Control Circuit
- DTC P0204: Injector #4 Control Circuit
- DTC P0205: Injector #5 Control Circuit
- DTC P0206: Injector #6 Control Circuit
- DTC P0207: Injector #7 Control Circuit
- DTC P0208: Injector #8 Control Circuit
- DTC P0300-0308: Multiple Cylinder Misfire
- DTC P0320: No Crank Reference Signal At Pcm
- DTC P0340: No Cam Signal At Pcm
- DTC P0351: Ignition Coil #1 Primary Circuit
- DTC P0352: Ignition Coil #2 Primary Circuit
- DTC P0353: Ignition Coil #3 Primary Circuit
- DTC P0354: Ignition Coil #4 Primary Circuit
- DTC P0355: Ignition Coil #5 Primary Circuit
- DTC P0356: Ignition Coil #6 Primary Circuit
- DTC P0357: Ignition Coil #7 Primary Circuit
- DTC P0358: Ignition Coil #8 Primary Circuit
- DTC P0420: 1/1 Catalytic Converter Efficiency
- DTC P0432: 2/1 Catalytic Converter Efficiency
- DTC P0441: EVAP Purge Flow Monitor
- DTC P0442, P0455 & DTC P0456: EVAP Leak Monitor Medium/Large/Small Leak Detected
- DTC P0443: EVAP Purge Solenoid Circuit
- DTC P0460: Fuel Level Unit No Change Over Miles
- DTC P0461: Fuel Level Unit No Change Over Time
- DTC P0462: Fuel Level Sending Unit Volts Too Low
- DTC P0463: Fuel Level Sending Unit Volts Too High
- DTC P0500: No Vehicle Speed Sensor Signal
- DTC P0505: Idle Air Control Motor Circuits
- DTC P0551: Power Steering Switch Failure
- DTC P0601: Pcm Internal Controller Failure
- DTC P0622: Generator Field Not Switching Properly
- DTC P0645: A/C Clutch Relay Circuit
- DTC P0700: EATX Controller DTC Present
- DTC P1195: 1/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1196: 2/1 O2 Sensor Slow During Catalyst Monitor
- DTC P1197: 1/2 O2 Sensor Slow During Catalyst Monitor
- DTC P1281: Engine Is Cold Too Long
- DTC P1282: Fuel Pump Relay Control Circuit
- DTC P1294: Target Idle Not Reached
- DTC P1296: No 5 Volts To Map Sensor
- DTC P1297: No Change In Map From Start To Run
- DTC P1388: Auto Shutdown Relay Control Circuit
- DTC P1389: No ASD Relay Output Voltage At Pcm
- DTC P1391: Intermittent Loss Of CMP Or CKP
- DTC P1398: Mis-Fire Adaptive Numerator At Limit
- DTC P1486: EVAP Leak Monitor Pinched Hose Found
- DTC P1491: Rad Fan Control Relay Circuit
- DTC P1492: Ambient/Batt Temp Sen Volts Too High
- DTC P1493: Ambient/Batt Temp Sen Volts Too Low
- DTC P1494: Leak Detection Pump SW Or Mechanical Fault
- DTC P1495: Leak Detection Pump Solenoid Circuit
- DTC P1594: Charging System Voltage Too High
- DTC P1682: Charging System Voltage Too Low
- DTC P1687: No Cluster Bus Message
- DTC P1696: Pcm Failure EEPROM Write Denied
- DTC P1698: No Bus Message From Trans Control Module
- Test NTC-1: No Trouble Code Test Menu
- Test NTC-2: No Response From TCM (4.7L Only)
- Test NTC-3: Checking A/C System
- Test NTC-4: Checking Ambient/Battery Temperature Sensor
- Test NTC-5: Checking Brake Switch
- Test NTC-6: Checking Charging System
- Test NTC-7: Checking Engine Coolant Temperature (ECT) Sensor Calibration
- Test NTC-8: Checking Engine Mechanical Systems
- Test NTC-9: Checking Engine Vacuum
- Test NTC-10: Checking Evaporative Emission System
- Test NTC-11: Checking Fuel Delivery
- Test NTC-12: Checking IAC Motor Operation
- Test NTC-13: Checking Intake Air Temperature (IAT) Sensor
- Test NTC-14: Checking Manifold Absolute Pressure (Map) Sensor Calibration
- Test NTC-15: Checking Oil Pressure Sensor
- Test NTC-16: Checking Pcm Power & Ground Circuits
- Test NTC-17: Checking Park/Neutral Switch
- Test NTC-18: Checking Radiator Fan Operation
- Test NTC-19: Checking Secondary Ignition System
- Test NTC-20: Checking Throttle Position (TP) Sensor Calibration
- Test NS-SEL: No Start Test Selection
- Test NS-1: Engine Cranks But Will Not Start
- Test NS-2: Engine Will Not Crank
- Test NS-3: Engine Does Not Start & Scan Tool Displays No Response
- Test NS-4: Start & Stall Condition
- Test VER-1: Powertrain Verification
- Test VER-2: Road Test Verification
- Test VER-3: Charging System Verification
- Test VER-4: Speed Control Verification
- Test VER-5: OBD-II Monitor Verification
- Test VER-6: Leak Detection Pump (LDP) Verification
- Test VER-7: Fuel/Misfire Verification
- Test VER-8: Transmission Verification
- Test VER-9: Transmission Verification